Sevylor Fiji User manual

INFLATABLE CANOES & KAYAKS

READ THE FOLLOWING

INSTRUCTIONS AND WARNINGS TO AVOID

DROWNING OR SERIOUS INJURY

Including the following Model Series:

Colorado™, Big Basin™ and Fiji™.

INFLATABLE CANOES

& KAYAKS

WARNING

Failure to follow these warnings could cause SEVERE INJURY or DEATH.

●

CONSULT WITH A PHYSICIAN p

rior to beginning paddle sport training.

Paddle sports can be very dangerous and physically demanding.

●

OBTAIN PADDLESPORT TRAINING

specific to this type of craft. Do not

exceed your padding ability - be honest with yourself. Obtain certified first aid

training and carry first aid and safety/rescue equipment.

●

WEAR U.S COAST GUARD APPROVED LIFE JACKETS,

and where appropriate, wear a helmet.

●

NOT A LIFE SAVING DEVICE.

●

NEVER PADDLE ALONE.

●

CHECK WEATHER FORECAST BEFORE DEPARTING DOCK and heed all

weather advisories.

● DRESS APPROPRIATELY for the weather conditions, as cold water

and/or cold weather can cause hypothermia.

● DO NOT PADDLE IN FLOOD CONDITIONS.

● BE AWARE OF THE WATER CONDITIONS, including appropriate water

levels,tidal changes, dangerous currents and other water hazards. Do not use in

high wind, strong currents, open water or dangerous tides. Always scout

unfamiliar waters, and portage where appropriate.

● NEVER PADDLE WHILE UNDER THE INFLUENCE

of drugs or alcohol.

● KEEP PROPER LOOKOUT AND SAFE

DISTANCE from other vessels and hazards

at all times.

● OBEY APPLICABLE BOATING LAWS. Know and follow local water safety

rules and boating regulations.

● READ THE OWNER’S MANUAL and follow the manufacturer’s

recommendations for the use this product. It is the owner’s responsibility to

carefully read the manual and instruct all users in safe operation of this product.

Consult the manufacturer’s information prior to adding aftermarket equipment.

● DO NOT OVERLOAD OR OVERINFLATE. Adults should inflate the

chambers in numbered sequence.

INFLATABLE CANOES & KAYAKS

IMPORTANT INFORMATION

The warnings below relate to various situations. Please observe them.

These products are made of the highest quality materials and comply

with NMMA (National Marine Manufacturers Association) regulations.

Denotes an imminent hazard which will result in severe injury if

you do not comply with the instructions.

CAUTION!

Do not over inﬂate. Pressurize product to “Inﬂation

Pressure” stated in the chart for your speciﬁc product.

CAUTION!

These products are not meant for towing because the extreme

pressure of the water while towing can tear the eyelets

and/or handles.

WARNING!

Never use a compressor, CO2or compressed air to inate the

product. Do not let your product come into contact with sharp,

pointed objects.

WARNING!

Keep product away from gasoline, battery acid, solvents, etc.,

as they can damage the product.

CAUTION!

Altering the construction of these products could jeopardize the

safety of the occupants and will void the limited warranty.

CAUTION!

It is the owner’s responsibility to make sure all users

carefully read and follow the instructions for safe operation

of this product. Observe all local and national laws. Always

wear a Personal Flotation Device approved by the proper

authorities. Please carefully observe the Capacity Plate

information which is printed on the product.

CAUTION!

Reminds you of safety measures which must be observed. Also

denotes unsafe practices which could result in personal injury

or damage to the product or property, if you do not comply with

the instructions.

WARNING!

INFLATABLE CANOES & KAYAKS

INFLATION INSTRUCTIONS

To inﬂate using any Sevylor®Pump:

1. To begin inﬂation, open external cap and pull ﬁrmly on

the lanyard to extend out. This will open internal yellow

seal.

3. When fully inﬂated, seal valve by pushing in with

adapter nozzle. This will seal the internal yellow

stopper and keep air from escaping while closing cap.

Gently twist adapter while backing hose out of valve.

2. Attach nozzle of hose to inﬂation end of pump. Insert

adapter nozzle into valve and start pumping.

4. Fully remove pump and hose and close external cap.

Valve should appear depressed into itself.

IF FOUND - CONTACT

SI SE ENCUENTRA - COMUNICARSE CON

EN CAS DE DÉCOUVERTE – CONTACTEZ

Name/Nombre/Nom:

Phone/Teléfono/Téléphone:

Please complete the “if found label” located on the boat with the boat

owners contact information in large print with a permanent marker.

INFLATABLE CANOES & KAYAKS

IMPORTANT! Inate the product chambers in the following order:

1. Inate the oor chamber(s).

2. Inate the outside main chamber(s).

The chambers on the product will also be numbered to indicate order

of ination also. This order of ination will ensure the proper volume

and buoyancy of the safety chamber.

Note: To inate the mini Double Lock™ valve, which is used on

some of the Sevylor®product oors and seat bottoms, follow the

same ination instructions above or previous instructions, using the

mini Double Lock™ valve adapter. The mini Double Lock™ valve

adapter is included with all Sevylor®pumps. The adapter can be

purchased from Sevylor Customer Service by calling 1-800-835-

3278 US | 1-800-387-6161 CA (Part Number 5010000707).

Water temperature and weather does affect the pressure in

inatable products. In cold weather your product will lose some

pressure due to the fact the air will contract. If this occurs, you

may want to add a little air to improve your products performance.

However, in hot weather, the air will expand. You must let some air

out to prevent your product from failing due to overpressure. You

should avoid exposing your product to extreme temperatures

(hot or cold).

CAUTION!

DEFLATION INSTRUCTIONS

Deﬂation instructions using any Sevylor®Pump:

Remove nozzle of hose from inﬂation end and attach to

opposite deﬂation end of pump. Repeat same steps as

inﬂation. This will draw the air out quickly.

To inﬂate using any Sevylor®Pump for Boston Valve:

Boston Valve is a two-way valve consisting of two parts: the valve insert (center

portion) and the square cap on top. To inate through a Boston valve screw-in the

center portion (the end with longer threads) into the valve-base on the bladder and

then attach the pump nozzle to it; to deate unscrew the valve insert (center portion).

The square cap with rubber gasket makes the valve air tight once it is screwed onto

the valve insert.

Boston Valve

Center Portion

INFLATE DEFLATE

NMMA (ABYC

Standard)

Persons

Capacity

Maximum

Payload

Capacity

Inflation

Pressure

Inflation

Pressure

Model # Persons Only Persons, Gear Main Chamber(s) Floor Chamber(s)

Fiji™ Kayak 2 Pers. or

380 lbs. 400 lbs. 0.9 PSI 0.9 PSI

NMMA (ABYC

Standard)

Persons

Capacity

Maximum Pay-

load Capacity Engine Inflation

Pressure

Inflation

Pressure

Model # Persons Only

Persons, Gear,

Motor

(if applicable)

Max. HP

Engine

Main

Chamber(s)

Floor

Chamber(s)

Colorado™ 2

Person HF

2 Pers. or

440 lbs. 500 lbs.

12V Electric

Motor Sevylor

2000004144

1.5 PSI 1.5 PSI

Do not attempt to mount a motor on any boat does not state a Max. HP

engine rating.

WARNING!

NMMA (ABYC

Standard)

Persons

Capacity

Maximum

Payload

Capacity

Inflation

Pressure

Inflation

Pressure

Model # Persons Only Persons, Gear Main Chamber(s) Floor Chamber(s)

Big BasinTM 3 Person 3 Pers. or 490 lbs. 490 lbs. 1.5 PSI 1.5 PSI

INFLATABLE CANOES & KAYAKS

Your product is NMMA certied using the ABYC standard.

Do not exceed the certified maximum capacities under any circumstances!

WARNING!

Do not exceed the certified maximum capacities under any circumstances!

WARNING!

INFLATABLE CANOES & KAYAKS

CARE & STORAGE:

• These products are made of the highest quality materials and

comply with NMMA (National Marine Manufacturers Association)

regulations. Altering the construction of these products will void

the limited warranty and could jeopardize the safety of

the occupants.

• If your product has been used in salt water, rinse it off with fresh

water as soon as possible.

• Remove tar spots or other soiled areas by using a mild soap and

rinsing with fresh water.

• Be sure your product is completely dry before storing.

• The products may be stored inated, but do not place any heavy

or sharp objects on it. Storage is best in a dry room.

OPERATING INSTRUCTIONS:

• Follow all local boating regulations and navigation rules.

Familiarize yourself with boating conditions where you plan to

use the boat. Use common sense and caution when operating in

unfamiliar places.

• Observe the maximum weight the product can carry and do not

overload past this limit. Over-loading jeopardizes the safety of

the occupants.

• Be sure all accessories and/or equipment (e.g. oars, life jackets)

are in proper working condition before using the boat. Each

person occupying the boat is to wear an approved Personal

Flotation Device (life preserver).

• Sharp objects are not to be carried in the product without

adequate protection or storage.

• When navigating the product in any water depth, watch for

submerged or sharp objects that may damage or pierce the

boat’s air chambers.

• Enter the product from the port (left) or starboard (right) sides -

not from the fore (front) or aft (back) sides.

• Never tow with a boat or any other vehicle.

MOTOR MOUNTING

Do not attempt to mount a motor on any boat does not state a Max. HP

engine rating.

WARNING!

ROTATING PROPELLER MAY CAUSE SERIOUS INJURY OR DEATH

•Keep away from the rear of boat while engine is running.

WARNING!

INFLATABLE CANOES & KAYAKS

REPAIRING SMALL PUNCTURES

Inadvertent punctures can be repaired using 2 different methods

described below.

Included “Sticky Back Repair Patch” (included with select models

only)

1. Thoroughly clean and dry the damaged area. Completely deate

the product.

2. Cut a portion of the patch to cover the puncture and allow an

additional ¼” on all sides. Always cut a round patch, never leave

square corners.

3. Be sure the repair area is completely dry.

4. Peel the backing from the patch.

5. Adhere the patch to the puncture.

6. Using your thumb or nger, apply even pressure across the entire

surface of the patch.

Included Vinyl Repair Patch (included with select models only)

If your model does not include the Sticky Repair Patch noted above,

then it will come with a Vinyl Repair Patch. This vinyl repair patch

does not include vinyl glue, but it can be purchased from any home

or hardware store (PVC cement).

1. Thoroughly clean and dry the damaged area. Completely deate

the product.

2. Cut a portion of the patch to cover the puncture and allow an

additional ¼” on all sides. Always cut a round patch, never leave

square corners.

3. Be sure the repair area is completely dry.

4. Apply generous coat glue to the vinyl repair patch and to the

product.

5. Allow the glue to dry for 2 to 3 minutes, or until the glue becomes

tacky.

6. Apply the patch to the product, using your thumb or nger; apply

even pressure across the entire surface of the patch. Make

sure the edges of the patch are pressed down along the entire

diameter.

7. Allow the product to dry for at least 10 hours before inating and

using.

2 PERSON

Fiji™

Two Seats (One

Removable)

2 Spray Covers

Two Main Chambers with

Tubular I-beam Floor

Adjustable Bucket Seats with

Raised Seat Position with Mini

Double Lock Valves

Handles

Main Chamber with

Boston Valve

Main Chamber with

Boston Valve

Floor Chamber with

Mini Boston Valve

Transport

Handle

Drain

Plug

Transport

Handle

Removable

Directional Fin on

bottom (not shown)

BIG BASIN™

3 PERSON

Directional Strakes

Moulded on the bottom

(not shown)

Handles

Gear Pockets

Transport

Handle Transport

Handle

Drain Plug

Main Chamber with

Boston Valve

Floor Chamber with

Mini Boston Valve

Removable Directional Fin

on bottom (not shown)

Adjustable

Bucket Seats

Main Chamber with

Boston Valve

Directional Strakes

Moulded on the bottom

(not shown)

Trolling Motor

Mounts

Rod Holder

Paddle Clips

Rod Holder Mount

2 PERSON FH For 2P only

Colorado™

INFLATABLE CANOES & KAYAKS

PRODUCT WARRANTY:

See the 90 days and 1 year limited warranty pages for details.

• Products without a fabric covered hull have a limited 90 day

warranty. Models as follows: Fiji Kayak Series.

• Products with a fabric covered hull have a limited 1 year warranty.

Models as follows: Colorado Kayak Series & Big Basin Kayak

Series.

INFLATABLE CANOES & KAYAKS

PADDLE ASSEMBLY:

SELECT MODELS ONLY.

Join the three shafts together by screwing them together with the

two couplers. Attach the blade to the shafts by screwing onto the

end of the shaft.

GUIDELINES FOR USAGE:

These kayaks may be wider than a typical kayak, which means they

may feel more stable. However, as with any narrow, at bottom

kayak, users must be aware of the possibility of the kayak tipping

and compensate for it. Paddle with short, even and easy strokes.

Paddle close to the kayak with the paddle almost vertical. Pull with

one hand and push with the other. If the nose of the kayak is moving

right to left you are probably paddling too hard. Ease off on the

force of your stroke to reduce the swaying of the front end. Paddling

backward or breaking can sometimes offer quick maneuverability.

Blade Shaft Shaft Shaft

Coupler Coupler

Blade

90 Days Limited Warranty

The Coleman Company, Inc. (“Coleman”) warrants that for a period of 90 days from the date

of original retail purchase, this product will be free from defects in material and workmanship.

Coleman, at its option, will repair or replace, free of charge, this product or any component of the

product found to be defective during the warranty period. Replacement will be made with a new

or remanufactured product or component at no cost to the consumer. If the product is no longer

available, replacement may be made with a similar product of equal or greater value. This is your

exclusive warranty.

This warranty is valid for the original retail purchaser from the date of initial retail purchase and is

not transferable. Keep the original sales receipt. Proof of purchase is required to obtain warranty

performance. Coleman dealers, service centers, or retail stores selling Sevylor®products do not

have the right to alter, modify or in any way change the terms and conditions of this warranty.

What This Warranty Does Not Cover

This warranty does not cover normal wear of parts, parts that are not genuine Sevylor®parts, or

damage resulting from any of the following: negligent use or misuse of the product; commercial

use of the product; use contrary to the operating instructions; disassembly, repair or alteration

by anyone other than Coleman or an authorized service center. Coleman expressly excludes

from this warranty and denies liability for defects or damage caused by repair or alteration by

anyone other than Coleman. Further, the warranty does not cover Acts of God, such as fire, flood,

hurricanes and tornadoes. Warranty void if damage to product results from the use of a part other

than a genuine Sevylor®part.

No terms of this warranty may be construed to apply to non-warranty service and maintenance.

Accordingly, Coleman also denies liability for defects and damage caused by the use of

unauthorized parts, repair, service or alteration outside the terms of this warranty.

COLEMAN SHALL NOT BE LIABLE FOR DEFECTS THAT ARE CAUSED BY THE USE

OF UNAUTHORIZED PARTS OR SERVICE. COLEMAN SHALL NOT BE LIABLE FOR

ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY THE BREACH OF

ANY EXPRESS OR IMPLIED WARRANTY OR CONDITIONS. EXCEPT TO THE EXTENT

PROHIBITED BY APPLICABLE LAW, ANY IMPLIED WARRANTY OF MERCHANTABILITY

OR FITNESS FOR A PARTICULAR PURPOSE IS LIMITED IN DURATION TO THE DURATION

OF THE ABOVE WARRANTY OR CONDITIONS. SOME STATES, PROVINCES, OR

JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR

CONSEQUENTIAL DAMAGES OR LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY

LASTS, SO THE ABOVE LIMITATIONS OR EXCLUSION MAY NOT APPLY TO YOU. THIS

WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER

RIGHTS THAT VARY FROM STATE TO STATE OR PROVINCE TO PROVINCE.

How to Obtain Warranty Service

Take the product to an authorized Coleman service center. You can find the nearest authorized

Coleman service center by visiting www.coleman.com or calling 1-800-835-3278 or

TDD 1-316-832-8707 in the united States or 1-800-387-6161 in Canada. If a service center is

not conveniently located, attach to the product a tag that includes your name, address, daytime

telephone number and description of the problem. Include a copy of the original sales receipt.

Carefully package the product and send either by courier or insured mail with shipping and

insurance prepaid to:

For products purchased in the United States: For products purchased in Canada:

The Coleman Company, Inc. Newell Brands Canada ULC

3600 North Hydraulic 20B Hereford Street

Wichita, KS 67219 U.S.A. Brampton, ON L6Y 0M1

The costs of transporting the product to Coleman or an authorized service center for warranty

service is the responsibility of the purchaser.

DO NOT RETURN THIS PRODUCT TO THE PLACE OF PURCHASE.

If you have any questions regarding this warranty please call 1-800-835-3278 or

TDD 1-316-832-8707 in the United States or 1-800-387-6161 in Canada.

INFLATABLE CANOES & KAYAKS

1 Year Limited Warranty

The Coleman Company, Inc. (“Coleman”) warrants that for a period of 1 year from the date