Scotsman SCN60 User manual

SCN60
Residential
NuggetIce
Machine

SCN60NuggetIce
•NuggetIce
–Whatitisn’t:Icefrozeninamold
–Whatitis:Achewableice,formedcontinuouslyby
forcingsofticethrutaperedholes.

Components
•Compared
tocubeice
machines:
–No spraypump
–No sprayjets
–No hotgasvalve
–No inletwater
solenoidvalve
•Butitdoes
have:
–Auger
–Gearreducer
–Floatvalve

SCN60Cabinet
•15inchwidecabinet
•Canbebuiltin–airin
andoutthefront
•Servicepanelonside
•Finishes
–Unfinisheddoor
•Fordecoratordoor
–Stainlessdoor

IntheBin
Ice Outlet Chute
Light
Bin Level Sensor
Dataplate

IntheBin
Drain
Condensate Drain Hose
Scoop Holder

Cabinet
•Airinandoutthe
front
•FrontService
Panel
•Kickplate
–Accessto
condenser

SideServicePanel
Provides access to bin drain, drain pump (when used), fan
motor and compressor.
Side access panel now on ALL SC Models!!

ReverseDoorSwing
•Removehingecovers
•Loosenthescrewonthe
keyholeslot,removethe
other
•Pulldoorfromunit
•Switchhingesondoor

ReverseDoorSwing
•Removetoppanel
•Removeandreplacetop
bracket

ReverseDoorSwing
•Removeandreplace
lowerdoorbracket
–Newbrackets
shippedloose
insidethebin
–Hardware
packageincludes
oppositedoor
hingecovers,90
degreedoorstop
pin&levelingleg
caps

DoorPanel
•Unfinished
unitsare
shipped
withoutdoor
covers
–UseWhite,Blackor
StainlessScotsmanpanel
kits
•Panelkitsincludehole
covers
–Makeandattacha
Hole Cover

Installation
•Power
–115voltmodelwithpowercord
•Water
–¼”ODcoppertubeonback,compressionfitting
shipsinattachedbag
•Drain
–Gravitymodel
–Pumpmodelorkit

Electrical
•115volt,60Hzpower
•Unitmustbeonseparate15amp
circuit
•Outletshouldbeaccessibleormust
usecircuitbreakertoshutoffpower
duringservice
•Noextensioncordspermitted

WaterSupplyConnection
•Connectionon
back
•Compression
fittingshipped
withunit
•20to80lb
pressure
•Coilinlettubingto
thisfittingwhen
unitbuiltin

Drain
•Gravity
–Connecttohoseinside
cabinet‐fieldsupplied
–Draintubingmustnot
trapwater
–Ventanduserigid
tubingoutsideof
cabinet
–Routeandslopeto
drain
–Maintaincodeairgap
•DrainPump
–Hosepre‐connected
–Routetodrain
–Maintaincodeairgaps
–Pumpwillactivate
whenwaterbacksup
intoinlethose

ControlPanel
Status Light-
Green
Check Water Light-
Red
Time-to-Clean
Indictor Light-
Yellow
Clean-
Reset
On/Off

InitialStartUp
•Connectpower
–Panellightsblink
•Turnonwater
supply
•PushOn‐Offbutton
–Icemakinglight
switchesON
•Compressor,Fan
MotorandAuger
DriveMotor
operate
•Inabout10minutes
icewillbegintofall
intothebin

ControlPanel–
IceMakingMode
•GreenLight
–Indicatesreadytomakeice
–Doesnotindicateoperation,binfullorempty

ControlPanel– CheckWater
•RedLight
– Indicates Lack of Water to Machine
– No ice will be made while light is on
– Restarts automatically when water restored