Sebart G-91 PAN EDF User manual

SebArt professional line
G-91 PAN EDF ARF
ASSEMBLY MANUAL
The real plane
The Fiat G.91 was an Italian jet fighter aircraft. It entered in operational service with the Italian Air Force
in 1961, with the West German uftwaffe, in 1962, and later with the Portuguese Air Force. It was in
production for 19 years. 756 aircraft were completed, including the prototypes and pre-production
models. The Fiat G.91 enjoyed a long service life that extended over 35 years.
The Fiat G.91 have served for many years with the Italian aerobatic team, the Frecce Tricolori as the G.91
PAN. The Frecce Tricolori (literally Tricolour Arrows), officially known as the 313° Gruppo Addestramento
Acrobatico, is the aerobatic demonstration team of the Italian Aeronautica Militare, based at Rivolto Air
Force Base. They were formed in 1961 as an Air Force team. On 28 December 1963 the “Frecce Tricolori”
received the first of about twenty of the new light tactic fighter jet, the Fiat G.91, duly modified for
aerobatic training. Among the main changes made to this aircraft, called the G.91PAN, was the addition
of a smoke–producing device fueled by subwing tanks and special counterweights installed in place of
onboard weapons. For the first time, since the end of World War II, an aerobatic team was equipped with
a fighter aircraft entirely designed and produced in Italy. With the delivery of the G.91PAN the “Frecce
Tricolori” developed two different flight schemes – high and low flight, the later adopted in case of
adverse weather conditions – which included well-known figures such as the Cardioid, the Double
Tonneau, the Arizona, the Bomb and subsequently the Apollo 313. With the G.91 the “Frecce Tricolori”
pilots could give their best and gained great popularity in Italy as well as overseas, rightfully placing
themselves among the greatest aerobatic teams in the world. The G91 equipped the Pattuglia Acrobatica
Nazionale (National Aerobatic Team) for 18 glorious years, during which the “Frecce Tricolori” pilots
received honors and recognition all over the world and in 1982 the G.91PAN was finally replaced by the
MB339PAN…
Specifications:
Year Built:………….……....……………………1956
Primary Function:……..Light eight Strike Fighter
Length:…………….………....….. 10.3 m (33 ft 9 in
Wingspan:……………………….. 8.56 m (28 ft 1 in
Weight Empty: …………..…..….3,100 kg (6,830 lb
Max. Speed:………... 1,075 km/h (580 kn, 668 mph
Engine: Bristol S.O.803 turbojet 22.2 kN (5,000 lbf
Thrust/weight:.......................................................0.42

The model
The G-91 PAN EDF ARF, was designed by the 15 times Italian
Champion Sebastiano Sil estri, ice-European Champion and
F.A.I World Cup winner F3A.
This professional ARF kit is the result of Sebastiano’s long
research, experience in aerobatics and his passion for jet and scale
planes. This combined with a light and strong weight foam/epo
structure and with small aerodinamical tricks gi e the G-91 PAN
EDF an impressi e precision and easy control at any airspeed and
flight condition.
The G-91 PAN EDF is simply unique... fly it and enjoy the scale
functions, as the flaps, the lights sytem, the electric landing gear
with scale doors and the parachute!
It can fly slow, it can fly fast and it can perform as the real Frecce
Tricolori all aerobatic manou ers!
.....the only limit is your fantasy!
Specifications:
Wing Span:………………...……..............................116 cm
Length:….......…….…………….........................…136,5 cm
Wing Area:……....................................................35,35 dm2
Weight:……....................................2.5 Kg. RTF less battery
Radio:....................................................minimum 7-Channel
Recommended battery pack…………….…5000-6S 50/60C

Required radio and battery packs
Radio equipment:
• Minimum 7-channel radio system and recei er
Recommended Li-Po battery pack for best performance:
• 5000-6S 50/60C with approx. 6 minutes flight time
arning
This RC aircraft is not a toy!
If misused, it can cause serius bodily harm and damage to property. Fly only in
open areas, preferably in official flying sites, following all instructions included
with your radio and motor.
Before starting assembly
Before starting the assebly, remo e each part from its bag and protection for a prior
inspection. Closely inspect the fuselage, wing panels, rudder, and stabilizer for
damage. If you find any damage or missing parts, contact the place of purchase.
arranty information
SebArt garantees this kit to be free from defects in both material and workmanship at
the date of purchase.
This warranty does not co er any parts damage by use or modification, and in no case
shall SebArt’s liability exceed the original cost of the purchased kit.
Further, SebArt reser e the right to change or modify this warranty without notice. In
that SebArt has no control o er the final assembly or material used for the final
assembly, no liability shall be assumed or accepted for any damage of the final user-
assembled product. By the act of using the product, the user accepts all resulting
liability.
If the buyer is not prepared to accept the liability associated with the use of this
product, the buyer is advised to return this kit immediately in new and unused
condition to the place of purchase.

Control throws
Please, follow the recommended linkage setups:
-For the FLAPS we recommend the following throws:
Normal & pattern flight: 0° (full UP)
Start: 20° down (mix elevator up 8%)
Landing: 40° down (mix elevator up 2%)
-For the AILERONS we recommend the following throws:
High rate left & right: 30°
Normal & pattern flight: D/R: 60% Expo: 20%
Start & landing: D/R: 100% Expo: 40%
-For the ELEVATOR we recommend the following throws:
High rate: 30° up & down
Normal & pattern flight: D/R: 60% Expo: 40%
Start & landing: D/R: 100% Expo: 80%
-For the RUDDER we recommend the following throws:
High rate: 30° left & right
Normal & pattern flight: D/R: 80% Expo: 60%
Start & landing: D/R: 100% Expo: 80%
Note: the Expo is (+) for JR systems, and (–) for Futaba systems.
Mixing
For best performance, we recommend a linear-mix*:
Rudder → Elevator DOWN
When you gi e full rudder to right or left side,
the ele ator ha e to go down (negati e) 5%
* if you ha e a programmable computer radio.
Recommended CG
The recommended Center of Gravity location is 180mm behind the leading
edge of the wing against the fuselage.
 175mm is good for windy conditions.
 185mm is good for normal condition.
You can use the lipo-battery pack, mo ing it forward or backward, to achie e the
correct balance.

Range test your radio
Before fly, be sure to range check your radio as manufacturer’s instruction
manual of you radio-system recommend.
Double-check all controls (aileron, flaps, ele ator, rudder and throttle) mo e in
the correct direction.
Be sure that your motor battery pack is fully charged, as per the instructions
included with your batteries and that your radio is fully charged as per its
instructions.
Check the parachute door is closed and locked before start!
.
Finally... have nice flights!
SEBART International S.r.l.
Via L. Tabellione, 1
47891 Ro ereta - Repubblica di San Marino (RSM)
www.sebart.it