Sony SA-VE312 User manual

SA-VE312/VE315/WMS315/
SS-CN315/V315
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
SERVICE MANUAL
MICRO SATELLITE SYSTEM
•The SA-VE312 system consists of one unit
of SA-WMS315 and two units of SS-V315.
•The SA-VE315 system consists of one unit
of SA-WMS315, one unit SS-CN315 and
four units of SS-V315.
SPECIFICATIONS
Photo: SA-WMS315 Photo: SS-CN315
Photo: SS-V315
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL
HARMONIC DISTORTION :
with 8 Ωloads both channels driven, from 20 - 150 Hz; rated
75 W per channel minimum RMS power, with no more than
0.8% total harmonic distortion from 250 mW to rated output.
SS-V315 (front and rear speakers)
Speaker system Full range, magnetically shielded
Speaker units 5 ×10 cm (2 ×4 in.), cone type
Enclosure type Bass reflex
Rated impedance 8 Ω
Power handling capacity
Maximum input power: 100 W
Sensitivity level 87 dB (1W, 1m)
Frequency range 90 Hz - 20,000 Hz
Dimensions (w/h/d) Approx. 68 ×150 ×125 mm
(23/4×6 ×5 in.), including front
grille
Mass
European model: Approx. 640 g (1 lb 7 oz) each
Other model: Approx. 740 g (1 lb 10 oz) each
SS-CN315 (center speaker)
Speaker system Full range ×2, magnetically
shielded
Speaker units 5 ×10 cm (2 ×4 in.), cone type
Enclosure type Bass reflex
Rated impedance 8 Ω
Power handling capacity
Maximum input power: 120 W
Sensitivity level 89 dB (1W, 1m)
Frequency range 90 Hz - 20,000 Hz
Dimensions (w/h/d) Approx. 301 ×68 ×125 mm
(117/8×23/4 ×5 in.), including front
grille
Mass
European model: Approx. 1.4 kg (3 lb 1 oz) each
Other model: Approx. 1.5 kg (3 lb 5 oz) each
SA-WMS315 (subwoofer)
System
Speaker system Active subwoofer, magnetically
shielded
Speaker unit Woofer : 16 cm (63/8in.),
cone type
Enclosure type Advanded SAW type
Continuous RMS power output
(8 Ω, 20 - 150 Hz, 0.8 % THD)
European model: 50 W
Other model: 75 W
Reproduction frequency range
28 Hz - 200 Hz
High frequency cut-off frequency
200 Hz
Inputs
LINE IN (input pin jack)
SPEAKER IN (input terminals)
Outputs
LINE OUT (output pin jack)
SPEAKER OUT (output terminals)
General
Power requirements
European model: 220 - 230 V AC, 50/60 Hz
Other model: 120 V AC, 60 Hz
Power consumptions
European model: 50 W
Other model: 70 W
Dimensions (w/h/d) Approx. 205 ×385 ×385 mm
(81/8×151/4×151/4in.), including
front grille
Mass Approx. 10.5 kg
(23 lb 2 oz)
Supplied accessories
SA-VE315
Foot pads (20)
Audio connecting cords (1)
Speaker connecting cords, 10 m (32 ft 93/4in.) (2)
Speaker connecting cords, 2.5 m (8 ft 21/2in.) (5)
SA-VE312
Foot pads (8)
Audio connecting cords (1)
Speaker connecting cords, 2.5 m (8 ft 21/2in.) (4)
Design and specifications are subject to change
without notice
Sony Corporation
Home Audio Company
Published by Sony Engineering Corporation
9-929-075-12
2004A16-1
© 2004.01
Ver 1.1 2004. 01

SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0OR DOTTED LINEWITH
MARK 0ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
After correcting the original service problem, perform the
following safety checks before releasing the set to the customer:
Checkthe antenna terminals,metaltrim, “metallized”knobs,screws,
and all other exposed metal parts forAC leakage. Check leakage as
described below.
LEAKAGE
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having
a return to chassis, must not exceed 0.5 mA (500 microamperes).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operatedAC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples of
a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2V AC range are suitable. (See
Fig. A)
SAFETY CHECK-OUT
To Exposed Metal
Parts on Set
0.15 µF1.5 kΩAC
Voltmeter
(0.75V)
Earth Ground
Fig.A. Using an AC voltmeter to check AC leakage.
2

3
SECTION 1
DIAGRAMS
1-1. NOTE FOR PRINTEDWIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
•X: parts extracted from the component side.
•b: Pattern from the side which enables seeing.
•Indication of transistor.
B
These are omitted.
CE
Q
Note on Schematic Diagram:
•All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
•All resistors are in Ωand 1/4W or less unless otherwise
specified.
•2: nonflammable resistor.
•C: panel designation.
•U: B+ Line.
•V: B– Line.
•Voltages are dc with respect to ground under no-signal
conditions.
no mark : AUDIO
•Voltagesare takenwithaVOM(input impedance10MΩ).
Voltage variations may be noted due to normal produc-
tion tolerances.
•Abbreviation
CND : Canadian model
•Circuit Boards Location
SA-WMS315
Note:
The components identi-
fied by mark 0or dotted
line withmark 0arecriti-
cal for safety.
Replace only with part
number specified.
Note:
Lescomposants identifiéspar
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
POWER board
POWER SWITCH board
LED board
CONTROL board
MAIN boar
d

4
•IC Block Diagrams
IC302 uPC1237H
IC301 STK350-230
1 2 3 4 5 6 7 8
OVER LOAD DET
F/F
OFFSET DET
LATCH/
AUTORESET
V
CC ON
MUTE
AC OFF
DET
V
CC
1
2
3
4
5
6
7
8
9
TR3 R1
R2
TR4
TR6
TR7
R4
R9
TR5
TR1
TR2
R6
D4 D3
R7
R8
TR8
D1 D2 R5
R3
INPUT
NF
-VEOUT
+VEOUT
VSS
GND
VCC
SUB

SA-VE312/VE315/WMS315/SS-CN315/V315
55
1-2. PRINTEDWIRING BOARD (SA-WMS315)
(EXCEPT AEP,UK) • See page 3 for Circuit Boards Location.
Ref. No. Location
D101 F-11
D102 F-11
D103 F-11
D104 F-11
D301 D-8
D302 D-8
D303 E-5
D304 E-7
D501 G-5
D502 F-7
D503 G-7
D801 B-11
IC101 F-11
IC102 F-9
IC103 D-11
IC201 B-8
IC301 C-9
IC302 D-9
Q101 G-9
Q102 F-8
Q103 D-10
Q303 E-9
Q401 A-3
Q402 A-3
Q403 A-5
Q404 A-2
• Semiconductor
Location
IC103
IC302
IC102 IC101
IC201
IC301
11
(11)
11
(11)
11
(11)
11
(11)
11
(11)
POWER SWITCH BOARD
POWER BOARD
CONTROL BOARD
LED BOARD
MAIN BOARD
POWER
SPEAKER
LEVEL
MODE
LINE
T501
POWER
TRANSFORMER
RL
OUT IN
ON : MUSYC
OFF: MOVIE
(POWER)
SP1
(SPEAKER)
AC
IN
12
A
B
C
D
E
F
G
H
3456789101112
Ver 1.1 2004.01

SA-VE312/VE315/WMS315/SS-CN315/V315
66
1-3. SCHEMATIC DIAGRAM (SA-WMS315)
(EXCEPT AEP,UK) • See page 4 for IC block diagrams.
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportant lenumérospécifié.
Ver 1.1 2004.01
T501
F501
C203
C204
R206
S201
RY301
C108 C114 C110
C111
C112
C104
R112
C101
C102
C103
R128
R101
R102
R103
R104
R129
R130
R301
R127
R404
R405
CN401
CN301
R317
R307
C307
C301
R309
R310
R314
R315
R312
R308
S1
R105
R106
R113 R114 C106 R131
R115
R132
R133
R116 R125
C115
R204 R205
R303
R306
C305
R126
C314
C2
R202
R311
R201
C202
D502
R501
R502
C510C508
C113
R119 R123
R122
R124
R120
R121
C107
R117
R109
C302R302
R203
R110
SP1
C1
C507 C509
R118
R406
R407
R402
IC302
D503
R401
R403
R304
TM101
C401
C208
C109
R305
R318
C310
R108
R107
D101 D102
D104
D103
C105
IC101(1/2)
IC101(2/2)
R111
IC102(1/2) IC102(2/2)
Q102Q101
Q103
IC103(1/2)
IC103(2/2)
IC201(1/2)
IC201(2/2)
CN101
CN201
CN202
CN801
C206
C207
C205
C201
RV201
D801
D303
Q303
D304
CN302
CN501
C308
CN502
CN1
R316
D501
C503
C504
C505
C506
R313
C309
C304
C303
D302
D301
IC301
C306
C312
C313
Q404Q401
Q402
Q403
C311
J101
C501
C502
10
50V
10
50V
22k
0.033 0.1 0.22
0.22
0.22
10
50V
1k
220p
220p 220p
3.9k
4.7k
4.7k
47k
47k
6.8k
6.8k
6.8k
82k
180
180
10
470
3.9p 10 50V
100k
100k
68k
12k
10k
10
10k
10k
1k 100k 220p 100k
10k
10k
10k
3.3k 5.6k
0.22
10k 6.8k
47
820
1000p
33k
100p
0.01
250V
220
10k
10k
0.01
MTZJ15B
1.5k
2W
1.5k
2W
0.1
10
50V
0.1
1k 1k
82k
33k
33k
4.7k
0.15
3.9k
1k
0.1100k
10k
1k
0.01
250V
10
50V 0.1
39k
0.22
2W
0.22
2W
2.2k
MTZJ15B
47k
560
56k
47
25V
0.1
0.22
56k
10
4.7 50V
10k
10k
1SS133T 1SS133T
1SS133T
1SS133T
47p
M5218AL
M5218AL
10k
M5218AL M5218AL
2SC2785-E2SC2785-E
2SC2785-E
M5218AL
M5218AL
M5218AL
M5218AL
10
50V
0.1
10
50V
47p
20k B
SEL6414E-LC05
1SS133T
DTC114ES
1SS133T
2P
VH
WHT
2P
UP-S
YEW
0.047
2P
VH-SN
WHT
2P VH-SN WHT
1.5k 1W
RBV402
6800
63V
6800
63V
100
25V
100
25V
1k 2W
100
16V
220 10V
10 50V
1SS133T
1SS133T
STK350-230
100p 500V
22
63V
22
63V
MP16202SC3623
2SA1175
MN2488
47
25V
0.01 100V
0.01
100V

SA-VE312/VE315/WMS315/SS-CN315/V315
77
1-4. PRINTEDWIRING BOARD (SA-WMS315)
(AEP,UK) • See page 3 for Circuit Boards Location.
1-676-565-
LED BOARD
LEVEL
1-677-993-
MODE
ON : MUSIC
OFF: MOVIE
(POWER)
11
(13)
11
(13)
11
(13)
POWER
11
(13)
CONTROL BOARD
POWER SWITCH
BOARD
POWER BOARD
IC103
IC302
IC401
IC201
IC101
IC102
11
(11)
MAIN BOARD
SPEAKER
LINE
T501
POWER
TRANSFORMER
RL
OUT IN
SP1
(SPEAKER)
AC
IN
12
A
B
C
D
E
F
G
H
34567891011
Ver 1.1 2004.01
Ref. No. Location
D101 G-11
D102 G-11
D103 G-11
D104 G-11
D301 F-8
D302 F-8
D303 F-5
D304 D-9
D501 G-5
D502 G-7
D503 H-7
D801 B-7
IC101 G-11
IC102 G-9
IC103 E-11
IC201 B-3
IC302 F-9
IC401 A-9
Q101 G-9
Q102 G-8
Q103 E-10
Q303 D-9
• Semiconductor
Location

SA-VE312/VE315/WMS315/SS-CN315/V315
88
1-5. SCHEMATIC DIAGRAM (SA-WMS315)
(AEP,UK) • See page 4 for IC block diagrams.
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportant lenumérospécifié.
Ver 1.1 2004.01
T501
F501
C203
C204
R206
S201
RY301
C108 C114 C110
C111
C112
C104
R112
C101
C102
C103
R128
R101
R102
R103
R104
R129
R130
R301
R127
C301
R309
R310
R314
R315
R312
S1
R105
R106
R113 R114 C106 R131
R115
R132
R133
R116
C115
R204
R126
R201
D502
C510C508
C113
R119 R123
R124
R120
R121
C107
R117
R109
C302
R203
R110
SP1
C507 C509
R118
IC302
D503
TM101
C208
C109
R108
R107
D101 D102
D104
D103
C105
IC101(1/2)
IC101(2/2)
R111
IC102(1/2) IC102(2/2)
Q102Q101
Q103
IC103(1/2)
IC103(2/2)
IC201(1/2)
IC201(2/2)
CN101
CN201
CN202
CN801
C206
C207
C205
C201
RV201
D801
D303
Q303
D304
CN302
CN501
CN502
CN1
C502
C501
D501
C505
C506
D302 D301
J101
R122
R125
R205
R316
CN301
C303
R306
R307
C305
R302
R502
C511
C512
R303
R304
CN401
IC401
C401
R401 R402
C503
C504
R313
R305 C304
C308
C307
C306
R501
C1
C2
R311
10
50V
10
50V
22k
0.033 0.1 0.22
0.22
0.22
10
50V
1k
220p
220p 220p
3.9k
4.7k
4.7k
47k
47k
6.8k
6.8k
6.8k
82k
10 50V
100k
100k
68k
12k
10k
10k
10k
1k 100k 220p 100k
10k
10k
10k
3.3k
0.22
10k
33k
10k
MTZJ15B
0.1
10
50V
0.1
1k 1k
33k
33k
4.7k
0.15
3.9k
1k
0.1
10k
1k
10
50V 0.1
39k
MTZJ15B
0.1
0.22
10k
10k
1SS133T 1SS133T
1SS133T
1SS133T
47p
M5218AL
M5218AL
10k
M5218AL M5218AL
2SC2785-E2SC2785-E
2SC2785-E
M5218AL
M5218AL
M5218AL
M5218AL
10
50V
0.1
10
50V
47p
20k B
SEL6414E-LC05
1SS133T
DTC114ES
1SS133T
2P
VH
WHT
2P
UP-S
YEW
2P
VH-SN
WHT
2P VH-SN WHT
0.1
100V
0.1 100V
RBV402
100
25V
100
25V
1SS133T 1SS133T
68k
4.7k
10k
680 1W
100
16V
10k
5.6k
10
50V
22k
820
2W
0.1
0.1
22k
390
TDA7294
22
50V 10k 10k
4700
50V
4700
50V
560 2W
10 0.1
47
25V
4.7 50V
100
16V
820
2W
4700p
250V
4700p
250V
6.8k

9
NOTE:
•-XX, -X mean standardized parts, so they may
have some differences from the original one.
•Items marked “*” are not stocked since they
are seldom required for routine service. Some
delayshouldbeanticipated when ordering these
items.
•Themechanicalpartswithnoreference number
in the exploded views are not supplied.
•Hardware (# mark) list and accessories and
packing materials are given in the last of this
parts list.
•Abbreviation
CND: Canadian model.
AUS:Australian model.
SP : Singapore model.
MY : Malaysia model.
AR : Argentine model.
G:German model.
SECTION 2
EXPLODED VIEWS
2-1. SA-WMS315 (1)
1
10
3567
9
8
11
4
not supplied
not supplied
12
2
supplied with
RV201, S201
#3
#8
#8
SP1
#2
#2
#9
#7
#7
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
1X-4952-542-1 FRAME ASSY, GRILLE
2X-4952-541-1 PANEL ASSY, FRONT
34-973-938-41 KNOB (A), PUSH
44-227-298-01 SHEET
54-226-228-01 KNOB (VOL)
64-226-213-01 INDICATOR
71-676-565-11 LED BOARD (AEP,UK)
71-676-815-11 LED BOARD (EXCEPT AEP,UK)
81-676-716-11 POWER SWITCH BOARD (AEP,UK)
81-676-814-11 POWER SWITCH BOARD (EXCEPT AEP,UK)
9A-4428-444-A CONTROL BOARD,COMPLETE (AEP,UK)
9A-4428-531-A CONTROL BOARD,COMPLETE
(EXCEPT AEP,UK)
10 A-4411-960-A CABINET ASSY, SPEAKER
11 4-981-864-01 FOOT
12 4-226-227-01 PACKING (D)
SP1 1-529-593-11 SPEAKER (16cm)
Ver 1.1 2004.01
The components identified by mark 0or
dotted line with mark 0are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.

10
2-2. SA-WMS315 (2)
#3
#3
#3
#3
#4
#4
#4
#6
not supplied
not supplied
not supplied
T101
53
54
51
55
56
52 (UK)
52 (AUS)
52 (AR)
52 (AEP, MY, SP, G)
52 (US, CND,)
57 (SP, MY)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportant lenuméro spécifié.
51 1-676-714-11 POWER BOARD (AEP,UK)
51 1-676-813-11 POWER BOARD (EXCEPT AEP,UK)
052 1-696-571-21 CORD, POWER (UK)
052 1-696-845-31 CORD, POWER (AUS)
052 1-782-603-11 CORD, POWER (AEP,MY,SP,G)
052 1-783-531-12 CORD, POWER (US,CND)
052 1-783-941-21 CORD, POWER (AR)
*53 3-703-244-00 BUSHING (2104), CORD
54 4-227-118-11 PANEL, REAR (US,CND)
54 4-227-118-21 PANEL, REAR (EXCEPT US,CND)
55 A-4428-530-A MAIN BOARD,COMPLETE (EXCEPT AEP,UK)
55 A-4726-478-A MAIN BOARD,COMPLETE (AEP,UK)
*56 3-701-946-23 LABEL, FUSE RATING (US,CND)
057 1-569-008-21 ADAPTOR, CONVERSION 2P (SP,MY)
0T101 1-435-335-11 TRANSFORMER, POWER (US,CND)
0T101 1-435-336-11 TRANSFORMER, POWER (AEP,UK,G)
0T101 1-435-337-11 TRANSFORMER, POWER (AR,MY,SP,AUS)
Ver 1.1 2004.01

11
2-3. SS-CN315
101
not supplied @@@
not supplied @@@
103
105
104
SP2
SP3
102
106
106
106
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
101 X-4952-576-1 GRILLE (CN) ASSY, FRONT
102 3-703-564-31 SCREW (3.5)
103 X-4952-577-1 CABINET (CN) ASSY
104 1-694-516-11 TERMINAL, SPEAKER
105 4-226-378-01 PANEL (CN), FRONT
106 4-226-531-01 SCREW (3.5 X 62), +P TAPPING
SP2 1-529-596-11 SPEAKER (5X10cm)
SP3 1-529-596-11 SPEAKER (5X10cm)

12
2-4. SS-V315
151
SP4
155
#1
153
154
not supplied
152
156
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
151 X-4952-570-1 GRILLE (SR) ASSY, FRONT
152 3-703-564-31 SCREW (3.5)
153 X-4952-571-1 CABINET (SR) ASSY
154 1-694-516-11 TERMINAL, SPEAKER
155 4-226-307-01 PANEL (SR), FRONT
156 4-226-531-01 SCREW (3.5 X 62), +P TAPPING
SP4 1-529-595-11 SPEAKER (5X10cm)

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
13
SECTION 3
ELECTRICAL PARTS LIST
NOTE:
•Due to standardization, replacements in the
parts list may be different from the parts
specifiedin the diagrams or the components
used on the set.
•-XX, -X mean standardized parts, so they
may have some difference from the original
one.
•Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
•CAPACITORS:
uF: µF
•COILS
uH: µH
•RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
•Abbreviation
CND: Canadian model.
AUS:Australian model.
SP : Singapore model.
MY : Malaysia model.
AR : Argentine model.
G:German model.
•SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
When indicating parts by reference number,
please include the board name.
The components identified by mark 0or
dotted line with mark 0are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
A-4428-444-A CONTROL BOARD, COMPLETE (AEP,UK)
A-4428-531-A CONTROL BOARD, COMPLETE (EXCEPT AEP,UK)
************************
< CAPACITOR >
C201 1-162-215-31 CERAMIC 47PF 5% 50V
C202 1-131-679-31 MYLAR 0.01UF 5% 50V
C203 1-126-964-11 ELECT 10uF 20.00% 50V
C204 1-126-964-11 ELECT 10uF 20.00% 50V
C205 1-126-964-11 ELECT 10uF 20.00% 50V
C206 1-126-964-11 ELECT 10uF 20.00% 50V
C207 1-130-495-00 MYLAR 0.1uF 5% 50V
C208 1-130-495-00 MYLAR 0.1uF 5% 50V
< CONNECTOR >
*CN201 1-564-511-11 PLUG, CONNECTOR 8P
*CN202 1-564-505-11 PLUG, CONNECTOR 2P
< IC >
IC201 8-759-634-50 IC M5218AL
< RESISTOR >
R201 1-249-429-11 CARBON 10K 5% 1/4W
R202 1-249-409-11 CARBON 220 5% 1/4W F
(EXCEPT AEP,UK)
R203 1-249-429-11 CARBON 10K 5% 1/4W
R204 1-249-429-11 CARBON 10K 5% 1/4W
R205 1-249-427-11 CARBON 6.8K 5% 1/4W
R206 1-249-433-11 CARBON 22K 5% 1/4W
< VARIABLE RESISTOR >
RV201 1-225-826-11 RES, VAR, CARBON 20K (LEVEL)
< SWITCH >
S201 1-771-632-12 SWITCH, ROTARY (MODE)
**************************************************************
1-676-565-11 LED BOARD (AEP,UK)
1-676-815-11 LED BOARD (EXCEPT AEP,UK)
**********
< CONNECTOR >
CN801 1-564-505-11 PLUG, CONNECTOR 2P
< DIODE >
D801 8-719-038-54 DIODE SEL6414E-LC05 (POWER)
**************************************************************
A-4428-530-A MAIN BOARD, COMPLETE (EXCEPT AEP,UK)
A-4726-478-A MAIN BOARD, COMPLETE (AEP,UK)
*********************
< CAPACITOR >
0C1 1-113-924-11 CERAMIC 0.0047uF 20.00% 250V
(AEP,UK)
0C2 1-113-924-11 CERAMIC 0.0047uF 20.00% 250V
(AEP,UK)
0C2 1-113-925-11 CERAMIC 0.01uF 20.00% 250V
(EXCEPT AEP,UK)
C101 1-162-286-31 CERAMIC 220PF 10% 50V
C102 1-162-286-31 CERAMIC 220PF 10% 50V
C103 1-162-286-31 CERAMIC 220PF 10% 50V
C104 1-126-964-11 ELECT 10uF 20.00% 50V
C105 1-162-215-31 CERAMIC 47PF 5.00% 50V
C106 1-162-286-31 CERAMIC 220PF 10% 50V
C107 1-136-167-00 MYLAR 0.15uF 5.00% 50V
C108 1-136-159-00 MYLAR 0.033uF 5.00% 50V
C109 1-136-169-00 MYLAR 0.22uF 5.00% 50V
C110 1-136-169-00 MYLAR 0.22uF 5.00% 50V
C111 1-136-169-00 MYLAR 0.22uF 5.00% 50V
C112 1-136-169-00 MYLAR 0.22uF 5.00% 50V
C113 1-136-165-00 MYLAR 0.1uF 5.00% 50V
C114 1-136-165-00 MYLAR 0.1uF 5.00% 50V
C115 1-136-169-00 MYLAR 0.22uF 5.00% 50V
C301 1-126-964-11 ELECT 10uF 20.00% 50V
C302 1-136-165-00 MYLAR 0.1uF 5.00% 50V
C303 1-126-933-11 ELECT 100uF 20.00% 16V
(AEP,UK)
C303 1-126-964-11 ELECT 10uF 20.00% 50V
(EXCEPT AEP,UK)
C304 1-126-934-11 ELECT 220uF 20.00% 10V
(EXCEPT AEP,UK)
C304 1-136-165-00 MYLAR 0.1uF 5.00% 50V
(AEP,UK)
C305 1-126-964-11 ELECT 10uF 20.00% 50V
(AEP,UK)
C305 1-162-294-31 CERAMIC 0.001uF 10% 50V
(EXCEPT AEP,UK)
C306 1-126-933-11 ELECT 100uF 20.00% 16V
(AEP,UK)
CONTROL LED MAIN
Ver 1.1 2004.01

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
14
C306 1-101-810-51 CERAMIC 100PF 5% 500V
(EXCEPT AEP,UK)
C307 1-126-963-11 ELECT 4.7uF 20.00% 50V
(AEP,UK)
C307 1-162-194-31 CERAMIC 3.9PF 10.00% 50V
(EXCEPT AEP,UK)
C308 1-126-947-11 ELECT 47uF 20.00% 25V
(AEP,UK)
C308 1-136-161-51 MYLAR 0.047uF 5.00% 50V
(EXCEPT AEP,UK)
C309 1-104-665-11 ELECT 100uF 20.00% 10V
(EXCEPT AEP,UK)
C310 1-126-963-11 ELECT 4.7uF 20.00% 50V
(EXCEPT AEP,UK)
C311 1-126-947-11 ELECT 47uF 20.00% 25V
(EXCEPT AEP,UK)
C312 1-128-551-11 ELECT 22uF 20.00% 63V
(EXCEPT AEP,UK)
C313 1-128-551-11 ELECT 22uF 20.00% 63V
(EXCEPT AEP,UK)
C314 1-162-282-31 CERAMIC 100PF 10% 50V
(EXCEPT AEP,UK)
C501 1-136-165-00 MYLAR 0.1uF 5.00% 50V
(AEP,UK)
C501 1-136-878-21 FILM 0.01uF 2.00% 100V
(EXCEPT AEP,UK)
C502 1-136-165-00 MYLAR 0.1uF 5.00% 50V
(AEP,UK)
C502 1-136-878-21 FILM 0.01uF 2.00% 100V
(EXCEPT AEP,UK)
C503 1-117-789-11 ELECT 6800uF 20.00% 63V
(EXCEPT AEP,UK)
C503 1-119-940-51 ELECT 4700uF 20.00% 50V
(AEP,UK)
C504 1-117-789-11 ELECT 6800uF 20.00% 63V
(EXCEPT AEP,UK)
C504 1-119-940-51 ELECT 4700uF 20.00% 50V
(AEP,UK)
C505 1-104-665-11 ELECT 100uF 20.00% 25V
C506 1-104-665-11 ELECT 100uF 20.00% 25V
C507 1-126-964-11 ELECT 10uF 20.00% 50V
C508 1-126-964-11 ELECT 10uF 20.00% 50V
C509 1-136-165-00 MYLAR 0.1uF 5.00% 50V
C510 1-136-165-00 MYLAR 0.1uF 5.00% 50V
C511 1-136-165-51 MYLAR 0.1uF 5.00% 50V
C512 1-136-165-51 MYLAR 0.1uF 5.00% 50V
< CONNECTOR >
*CN101 1-564-511-11 PLUG, CONNECTOR 8P
CN301 1-564-509-11 PLUG, CONNECTOR 6P (EXCEPT AEP,UK)
*CN301 1-564-510-11 PLUG, CONNECTOR 7P (AEP,UK)
*CN302 1-565-792-11 PIN, CONNECTOR 2P
*CN501 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P
*CN502 1-564-687-11 PIN, CONNECTOR 3P
< DIODE >
D101 8-719-991-33 DIODE 1SS133T-77
D102 8-719-991-33 DIODE 1SS133T-77
D103 8-719-991-33 DIODE 1SS133T-77
D104 8-719-991-33 DIODE 1SS133T-77
D301 8-719-991-33 DIODE 1SS133T-77
D302 8-719-991-33 DIODE 1SS133T-77
D303 8-719-991-33 DIODE 1SS133T-77
D304 8-719-991-33 DIODE 1SS133T-77
D501 8-719-312-47 DIODE RBA-406B
D502 8-719-921-92 DIODE MTZJ-15B
D503 8-719-921-92 MTZJ-15B
< FUSE >
0F501 1-533-296-11 FUSE, GLASS TUBE 2A/125V (US,CND)
0F501 1-532-500-51 FUSE T0.63AL/250V (EXCEPT US,CND)
< IC >
IC101 8-759-634-50 IC M5218AL
IC102 8-759-634-50 IC M5218AL
IC103 8-759-634-50 IC M5218AL
IC301 8-749-011-16 IC STK350-230 (EXCEPT AEP,UK)
IC302 8-759-111-68 IC uPC1237HA
< JACK >
J101 1-785-795-11 JACK, PIN 2P (LINE)
< TRANSISTOR >
Q101 8-729-178-55 TRANSISTOR 2SC2785-E
Q102 8-729-178-55 TRANSISTOR 2SC2785-E
Q103 8-729-178-55 TRANSISTOR 2SC2785-E
Q303 8-729-029-66 TRANSISTOR DTC114ES
< RESISTOR >
R101 1-249-425-11 CARBON 4.7K 5% 1/4W F
R102 1-249-425-11 CARBON 4.7K 5% 1/4W F
R103 1-249-437-11 CARBON 47K 5% 1/4W
R104 1-249-437-11 CARBON 47K 5% 1/4W
R105 1-249-429-11 CARBON 10K 5% 1/4W
R106 1-249-429-11 CARBON 10K 5% 1/4W
R107 1-249-429-11 CARBON 10K 5% 1/4W
R108 1-249-429-11 CARBON 10K 5% 1/4W
R109 1-249-417-11 CARBON 1K 5% 1/4W F
R110 1-249-417-11 CARBON 1K 5% 1/4W F
R111 1-249-429-11 CARBON 10K 5% 1/4W
R112 1-249-417-11 CARBON 1K 5% 1/4W F
R113 1-249-417-11 CARBON 1K 5% 1/4W F
R114 1-249-441-11 CARBON 100K 5% 1/4W
R115 1-249-429-11 CARBON 10K 5% 1/4W
R116 1-247-843-11 CARBON 3.3K 5% 1/4W
R117 1-249-424-11 CARBON 3.9K 5% 1/4W F
R118 1-249-436-11 CARBON 39K 5% 1/4W
R119 1-249-417-11 CARBON 1K 5% 1/4W F
R120 1-249-435-11 CARBON 33K 5% 1/4W
R121 1-249-425-11 CARBON 4.7K 5% 1/4W F
R122 1-249-439-11 CARBON 68K 5% 1/4W
(AEP,UK)
R122 1-249-440-11 CARBON 82K 5% 1/4W
(EXCEPT AEP,UK)
R123 1-249-417-11 CARBON 1K 5% 1/4W F
R124 1-249-435-11 CARBON 33K 5% 1/4W
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportant lenuméro spécifié.
MAIN
Ver 1.1 2004.01

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
15
R125 1-249-425-11 CARBON 4.7K 5% 1/4W
(AEP,UK)
R125 1-249-426-11 CARBON 5.6K 5% 1/4W
(EXCEPT AEP,UK)
R126 1-249-435-11 CARBON 33K 5% 1/4W
R127 1-249-440-11 CARBON 82K 5% 1/4W
R128 1-249-424-11 CARBON 3.9K 5% 1/4W F
R129 1-249-427-11 CARBON 6.8K 5% 1/4W F
R130 1-249-427-11 CARBON 6.8K 5% 1/4W F
R131 1-249-441-11 CARBON 100K 5% 1/4W
R132 1-249-429-11 CARBON 10K 5% 1/4W
R133 1-249-429-11 CARBON 10K 5% 1/4W
R301 1-249-427-11 CARBON 6.8K 5% 1/4W F
R302 1-249-433-11 CARBON 22K 5% 1/4W
(AEP,UK)
R302 1-249-441-11 CARBON 100K 5% 1/4W
(EXCEPT AEP,UK)
R303 1-249-433-11 CARBON 22K 5% 1/4W
(AEP,UK)
R303 1-249-401-11 CARBON 47 5% 1/4W F
(EXCEPT AEP,UK)
R304 1-249-412-11 CARBON 390 5% 1/4W
(AEP,UK)
R304 1-249-438-11 CARBON 56K 5% 1/4W
(EXCEPT AEP,UK)
0R305 1-212-857-00 FUSIBLE 10 5% 1/4W
(AEP,UK)
R305 1-249-438-11 CARBON 56K 5% 1/4W
(EXCEPT AEP,UK)
R306 1-249-416-11 CARBON 820 5% 1/4W F
(EXCEPT AEP,UK)
R306 1-249-429-11 CARBON 10K 5% 1/4W
(AEP,UK)
R307 1-249-413-11 CARBON 470 5% 1/4W F
(EXCEPT AEP,UK)
R307 1-249-426-11 CARBON 5.6K 5% 1/4W
(AEP,UK)
0R308 1-212-857-00 FUSIBLE 10 5% 1/4W
(EXCEPT AEP,UK)
R309 1-249-441-11 CARBON 100K 5% 1/4W
R310 1-249-441-11 CARBON 100K 5% 1/4W
R311 1-249-427-11 CARBON 6.8K 5% 1/4W
(AEP,UK)
R311 1-249-429-11 CARBON 10K 5% 1/4W
(EXCEPT AEP,UK)
R312 1-249-429-11 CARBON 10K 5% 1/4W
R313 1-215-892-11 METAL OXIDE 1K 5% 2W
(EXCEPT AEP,UK)
R313 1-216-455-11 METAL OXIDE 560 5% 2W
(AEP,UK)
R314 1-249-439-11 CARBON 68K 5% 1/4W
R315 1-249-430-11 CARBON 12K 5% 1/4W
R316 1-215-868-00 METAL OXIDE 680 5% 1W
(AEP,UK)
R316 1-215-870-11 METAL OXIDE 1.5K 5% 1W
(EXCEPT AEP,UK)
0R317 1-249-393-11 CARBON 10 5% 1/4W F
(EXCEPT AEP,UK)
0R318 1-249-393-11 CARBON 10 5% 1/4W F
(EXCEPT AEP,UK)
R501 1-216-456-00 METAL OXIDE 820 5% 2W
(AEP,UK)
R501 1-215-893-11 METAL OXIDE 1.5K 5% 2W
(EXCEPT AEP,UK)
R502 1-215-893-11 METAL OXIDE 1.5K 5% 2W
(EXCEPT AEP,UK)
R502 1-216-456-00 METAL OXIDE 820 5% 2W
(AEP,UK)
< RELAY >
RY301 1-515-920-11 RELAY (24V)
< TERMINAL >
TM101 1-537-922-11 TERMINAL BOARD (SPEAKER)
**************************************************************
1-676-714-11 POWER BOARD (AEP,UK)
1-676-813-11 POWER BOARD (EXCEPT AEP,UK)
*************
< CAPACITOR >
C401 1-126-947-11 ELECT 47uF 20.00% 25V
(EXCEPT AEP,UK)
C401 1-126-965-11 ELECT 22uF 20.00% 50V
(AEP,UK)
< CONNECTOR >
*CN401 1-564-509-11 PLUG, CONNECTOR 6P (EXCEPT AEP,UK)
*CN401 1-564-510-11 PLUG, CONNECTOR 7P (AEP,UK)
< IC >
IC401 8-759-660-72 IC TDA7294 (AEP,UK)
< TRANSISTOR >
Q401 8-729-141-30 TRANSISTOR 2SC3623ATP-LK
(EXCEPT AEP,UK)
Q402 8-729-119-76 TRANSISTOR 2SA1175-HFE (EXCEPT AEP,UK)
Q403 8-749-010-25 IC MN2488-OPY-M (EXCEPT AEP,UK)
Q404 8-749-010-26 IC MP1620-OPY-M (EXCEPT AEP,UK)
< RESISTOR >
R401 1-249-429-11 CARBON 10K 5% 1/4W
(AEP,UK)
R401 1-249-437-11 CARBON 47K 5% 1/4W
(EXCEPT AEP,UK)
R402 1-249-421-11 CARBON 2.2K 5% 1/4W F
(EXCEPT AEP,UK)
R402 1-249-429-11 CARBON 10K 5% 1/4W
(AEP,UK)
R403 1-249-414-11 CARBON 560 5% 1/4W F
(EXCEPT AEP,UK)
0R404 1-247-703-11 CARBON 180 5% 1/4W F
(EXCEPT AEP,UK)
0R405 1-247-703-11 CARBON 180 5% 1/4W F
(EXCEPT AEP,UK)
0R406 1-217-151-00 METAL 0.22 10% 2W
(EXCEPT AEP,UK)
0R407 1-217-151-00 METAL 0.22 10% 2W
(EXCEPT AEP,UK)
**************************************************************
POWER
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportant lenumérospécifié.
Ver 1.1 2004.01
MAIN

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
16
1-676-716-11 POWER SWITCH BOARD (AEP,UK)
1-676-814-11 POWER SWITCH BOARD (EXCEPT AEP,UK)
********************
< CAPACITOR >
0C1 1-113-925-11 CERAMIC 0.01uF 20.00% 250V
(EXCEPT AEP,UK)
< CONNECTOR >
CN1 1-564-321-00 PIN, CONNECTOR 2P
< SWITCH >
0S1 1-554-920-11 SWITCH, PUSH (AC POWER)(1 KEY)(POWER)
(AEP,UK)
0S1 1-554-920-61 SWITCH, PUSH (AC POWER)(1 KEY)(POWER)
(EXCEPT AEP,UK)
**************************************************************
MISCELLANEOUS
**************
052 1-696-571-21 CORD, POWER (UK)
052 1-696-845-31 CORD, POWER (AUS)
052 1-782-603-11 CORD, POWER (AEP,MY,SP,G)
052 1-783-531-12 CORD, POWER (US,CND)
052 1-783-941-21 CORD, POWER (AR)
104 1-694-516-11 TERMINAL, SPEAKER
154 1-694-516-11 TERMINAL, SPEAKER
0T101 1-435-335-11 TRANSFORMER, POWER (US,CND)
0T101 1-435-336-11 TRANSFORMER, POWER (AEP,UK,G)
0T101 1-435-337-11 TRANSFORMER, POWER (AR,MY,SP,AUS)
SP1 1-529-593-11 SPEAKER (16cm)
SP2 1-529-596-11 SPEAKER (5X10cm)
SP3 1-529-596-11 SPEAKER (5X10cm)
SP4 1-529-595-11 SPEAKER (5X10cm)
**************************************************************
ACCESSORIES & PACKING MATERIALS
*******************************
1-769-329-21 CORD, CONNECTION (PIN-PIN)
1-769-433-11 CORD, SPEAKER (WMS315)
1-769-433-21 CORD, SPEAKER
4-226-697-11 MANUAL, INSTRUCTION
(ENGLISH/SPANISH)(US,UK,SP,MY)
4-226-697-21 MANUAL, INSTRUCTION
(ENGLISH/FRENCH)(AEP,CND,AR,G,AUS)
4-226-697-31 MANUAL, INSTRUCTION
(GERMAN/SPANISH/DUTCH/SWEDISH/ITALIAN/
PORTUGUESE/DANISH/FINNISH/POLISH/RUSIAN)(AEP,G)
4-226-697-41 MANUAL, INSTRUCTION
(SPANISH/CHINESE)(SP,MY,AR)
4-972-322-01 FOOT (Y)
**************************************************************
**************
HARDWARE LIST
**************
#2 7-685-165-01 SCREW +PTP 4X25 TYPE1
#3 7-685-647-79 SCREW +P 3X10 TYPE2 NON-SLIT
#4 7-685-648-79 SCREW +P 3X12 TYPE2 NON-SLIT
#6 7-685-660-19 SCREW +BVTP 4X10 TYPE2 N-S
#7 7-685-663-79 SCREW +BVTP 4X16 TYPE2 N-S
#8 7-685-664-79 SCREW +PTP 4X20 TYPE1
#9 7-685-665-79 SCREW +BVTP 4X25 TYPE2 N-S
The components identified by
mark 0or dotted line with mark
0are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque 0sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportant lenuméro spécifié.
Ver 1.1 2004.01
POWER SWITCH

17
MEMO

SA-VE312/VE315/WMS315/SS-CN315/V315
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver. Date Description of Revision
1.0 2000.02 New
1.1 2004.01 Addition of information for AEP and UK models (SPM-03132)