Sony TA-N220 User manual

SERVICE MANUAL
TA-N220
AEP Model
UK Model
E Model
SPECIFICATIONS
Audio power specifications
POWER OUTPUT AND TOTAL HARMONIC
DISTORTION:
With 6 ohm loads, both channels driven,
from 20 - 20,000 Hz; rated 50 watts per
channel minimum RMS power, with no
more than 0.12 % total harmonic
distortion from 250 milliwatts to rated
output
Other specifications
Continuous RMS power output (both channels driven simultaneously)
Model for Scandinavian countries
Normal: 30 W x 4 (6 ohms, 0.12 %, 20 Hz - 20 kHz)
40 W x 4 (6 ohms, DIN)
BTL: 75 W x 2(8 ohms, 0.12 %, 20 Hz - 20 kHz)
95 W x 2 (8 ohms, DIN)
Models for other countries
Normal: 50 W x 4 (6 ohms, 0.12 %, 20 Hz - 20 kHz)
60 W x 4 (6 ohms, DIN)
BTL: 100 W x 2(8 ohms, 0.12 %, 20 Hz - 20 kHz)
130 W x 2 (8 ohms, DIN)
Power bandwidth (IHF)
12 Hz - 40 kHz (6 ohms, THD 0.5 %)
Frequency response 7Hz-100kHz “°dB
Input sensitivity 370 mV (50 kohms)
Signal-to-noise ratio 90 dB (input shorted)
Speaker output Normal: 6 - 16 ohms
BTL: 8-16 ohms
General
System Complementary Darlington SEPP power amplifier with
ail stages direct coupled ;
Power requirements
U.K. model:
240 V AC, 50/60 Hz
European model:
220/230 V AC, 50/60 Hz
Models for other countries:
120, 220, or 240 V AC adjustable, 50/60 Hz
Power consumption
140 W
U.K. model:
Approx. 430 x 135 x 370mm (w/h/d)
(17 x 5% x 14% inches)
Models for other countries
Approx. 470 x 135 x 370 mm (w/h/d)
(185% x 5% x 14% inches)
including projecting parts and controls
Weight U.K. model:
Approx. 9.5 kg (15 Ib 10 oz), net
Models for other countries
Approx. 10 kg (22 Ib 7 02), net
Supplied accessory Screws (4) (except for U.K. model)
Dimensions
Design and specifications are subject to change without naice.
Note
This appliance conforms with EEC Directive 87/308/EEC regarding
interference suppression.
STEREO POWER AMPLBFIER
meets
MICROFILM
SONY.

TA-N220
MODEL IDENTIFICATION
—Mode! Number Label —
SONY. MODEL NO. TA-N220
STEREO POWER AMPLIFIER
OOO20)
SERIAL NO.
MADE IN JAPAN
AE1, AE2, Germany Models: AC: 220V —230V ~ 50/60Hz
UK Model: AC: 240V ~ 50/60Hz
E Model: AC: 120/220/240V ~ 50/60Hz
AE2 Model only
SECTION 1
GENERAL
This section is extracted from
instruction manual.
1-1. LOCATION AND FUNCTION OF CONTROLS
POWER switch OPERATION indicators
Lights up to indicate the number of channels to he
[2] NORMAL/BTL switches used.
When the NORMAL/BTL switches are set to the
Selects the amplifier operation according to the input NORMAL positions, the AMP 1, 2, 3 and 4 indicaiors
and speaker connections.
AMP 4, 2 light up.
NORMAL: When the SPEAKER 1 and/or 2. terminals Wen he NORMALE Lowite sete oallo ne ETS
and the INPUT 1 and/or 2 jacks are used. positions, the BTL indicators light up.
BTL: When the SPEAKER BTL A terminal and
the INPUT A jack are used. INPUT LEVEL controls
AMP 3, 4 AMP 1, 2: Adjusts the input signal connected to he
NORMAL: When the SPEAKER 3 and/or 4 terminals INPUT 1 and 2 jacks.
and the INPUT 3 and/or 4 jacks are used. AMP 3, 4: Adjusts the input signal connected to he
BTL: When the SPEAKER BTL B terminal and INPUT 3 and 4 jacks.
the INPUT B jack are used.
* See the “Hooking up a system” section for the system
setup and the settings of these switches.

SECTION 2
DIAGRAMS
2-1. BLOCK DIAGRAM
RVIOI-1
IC1Ol (1/2)
POWER AMP
INPUT} Jl0l-2
ICl01 (2/2)
RvioN-2 POWER AMP
0505
RY503
0515
RV301-1
INPUT
LEVI
IC3OI( 1/2)
POWER AMP
Qlor
OVER CURRENT
DET
CNIOL (1/2)
&
&)
$502
AMP 3,4
BTL
NORMAL
Q502
REG
t 0504
o
a
=
Q301
OVER CURRENT
DET
JIOI-4
i]
IC301 (2/2)
RV30I-2 POWER AMP
INPUT
LEVEL
0502
CNIO1(2/2)
SPEAKER
O
ca
0507
=
I
AB 0503 0501 |
LED SWITCH i
|
$501
AMP |, 2
BTL
t
NORMAL
PTI
POWER
F501. 16.38 TRANSFORMER |
OND |
|
r
F502 T6.3A
I
F503 T6.3A |
2
I
I
|
|
F504 76.34
I
|
oS
aoe
D509 0510
EXCEPT E
VOLTAGE
SELECTOR
\20V -240V -220V
CNPI

VOLTAGE
SELECTOR
120V —240V -220V
05i4
$502 art)
1C50 = ‘di
050!
PROTECTION
a ee be | p52 S83
RYS5OI
o— AMP3] [AMP4
C4 Ga
: > OOH
i
-| i \
oto | oO
| DSI
host
CNIOL(1/2)
BTL]
=
[SPEAKER]
es
Oy.
4
A “a an
= \ (>) )
0503 : l 0509 D510
—— LED SWITCH =
a !
$501
BTL
'
H NORMAL
I
|
I
|
Se
EXCEPT E
- 0502 : SI FL T3ISA
PT! | o- S\_9-
POWER
aS Fal !
:
-1 3 SSS SSS
D507 q 8
CNIO1(2/2) F502 76.38 1 9
a | F2
F503 6.
SPEAKER ee |
a |
|
|
cs
F504 16.30
I
| |
My a Ns ee ee d
E model
2-2. CIRCUIT BOARDS LOCATION
RELAY BOARD
AC SW BOARD
SW BOARD
LED BOARD
2-3. SEMICONDUCTOR LEAD LAYOUTS
uPC1237HA 2SA988-PAFAEA
12345678 I
STK-4182MK2 2SC2603-E F
as
2SD774-34
EC 8
VOL BOARD
11ES2 SEL2510C-D
HZS27-2L SEL2810A
cathode
; tong short
anode enéde cathode
RBV-602-01
+
e
e
iil
181585
cathode
anode
er
TA-N220
VS BOARD (E model)
MAIN BOARD

TA-N220
® Semiconductor
Location
2-4. PRINTED WIRING BOARDS
@ See page 5 for Semiconductor Lead Layouts.
1
3
14 | 5
Location
E model
{VOL BOARD]
; a
{VS BOARD]
VOLTAGE SELECTOR
(20V=— 240V— 220V
ee
: .
Note:
CNP
AC IN
TI
POWER TRANSFORMER
[MAIN BOARD]
@ o——: parts extracted from the component side.
e Abbreviation
G: Germany model
ce
_
oo
one
EXCEPT E FI
C5
a
s
\
te
y
:
i
& se eta
ee ee
I
e/he
{ eS :
i
:
|
&
[LED BOARD)
RSIS
C R50:
+
515
R
1
404
C¥o7°
N50!
05

Bie Ot ke eee OO AO it A a ee 15 16 17 e | 90 | o | a |
[LED BOARD]
(SW BOARD]
;
i-64/-089-J [11] ~ 1-641-088- J [I1]
{MAIN BOARD]
oammenecconenna a
_ssorsmanRe
oO a
"sentence
nr oO
“yt
a
13
AE2 , G model
!
|
Tl
POWER TRANSFORMER
CNIOI
SPEAKER
IMPEDANCE USE 6-162
BTL USE 8-162
fe) fe) fe) fe) fe) 9
gol ee
| |E model A
L—|-4
—-*
i
$3
_ grins
od
"ons onsnneaemisi neonate
“oasasrsmmannsgsa teres
EXCEPT E FI
2 peepee e

2-5. SCHEMATIC DIAGRAM
1
[MAIN BOARD]
A |
J10l-1
i
a
cil4
G model |
INPUT
J101-3
ep)
ae
©)
314
SOp
G model
G model
ee
38
1C101 wy
over UGAREMT per
3&2 | Ref. No EXCEPT AE2| AE2
POWER AMP ae tht
0 (12) At.
+40) ow
oO
8
ZT IC101 (172)
=z
ar @ (15) (6)
St] La-Vo.g a] |g
8 ers es ri
3
L101
Qio1 25a988 -~* -1
$505
1$1585
12 13
ae Gee
RYSO3 UST090M
>t
a £516
US1090M
ial
R102 5Sé&k
WwW
C104 47 SOV
=
une. Ww
ver F
2 iS ™
ee NO SN:
Sos
xs)
i if
uw
—- Dot
ao Neo=
= @
C204 47 SOV
T dt
1
cl
0
ANY
RI16 SK
2 +
Te" \/2w!
+—
at
yee Sad:
We G model
+
oo: <3
~ R
10
Cil2
0.01 t
cit
R202 Sék
Ww
C203 270p
[eene | eceete [6 |
CIOr. 207. 301. 401 4.7/50V
g
PROTECTOR
ae
hate
b
S01
Q301, 401
OVER CURRENT SET
3+
C311 100 SOV
7 _ as =
R3I7
Loreto 8.2
| POWER AMP {eH
H Rats 41.6
i 41. 01
yD) © oO | 25a988
Fa
|
“A
are 0 1C301 (1/2) 1
4
| 1k wl (17) @) (7) (8)
| st (5)
| a (3) (4) ~4)
| R304 nd
KI < Fa 56k Ra
c3ol| 8 RA
bee TT (eel ee
| 37 C305 172 50v
ie R497 R508
czoze | VL
C302 se caa7 1720 \72W
% | R305
B | R305 | 5
R405
aye oc
6c402 Ml egos %
—y %100p+L ST Sp
lay
~~ ~
H]o ew
Tats
je
8
at
R401 é
Tk
aT
ab
toe ess
33] Ref.No EXCEPT AE2 AE2
R506-509 360 |/2W 220 |/2W
504
F50I~504
T6.3A 250V
CNt03 ies
$501
AMP 1, 2
NORMAL > BTL
{VS BOARD]
(20V<- 240V 220V
[AC SW BOARD)
2-6. IC BLOCK DIAGRAM
1C501 uPC1237HA
OVER LOAO OET
| orFseT o€T | OET
LATCH /
AUTORESET
AC
DET
C2) @) ©
Note:
e All capacitors are in uF unless otherwise
50WV or less are not indicated except
and tantalums.
@ All resistors are in 2 and 1/,W or less
specified.
e edt : nonflammable resistor.
e fw: fusible resistor.
e [Bt] : B+ line.
e [B=] : B- line.
e@ Voltages are taken with a VOM. (Input i
Voltage variations may be noted due to
tion tolerances.
@ Signal path.
=> : SOUND
tine with mark are critical for saf¢
Note: The nth mark fae rit by mark
Replace only with part number speci
e Abbreviation
G: Germany model

SPEAKER
CNIO1 (7/2)
1C101 (2/2)
9
3 Lg AT RYSor
| |
=
{=
12 13 14 15
9517
US1090M
3
Lt
5 L201
fa 1.9u
excepetG | 6 |
T10/100V
:
Q301, 401
OVER CURRENT BET
L301
+
Q501
28C2458
LEB SWITCH
O11
<-4
alan
“312 0.01
é
C311 100 SOV
G model
r
‘ t
|
Ui senstoh ans ata oh
[SPEAKER
CNIO1t (2/72)
|
g
|
313
0.0) Smodel
1
5
H Hi
sd:
{
410
06
Rai 47k
a
6tBw
¢
G model cals vil
=a
©
|
|
fe
9-9-0" O-— aa
1C301 (2/2)
3K 3] Ref. No EXCEPT AE2 AE2
R506-509 360 |/2W 220 |/2W
4
F50i~504
T6.3A 250V
AMP 1, 2
. NORMAL > BTL
EXCEPT E
[VS BOARD]
| $2
VOLTAGE
SELECTOR
120V<-240V —220V
E model
2-6. IC BLOCK DIAGRAM
1C501 uPC1237HA
LATCH /
AUTORESET
AC OFF
DET
(4) G)
Note:
e All capacitors are in uF unless otherwise noted. pF: wuF
SOWV or less are not indicated except for electrolytics
and tantalums.
e@ All resistors are in Q and 1/,W or less unless otherwise
specified.
oe #4 : nonflammable resistor.
e {1} : fusible resistor.
e [B+] : Bt line.
e [B=] : B- line.
e@ Voltages are taken with a VOM. (Input impedance 10MQ)
Voltage variations may be noted due to normal produc-
tion tolerances.
e Signal path.
> :SOUND
tine with mark are critical for safety.
Replace only with part number specified.
Note: The nth mark fae ert by mark A or dotted
e Abbreviation
G: Germany model
TA-N220

TA-N220
SECTION
3
AC
SW
|
[LED
|
|
MAIN
|
EXPLODED
VIEW
Ref.No.
Part
No.
Description
Remark
1
4-946-624-01
PANEL,
FRONT
2
4-942-568-01
EMBLEM
(NO.5),
SONY
SECTION
4
NOTE:
3
4-926-852-01
ESCUTCHBON,
POWER
ELECTRICAL
PARTS
LI
@
-XX,-X
mean
standardized
parts,
so
they
@
Items
marked”
*”
are
not
stocked
since
The
components
identified
by
mark
4
3-354-912-01
KNOB, POWER
may
have
some
difference
from
the
orig- they
are
seldom
required
for
routine
ser-
A
or
dotted
line
with
mark
5
4-946-617-01
ESCUTCHEON
(L),
SIDE
inal
one.
vice.
Some
delay
should
be
anticipated
are
critical
for
safety.
NOTE:
_
oer
©
Color
indication
of
Appearance
Parts.
when
ordering
these
items.
Replace
only
with
part
number
6
4-946-618-01
ESCUTCHEON
(R),
SIDE
®
Due
to
standardization,
replacements
in
the
®
Items
marked”
*
are
not
stocked
sin
Example:
©
The
mechanical
parts
with
no
reference
specified:
q
3-533-938-00
CLOTH
parts
a
may
be
Gifferent
from
the
part
they
are
seldom
required for
routine
se!
KNOB,BALANCE
(WHITE)
..
.
(RED)
number
in
the
exploded
views
are
not
8
4~945-173-01
KNOB
(R21)
specified
in
the
diagrams
or
the
compo-
vice.
Some
delay
should
be
anticipat
t
t
supplied.
e@
Abbreviation
9
X-4941-829-1
ESCUTCHEON
(LED)
ASSY
nents
used
on
the
set.
when
ordering
these
items.
Parts
Cabinet's
©
Hardware
(
# mark)
list
is
given
in
the
last
G:
Germany
model
10
4-938-518-01
INDICATOR
(C)
®
-XX,-X
mean
standardized
parts,
so
they
@
SEMICONDUCTORS
Color
Color
may
have
some
difference
from
the
orig-
In
each
case,u:
w
for
example
:
of this parts list.
inal one. uA...: WA..., uPA...: WPA...
11 4-916-745-01 KNOB (DIA. 21) ee as ae ae os
uPB...: “PB..., uPC...: “PC...,
* 13 1-641-089-11 SW BOARD
x14 1-641-087-11 VOL BOARD All resistors are in ohms uPD...: “PD...
METAL: Metal-film resistor @ CAPACITORS
METAL OXIDE : Metal Oxide-film re- uF: uF
15 3-721-342-11 SCREW, SIDE WOOD (EXCEPT UK)
15 3-704-366-01 SCREW (CASE) (M3X8) (UK) sistor ¢ COILS
16 X-4941-830-1 PANEL (L) ASSY, SIDE (AEI, AE2, E) F : nonflammable uH: “wH
Emodel _ 16 X-4941-836-1 PANEL (L) ASSY, SIDE (G)
3-1. GENERAL SECTION 4 29 i
SP 17 4-924-920-71 CASE (EXCEPT AE2) Ref.No. Part No. Description Remark Ref.No. Part No.
1 ~~ | 17 4-941-354-01 CASE (AE2) x 1-641-090-11 AC SW BOARD x
(cna
18
X-4941-831-1
PANEL
(R)
ASSY,
SIDE
(AE1,
AE2,
E)
SOEREEE
b--~—-—-~— 4 18 X-4941-837-1 PANEL (R) ASSY, SIDE (G)
eas
model
1-533-225~11
HOLDER,
FUSE
(EXCEPT
E)
not supplied { 19 4-943-148-42 FOOT (F58175S¥) C101 = 1-124-
} 20 1-533-225-11 HOLDER, FUSE < CAPACITOR > C101 = 1-12
| ; * 21 1-641-090-11 AC S¥ BOARD C102 = 1-110-
* 22 1-641-094-11 RELAY BOARD aN Cl 1-161~744-00 CERAMIC 0. OluF 400V
C103 —-1-110-
* 23 A-4345-674-A MAIN BOARD, COMPLETE (AE1, UK, E) < CONNECTOR > C104 = 1-124
* 23 A-4345-675-A MAIN BOARD, COMPLETE (G) C105—s 1-16
* 23 A-4345-795-A MAIN BOARD, COMPLETE (AE2) * CN1 1-564-321-00 PIN, CONNECTOR 2P C106 = 1-13
24 4-928-635-11 SCREW, +BV (2. 6X16) TAPPING CNS 1-568-106-11 PIN, CONNECTOR 4P (E) Cl107~—s- 1-126-"
CN6 1-564-321-00 PIN, CONNECTOR 2P
* 25 3-703-244-00 BUSHING (2104), CORD (EXCEPT E) pettststtsteresssttstssssststctsts ites e ees rst esti sess e Sele sy C108
* 25 3-703-571-11 BUSHING (S) (4516), CORD (E) C109
* 26 4~946-623-01 PANEL, BACK (EXCEPT E) * 1~641-088~11 LED BOARD C110
* 26 4-946-623-11 PANEL, BACK (E) HHEEKEREE Clll
* 27 4-942-204-01 PLATE, GROUND C112
lnot ok < DIODE >
supplied “s.35 26 * 28 1-641-088-11 LED BOARD C113. -1-136-
hv 29 1-569-007-11 ADAPTER, CONVERSION 2P (E) D509 8-719-303-02 LED SEL2510C-D (AMP1) C1l4—s1-16
30 3-701-947-16 LABEL (T3.15A), FUSE (EXCEPT E) D510 8-719-303-02 LED SEL2510C-D (AMP2) C115
31 3-701-947-19 LABEL (T6. 3A), FUSE D511 8-719-301-49 LED SEL2810A (BTL) C201 =
* 35 1-641-092-11 VS BOARD (E) D512 8-719-303-02 LED SEL2510C-D (AMP3) C201
D513 = 8-719-303-02 LED SEL2510C-D (AMP4)
A\: CNP1 1-575-651-11 CORD, POWER (AE1, AE2, G) C202 -
/\* CNP1 — 1-575-652-11 CORD, POWER (UK) D514 8-719-301-49 LED SEL2810A (BTL) C203) 1-11
/\s CNP] 1-575-653-11 CORD, POWER (E) C204 =
< RESISTOR > C205 —sI-1
fs Fl 1-532-237-00 FUSE, TIME-LAG (BET) (3.15A) (EXCEPT E) C208 = I-
not supplied e F2 1-532-237-00 FUSE, TIME-LAG (BET) (3.15A) (E) R516 =1-247-754-11 CARBON 1.5K 5% 1/24
Av F3 1-532-237-00 FUSE, TIME~LAG (BET) (3.15A) (E) R517. =: 1-247-755-11 CARBON 1.8K 5% 1/2¥ C210 = 1-1
5 ; © F501 1-532-325-00 FUSE, TIME-LAG (6. 3A) R518 =1-247-754~11 CARBON 1.5K 5% 1/24 C212. 1-13
mpelieg e F502 1-532-325-00 FUSE, TIME-LAG (6. 3A) R519 =1-247-755~11 CARBON 1.8K 5% 1/24 C213 -136-
with. « F503 1-532-325-00 FUSE, TIME-LAG (6. 3A) petstteseteeterstestietrertescestitessitestetetssre reese sis ss C214. —-1-164-0
a F504 =1-532-325-00 FUSE, TIME-LAG (6. 3A) C215 -1-136-
* A-4345-674-A MAIN BOARD, COMPLETE(AE1, UK, E)
ie Sl 1-554-920-31 SWITCH, PUSH (AC POWER) (1 KEY) Postsetetstetetetsiesssstes ts] C301
Ay Tl 1-450-698-11 TRANSFORMER, POWER (AE1, G) k A-4345-675-A MAIN BOARD, COMPLETE (G) C301
y Tl 1-450-699-11 TRANSFORMER, POWER (UK) petseesteseetsertsesse s%
y Tl 1-450-700-11 TRANSFORMER, POWER (E) x A-4345-795-A MAIN BOARD, COMPLETE (AE2)
Ay Tl 1-450-701-11 TRANSFORMER, POWER (AE2) HARARE AKERAK AE ERAKERER AK
=\2—= == —14—

SECTION 3
KPLODED VIEW
TT
"Ac
SW]
[LED]
[MAIN
Ref.No. Part _No. Description Remark
1 4-946-624-01 PANEL, FRONT
2 4-942-568-01 EMBLEM (NO.5), SONY SECTION 4
3 4-926~852-01 ESCUTCHEON, POWER ELECTRICAL PARTS LIST
Items marked” *” are not stocked since The components identified by mark 4 3-354-912-01 KNOB, POWER
they
are
seldom
required
for
routine
ser-
A
or
dotted
line
with
wane
5
4-946-617-01
ESCUTCHEON
(L),
SIDE
vice. Some delay should be anticipated are critical for safety. NOTE: a : ae ; _——~
when
ordering
these
items.
Replace
only
with
part
number
6
4~946-618-01
ESCUTCHEON
(R),
SIDE
®
Due
to
standardization,
replacements
in
the
@
Items
marked
”
*
are
not
stocked
since
When
ungieaung
parts
by
reference
The mechanical parts with no reference specified. 7 3-533-938-00 CLOTH parts es may be different from the part they are seldom required for routine ser- number, please include the board
number
in
the
exploded
views
are
not
8
4-945-173-01
KNOB
(R21)
specified
in
the
diagrams
or
the
compo-
vice.
Some
delay
should
be
anticipated
name.
supplied. e@ Abbreviation 9 X-4941-829-1 ESCUTCHEON (LED) ASSY nents used on the set. when ordering these items.
Hardware (# mark) list is given in the last G: Germany model 10 4-938-518-01 INDICATOR (C) @ -XX,-X mean standardized parts, so they @ SEMICONDUCTORS The components identified by mark
af
this
vars
list
may
have
some
difference
from
the
orig-
In
each
case,u:
yg
,for
example
:
A
or
dotted
line
with
mark
ll 4-916-745-01 KNOB (DIA. 21) inal one. UA...: WA... UPA... UPA..., are critical for safety.
#13 1-641-089-11 SW BOARD © RESISTORS uPB...: “PB... UPC... : UPC..., Replace only with part number
x14 1-641-087-11 VOL BOARD All resistors are in ohms uPD...: “PD... specified.
METAL: Metal-film resistor @ CAPACITORS
15 3-721-342-11 SCREW, SIDE WOOD (EXCEPT UK) METAL OXIDE : Metal Oxide-film re- uF: uF @ Abbreviation
15 3-704-366-01 SCREW (CASE) (M3X8) (UK) sistor ¢ COILS By Germaby migdsl
16 X-4941-830-1 PANEL (L) ASSY, SIDE (AE1, AE2, E) F : nonflammable uH : “#H
mor moe 16 X-4941-836-1 PANEL (L) ASSY, SIDE (G)
1 29 t
SP 417 4-924-920-71 CASE (EXCEPT AE2) Ref.No. Part_No. Description Remark Ref.No. Part No. Description Remark
1 (SX [ 17 4-941-354-01 CASE (AE2) x 1-641-090-11 AC SW BOARD * 4-942-204-01 PLATE, GROUND
\4
S
ae
18
X-4941-831-1
PANEL
(R)
ASSY,
SIDE
(AE1,
AE2,
E)
Peete
tseted
fF--—-—-- 4 18 X-4941-837-1 PANEL (R) ASSY, SIDE (G) < CAPACITOR >
Remodel. § 1-533-225-11 HOLDER, FUSE (EXCEPT 2)
not
supplied
| {
19
4-943-148-42
FOOT
(F58175S¥)
C101
=:
1-124-667-11
ELECT
10uF
20%
100V
(EXCEPT
G)
20 1-533-225-11 HOLDER, FUSE < CAPACITOR > C101 = 1-123-369-00 ELECT 4, TuF 20% 50V (G)
S : * 21 1-641-090-11 AC SW BOARD C102 =: 1-110-335-11 MYLAR 100PF 5% 50V
t * 22 1-641-094-11 RELAY BOARD & C1 1-161-744~-00 CERAMIC 0. OluF 400V
C103. 1-110-340-11 MYLAR 270PF 5% 50V
| * 23 A-4345-674-A MAIN BOARD, COMPLETE (AE1, UK, E) < CONNECTOR > C104. 1-124-910~-11 ELECT 4TuF 20% 50V
* 23 A~4345-675-A MAIN BOARD, COMPLETE (G) C105 1-164-041-11 CERAMIC 5PF 0. 25PF50V
* 23 A-4345-795-A MAIN BOARD, COMPLETE (AE2) * CN1 1-564-321-00 PIN, CONNECTOR 2P C106 =: 1-136~-163-00 FILM 0.068uF 5% 50V
24 4-928-635-11 SCREW, +BV (2. 6X16) TAPPING CN5 1-568-106-11 PIN, CONNECTOR 4P (E) C107. =: 1-126-052-11 ELECT 100uF 20% SOV
CNG 1-564-321-00 PIN, CONNECTOR 2P
* 25 3-703-244-00 BUSHING (2104), CORD (EXCEPT E) bestetstteitei¢ctecsscsstecsttersist tities testes tests ess so C108 =. 1-124-910-11 ELECT 47uF 20% 50V
* 25 3-703-571-11 BUSHING (S) (4516), CORD (E) C109 =: 1-126-618-11 ELECT 33uF 20% 50V
* 26 4-946-623-01 PANEL, BACK (EXCEPT E) * 1~641-088-11 LED BOARD C110 =: 1-136-163-00 FILM 0.068uF 5% 50V
* 26 4~946-623-11 PANEL, BACK (E) KAKEKEKEK C111. =: 1-126-052-11 ELECT 100uF 20% 50V
* 27 4-942-204-01 PLATE, GROUND C112): 1-136-153-00 FILM 0. OluF 5% 50V (G)
< DIODE >
* 28 1-641-088-11 LED BOARD C113). 1-136-153-00 FILM 0. OluF 5% 5OV (G)
Ay 29 1-569-007-11 ADAPTER, CONVERSION 2P (E) D509 «= 8-719- 303-02 LED SEL2510C-D (AMP1) C114. —s-1-164-075-11 CERAMIC 150PF 10% 50V (G)
30 3-701-947-16 LABEL (T3.15A), FUSE (EXCEPT E) D510 8-719-303-02 LED SEL2510C-D (AMP2) C115: 1-136-163-00 FILM 0.068uF 5% 50V
31 3-701-947-19 LABEL (T6. 3A), FUSE D511 =8-719-301-49 LED SEL2810A (BIL) C201 = 1-124-667-11 ELECT 10uF 20% 100V (EXCEPT G)
* 35 1-641-092-11 VS BOARD (E) D512 =8-719-303-02 LED SEL2510C-D (AMP3) C201 =: 1-123-369-00 ELECT 4, TuF 20% 50V (G)
D513 = 8-719-303-02 LED SEL2510C-D (AMP4)
‘Ny CNPl 1-575-651-11 CORD, POWER (AE1, AE2, G) C202 = 1-110-335-11 MYLAR 100PF 5% 50V
/\: CNP1 1-575-652-11 CORD, POWER (UK) D514 = 8-719-301-49 LED SEL2810A (BTL) C203 =: 1-110-340-11 MYLAR 270PF 5% 50V
/\s CNP1 1-575-653-11 CORD, POWER (E) C204 =1-124-910-11 ELECT 4TuF 20% 50V
< RESISTOR > C205 = 1-164-041-11 CERAMIC 5PF 0. 25PF50V
Fl 1-532-237-00 FUSE, TIME-LAG (BET) (3.15A) (EXCEPT E) C208 =.1-124-910-11 ELECT 47uF 20% 50V
not supplied /\: F2 1-532-237-00 FUSE, TIME-LAG (BET) (3.15A) (E) R516 =: 1-247-754-11 CARBON 1.5K 5% 1/24
Ay F3 1-532-237-00 FUSE, TIME-LAG (BET) (3.15A) (E) R517 ~—-:1-247-755~-11 CARBON 1.8K 5% 1/24 C210 =. 1-136-163-00 FILM 0. 068uF 5% 50V
Supuied F501 1-532-325-00 FUSE, TIME-LAG (6. 3A) R518 = 1-247-754-11 CARBON 1.5K 5% 1/24 C212: 1-136-153-00 FILM 0. OluF 5% 50V (G)
: AN F502 = 1-532-325-00 FUSE, TIME-LAG (6. 3A) R519 1-247-755-11 CARBON 1.8K 5% 1/24 C213 =: 1-136-153-00 FILM 0. OluF 5% 50V (G)
with
VR
A
F503
©
1~532~325-00
FUSE,
TIME-LAG
(6.
3A)
SRE
EERE
AERE
ERA
EERE
RARE
RR
IRE
ER
EE
AREER
K
AKER
ERE
C214
1-164-075-11
CERAMIC
150PF
10%
50V
(G)
F504 1-532-325-00 FUSE, TIME-LAG (6. 3A) C215: 1-136-163-00 FILM 0. 068uF 5% 50V
* A-4345-674-A MAIN BOARD, COMPLETE (AE1, UK, E)
i Sl 1-554-920-31 SWITCH, PUSH (AC POWER) (1 KEY) Scttistestetestotes ts fete ss ¢ C301: 1-124-667-11 ELECT 10uF 20% 100V (EXCEPT G)
A\ Tl 1-450-698-11 TRANSFORMER, POWER (AE1, G) * A-4345-675-A MAIN BOARD, COMPLETE (G) C301 = 1-123-369-00 ELECT 4, TuF 20% 50V (G)
As Tl 1-450-699-11 TRANSFORMER, POWER (UK) KKEKEKKKE ER AREEAEE ER ERE
A: 71 1-450-700-11 TRANSFORMER, POWER (E) ¥ A-4345-795-A MAIN BOARD, COMPLETE (AE2)
Ay Tl 1-450-701-11 TRANSFORMER, POWER (AE2) pescaestasstastieartsrtir se
—13—
an

| TA-N220
Ref.No. Part No. Description Remark Ref.No. Part No. Description Remark
C302 ~=1-110-335-11 MYLAR 100PF 5% 50V < DIODE >
C303 = 1-110-340-11 MYLAR 270PF 5% 50V
C304 ~=1-124-910-11 ELECT 4TuF 20% 50V D101 8-719-815-85 DIODE 181585
C305 1-164-041-11 CERAMIC 5PF 0. 25PF50V D102.» ~=—-8-719-815-85 DIODE 181585
C306 ~=1-136-163-00 FILM 0.068uF 5% 50V D201 8-719-815-85 DIODE 181585
D202 8-719-815-85 DIODE 181585
C307 = 1-126-052-11 ELECT 100uF 20% 50V D301 8-719-815-85 DIODE 181585
C308 =1-124-910-11 ELECT ATuF 20% 50V
C309 1-126-618-11 ELECT 33uF 20% 50V D302 8-719-815-85 DIODE 181585
C310 1-136-163-00 FILM 0.068uF 5% 50V D401 8-719-815-85 DIODE 181585
C311 = 1-126-052-11 ELECT 100uF 20% 50V D402» 8-719-815-85 DIODE 181585
D501 8-719-815-85 DIODE 181585
C312 = 1-136-153-00 FILM 0. OluF 5% 50V (G) D502 = 8-719-815-85 DIODE 181585
C313: 1-136-153-00 FILM 0. OluF 5% 50V (G)
C314 = 1-164-075-11 CERAMIC 150PF 10% 50V (G) D503. = 8-719-200-82 DIODE 11ES2
C315 = 1-136-163-00 FILM 0.068uF 5% 50V D504 8-719-934-18 DIODE HZS27-2L
C401 =1-124-667-11 ELECT 10uF 20% 100V (EXCEPT G) D505 8-719-815-85 DIODE 181585
D506 8-719-815-85 DIODE 181585
C401 ~=1-123-369-00 ELECT 4, TuF 20% 50V (G) D507 + 8-719-302-38 DIODE RBY~-602-01
C402 = 1-110-335-11 MYLAR 100PF 5% 50V
C403
=:
1-110-340-11
MYLAR
270PF
5%
50V
D508
8-719-302-38
DIODE
RBY-602-01
C404 =: 1-124-910-11 ELECT 47uF 20% 50V D515 = 8-719~-815-85 DIODE 151585
C405 =1-164-041-11 CERAMIC 5PF 0. 25PF50V D516 = 8-719-815-85 DIODE 1S1585
D517 ~=—8-719-815-85 DIODE 151585
C408 = 1-124-910-11 ELECT 47uF 20% 50V D518 =8-719-815-85 DIODE 151585
C410 =: 1-136-163-00 FILM 0.068uF 5% 50V
C412 =: 1-136-153-00 FILM 0. OluF 5% 50V (G) < IC >
C413: 1-136-153-00 FILM 0. OluF 5% 50¥ (@
C414 —-1-164-075-11 CERAMIC 150PF 10% 50V (G) IC101 8-749-900-34 IC STK-4182MK2
1C301 8-749-900-34 IC STK-4182MK2
C415 =: 1-136-163-00 FILM 0.068uF 5% 45O0V 1C501 8-759-111-68 IC uPC1237HA
C501 =: 1-136-153-00 FILM 0.0luF 5% 50V
C502 = 1-126-176-11 ELECT 220uF 20% 10V « JACK >
C503 =: 1-136-157-00 FILM 0.022uF 5% 50V
C504 =: 1-124-477-11 ELECT 47uF 20% 257 J101 = 1-569-378-11 JACK, PIN 4P (INPUT)
C505 = 1-124-477-11 ELECT ATuF 20% 25V < COIL >
C506 =: 1-124-907-11 ELECT 10uF 20% SOV
>
C507 1-126-307-11 ELECT 6800uF 20% 50V * L101 1-420-872-00 COIL, AIR CORE 1. 9uH
C508
1-126-307-11
ELECT
6800uF
20% 50V
*
1201
1-420-872-00
COIL,
AIR
CORE
1.
9uH
C509 1-126-307-11 ELECT 6800uF 20% 50V * L301 1-420-872-00 COIL, AIR CORE 1. 9uH
* L401 1-420-872-00 COIL, AIR CORE 1. 9uH
C510 1-126-307-11 ELECT 6800uF 20% 50V
C513: 1-136-165-00 FILM 0. luF 5% 50V (AE2, G) < TRANSISTOR >
C514‘ 1-136-165-00 FILM 0. luF 5% 50V (AE2, G)
C515:
1-136-165-00
FILM
0.
luF
5%
50V
(AE2,
G)
Ql01
8-729-140-82
TRANSISTOR
2SA988-PAFAEA
C516 = 1-136-165-00 FILM 0. luF 5% 50V (AEZ2, G) Q201 8-729-140-82 TRANSISTOR 2SA988-PAFARA
Q301 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
< CONNECTOR > Q401 8-729-140-82 TRANSISTOR 2SA988-PAFAEA
Q501 8-729-620-05 TRANSISTOR 2SC2603-EF
CN101 1-537-235-11 TERMINAL BOARD (SP) (SPEAKER)
(AE1, UK, E) Q502 8-729-140-96 TRANSISTOR 2SD774-34
CN101 1-537-227-11 TERMINAL BOARD (SP) (SPEAKER) (AE2)
CN101
1-537-228-11
TERMINAL
BOARD
(SP)
(SPEAKER)
(G)
<
RESISTOR
>
* CN106 1-569-648-11 PIN, CONNECTOR (PC BOARD) 11P
R101 1-247-713-11 CARBON 1K 5% «1/48
CN501
1-564-104-00
PIN,
CONNECTOR
(B3P-VH)
3P
R102
1-249-466-11
CARBON
56K
oe
1/44
*
CNS02
1-564-104-00
PIN,
CONNECTOR
(B3P-VH)
3P
R103
1-247-710-11
CARBON
560
5%
1/4
R104 1-249-466-11 CARBON 56K 5% 1/49
"«
Note : The components identified by mark A\or dotted ime
with mark /\ are critical for safety.
Replace only with part number specified.

TA-N220 |
Ref, No.
R105
R106
R107
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R201
R202
R203
R204
R205
R206
R207
R211
R212
R213
R214
R215
R216
R218
R301
R302
R303
R304
R305
R306
R307
R308
R309
R310
R311
R312
R313
R314
R315
R316
R317
R318
R401
R402
R403
R404
Part No.
1-247-714~11 CARBON
1-249-681-11 CARBON
1-249-681-11 CARBON
1-249-673-11 CARBON
1-249-673-11 CARBON
1-249-466-11 CARBON
1-247-716-11 CARBON
1-247-726-11 CARBON
Description
1. 2K
2. 2K
2. 2K
1K
1K
56K
1. 8K
33K
1-217-151-00 RES, METAL PLATE
1-247-727-11 CARBON
1-247-727-11 CARBON
1-249-466-11 CARBON
1-249-458-11 CARBON
1-247-727-11 CARBON
1-247-713-11 CARBON
1-249-466-11 CARBON
1-247-710-11 CARBON
1-249-466-11 CARBON
1-247-714-11 CARBON
1-249-681-1] CARBON
1-249-681-11 CARBON
1-247-716-11 CARBON
1-247-726-11 CARBON
10
10
56K
8.2
10
1K
56K
560
56K
1. 2K
2. 2K
2. 2K
1. 8K
33K
1-217-151-00 RES, METAL PLATE
1-247-727-11 CARBON
1-247-727-11 CARBON
1-249-465-11 CARBON
1-247-727-11 CARBON
1-247-713-11 CARBON
1-249-466-11 CARBON
1-247-710-11 CARBON
1-249-466-11 CARBON
1-247-714-11 CARBON
1-249-681-11 CARBON
1-249-681-11 CARBON
1-249-673-11 CARBON
1-249-673-11 CARBON
1-249-466-11 CARBON
1-247-716-11 CARBON
1-247-726-11 CARBON
10
10
47K
10
1K
56K
560
56K
1. 2K
2. 2K
2. 2K
1K
1K
56K
1. 8K
33K
1-217-151-00 RES, METAL PLATE
1-247-727-11 CARBON
1-247-727-11 CARBON
1-249-466-11 CARBON
1-249-458-11 CARBON
1-247-727-11 CARBON
1-247-713-11 CARBON
1-249-466-11 CARBON
1-247-710-11 CARBON
1-249-466-11 CARBON
10
10
56K
8.2
10
1K
56K
560
56K
5%
54%
5%
5%
5%
5%
5%
5%
1/44
1/24
1/24
1/24
1/2¥
1/44
1/4¥
1/4¥
0.22 2W
5%
5%
5%
5%
5%
5%
5%
5%
5%
54
5%
5%
5%
5%
1/2
1/24
1/44
1/4¥
1/24
1/44
1/4¥
1/44
1/4¥
1/4¥
1/2
1/24
1/4¥
1/4¥
0.22 2W
5%
5%
5%
5%
5%
5%
By.)
5%
5%
5%
5%
5%
5%
5%
5%
5%
1/24
1/28
1/44
1/24
1/4¥
1/4¥
1/4¥
1/4¥
1/4¥
1/24
1/2¥
1/2¥
1/24
1/44
1/4¥
1/4¥
0.22 24
5%
5%
5%
5%
5%
5%
5%
5%
5%
1/24
1/24
1/4¥
1/4¥
1/24
1/44
1/44
1/4¥
1/4¥
(@)
(G)
(6)
Remark Ref. No.
R405
R406
R407
R411
R412
R413
R414
R415
R416
R418
R501
R502
R503
R504
R505
R506
R506
R507
R507
R508
R508
R509
R509
R510
R511
R512
R513
R514
R514
R515
R515
RY501
RY502
RY503
RY504
Part No.
1-247-714-11 CARBON
1-249-681-11 CARBON
1-249-681-11 CARBON
1-247-716-11 CARBON
1-247-726-11 CARBON
Description
1, 2K
2. 2K
2. 2K
1. 8K
33K
1-217-151-00 RES, METAL PLATE
1-247-727-11 CARBON
1-247-727-11 CARBON
1-249-465-11 CARBON
1-247-727-11 CARBON
1-247-719-11 CARBON
1-249-469-11 CARBON
1-247-717-11 CARBON
1-249-467-11 CARBON
1-247-713-11 CARBON
1-247-229-00 CARBON
1-247-743-11 CARBON
1-247-229-00 CARBON
1-247-743-11 CARBON
1-247-229-00 CARBON
1-247-743-11 CARBON
1-247-229-00 CARBON
1-247-743-11 CARBON
1-247-724-11 CARBON
1-247-725-11 CARBON
1-212-873-11
1-247-725-11
1-247-716-11
1-247-714-11
1-247-716-11
FUSIBLE
CARBON
CARBON
CARBON
CARBON
1-247-714-11 CARBON
< RELAY >
1~515-533-11
1-515-533-11
1-515-727-11
1-515-727-11
RELAY
RELAY
RELAY
RELAY
10
10
ATK
10
3. 3K
100K
2. 2K
68K
IK
360
220
360
220
360
220
360
220
8. 2K
10K
AT
10K
1. 8K
1, 2K
1, 8K
1. 2K
5%
5%
5%
5%
5%
Remark
1/44
1/24
1/24
1/4¥
1/4¥
0.22 2W F
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
5%
1/2¥
1/24
1/4
1/24 (G)
1/4W
1/4¥
1/4¥
1/4¥
1/4¥
1/2W (EXCEPT AE2)
1/2W (AE2)
1/2W (EXCEPT AE2)
1/24 (AE2)
1/2¥ (EXCEPT AE2)
1/2 (AE2)
1/2 (EXCEPT AE2)
1/2¥ (AE2)
1/44
1/4¥
1/4¥ F
1/44
1/48 (EXCEPT AE2)
1/4 (AE2)
1/4W (EXCEPT AE2)
1/4W (AE2)
EKERLARERERERER ERE RE RRR EAERE EERE R AER ARE RRR E EE EE REE AEE EERE
x
1-641-094-11 RELAY BOARD
REKERERKEKE
1-533-225-11 HOLDER, FUSE
< CONNECTOR >
* (N503 1-564-104-00 PIN, CONNECTOR (B3P-VH) 3P
1-564-104-00 PIN, CONNECTOR (B3P-VH) 3P
ERRERAAKE EEE REE REA EE RARE EERIE AEE IEE EI IRI EA EARTH HE
* CN504
Note:
The components identified by mark Aor dotted line
with mark Aare critical for safety.
Replace only with part number specified.

Ref.No. Part No. Description Remark Ref. No
* 1-641-089-11 SW BOARD fs Tl
FERKKEEE . Tl
Ay Tl
< CONNECTOR > A Tl
| TA-N220
| SW ||VOL]/vs |
Part_No. Description
1-450-698-11 TRANSFORMER,
1-450-699-11 TRANSFORMER,
1-450-700-11 TRANSFORMER,
1-450-701-11 TRANSFORMER,
Remark
POWER (AE1, G)
POWER (UK)
POWER (E)
POWER (AEZ2)
* CN104 1-560-531-00 PIN, CONNECTOR 5P
< SWITCH >
S501 1-572-918-11 SWITCH, ROTARY (AMP 1, 2)
S502 1-572-918-11 SWITCH, ROTARY (AMP 3, 4)
RREKRR REE ERR ERE ERE EERE RR ERE ARE REPRE EERE EE EER EEA REAR EERE
* 1-641-087-11 VOL BOARD
FEEEREEES
< CONNECTOR >
* CN107 1-563-381-11 SOCKET, CONNECTOR 11P
< VARIABLE RESISTOR >
RV101 1-238-176-11 RES, VAR, CARBON 100K/100K (AMP 1, 2)
RV301 1-238-176-11 RES, VAR, CARBON 100K/100K (AMP 3, 4)
FAERIE AREA IEEE ARERR ARERR EER EERE EAE
* 1-641-092-11 VS BOARD (E)
FERKEREEERALEE
1-533-225-11 HOLDER, FUSE
< CONNECTOR >
* CN2 1-564-321-00 PIN, CONNECTOR 2P
CN4 1-568-106-11 PIN, CONNECTOR 4P
< SWITCH >
S2 1-572-009-11 SELECTOR, VOLTAGE (VOLTAGE SELECTOR)
ERERERE RE EKER ERE EEER EERE EEEE EEE IER EERE REE ER ERE ERE EEE EEEE
MISCELLANEOUS
EEAEEKEEARELE
fs 29 1-569-007-11 ADAPTER, CONVERSION 2P (E)
y CNP1 = 1-575-651-11 CORD, POWER (AEI, AE2, G)
fs CNP1 = 1-575-652-11 CORD, POWER (UK)
y CNP1 = 1-575-653-11 CORD, POWER (E)
BX Fl 1-532-237-00 FUSE, TIME-LAG (BET) (3.154) (EXCEPT £)
° F2 1-532-237-00 FUSE, TIME-LAG (BET) (3.15A) (E)
+
F3
1-532-237-00
FUSE,
TIME-LAG
(BET)
(3.
15A)
(EB)
Ay F501 — 1-532-325-00 FUSE, TIME-LAG (6. 3A)
As F502 — 1-532-325-00 FUSE, TIME-LAG (6. 3A)
Avy F503 — 1-532-325-00 FUSE, TIME-LAG (6. 3A)
Ax
F504
1-532-325-00
FUSE,
TIME-LAG
(6.
3A)
A Sl 1~554-920-31 SWITCH, PUSH (AC POWER) (1 KEY)
HREKEEREREREREREREER EAE AAE ARES AREER AEE AEA EEE ERE ERE RRAR
ACCESSORIES & PACKING MATERIALS
EKEKEREREEKERE EEE EER EAE AEE RE ES
3-677-503-00 SHEET (LARGE), PROTECTION
3-703-710-41 STICKER, SONY SYMBOL (12)
3-704-366-01 SCREW (CASE) (M3X8) (EXCEPT UK)
3-753-946-11 MANUAL, INSTRUCTION (EXCEPT G)
(ENGLISH, FRENCH, SPANISH, PORTUGUESE)
3-753-946-41 MANUAL, INSTRUCTION (AE1, AE2, G)
(GERMAN, DUTCH, SWEDISH, ITALIAN)
4-923-860-01 CUSHION (EXCEPT UK)
4-929-219-01
CUSHION
(UK)
4-947-336-01 INDIVIDUAL CARTON (EXCEPT UK)
4-947-337-01 INDIVIDUAL CARTON (UK)
HKERAAKERERERER KEELER ERARAE RRR EERE RE RRAR EERE AAR ARERR EERE
ee He He
SE SLEEEEEELLELEELLL LAS
HARDWARE LIST
KAKEAKARAAEER ERE SER EREEE
#1 7-682-548-04 SCREW +BVIT 3X8 (S)
#2 7-682-548-09 SCREW +BVIT 3X8 (S)
#3
7-682-549-04
SCREW
+BVIT
3X10
(S)
#4 7-682-560-04 SCREW +BVIT 4X6 (S)
#5 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
#6 7-621-849-00 SCREW, TAPPING
The components identified by mark A\ or dotted line
with mark Aare critical for safety.
Replace only with part number specified.
Note: