Sony Xperia ZR User manual

1287.4302 Rev 1
Sony Mobile Communications AB –Company Internal
Component Replacement
- electrical -
XperiaTM ZR
C5502 /C5503/ M36h

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
2(10)
CONTENTS
1Replaceable Components .............................................................3
2Component Placing........................................................................5
3Additional Repair info....................................................................6
4Revision History...........................................................................10
For general information about electrical repair related issues, refer to
1220-1336: Generic Repair Manual - electrical
Test after electrical replacement: refer to 1273-1772 Mechanical Test Instruction
Do not remove shield can lids (Heat pasta are added and RF performance will be damaged)

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
3(10)
1 Replaceable Components
EXPLANATION OF ABBREVIATIONS USED IN THE COLUMN ‘COMMENTS’ BELOW
COMPONENT LOCATION
P= Primary side
S= Secondary side
REPAIR METHOD
HA = Hot Air (removal & mounting)
ST = Soldering Tool (removal & mounting)
HA/ST = Hot Air for removal - Soldering Tool for mounting
BGA = BGA Station
BH = Bottom Heater
ADDITIONAL INFORMATION
1 (2,3,4, etc.) = Proceed to ‘Additional Repair Info’ for further instructions in the indicated section(s).

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
4(10)
Position
Component
Part no.
Comments
F5102
Fuse 0.25A 1.0*0.5mm
1265-7224
P HA+BH 1
F7652
Fuse 0.25A 1.0*0.5mm
1265-7224
P HA+BH 2
L2201
Filter 220ohm 0603 2A 0.05ohm Bead
1001-1896
P HA+BH 3
R1300
Resistor 0.01 Ohm +/-1% 200.0 mW (1.6x0.
1238-2147
S HA+BH 4
X1300
Conn Pogopin Receptacle 5p Battery
1268-3454
S HA+BH or BGA 5
X2200
Conn USB B Receptacle 5p
1268-3388
P HA+BH or BGA 6
X2801
Conn Coax Receptacle 0p test switch
1221-6477
S HA+BH 7
X2802
Conn Coax Receptacle 1p
1261-3585
P HA+BH 8
X2804
Conn Coax Receptacle 0p test switch
1221-6477
S HA+BH 9
X2811
Conn Leaf Spring Receptacle 1p Antenna/G
1238-5879
S HA+BH 10
X3501
Conn Pogopin Plug 1p
1267-0901
S HA+BH 11
X3502
Conn Pogopin Plug 1p
1267-0901
S HA+BH 11
X8001
Conn Coax Receptacle 0p test switch
1221-6477
S HA+BH 12
X8003
Conn Pogopin Plug 1p
1267-0901
S HA+BH 13
X8006
Conn Pogopin Plug 1p
1267-0901
S HA+BH 13
X8400
Conn Pogopin Plug 1p
1267-0901
S HA+BH 14
X8600
Conn Leaf Spring Plug 1p Antenna/Groundi
1238-5876
S HA+BH 15

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
5(10)
2 Component Placing
To access the Component Placing document, double-click the icon below.
Applicable for on-screen viewing only –icon not shown on hard-copies.
Primary side
Secondary side

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
6(10)
3 Additional Repair info
1
F5102
Replace if open circuit (Vibrator not working)
Protect the BtB connectors with capton tape!
2
F7652
Replace if open circuit (No display)
Protect the BtB connector with capton tape!
3
L2201
Replace if open circuit (USB charger not working)
Protect the USB and BtB connectors with capton tape!
4
R1300
Replace if open circuit (Phone dead)
Protect the Battery connector with capton tape!

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
7(10)
Repair Actions: Additional Repair Info
5
X1300
Replace if mechanical damaged. (Phone dead or power
off)
6
X2200
Replace if mechanical damaged (USB charger or data
transfer not working)
Protect the BtB connector with capton tape!
7
X2801
Replace if open circuit 1-2 (No or bad network, main
antenna)
8
X2802
Replace if mechanical damaged (No or bad network,
main antenna)

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
8(10)
Repair Actions: Additional Repair Info
9
X2804
Replace if open circuit 1-2 (Bad network, secondary
antenna)
Protect the BtB connectors with capton tape!
10
X2811
Replace if mechanical damaged (Bad network,
grounding pins)
11
X3501, X3502
Replace if mechanical damaged (No ear speaker)
Protect the Coax, USB and BtB connectors with capton
tape!
12
X8001
Replace if open circuit 1-2 ( no or bad WLAN/ BT/ GPS)
Protect the BtB connector with capton tape!

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
9(10)
Repair Actions: Additional Repair Info
13
X8003, X8006
Replace if mechanical damaged (Bad network,
secondary antenna)
Protect the Coax, USB and BtB connectors with capton
tape!
14
X8400
Replace if mechanical damaged ( no or bad WLAN/ BT/
GPS)
Protect the Coax connector with capton tape!
15
X8600
Replace if mechanical damaged ( no or bad NFC)
Protect the Coax, USB and BtB connectors with capton
tape!

1287-4302 Rev 1
Sony Mobile Communications AB –Company Internal
10(10)
4 Revision History
Rev.
Date
Changes / Comments
1
2014-04-18
Initial release