smartCARA PCS 550 User manual

8. Smart Verbal Narration Function
!
2

Lid
3. What’s inside the box
Body
Storage Container
Power Cable
Steam Cover
Water Tray
Caution: Please empty water tray when full
Filter
Receptacle

Lid
*Warning
Contact with the hot steam
release during operation may
cause servere burns.
PUSH Button
Power Button
Display Lamp
Cleansing Button
Lock/Unlock Slide
Open Button
Filter Cover
Steam Vent
Front View Back View
Push Button
Bottom Cover
Drain Hose & Power Cable

4. How to use
Please keep all surfaces at least 30cm away from the steam vent at the rear side of the product.
Install the filter according to these instructions before first use.
Connecting the power cord.
1. Open the Filter Cover using the PUSH Button on the rear of the product
2. Remove the packing material then take out the plastic-wrapped filter.
3. Remove the plastic-wrap then place the filter back to its original position.
4. Slide the Filter Cap on top of the filter until it clicks so the filter is tightly fixed. **Very important**
5. Close the Filter Cover then hook the Steam Cover below the steam vent as shown in the picture below.
1. Open the bottom cover using the PUSH Button on the rear of the product.
2. Connect the power cable.
3. Adjust the rubber packing on the cable until it fits with the bottom cover as shown in the picture below.
4. Close the bottom cover by using the PUSH Button.
How to use the product
1. Plug-in the power cord.
2. Slide up to unlock the Lid.
3. Push the Open Button.
4. Lift up the receptacle and remove the sticker from the bottom before first use.
5. Fill the receptacle with food waste up to the recommended fill line.
6. Match the triangular arrow of the receptacle to that of the product to ensure proper closure of the Lid.
(If the Lid does not close after this step, press the Power Button while the Lid is opened, and the
receptacle will automatically adjust itself to fit.)
7. After closing the Lid, slide down to lock then press the Power Button to start operation.
8.The product will announce "Food waste disposal complete" when operation is complete.
The Cooling Lamp will light up when operation is complete. Cleansing complete" when operation is com-
pleted. *If the product is on mute, it will not narrate itself.
Contact with the hot steam released during operation may cause severe burns
1. When the product is unlocked, the Power Button and the Cleansing Button will not operate.
2. If you add more food waste in the middle of operation, the Power Button must be pressed again to
continue operation. (Simply closing and locking the Lid without pressing the Power Button will only
put the product into Storage Mode.)
Warning
!
!
!
Caution

1. Open the Filter Cover using the PUSH Button on the rear of the product.
2. Pull out the Filter Cap.
3. Take out the filter using two hands.
4. Remove the plastic wrap of the new filter then place it in the device.
5. Slide the Filter Cap on top of the filter until it clicks so the filter is tightly fixed. **Very important**
6. Close the Filter Cover then hook the Steam Cover bleow the steam vent as shown in the picture below.
1. Fill water half way up to the receptacle.
2. Close the Lid, lock the slide, press the Cleansing Button to start the process.
3. Cleansing will continue for 60 minutes. The product will narrate itself "Receptacle cleansing complete"
when operation is completed. *If the product is on mute, it will not narrate itself.
1. Food wastes can be stored in the receptacle. While being stored, the volume will slowly decrease
without causing bad odor.
2. Depending on the food type and weather, it can be stored up to 6 days.
3. Storage function will run only if the product is properly connected to power and if the Lid slide is
locked.
4. Power Button's lamp will be on lightly to show that the product is on Storage Mode.
Changing the filter
!
Using the Cleansing function
Cleansing is recommended once every other week.
Smart CARA's receptacles do not have to be cleaned after every operation since it uses very high
heat which will automatically eliminate bacteria. If inappropriate firm object are stuck in the recep-
tacle, the cleansing function will help clean the receptacle more easily.
!
About the Storage funcion
What is the power consumption of the product?
Approximately 2.0kwh of power is consumed per 4 liters of food waste.
(Actual consumption may vary depending on the country)
!

• Avoid processing food waste that is mostly composed of carbohydrates and/ or food with a high
sugar content. Processing mixed food waste from a variety of sources is recommended.
• Do not open the Lid while the device is operating. The high temperatures achieved during opera-
tion may cause severe burns.
• Food waste only : Hard waste such as metal, glass, or firm bone may cause premature breakdown
of the product (fish, chicken bones are okay).
• Device is made to be used indoors.
- Device shall self-diagnose its condition
- Narrates its operating status and the type of errors
Power lamp will light-out automatically 15 seconds after when the
power is connected for the first time or when forced shutdown
while operating, or cleansing is completed.
Precaution
Firm bones such as cow/pig bones
Self-diagnosis function
Power saving function
Error signal can be reset by holding down the Power button for 5
seconds while the Lid is closed and locked.
Error reset function
This helps to preserve and naturally dry the food waste without
having it to operate so the user can keep adding food wastes
until it is filled up to the indicated line in the receptacle. (Maxi-
mum of 6 days of storage is recommended)
Storage function
Alcohol

• Make sure the rubber seal where the filter is placed is not missing.
• If the filter can be moved while in position or if the Filter Cover does notclose, the
filter is not installed properly. Please refer to the filter instructions for proper
installation. (Page 05)
- If the filter is not properly installed, the food waste odor can leak.
• When operated twice a week, filter must be replaced every 3 months.
- Odors and errors may occur if the filter is overused.
• Must use original filters made by Smart CARA.
• As shown below, the Filter Cap must be installed correctly on top of the filter. If
not, the steam may be trapped inside the devive and cause a damage.
For Reference

Drying status
Cooling status
1.This error is caused when too much
food waste/high carbohydrates/high
sugar content was processed.
2. Empty the receptacle, then unplug
the power. Replug the power after 10
seconds.
1. This error is caused when firm waste
is detected inside the receptacle.
2. Empty the receptacle, then unplug
the power. Replug the power after 10
seconds.
1. This error is caused when too much
water has collected at the bottom of
the product.
2. Open the bottom cover where the
power cord is connected. Place a small
tray under the hose then turn the blue
knob to empty the collected water.
Close the knob and reset the product
by unplugging the power cord. After 10
seconds, plug it back in to continue
using the product.
3. Refer to Page 9 for more details.
Error 1 Motor overload
When an error is detected,
pressing the Power Button will
make the product narrate the
applicable error number.
Cleansing status
Self-diagnosis
Error display and troubleshoot
Grinding status
Error 8 Other substances detected
Error 12 Water sensor error

1. This error is caused when the filter is
overused or when steam is not venti-
lating properly.
2. Please replace the filter, then reset
the product by unplugging the power
crod then plugging it back in after 10
seconds.
1. These errors are detected when the
product self-diagnosesduring opera-
tion. Unplug the power cord, then plug
it back in after 10 seconds. Try running
the product again. If the same error is
detected, please contact your retailer's
customer service center.
1. Disconnect the power cord. (Remove power)
2. Open the Bottom Cover using the PUSH button on the rear of the product.
3. Gently grab the Drain Hose and prepare a small n on plate the to rear
collect of the the water. product.
4. Turn the blue valve to remove collected water.
- Make sure to close the Drain Hose before putting the Bottom Cover back.
Water may leak out when it is not closed properly.
5. Turn the blue valve back to its original position to close the Drain Hose.
Close the Bottom Cover by using the PUSH Button . Reconnect the power
then try operating it again.
Display and troubleshoot
Water sensor error
Error 5 Operation Error
When an error is detected, pressing the Power Button will make the
product narrate the applicable error number.
Follow the instructions below to remove water from the Drain Hose.
Error 2, 3, 4, 6, 7, 9, 10, 11
Operation Error

What is the power consumption of the product?
Approximately 2.0kwh of power is consumed per4 liters of food waste.
(Actual consumption may vary depending on the country)
Can I mute the audio guide system? I Can I turn on the audio guide system?
Hold on to the Cleansing Button for 10 seconds to turn on/off the audio
guide.
Do I have to keep the product connected to power at all times?
To use the Storage function, the product must always be connected to power.
Monthly electrical consumption when connected is approximately 2kw.
How much food waste can be processed every time?
It can process up to 4 liters at a time as indicated on the receptacle.
Can it process chicken bones?
Yes. However, please note that processing chicken bones too often may
shorten the lifespan of the receptacle.
How long is the processing time?
It takes as little as 3 hours and up to 7 hours depending on the type and
volume of food waste.
Is there a recommended area to place the device?
Please keep all surfaces at least 30cm (12in) away from the steam vent at the
rear side of the product . As shown in the image below, attach the Steam
Cover so the steam would go upwards and evaporate.
5. FAQ

Product Name
Model Name
Processing Method
Installation Method
Power
Power Consumption
Operation Capacity
Reducation Rate
Weight
Size(mm)
Manufactured by
Smartcara Innovation
PCS-500D
Dry & Grind
Stand-Alone type
220V/50H
1.0kw
Approx.4 liters
Approx.81%
20kg
340(W) x 372 (D) x 727 (H)
Smart Cara.Co, Ltd
Made in South Korea
PCS-500D Specification

The content below is to help prevent any injuries and/or damage
to the product please read throughly before using the product.
User may get a serious injury from mishandling.
User may get a wound from mishandling.
User may get a wound or a damage on the product from mishandling.
1. Food wastes shall rot and cause bad odor if power is not connected to the
product.
2. Recommended capacity line is shown inside the receptacle.
3. An overflow of food waste may cause a breakdown.
4. When one cycle does not completely dry the food waste, please run the
product one more time.
5. Steam exiting the back of the product is hot, so please be cautious.
6. If the lid is opened or unlocked, the product will beep every hour.
Safety precautions are classified into three symbols: Danger, Warning, and Caution
Please ensure these safety instructions are made available to all product users.
Additional notes
5. FAQ

Electric shock, fire hazard
Do not use when the power cord is damaged.
6. Safety Instructions
Electric shock, fire hazard
Do not pull out the power cord by force.
Electric shock, fire hazard
Do not touch the power cord with a wet hand. Use a dry cloth to
remove any substances on the cord.
Electric shock, fire hazard
Inappropriate way of using a multi-tab power strip may cause an
electric shock or fire.
Fire hazard
Keep the product away from any type of heating apparatuses
Please use a grounded outlet and check the power voltage before
use.
Fire hazard
Do not run the product with any hot water or oil.
Product deformed and broken
Do not run the product with any living organism, non-food wastes.
Electric shock, fire hazard
Place the product on a flat surface to prevent the product from
falling over.
Fire hazard
Keep the product away from direct sunlight.
Power-related
General Cautions