Sony STR-DE350Z User manual

STR+D3502/D4502/DE405/DES05
SERVICE
MANUAL
US
Model
Canadian Model
a
Photo : STR-DE505
a
A
I
SPECIFICATIONS
Manufactured
under
license
from
Dolby
Amplifier
section
Se
oe
a
Laboratories
Licensing
Corporation.
Sn
Oe
Oe
eer
ne
Sy
Ra
ee
Additionally
licensed
under
Canadian
Front:
fate
STR-DES505/D450Z:
patent
number
1,037,877.
“Dolby
”
the
100
W/ch
io
ee
SDeine. 5m 50 :
double-D
symbol
caand
”
Pro
Logic”
Sean
ee
(MM)
kilohms
72
dB*
are
trademarks
of
Dolby
Laboratories
Canadian
model
:
70W/ch
(A,
2.5
mV)
. ;
STR-D3502:
CD
Licensing
Corporation.
te
ee
ewes
200
mV
Canadian model : 70W/ch TAPE? 50 82dB
oe Center: MD, kilohms — 82dB*
Audio
power
specifications
ila
sirce
aaa
Me
150
mV
(A,
150mV)
100 5
STR-DE405: VIDEO
POWER
OUTPUT
AND
TOTAL
US
model
:
80W
-
en
ae
ee
eae
Canadian model : 7
HARMONIC
DISTORTION
cee
utpus
«=
TAPE/MORECOUT:
oe mode) a iepeluncsionhed
US
Model
:
aa
ria
ene
VIDEO
AUDIO
OUT:
i
2
Voltage
150
mV,
With
8
ohm
load,
both
ane
LOCIG
Impedance
10
kilohms
channels
driven,
from
20
-
eae
e)
MIX
AUDIO
OUT
20,000
Hz,
rated
100
watts
STR-DE50S
/D4502:
Saag
(STR-DE5S05/D450Z),
STR
Rasa
.
Impedance:
10
kilohms
80
watts
(STR-DE405)
or
US model
:
80W
7 eel
igh
enpetanes
60
watts
(STR-D350Z)
per
Canadian
model
:
70W
head
phones
channel
minimum
RMS
ou eeu
°
US
model
:
60W
_
power,
with
no
more
than
Canadian
model
:
70W
—
Continued on
page
2
—
0.09
%
total
harmonic
Frequency
PHONO:
RIAA
distortion
from
150
response
Sago
milliwatts
to
rated
output.
CD,
TAPE/MD,
VIDEO:
10 Hz -50 kHz 21 dB
Canadian Model :
20 — 20,000 Hz 0.09%
100W+100W (STR-D450Z, DE505)
20 — 20,000 Hz 0.09%
70W+70W
(STR-D350Z,
DE405)
FIV
STEREO)
FI
-A\
RECEIVER
SONTY.

Muting
BASS BOOST
TONE
Full mute
+10 dB at 70 Hz
+8 dB at 100 Hz and
10 kHz
FM tuner section
Tuning range
Antenna
terminals
Sensitivity
Usable sensitivity
SIN
Harmonic
distortion at
1 kHz
Separation
Frequency
response
Selectivity
87.5 - 108.0 MHz
75 ohms, unbalanced
300 ohms, unbalanced
Mona: 18.3 dBf, 4.5 pV
Stereo: 38.3 dBf, 45 pV
11.2 dBf, 2 pV (THF)
Mono: 76 dB
Stereo: 70 dB
Mono: 0.3 %
Stereo: 0.5 %
45 dBat1 kHz
ous
30 Hz-15 kHz, dB
60 dB at 400 kHz
AM tuner section
Tuning range
Antenna
With 10 KHz interval**:
530 - 1710 kHz
With 9 KHz interval:
531-1710 kHz
Loop antenna
Usable sensitivity 50 dB/m (at 1,000 kHz or
999 kHz)
SIN 54 dB (at 50 mV/m)
Harmonic 0.5% (50 mV/m,
distortion 400 kHz)
Selectivity At9 kHz: 35 dB
At 10 kHz: 40 dB
** You can change the AM tuning interval
to 9 kHz. After tuning in any AM station,
turn off the receiver. Hold down the
Power
requirements
Power
consumption
120 V AC, 60 Hz
STR-DE505/D450Z
US model : 200W
Canadian model : 295VA
STR-DE405
US model : 165W
Canadian model : 225VA
STR-D350Z
US model : 150W
Canadian model : 225VA
1 switched, total 120 W/
1A Max
430 x 148 x 295 mm
(17 x 57/6x 114/s inches)
STR-DES05 / DASUZ:
7.3 kg (16 Ib 1 oz)
STR-DE405 / D350Z.
6.5 kg (14 Ib 5 oz)
FM wire antenna (1)
AM loop antenna (1)
Remote controller
(remote) (1)
Size AA (R6) batteries (2)
Design and specifications are subject tu
TUNING + button and press the POWER AC outlets
button. All preset stations will be erased
when you change the interval. To reset . ;
the interval to 10 kHz, repeat the Dimensions
procedure.
Video
section
Mass
(Approx.)
inputs VIDEO, TV/DBS:
1 Vp-p 75 ohms
Outputs VIDEO: Supplied
Wotton ohms accessories
1 Vp-p 75 ohms
General
System Tuner section: PLL : :
quartz-locked digital change without notice.
synthesizer system
Preamplifier section:
Low-noise NF type
equalizer
Power amplifier section:
Pure-complimentary
SEPP
TABLE OF CONTENTS
Section Title Page
specifications eo eccccnes Cece cecccoes Por eeeersceoves weer een ecerocoeeoer oe f
1. GENERAL
Location and Function of controls «**325*sst+<eeesexsoeneses sce esy 4
2. EXPLANATION OF IC TERMINALS -+-+---+-+-0002020 6
3. DIAGRAMS
3-1. Circuit Boards Location :°°:° deveccees eeeeeee rere rrerrr ry 8
3-2. Printed Wiring Boards (Main Section) -+++++++++ererer sees 9
3-3. Schematic Diagram (Main Section) srrrrrrrerseeseeererees 13
3-4. Schematic Diagram (Display Section) ----- eases nasa seus 18
3-5. Printed Wiring Boards (Display Section)+++++++++++r++++* 21
4. EXPLODED VIEWS
4-1. Front panel Section crresesteceececeeceee errr reer rere rer cones 24
4-2. Chassis Section eoeceeeees deem eeecereeeserecrecseres sececescee DS
5. ELECTRICAL PARTS LIST------- sabe ti shocemea lapses OG

SAFETY
After correcting the original service problem,
perform the following safety check before releasing
the set to the customer:
Check the antenna terminals, metal trim, ‘“‘metallized”’
knobs, screws, and all other exposed metal parts for
AC leakage. Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to
earth ground and from all exposed metal parts to any
exposed metal part having a return to chassis, must
not exceed 0.5mA (500 microampers). Leakage
current can be measured by any one of three
methods.
1. A commercial leakage tester, such as the
Simpson 229 or RCA WT-540A. Follow the
manufacturers’ instructions to use these instru-
ments.
2. A battery-operated AC milliammeter. The Data
Precision 245 digital multimeter is suitable for
this job.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK A OR DOTTED
LINE WITH MARK A ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.
CHECK-OUT
3. Measuring the voltage drop across a resistor by
means of a VOM or battery-operated AC volt-
meter. The “limit” indication is 0.75 V, so
analog meters must have an accurate low-
voltage scale. The Simpson 250 and Sanwa
SH-63Trd are examples of a passive VOM that
is suitable. Nearly all battery operated digital
multimeters that have a 2V AC range are
suitable. (See Fig. A)
To Exposed Metal
Parts on Set
wal
0.15 pF voltmeter
eal (0.75 V)
= Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
ATTENTION AU COMPOSANT AYANT RAPPORT
A LA SECURITE!
LES COMPOSANTS IDENTIFIES PAR UNE MARQUE /\
SUR LES DIAGRAMMES SCHEMATIQUES ET LA LISTE
DES PIECES SONT CRITIQUES POUR LA SECURITE
DE FONCTIONNEMENT. NE REMPLACER CES COM-
POSANTS QUE PAR DES PIECES SONY DONT LES
NUMEROS SONT DONNES DANS CE MANUEL OU
DANS LES SUPPLEMENTS PUBLIES PAR SONY.

SECTION 1
GENERAL
LOCATION AND FUNCTION OF CONTROLS
{FRONT PANEL]
4} 2} [3} [4] LS) Le, 8} [9] [10] [44] {12} [13] [14
T==1K6)
oat ee
24} 23} [22] [24] 20] 19] [18] 16} [15]
SPEAKERS switches [9] PRESET TUNING +, — buttons FM/AM button
POWER switch MASTER VOLUME control TUNIG +, — buttons
CENTER MODE button SHIFT button FUNCTION buttons
SURROUND
ON/OFF,
FM
MODE
button
DIRECT
button
MODE
buttons
BASS
contel
REAR
LEVEL
+,
—
buttons
5|
CENTER
LEVEL
+,
—
buttons
TREBLE
control
DELAY
TIME/EFFECT
button
[6]
PROLOGIC,
THEATER,
HALL
.
indicators
BALANCE
control
PHONES
jack
mamene
pune
BASS
BOOST
button/indicator
VIDEO,
TV/DBS
indicators
MEMORY
button
[REAR PANEL]
ANTENNA (AM/FM) MIX AUDIO OUT (STR-DES05 only) SURROUND SPEKERS (REAR)
rh ground terminal AC power cord VIDEO
CD SWITCHED AC OUTLET TAPE/MD
TV/DBS FRONT SPEAKERS (A/B) PHONO
MONITOR SURROUND SPEKER (CENTER)

[Remote]
te) (8 ee) sy
VISUAL POWER button
TV control button
FUNCTION buttons
Numeric buttons
>10/SHIFT button
TV/Deck control buttons
SURROUND control buttons
REAR LEVEL +, — buttons
[9] CENTER LEVEL +, — buttons
SYSTEM OFF button
LEARN button/indicator (DESOS : Canadian model)
ENTER button
MUTING button
MASTER VOLUME +/-— buttons

SECTION 2
EXPLANATION OF IC TERMINALS
1/0 Description
DIG7 |
coo
DIG6 S|
Os!
Bedi
1C201 ( u PD78044AGF-165-3B9)
DIGS
DIG4
DIG3
DIG2
DIGI
Fluorescent indicator tube drive.
+ N
x
Chip enable input.
op) S
vay
S. DATA
PLL. DATA
5S: CE (LC7288)
S. CE (LV100)
VERISON
PROTECT
BRIDGE
RESET
AUTO-STOP
STEREO-IN
AVss
SP-RY
SURR-RY
POWER-RY
©
1]
2
5
—
— —
_
5
—
— oO
Standby relay ON/OFF control
System reset terminal
Auto stop detect input
i
Not
used.
(Open)
— 8
9 —
1
N
bo DOF RO | Bb _ m— be | ee
ee) > © ~“ os
1.)
2
Zz
q
U
bd 3
NPD |
Nn
6 SIGNAL
A/D2
A/D1
AVDD
AV. REF
GN
bt
NTN
“
Ww
‘Oo
W
FO W Ww N
‘oO & 1] W me 1oO
7)
WwW SS
Z
O
Ww
NA
<
Oo
IC. MUTE
PROLOGIC
SIMULATED
HALL
T. MUTE
3
38
“I
0

VIDEO | = | Video LED drive.
| 42 | TV/LD | ~ | TV/DBS LED drive.
peeaee STANDBY | | Standby LED drive.
44 SYS. POWER System power ON/OFF.
45 RDS.DATA.IN | —_ | Not used. (Open)
46 RDS.CLK.IN | — | Not used. (Open)
STOP Stop signal input from NJM2103D (IC950).
RET
SIRCS Sircs signal input.
POWER SW Power switch input terminal.
ss
= [Poversunin G5)
=
Bass boost LED drive.
oo
nt >
\o
0
— NS
53
54
LOW BOOST
FUNC. MUTE Line mute drive.
Le
eS Ground.
= in 5,
9.2 |. 7 ASRS eR
=e in 2
ec REE
=2008 | = | Comenouomd———SSCSCSC~C“C*‘“‘“‘“‘(CSS
Key out 15.
Key out 14.
NAIL Nn Nn Of; WENT AEN
ON > Key out 13.
ON Wn Key out 12.
Key out 9.
S11
XQ
Key out 8.
Eon
| 0 |
om
| Oo
| 0 | K
| 0 _|K
aoe
E08)
com Key out 7.
VLOAD =
On
ee
[so
[son
peony
[ood
| Oo
“N Connect to ground.
~
bd Key out 6.
8
To [keys SSSC~—C—CSCSC“‘“‘“S*S*S*SCS~*S
Key out 2.
~ ~ ATR} w
Key out 1.
~]
oO DIG10
DIG9
DIG8
~ \Oo
i ~ x ion DIA TA Nin nn ph Sp oO re 1 Oo Winter am “i
Fluorescent indicator tube drive.

SECTION 3
DIAGRAMS
3-1. CIRCUIT BOARDS LOCATION
SECONDARY board
STANDBY board
PRIMARY board
VIDEO board
SP SW board
MAIN board
DISPLAY board
VOLUME board
TONE board

STR-D350Z/D4502Z/DE405/DE505 3-2. PRINTED WIRING BOARDS (MAIN SECTION)
fel elles cde Oe lee nee ee Me) cree sce ie Oe cm Oe IO a SN MO wl se NO ie MS oo AB aa ASO oe aN adie BOOTS hn 9 cae ON |= 320 26
@ SEMICONDUCTOR LOCATION
TM60!
[sno [ tecaton | Rot Ne | tovaton a = a ee
VIDEO REAR] chiage
G-4 a re iS ti ART {i} ARO AAO, {AUTON a nl irs
nea MAIN 6 5 S eee eg é é 5 ware a STANDBY) Lo 4 (:20wia wax)
ro) ° ° ° 9) ° 9 ) O O Oo ° O O O ) O O [ )
ie [sonto aa RU Geet hack ate etines ea a a er eee eee [SECONDARY BOARD] ee ——
H
-
10
“
"
és
sopebemerwodenrrseuerd
sever
dL
ptininedhsencemlapsacccs
ae
eo
=e
:
SEA
| : |
EN
H-10
1-10
H-10
1-10
DESOS
ra
9252
—4
r—
151
—4
5253
I-10 -—_—[Wi0E0) [wx]
F-16
© r@® -o -@
bea aaa eas
>
c g
So °
lo
]
J-11
J-12
C-17
C-17
C-17
(CHASSIS) (CHASSIS)
0090000000000000
CF ii
C-17 POWER
C-16
TRANSFORMER
C-16
E-25
POWER
TRANSFORMER
F-10
[VIDEO BOARD]
D-17
t-660—189—
[VOLUME BOARD]
1
NOOO W&
$701 -1,-2-3 -4,-5,-6
SPEAKER A
[SP SW(B) BOARD]
[SP SW(A) BOARD]
T1 1-660-193—
{SP SW BOARD] hi , Wy
a) 1-660-188— ee at oo ae : j : ; : : 182—- bi =|
ae ui J7al
Note:
RV404
* O-— : parts extracted from the component side. C a (CHASSIS) (CHASSIS)
:
*:
;
Pattern
on
the
side
which
is
seen.
rn
[PHONES]
TONE BOARD DISPLAY BOARD
CNS401 CNS202
Sad DISPLAY BOARD
* Abbreviation €NS201
CND: Canadian
fees A Bs ee ee lS ee ee)

STR-D3502Z/D4502/DE405/DE505
3-3. SCHEMATIC DIAGRAM (MAIN SECTION) @ Refer to page 17 for IC Block Diagrams.
1 2 3 4 5 6 7 8 ) 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24. 25 26 27 28 29 30 31
ee ee ee = SS enn Se ee SS SS SS SSS Se Se Se ee SP SW (B)
A
ate
{
VOLUME
BOARD]
[
MAIN
BOARD]
10701
ans
BOARD
|
(SP
SW
BOARD]
R782
162k
1/2
5
I PROTECTOR
a
I
|
C701
47-4
si
Q703
SOWER
ae
ie
oe
R733
1.2K
1/2
h
J741
BISPLAY BOARS (B) eesens BH iy tet MN2488 (FRNT L-CH) | BIBE eee ee | '——c-yal} PHONES
cnsz02 ae , ! a
9720 CNP702 — CNS702 A783 1.2k 1/2
RV404 254988 L701 ote jd j
ie ; OVER LOAD v9 a 2 eee ee ee es ee 2 eee ee eee
MASTER 4 See Gar Sa a Fee
B Se = et pete
astes sia rel cl) Sa GN OW Al i
| a | CNP704
16V
Q710
=)
=>
Sra]
8
re : ie 28€2785 I | fof fe 8
CNP4ON Yes ARO 42s cnséoz | cns7o1 = id c ) Heer i 1 te | head yl
R715 ars
—— ad he
OVER LOA@ BET ol :
Pepe | | 1 ie
Cc ve eeare 2 a ae oS rn T + e}—4
CNS401 non i 1 _| [ ° 0
GND Pe . ~~ = $701 -7.8 eee ee a i ee
Bll Eee eee a aes ee ee J
R476
68k
ON
ees
es
MT,
cNe706
C470 229 SP SW (A) f cnr704 !
vee BOARD ee “6-5 5701
SBFB
G401
:
|
>
< > <
“12.3458
CONTROL | 2Sk246GR Rese 1 EOS, 653. 703, 753 a= | | l
D ——— eee cae aa - 9350Z | 9450Z, BE505 all le — ux heey ON I I |
eka ~ ET '
ces [ VIDEO BOARD ] Q721. 722, 723 | => OFF
at 10251 155 a7.g 060% 604 er ne ne aE TES pe Ee
< @—};— ; R52 VIQEO SWITCH Pt PROTECTOR : ee l
Ea
Q451,
452
MPC2581
j_
a
_
=
ae
i
os
=
]
BBFB BRIVECEMP. Str Wea A Gl Met ees a Beeepe a ee eg ee
E CONTROL fils r R731 220k “7 2
eee WNesBe Q603, 604
POWER AMP ae L_R781 220K __ |
IY
(REAR)
|
6B
|
D450Z,
BESOS
ae 2 4
wise 577 cL ES ' | oetke Bb, yt eeegr sy a8 |
F
cndoso
CNS251
BESOS,
24502
ic
(+)
(+)
I
Cele ©
TM701
2sties
ae ay Peel
BRIVE
{ 7
RI
TMé601 L__ Rpt L__qj—__
SURROUND
SPEAKER TM704
FRONT
SPEAKER
— ee ee te
9602
2503623 9602
OVER LOAD BET
MIXOUT | RoR
¥X}
EF
e WAVEFORM
choz 602
100 88k
SURROUN® 3
Q303, 304 AMP
SS OOOe
PT
OOS
MUT ING
Q741
2SC 1841
Q620, 770
OVER LOAR® QET
*3 C803, 804
[ —~_[pe505/e4s0z[ — Be405 2350Z
MNoe88 Q753, 754
POWER AMP
TUOO!
7 C45
I
eMrte I _& Se 47.4 FRONT R-CH |
gs rs oe !
eV
2
re
ou
Q740.
741
iC300 @ BE E weEES ke oe -Freaa POWER AMP
=< = = tae 4 = > 2 DDwe
a [email protected] ay Pp ogozeuw MUTE CN8 MODEL
EEBE EG HHRS T2388 15 ec HES
(3) C7XEXEXi) CXISXI6) |
i | i
—
| SECONDARY
NBO] CNP8OI BOARD
3 py pit
AHO
ae He 14 1» | PRIMARY
PROCESSOR POWER
J reer TRANSFORMER BOARD
OHO ?
Oe ees bs eee Oe ==
eee rs
24 eb ee ee
R810 1
[
CSIs
CB16
[|
ra
Ga
naa
=
J
4401 1 49 ey = 1
ats tee [2
kK = lee Een 8 |
iy Y
REC OUT =
J402 TAPE/MB ; zx
(172)
[TN]
i
.
1
TV/DBS I L_ cg — aed
[AUBIO IN(O) CNPS02
— 4
L J403 msIE-oI@—}—
(1/2) ee 6 = | Note:
| P| BOLBY PROLOGIC
y MATRIX I ccHassts) - All capacitors are in y F unless otherwise noted. pF: u u F
FUNCTION eCuHEr 50WV or less are not indicated except for electrolytics and
4
tantalums.
AUSIO_IN|(O}—$——t+———#----———— | | LEYTON pp RR aN [Se iS lS | Ue SN RNR Rf Bene eee ¢ All resistors are in Q and %W or less unless otherwise
M
oe
mee
Tt
7)
specified.
aUSTO GUT(O—4 C337 C339 C340 1 0.7 | 5548 C348 = C350 C35) C352 i : ie
= 5a as Roe oe ay TF a GH oe ke tl GF A. internal component.
J 50V 50V . ‘ : ;
AUDIO-IN Cs a a nee wal A825 wv} 2808. EM : nonflammable resistor.
[R) 20 v402 [TN oa 7 Note : Note :
(272) [TAPE/M8) 1 rosy te 2882525 ago2, 803 ; The components identi- | Les composants identifiés par
= Cm aes s B+] 5.42* REG, « [Bd RELAY RINE fied by mark /{\ ordot- | une marque /\\ sont critiques
N r— y &, ted line with mark pour la sécurité.
J401 are critical for safety. Ne les remplacer que par une
7
: ? °
(2/2) Replace only with part piéce portant le numéro spéci-
| ELONG Cae a eae number specified. fié.
47 1
:
et
812
11652
=
7
-
,
[B+
|
:
B+
Line
R298
~t
ol
.
:B-
Line
P Te iit ot tt [STANDBY BOARD] | EB ,
é
caz0
*
Voltage
and
waveforms
are
de
with
respect
to
ground
under
N . nye
ae
EB
2
BHA
O84?
I
Plen
no-signal
(
detuned
)
conditions.
ae x 5.5 iC950 no mark: FM
Rébb
|
1
2 = | zI8 = STANBBY eae cNS802 [cssse eer ( ): AM
esta Ov 2 = s R956 C953 C954 toh T}e- . ;
penser e Te = Raa 2 2 S| Oe AV 2810 1152 bel ab AC + Voltages are taken with a VOM ( Input impedance 10M 2 ).
1 10402 Bes Dis HEAOS | S82 0e: PERO asa = ce oe fered at ae Voltage variations may be noted due to normal production
[us [cna [us [cna | cgse
P | EQ AMP ri | 2.2] 4.7 | 2.2 —|a}ro|+ N bad Bd cd ed dD SInIN| Oe 8611 11ES2 heal Eb tolerances.
4g
.
.
wins
-l|-
—jepel=
NINT
NIN
Sov.
ft
@)
&
es a: ee at eee — = B14 1NG148M al
~
tolerances.
* Circled numbers refer to waveforms.
§.CE (7822, 72130) C.CE (Lvtatt) AUTO-STOP STEREQ PLL BATA OUT SP-RY
BRIDGE
5.CLOCK S.DATA SURR-RY POWER-RY SIGNAL
IC MUTE
F.MUTE TUNER-MUTE PROTECT IN STOP +5.6V
=> :FM
* Abbreviation
CND: Canadian
—
SS
a
ee
lo
:
AY
¢-
Waveforms
are
taken
with
a
oscilloscope.
CNS204
.
an
|
ee
pee
:
5
CNPSO4
Voltage
variations
may
be
noted
due
to
normal
production
AC
IN
(CHASSIS)
A
T902
POWER
:
:
I
TRANSFORMER
Signal
path.
NILSIN
peje
DISPLAY BOARS
(CNS201)
Se
—
14
—
—
15
—
—
16
—

STR-D350Z/D4502Z/DE405/DE505
e WAVEFORM ® IC BLOCK DIAGRAM — DISPLAY SECTION — Note :
1C202 BA6208 * All capacitors are in uy F unless otherwise noted. pF: yw uw F - Voltages are taken with a VOM ( Input impedance 10M Q ).
50WV or less are not indicated except for electrolytics and Voltage variations may be noted due to normal production
tantalums. tolerances.
+ All resistors are in Q and %W or less unless otherwise + Waveforms are taken with a oscilloscope.
specified. Voltage variations may be noted due to normal production
* A: internal component. tolerances.
7 : : * Circled numbers refer to waveforms.
e
IC
BLOCK
DIAGRAMS
—
MAIN
SECTION
—
:
B+
Line
~/Sianeiigath
° [B-—] :B- Line
4.19MHz ; => :FM
1C251
NJM2279D
IC300
LV1011
*
Voltage
and
waveforms
are
dc
with
respect
to
ground
under
no-signal ( detuned ) conditions.
IC201 @ geen, (4S) © (3) eee
2
5
5
=
2
4
3)
rit av = = =
z Zz
= Lom}
3-4. SCHEMATIC DIAGRAM (DISPLAY SECTION)
1
2
3
4
5
6
7 8 9
10
11
12
13
14
15
16 17
18
19
A SS Sf A Li TS tS |e __ eS tt
[DISPLAY
BOARD]
(TONE
BOARD
]
sebeBiOA ve 9287 NT
(¥) (BASS BOOST] =
[1203] C203 acre aoa Sie $238 Soe
(8)
L-HIx-0uT
SIRCS
Bad
bal
:
on
MEMORY
C) S&S © ©
(15)
R-M1X-0UT
oP
ERK
FL201
e
e
B
es
(13) s-out LO} te R238 R239 R240 R241
236 R237
ec ee ae ee 4 15k ong 22k nd
> $230 ‘ $231 4° $232 qe $233 4° $234 4° $235 d- $236
TUNING PRESET
MEMORY
io (4
pp — $10 co
KHz -S1) fr
ie] ic
MHz = -S12
PRESET | [TUNING -} | PRESET SHIFT FMZAM FM MODE} [BASS BOOST
TUNING —- TUNING +
RV422
1C301 LA2785 1C401 LC7822 aves 7
ie
a)
0 l
I
r
1
3.4
9231
BAIF4M
LEB @RIVE
VOLUME BOAR
E i CNP401
t
x
Ss ely
8233 8234 8235 2236 2237 x a
£NS201 VIseo] [TV7SB5] PROLOGIC) [HEATER] [HALL ' 3
RAS CLK IN I
ROS BATA IN $201 $202 $203 $204 i, $205
F sw (12V) a a: Ray
SW (RY) | 24 | : Hy ; BELAY TIME
ee ——— 5.BATR 7 SL_| 5, SUREGT ||_verrecr
oh PLL. BATA 1C201] rerio mre ion 22 a ie jess
8.cE (C7288) me BASS BOOST 8
SCE CVO ae +5V REAR
BRIAGE | 19 | VERSION LEVEL+
8. CLOCK 18 | PROTECT POWER SW oe
S. BATA BRIDGE SIRCS
abies [PHONO]
G PLL BATA IN | 16 | RESET vss [PHONG] I
§.CE (7822, 72130) 15 | AUTO-STOP STOP Alou ara
. euaeae $.CE (LV1010) STEREO-IN RBS. CLK. IN =:
& AUTO STOP | 13 | AVSS RBS. BATA. IN CENTER
z STEREO IN Ea SP-RY SYS. POWER ae
4 SP-RY Ea SURR-RY STANDBY
oe 2.
SURR-RY | 10 | POWER-RY w sr I
H POWER-RY Es BOWN Z 5 x:
SIGNAL re | z Z| TONER
IC. MUTE Ee o oe
F.MUTE Ea
TUNER MUTE sy
PROTECT IN | 4 | I
=x Sa Caee
I a et {1 i a! Pao 2
=a =
IC950 NJM2103D | (as ee ee 2 ee eee a
i
4.7 u . ee ee
0202
BAIF4M
u
Mw
u
“
R216
| J 9201, 202 22k
SYSTEM RESET
J 1
: :
I
CNS202
K
NB
|
4
|
S
i 5 3 [C202
(B) VOL. UP | 3 | 3
VOLUME
BOARS
VOL.80WN
|
2
|
5
VOLUME
MOTOR
Low Boost | 1 | = CONYROL |
02
cod ae == 10 S19 20

STR-D3502Z/D4502Z/DE405/DE505
3-5. PRINTED WIRING BOARDS (DISPLAY SECTION)
Pie MeO i nO Oe ee ee NO I A i
[TONE BOARD]
[DISPLAY BOARD]
Te
o
& |
ros
5 " ee Soo oe Ses Seon - bo
B VOLUME BOARD
CNP202
S
Note:
VOLUME
BOARD
MAIN
BOARD
CNP4OI
CNS204
* O—-: parts extracted from the component side.
: Pattern on the side which is seen.
qa0g00m
O09
coal
2
ee
4
as
—
23
—

NOTE :
@ -XX, -X mean standardized parts, so they may
have some difference from the original one.
@ Items marked “ * are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
SECTION 4
EXPLODED VIEWS
@ The mechanical parts with no reference number
in the exploded views are not supplied.
@ Hardware (# mark) list and accessories and
packing materials are given in the last of this
parts list.
@ Abbreviation
The components identified by mark A\
or dotted line with mark A\ are critical
for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque A\ sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
CND : Canadian
4-1. FRONT PANEL SECTION
3 (including 4)
a ae 8
supplied with RV404
Ref.No. Part No. Description Remark Ref. No. Part No. Description Remark
1 4-980-639-01 KNOB (R14) 8 3-704-366-01 SCREW (CASE) (M3x8)
2 X-4946-873-1 KNOB (R48) ASSY roe A-4389-631-A DISPLAY BOARD, COMPLETE
3 X-4945-866-1 PANEL ASSY, FRONT (DE405) 10 1-765-343-11 WIRE (FLAT TYPE) (23 CORE)
3 X-4946-869-1 PANEL ASSY, FRONT (DESO5) 1 1-765-314-11 WIRE (FLAT TYPE) (7 CORE)
3 X-4947-050-1 PANEL ASSY, FRONT (D450Z) * 12 A-4389-633-A VOLUME BOARD, COMPLETE
3 X-4947-051-1 PANEL ASSY, FRONT (D350Z) 13 4-951-620-01 SCREW (2.6X8), +BVTP
4 4-980-109-01 BUTTON (P-M) * 14 A-4389-634-A TONE BOARD, COMPLETE
ae 4-921-941-01 CUSHION (FL) FL201 1-517-141-11 INDICATOR TUBE, FLUORESCENT
28 4-943-107-11 HOLDER (FL TUBE)
* 7 4-980-658-01 CASE (413226)

* * + * * * *
* * * * *
4-2. CHASSIS SECTION
T901
56
iw
Part No.
1-660-193-11
1-660-192-11
4-951-801-01
1-660-191-11
1-533-233-11
1-660-189-11
1-660-190-11
A-4389-632-A
4-924-098-31
4-812-134-00
3-905-609-01
3-703-244-00
4-980-646-01
4-980-646-11
4-980-646-61
4-980-646-71
4-980-647-01
4-980-647-11
4-980-647-51
4-980-647-61
1-660-195-11
not supplied
Description
SP SW (B) BOARD
SP SW (A) BOARD
BUTTON (S)
SP SW BOARD
HOLDER, FUSE
PRIMARY BOARD
SECONDARY BOARD
STANDBY BOARD, COMPLETE
HOLDER, PC BOARD
RIVET (DIA. 3.5), NYLON
SCREW (TRANSISTOR)
BUSHING (2104), CORD
PANEL, BACK (DES505:US)
PANEL, BACK (DE505:CND)
PANEL, BACK (D450Z:US)
PANEL, BACK (D450Z:CND)
PANEL, BACK (DE405:US)
PANEL, BACK (DE405:CND)
PANEL, BACK (D350Z:US)
PANEL, BACK (D350Z:CND)
VIDEO BOARD
Remark
Ref. No.
65
* 66
* 66
* 66
not supplied
The components identified by mark
A\ or dotted line with mark A\ are
critical for safety.
Replace only with part number
specified.
Part No.
1-769-908-1141
A-4364-908-A
A-4389-532-A
A-4389-640-A
A-4389-641-A
A-4390-701-A
X-4947-208-1
1-769-743-11
4-924-098-01
4-909-982-11
1-576-109-11
1-429-699-11
1-429-522-11
1-429-525-11
1-429-526-11
Les composants identifiés par une
marque A\ sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Remark
Description _
WIRE (FLAT TYPE) (9 CORE)
MAIN BOARD, COMPLETE (DE405:US)
MAIN BOARD, COMPLETE
(D350Z:CND/DE405:CND)
MAIN BOARD, COMPLETE
(D4502Z:US/DE505:US)
MAIN BOARD, COMPLETE
(D450Z:CND/DES05:CND)
MAIN BOARD, COMPLETE (D350Z:US)
FOOT ASSY (F50150S)
CORD, POWER
HOLDER, PC BOARD
SCREW, TAPPING
FUSE (5A/125V)
TRANSFORMER, POWER(D350Z:US/DE405:US)
TRANSFORMER, POWER
(D350Z:CND/DE405: CND)
TRANSFORMER, POWER(D450Z:US/DE505:US)
TRANSFORMER, POWER
(D450Z:CND/DESO05: CND)

NOTE :
®@ Due to standardization, replacements in the
parts list may be different from the parts speci-
fied in the diagrams or the components used on
the set.
@ -XX, -X mean standardized parts, so they may
have some difference from the original one.
@ RESISTORS
All resistors are in ohms
METAL : Metal-film resistor
METAL OXIDE :Metal oxide-film resistor
F : nonflammable
@ Items marked “ * ’are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
SECTION 5
ELECTRICAL PARTS LIST
@® SEMICONDUCTORS
In each case, u: p , for example :
uA... A... UPA... : pt PA...
uPB....: p PB...., uPC....: up PC....
uPD.... : uw PD....
@ CAPACITORS
uF : uF
@ COILS
uH: pH
@ Abbreviation
CND : Canadian
Ref. No. Part No. Description R
* A-4389-631-A DISPLAY BOARD, COMPLETE
* 4-921-941-01 CUSHION (FL)
* 4-943-107-11 HOLDER (FL TUBE)
< CAPACITOR >
C201 1-104-905-11 CAPACITOR 0.22F
C202 ~=1-164-159-11 CERAMIC 0.1uF
C203. = 1-124-465-00 ELECT 0.47uF 20%
C204 = 1-164-159-11. CERAMIC 0.1uF
C205 = 1-162-294-31 CERAMIC 0.001 uF 10%
C206 = 1-164-159-11 CERAMIC 0.1uF
C207 = 1-126-096-11 ELECT 10uF 20%
C208 = 1-162-294-31 CERAMIC 0.001 uF 10%
< CONNECTOR >
* CNS201 1-568-741-11 SOCKET, CONNECTOR 23P
CNS202 1-770-397-11 HOUSING, CONNECTOR(PC BOARD)4P
* CNS203 1-565-481-11 CONNECTOR, BOARD TO BOARD 5P
< DIODE >
D201 ~=8-719-987-63 DIODE 1N4148M
D202. ~=8-719-987-63 DIODE 1N4148M
D203 ~=8-719-987-63 DIODE 1N4148M
D204 ~=8-719-987-63 DIODE 1N4148M
D211 8-719-987-6383 DIODE 1N4148M
D212 = 8-719-987-63 DIODE 1N4148M
D213 = 8-719-987-63 DIODE 1N4148M
D214 = 8-719-987-6383 DIODE 1N4148M
D215 ~=8-719-987-63 DIODE 1N4148M
D231 = 8-719-987-6383 DIODE 1N4148M
D233 = 8-719-313-72 LED SEL3810A-CD (VIDEO)
D234 ~=8-719-313-72 LED SEL3810A-CD (TV/DBS)
D235 ~=—-8-719-313-72 LED SEL3810A-CD (PRO LOGIC)
D236 = 8-719-313-72 LED SEL3810A-CD (THEATER)
D237 = 8-719-313-72 LED SEL3810A-CD (HALL)
emark
5.5V
50V
50V
50V
50V
50V
35V
50V
Ref. No.
*
FL201
G900
10201
1C202
1C203
Q201
Q202
Q231
R200
R201
R202
R203
R204
R205
R207
R211
R212
R213
R214
R215
R216
R221
R222
R223
R224
R225
R226
Part No.
1-517-141-11
1-537-738-21
8-759-385-78
8-759-962-08
8-749-923-11
8-729-900-63
8-729-900-36
8-729-900-36
1-249-433-11
1-247-903-00
1-249-429-11
1-249-429-11
1-249-425-11
1-249-441-11
1-249-429-11
1-249-433-11
1-249-433-11
1-249-433-11
1-249-433-11
1-249-433-11
1-249-433-11
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
1-249-441-11
The components identified by mark A\
or dotted line with mark A\ are critical
for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque A\ sont critiques pour la
sécurité,
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Description Remark
< INDICATOR TUBE >
INDICATOR TUBE, FLUORESCENT
< TERMINAL, EARTH >
TERMINAL, EARTH
<IC>
IC uPD78044AGF-165-3B9
IC BA6208
IC GP1U58XB
< TRANSISTOR >
TRANSISTOR DTA124ES
TRANSISTOR DTC124ES
TRANSISTOR DTC124ES
< RESISTOR >
CARBON 22K 5% 1/4W
CARBON 1M 5% 1/4W
CARBON 10K 5% 1/4W
CARBON 10K 5% 1/4W
CARBON 4.7K 5% 1/4W
CARBON 100K 5% t/4W
CARBON 10K 5% 1/4W
CARBON 22K 5% 1/4W
CARBON 22K 5% 1/4W
CARBON 22K 5% t/4W
CARBON 22K 5% 1/4W
CARBON 22K 5% 1/4W
CARBON 22K 5% 1/4W
CARBON 100 5% 1/4W
CARBON 100 5% 1/4W
CARBON 100 5% 1/4W
CARBON 100 5% 1/4W
CARBON 100 5% 1/4W
CARBON 100K 5% 1/4W

Ref. No. Part No.
R227 = 1-249-441-11
R228 = 1-249-411-11
R229 = 1-249-407-11
R230 = 1-249-407-11
R231 1-249-427-11
R242 = 1-249-427-11
R741 1-247-753-11
R742 ~—- 1-247-753-11
R791 1-247-753-11
R792 = 1-247-753-11
$200 1-554-303-21
$201 1-554-303-21
$202 1-554-303-21
$203 1-554-303-21
$204 1-554-303-21
$205 = 1-554-303-21
$206 = 1-554-303-21
S207 = 1-554-303-21
$208 1-554-303-21
$209 1-554-303-21
$210 1-554-303-21
$211 1-554-303-21
$212 1-554-303-21
$213 1-554-303-21
$214 1-554-303-21
$215 = 1-554-303-21
$216 = 1-554-303-21
$217 1-554-303-21
$218 1-554-303-21
$219 1-554-303-21
$220 1-554-303-21
$221 1-554-303-21
$222 1-554-303-21
§223 1-554-303-21
$224 1-554-303-21
$225 1-554-303-21
X201 1-577-101-11
Description Remark
CARBON 100K 5% 1/4W
CARBON 330 5% 1/4W
CARBON 150 5% 1/4W
CARBON 150 5% 1/4W
CARBON 6.8K 5% 1/4W
CARBON 6.8K 5% 1/4W
CARBON 1.2K 5% 1/2W
CARBON 1.2K 5% 1/2W
CARBON 1.2K 5% 1/2W
CARBON 1.2K 5% 1/2W
< SWITCH >
SWITCH, TACTILE (POWER)
SWITCH, TACTILE (1 )
SWITCH, TACTILE (2 )
SWITCH, TACTILE (3)
SWITCH, TACTILE (DIRECT)
SWITCH, TACTILE (DELAY TIME/EFFECT)
SWITCH, TACTILE (4)
SWITCH, TACTILE (5 )
SWITCH, TACTILE (6 )
SWITCH, TACTILE (REAR LEVEL, -)
SWITCH, TACTILE (REAR LEVEL, +)
SWITCH, TACTILE (7 )
SWITCH, TACTILE (8 )
SWITCH, TACTILE (9)
SWITCH, TACTILE (0)
SWITCH, TACTILE (PHONO)
SWITCH, TACTILE (SURROUND, ON/OFF)
SWITCH, TACTILE (SURROUND, MODE)
SWITCH, TACTILE (CENTER MODE)
SWITCH, TACTILE (CENTER LEVEL, -)
SWITCH, TACTILE (CENTER LEVEL, +)
SWITCH, TACTILE (VIDEO)
SWITCH, TACTILE (TV/DBS)
SWITCH, TACTILE (TAPE/MD)
SWITCH, TACTILE (CD)
SWITCH, TACTILE (TUNER)
< VIBRATOR >
VIBRATOR, CERAMIC (4.19MHz)
Ref. No.
C302
- €303
C304
C305
C306
C307
C308
C309
C310
C314
C312
C313
C314
C316
C317
C318
C322
C323
C324
C325
C326
C327
C328
C329
C330
C331
C332
C333
C334
C335
C336
C337
C338
C339
C340
C341
C342
C343
DE405:CND)
DE505:US)
DE505:CND)
Part No. Description
A-4364-908-A MAIN BOARD, COMPLETE (DE405:US)
A-4389-532-A MAIN BOARD, COMPLETE (D350Z:CND/
A-4389-640-A MAIN BOARD, COMPLETE (D450Z:US/
A-4389-641-A MAIN BOARD, COMPLETE (D450Z:CND/
A-4390-701-A MAIN BOARD, COMPLETE (D350Z:US)
3-905-609-01 SCREW (TRANSISTOR)
4-812-134-00 RIVET (DIA. 3.5), NYLON
7-682-548-04 SCREW +BVTT 3X8 (S)
< CAPACITOR >
1-126-934-11. ELECT 220uF 20%
1-130-489-00 MYLAR 0.033uF 5%
1-137-365-11 FILM 0.0015uF 5%
1-130-489-00 MYLAR 0.033uF 5%
1-124-903-11 ELECT {uF 20%
1-126-964-11 ELECT 10uF 20%
1-126-964-11 ELECT 10uF 20%
1-162-291-31 CERAMIC 560PF 10%
1-126-962-11 ELECT 3.3uF 20%
4-124-925-11 ELECT 2.2UF 20%
1-126-934-11 ELECT 220uF 20%
4-126-934-11 ELECT 220uF 20%
1-136-165-00 FILM 0.1uF 5%
1-126-964-11 ELECT 10uF 20%
1-126-933-11 ELECT 100uF 20%
1-137-363-91 FILM 680PF 5%
1-126-962-11 ELECT 3.3uF 20%
1-136-173-00 FILM 0.47uF 5%
1-126-967-11 ELECT 47uF 20%
1-136-165-00 FILM 0.1uF 5%
1-136-165-00 FILM 0.tuF 5%
1-124-902-00 ELECT 0.47uF 20%
1-126-963-11 ELECT 4.7uF 20%
1-124-902-00 ELECT 0.47uF 20%
1-126-963-11 ELECT 4.7UF 20%
1-124-250-11 ELECT 0.15uF 20%
4-126-962-11 ELECT 3.3uF 20%
1-124-250-11 ELECT 0.15uF 20%
1-137-372-11 FILM 0.022uF 5%
1-136-161-00 FILM 0.047uF 5%
1-126-934-11 ELECT 220uF 20%
1-126-964-11 ELECT 10uF 20%
1-126-964-11 ELECT 10uF 20%
1-126-964-11 ELECT 10uF 20%
1-126-964-11 ELECT iOuF 20%
1-126-934-11 ELECT 220uUF 20%
{-126-962-11 ELECT 3.3uF 20%
4-126-962-11 ELECT 3.3uF 20%
Remark
16V
50V
50V
50V
50V
50V
50V
50V
50V
100V
16V
16V
50V
50V
16V
50V
50V
50V
16V
50V
S0V
50V
S0V
S0V
50V
50V
50V
50V
S0V
50V
16V
50V
50V
50V
50V
16V
50V
50V

Ref. No. Part No.
C344 = 1-136-165-C0
C345 ~=—- 1-136-165-00
C346 = 1-124-902-00
C347 =. 1-126-963-11
C348 =. 1-124-902-00
C349 = 1-126 -963-11
C350 = 1-124-250-11
C351 1-126-962-11
C352. 1-124-250-11
C353: 1-164-159-11
C354 = 1-164-159-11
C355 = 1-164-159-11
C356 ~—- 1- 164-159-11
C357 ~—s 1-164-159-11
C359 ~=—- 1-126 -963-11
C360 ~=—- 1-126 -963-11
C363: 1-164-159-11
C365 = 1-126-966-11
C366 =. 1-164-159-11
C401 1-162-282-31
C402 = 1-126 -962-11
C403 ~—s-: 1-126 -966-11
C404 =. 1-162-282-31
C405 ~=—s- 1-137-459-11
C406 = 1-164-159-11
C407 =. 1-137-365-11
C408 = 1-16 2-294-31
C409 ~—- 1-126 -962-11
C410 ~=—- 1-164-159-11
C412 = 1-162-291-31
C413 = 1-164-159-11
C415 ~—- 1-164-159-11
C416 = 1-164-159-11
C434 =. 1-162-286-31
C435 =. 1-162-286-31
0451 1-162-282-31
C452 = 1-126-962-11
C453 ~—s- 1-126-966-11
C454 = 1-162-282-31
C455 ~—s- 1-137-459-11
C457 = 1-137-365-11
C459 ~—s- 1-126-962-11
C460 ~=—- 1-164-159-11
C602 = 1-162-282-31
C603 ~=—- 1-126 -933-11
C605 ~=—- 1-102-233-00
C610 =: 1-126 -967-11
C611 1-137-372-11
C620 ~—- 1- 162-286-311
C652 ~—s 1-162-282-31
C653 ~—s- 1-126 -933-11
C655 ~—- 1-102-233-00
Description
FILM
FILM
ELECT
ELECT
ELECT
ELECT
ELECT
ELECT
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
FILM
CERAMIC
FILM
CERAMIC
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
ELECT:
CERAMIC
FILM
FILM
ELECT
CERAMIC
CERAMIC
ELECT
CERAMIC
ELECT
FILM
CERAMIC
CERAMIC
ELECT
CERAMIC
0.1uF
0.1uF
0.47uF
4.7uF
0.47uF
4.7uF
0.15uF
3.3uF
0.15uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
4.7uF
4.7uF
0.1uF
33uF
0.1uF
100PF
3.3uF
33uF
100PF
0.0056uF
0.1uF
0.0015uF
0.001uF
3.3uF
0.1uF
560PF
0.1uF
0.1uF
0.1uF
220PF
220PF
100PF
3.3uF
33uF
100PF
0.0056uF
0.0015uF
3.3uF
0.1uF
100PF
100uF
33PF
47uF
0.022uF
220PF
100PF
100uF
33PF
Remark
5%
5%
20%
20%
20%
20%
20%
20%
20%
20%
20%
20%
10%
20%
20%
10%
5%
5%
10%
20%
10%
10%
10%
10%
20%
20%
10%
5%
3%
20%
10%
20%
10%
20%
5%
10%
10%
20%
10%
50V
S0V
50V
50V
SOV
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
16V
50V
50V
50V
16V
50V
100V
50V
S0V
50V
50V
50V
50V
50V
S0V
S0V
SOV
50V
SOV
50V
16V
50V
100V
50V
d0V
50V
50V
10V
500V
16V
50V
50V
50V
10V
500V
Ref. No.
C660
C661
C670
C702
C703
C705
C710
C714
C720
C721
C722
C740
C744
C742
C752
C753
C755
C760
C761
C770
C801
C802
C803
C803
C803
C803
C804
C804
C804
C804
C805
C806
C807
C808
C809
C810
C811
C812
C813
C814
C815
C816
C820
C821
C822
Part No.
1-126-967-11
1-137-372-11
1-162-286-31
1-162-282-31
1-126-933-11
1-102-233-00
1-126-967-11
1-137-372-11
1-162-286-31
1-126-923-11
1-126-965-11
1-128-563-11
1-128-563-11
1-126-923-11
1-162-282-31
1-126-933-11
1-102-233-00
1-126-967-11
1-137-372-11
1-162-286-31
1-104-664-11
1-104-664-11
1-125-556-11
1-128-591-11
1-109-932-12
1-107-766-11
1-125-556-11
1-128-591-11
1-109-932-12
1-107-766-11
1-137-420-11
1-137-420-11
1-124-903-11
1-104-664-11
1-104-664-11
1-124-903-11
1-126-951-11
1-126-951-11
1-164-088-11
1-164-088-11
1-104-664-11
1-104-664-11
1-161-494-00
1-161-494-00
1-104-664-11
Description Remark
ELECT 47uF 20% 16V
FILM 0.022uF 5% SOV
CERAMIC 220PF 10% SOV
CERAMIC 100PF 10% SOV
ELECT 100uF 20% 10V
CERAMIC 33PF 10% S00V
ELECT 47uF 20% 16V
FILM 0.022uF 5% S0V
CERAMIC 220PF 10% SOV
ELECT 220uF 20% 10V
ELECT 22uF 20% 50V
ELECT 100uF 20% 100V
ELECT 100uF 20% 100V
ELECT 220uF 20% 10V
CERAMIC 100PF 10% 50V
ELECT 100uF 20% 10V
CERAMIC 33PF 10% S00V
ELECT 47uF 20% 16V
FILM 0.022uF 5% SOV
CERAMIC 220PF 10% SOV
ELECT 47uF 20% 25V
ELECT 47uF 20% 25V
ELECT(BLOCK) 8200uF 20% 56V
(D350Z:US)
ELECT 6800uF 20% S6V
(D350Z:CND/DE405:CND)
ELECT 10000uF = 20% 71V
(D4502Z:US/DES05:US)
ELECT 8200uF 20% 71V
(D4502:CND/DE405:US/DE505:CND)
ELECT(BLOCK) 8200uF 20% S6V
(D3502Z:US)
ELECT 6800uF 20% S6V
(D350Z:CND/DE405:CND)
ELECT 10000uF = =—20% =71V
(D4502:US/DE505:US)
ELECT 8200uF 20% 71V
(D450Z:CND/DE405:US/DES05:CND)
FILM 0.047uF 10% 100V
FILM 0.047uF 10% 100V
ELECT quF 20% SOV
ELECT 47uF 20% 25V
ELECT 47uF 20% 25V
ELECT TuF 20% 50V
ELECT 470uF 20% 35V
ELECT 470uF 20% 35V
CERAMIC 0.001 uF SOV
CERAMIC 0.001 uF 50V
ELECT A7uF 20% 25V
ELECT 47uF 20% 25V
CERAMIC 0.022uF 25V
CERAMIC 0.022uF 25V
ELECT 47uF 20% 25V

Ref. No.
C823
C950
C951
C952
C953
C954
C955
CNP702
CNP706
* CNS204
* CNS251
* CNS301
* CNS701
CNS802
D610
D710
D721
D722
D723
D724
D725
D801
D802
D804
D805
D810
D811
D812
D813
D814
D815
D817
D818
D820
D821
D822
D823
* G200
* G201
* G202
1C300
IC301
10302
10401
Part No.
1-104-664-11
1-126-952-11
1-164-097-11
1-124-903-11
1-124-464-11.
1-126-964-11
1-164-159-11
1-750-388-11
1-764-477-11
1-568-742-11
1-568-439-1 1
1-568-442-11
1-568-439-11
1-766-200-11
8-719-987-63
8-719-987-63
8-719-815-85
8-719-815-85
8-719-987-63
8-719-987-63
8-719-987-63
8-719-002-33
8-719-302-38
8-719-010-38
8-719-002-33
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
8-719-987-63
8-719-987-63
8-719-001-30
8-719-987-63
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
1-537-738-21
1-537-738-21
1-537-738-21
8-759-341-23
8-759-248-74
8-759-636-74
8-759-805-14
Description Remark
ELECT 47uF 20% 25V
ELECT 1000uF 20% 16V
CERAMIC 0.022uF 50V
ELECT 1uF 20% 50V
ELECT 0.22uF 20% 50V
ELECT 10uF 20% 50V
CERAMIC 0.1uF 50V
< CONNECTOR >
PIN, CONNECTOR 5P
PIN, CONNECTOR (PC BOARD) 8P
SOCKET, CONNECTOR 23P
SOCKET, CONNECTOR 7P
SOCKET, CONNECTOR 9P
SOCKET, CONNECTOR 7P
SOCKET, CONNECTOR PIN 5P
< DIODE >
DIODE
DIODE
DIODE
DIODE
DIODE
1N4148M
1N4148M
181585
181585
1N4148M
DIODE
DIODE
DIODE
DIODE
DIODE
1N4148M
1N4148M
UZL-24L
RBV-602-01
UZ-5.1BSB
DIODE
DIODE
DIODE
DIODE
DIODE
UZL-24L
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
DIODE
DIODE
DIODE
DIODE
DIODE
1N4148M
1N4148M
UZL-9H3
1N4148M
11ES2-NTA2B
DIODE
DIODE
DIODE
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
< TERMINAL, EARTH >
TERMINAL, EARTH
TERMINAL, EARTH
TERMINAL, EARTH
<IC>
iC LV1014
iC LA2785
IC M5218AP-22
IC LC7822
Ref. No.
1C402
1C701
C702
1C801
1C802
1C950
J401
J402
J403
L301
L302
L401
L601
L651
L701
L751
Q303
Q304
Q307
Q308
Q601
Q602
Q603
Q604
Q610
Q620
Q651
Q652
Q653
Q654
Q670
Q701
Q702
Q703
Q704
Q710
Q720
Q721
Q722
Q723
Q740
Q741
Q751
Q752
Q753
Q754
Part No.
8-759-636-74
8-759-326-52
8-759-326-52
8-759-287-58
8-759-604-45
8-759-333-83
1-695-188-31
1-770-015-11
1-573-028-31
1-410-509-11
1-410-509-11
1-410-509-11
1-420-872-00
1-420-872-00
1-420-872-00
1-420-872-00
8-729-922-37
8-729-922-37
8-729-922-37
8-729-922-37
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-119-78
8-729-140-82
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-140-82
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
8-729-119-78
8-729-140-82
8-729-140-82
8-729-140-84
8-729-119-78
8-729-140-84
8-729-140-84
8-729-119-76
8-729-141-30
8-749-010-25
8-749-010-26
Description
IC M5218AP-22
Remark
IC uPC2581V
IC uPC2581V
iC TA78M12P
(C M5F79M12
IC NJM2103D
< JACK >
JACK, PIN 4P (PHONO,CD)
JACK, PIN 6P (TAPE/MD,TV/DBS)
JACK, PIN 4P (VIDEO)
< COIL >
INDUCTOR
INDUCTOR
INDUCTOR
COIL, AIR-CORE
COIL, AIR-CORE
10uH
10uH
10uH
COIL, AIR-CORE
COIL, AIR-CORE
< TRANSISTOR >
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
28021448
28D2144S
28D2144S
28D2144S
2SA1175-HFE
TRANSISTOR 2SC3623A-LK
IC MN2488-OPY-M
IC MP1620-OPY-M
TRANSISTOR 2SC403SP-51
TRANSISTOR 2SA988-PAFAEA
TRANSISTOR 2SA1175-HFE
TRANSISTOR 2SC3623A-LK
iC MN2488-OPY-M
iC MP1620-OPY-M
TRANSISTOR 2SA988-PAFAEA
TRANSISTOR 2SA1175-HFE
TRANSISTOR 2SC3623A-LK
IC MN2488-OPY-M
IC MP1620-OPY-M
TRANSISTOR 2SC403SP-51
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA988-PAFAEA
2SA988-PAFAEA
2801841-PAFAEA
280403SP-51
2501841-PAFAEA
TRANSISTOR 25C1841-PAFAEA
TRANSISTOR = 2SA1175-HFE
TRANSISTOR 25C3623A-LK
IC MN2488-OPY-M
IC MP1620-OPY-M

Ref. No.
Q770
Q801
Q802
Q803
Q808
Q809
Q951
A R298
A R298
A, R298
AX R299
A, R299
Ay R299
R300
R301
R302
R303
R304
R306
R307
R308
R309
R352
R353
R354
R355
R356
R357
R358
R359
R360
R361
R362
R363
R401
R402
R403
R404
R405
R406
R407
R408
R409
R410
R411
Part No.
8-729-140-82
8-729-140-97
8-729-119-78
8-729-030-18
8-729-180-92
8-729-119-78
8-729-030-18
1-249-381-11
1-249-385-11
1-249-389-11
1-249-381-11
1-249-385-11
1-249-389-11
1-247-903-00
1-249-421-11
1-249-421-11
1-249-439-1 1
1-249-441-11
1-249-436-11
1-247-862-11
1-249-421-11
1-249-421-11
1-249-441-11
1-249-425-11
1-249-425-11
1-249-425-11
1-249-425-11
1-249-441-11
1-249-441-11
1-249-425-11
1-249-425-11
1-249-429-11
1-249-429-11
1-249-411-11
1-249-411-11
1-249-421-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-429-11
1-249-437-11
1-247-897-11
1-249-416-11
Description
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
< RESISTOR >
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
Remark
2SA988-PAFAEA
2SB7 34-34
2S8C403SP-51
28D2525
2SD809-K
2S80403SP-51
28D2525
1 5% 1/4W F
(D350Z:US/DE405:US)
2.2 5% 1/6W F
(CND)
47 5% 1/4W F
(D450Z:US/DE505:US)
1 5% 1/4W F
(D350Z:US/DE405:US)
2.2 5% 1/6W F
(CND)
47 5% 1/4W F
(D450Z:US/DE505:US)
1M 5% 1/4W
2.2K 5% 1t/4W
2.2K 5% 1/4W
68K 5% 1/4W
100K 5% 1/4W
39K 5% 1/4W
20K 5% 1/4W
2.2K 5% 1/4W
2.2K 5% 1/4W
100K 5% 1/4W
4.7K 5% 1/4W
4.7K 5% i1/4W
4.7K 5% 1/4W
4.7K 5% 1/4W
100K 5% 1/4W
100K 5% 1/4W
4.7K 5% 1/4W
4.7K 5% 1/4W
10K 5% 1/4W
10K 5% 1/4W
330 5% 1/4W
330 5% 1/4W
2.2K 5% 1/4W
1K 5% 1/4W
1K 5% 1/4W
1K 5% 1/4W
1K 5% 1/4W
1K 5% 1/4W
10K 5% 1/4W
47K 5% 1/4W
560K 5% 1/4W
820 5% 1/4W
Ref. No.
R412
R413
R414
R415
R416
R417
R420
R435
R442
R443
R447
R448
R449
R451
R452
R453
R454
R455
R456
R457
R458
R459
R460
R461
R462
R463
R465
R466
R467
R470
R601
R602
R603
R603
R604
R610
R611
R613
A, R614
A, R615
AX R616
ZN R617
R618
R620
R621
R623
R630
R631
Part No.
1-247-897-11
1-249-437-11
1-249-425-11
1-249-417-11
1-249-417-11
1-247-897-11
1-249-441-11
1-249-418-11
1-249-418-11
1-249-418-11
1-249-416-11
1-249-429-11
1-249-433-11
1-249-411-11
1-249-421-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-429-11
1-249-437-11
1-247-897-11
1-249-416-11
1-247-897-11
1-249-437-11
1-249-417-11
1-249-417-11
1-247-897-11
1-249-441-11
1-249-417-11
1-249-439-11
1-249-413-11
1-249-412-11
1-249-439-11
1-249-421-11
1-249-437-11
1-249-414-11
1-249-408-11
1-249-408-11
1-233-352-21
1-249-393-11
1-249-389-11
1-249-419-11
1-249-427-11
1-249-437-11
1-249-426-11
1-247-887-00
Description Remark
CARBON 560K 5% 1/4W
CARBON 47K 5% 1/4W
CARBON 4.7K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 560K 5% 1/4W
CARBON 100K 5% 1/4W
CARBON 1.2K 5% 1/4W
CARBON 1.2K 5% 1/4W
CARBON 1.2K 5% 1/4W
CARBON 820 5% 1/4W
CARBON 10K 5% 1/4W
CARBON 22K 5% 1/4W
CARBON 330 5% 1/4W
CARBON 2.2K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 10K 5% 1/4W
CARBON 47K 5% 1/4W
CARBON 560K 5% 1/4W
CARBON 820 5% 1/4W
CARBON 560K 5% 1/4W
CARBON 47K 5% i1/4W
CARBON 1K 5% 1/4W
CARBON 1K 5% 1/4W
CARBON 560K 5% 1/4W
CARBON 100K 5% i1/4W
CARBON 1K 5% 1/4W
CARBON 68K 5% 1/4W
CARBON 470 5% 1/4W
(D3502Z/DE405:CND)
CARBON 390 5% 1/4W
(D450Z/DE405:US/DE505)
CARBON 68K 5% 1/4W
CARBON 2.2K 5% 1/4W
CARBON 47K 5% 1/4W
CARBON 560 5% %1/4W
CARBON 180 5% 1/4W F
CARBON 180 5% 1/4W F
ENCAPSULATED COMPONENT F
CARBON 10 5% 1/4W F
CARBON 4.7 5% 1/4W
CARBON 1.5K 5% 1/4W
CARBON 6.8K 5% 1/4W
CARBON 47K 5% 1/4W
CARBON 5.6K 5% 1/4W
CARBON 220K 5% 1/4W
(D450Z/DE505)
The components identified by mark
AX or dotted line with mark A\ are
critical for safety.
Replace only with part number
specified.
30 —
Les composants identifiés par une
marque A\ sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.

Ref.
No.
Part
No.
Description
Remark
Ref.
No.
Part
No.
Description
Remark
R632
1-249-426-11
CARBON
5.6K
5%
1/4W
R751
~=—-1-249-417-11
CARBON
1K
5%
1/4W
R651.
~—s«-
1-249-417-11
CARBON
1K
5%
1/4W
R752
~=—-1-249-439-11
CARBON
68K
5%
1/4W
R652
~=1-249-439-11
CARBON
68K
5%
1/4W
R653.
~—«-1-249-413-11
CARBON
470
5%
1/4W
R753.
~—«-
1-249-413-11
CARBON
470
5%
1/4W
(D350Z/DE405:CND) (D350Z/DE405:CND)
R753 =: 1-249-412-11 CARBON 390 5% 1/4W
R653.
~=—«-1-249-412-11
CARBON
390
5%
1/4W
(D450Z/DE405:US/DE505)
(D4502Z/DE405:US/DE505)
R754
~—-1-249-439-11
CARBON
68K
5%
1/4W
R654
~=—-
1-249-439-11
CARBON
68K
5%
1/4W R760
=
1-249-421-11
CARBON
2.2K
5%
1/4W
R660
=—1-249-421-11
CARBON
2.2K
5%
1/4W
R761
~—-1-249-437-11
CARBON
47K
5%
1/4W
R661 ~=1-249-437-11 CARBON 47K 5% 1/4W
R663
=
1-249-414-11
CARBON
560
5%
1/4W
R763
=
1-249-414-11
CARBON
560
5%
1/4W
A\ R764 —-1-249-408-11 CARBON 180 5% 1/4W F
A,
R664
=:
1-249-408-11
CARBON
180
5%
1/4W
F
|
A
R765
1-249-408-11
CARBON
180
5%
1/4W
F
A.
R665
~—-
1-249-408-11
CARBON
180
5%
1/4W
F
|
A
R766
1-233-352-21
ENCAPSULATED
COMPONENT
F
Ay
R666
~—-
1-233-352-21
ENCAPSULATED
COMPONENT
F
|
A
R767
~—-1-249-393-11
CARBON
10
5%
1/4W
F
A\ R667 ~—s- 1-249-393-11 CARBON 10 5% 1/4W F
R668
1-249-389-11
CARBON
4.7
5%
1/4W
R768
1-249-389-11
CARBON
47
5%
1/4W
R770 ~—-1-249-419-11 CARBON 1.5K 5% 1/4W
R670
~=—-
1-249-419-11
CARBON
1.5K
5%
1/4W
R771
~—-1-249-427-11
CARBON
6.8K
5%
i/4W
R671
~—«-1-249-427-11
CARBON
6.8K
5%
1/4W
R773.
1-249-437-11
CARBON
47K
5%
1/4W
R673
~=—-
1-249-437-11
CARBON
47K
5%
1/4W
R781
1-247-887-00
CARBON
220K
5%
1/4W
R701
=
1-249-417-11
CARBON
1K
5%
1/4W
(D450Z/DE505)
R702 1-249-439-11 CARBON 68K 5% 1/4W
ZA. R803. =: 1-247-739-11 CARBON 100 5% 1/2W F
R703
=
1-249-413-11
CARBON
470
5%
1/4W
R804
~—-
1-249-425-11
CARBON
4.7K
5%
1/4W
(D350Z/DE405:CND) | A\ R806 = 1-247-739-11 CARBON 100 5% 1/2W F
R703 = 1-249-412-11 CARBON 390 5% 1/4W
(D450Z/DE405:US/DE505) R807 =1-249-425-11 CARBON 4.7K 5% 1/4W
R704
=
1-249-439-11
CARBON
68K
5%
1/4W
R821
=
1-249-437-11
CARBON
47K
5%
1/4W
R710
1-249-421-11
CARBON
2.2K
5%
1/4W
R822
1-249-425-11
CARBON
4.7K
5%
1/4W
R711
=
1-249-437-11
CARBON
47K
5%
1/4W
R823
1-249-437-11
CARBON
47K
5%
1/4W
R824 ~=1-249-425-11 CARBON 4.7K 5% 1/4W
R713. 1-249-414-11 CARBON 560 5% 1/4W
A,
R714
~—-1-249-408-11
CARBON
180
5%
1/4W
F
R825
~=—«-1-249-407-11
CARBON
150
5%
1/4W
A.
R715
~—-1-249-408-11
CARBON
180
5%
1/4W
F
R950
=1-249-421-11
CARBON
2.2K
5%
1/4W
4“.
R716
~—-1-233-352-21
ENCAPSULATED
COMPONENT
F
R951
~—«-
1-249-429-11
CARBON
10K
5%
1/4W
A,
R717.
~—-
1-249-393-11
CARBON
10
5%
1/4W
F
R952.
~=—«-
1-249-423-11
CARBON
3.3K
5%
1/4W
R953 ~—s- 1-249-433-11 CARBON 22K 5% 1/4W
R718 1-249-389-11 CARBON 4.7 5% 1/4W
R720
=1-249-419-11
CARBON
1.5K
5%
1/4W
R954
=
1-249-439-11
CARBON
68K
5%
1/4W
R721
1-249-427-11
CARBON
6.8K
5%
1/4W
R955
~—-
1-249-429-11
CARBON
10K
5%
1/4W
R722
1-249-431-11
CARBON
15K
5%
1/4W
R956
~—«-
1-249-423-11
CARBON
3.3K
5%
1/4W
R723
=
1-249-437-11
CARBON
47K
5%
1/4W
R957.
~—s-
1-249-417-11
CARBON
1K
5%
1/4W
R958 1-249-401-11 CARBON 47 5% 1/4W
R724 1-249-429-11 CARBON 10K 5% 1/4W
R725
=
1-249-429-11
CARBON
10K
5%
1/4W
R960
1-249-429-11
CARBON
10K
5%
1/4W
R726 = 1-249-417-11 CARBON 1K 5% 1/4W
R727 ~—-1-249-427-11 CARBON 6.8K 5% i1/4W < RELAY >
R730 1-249-429-11 CARBON 10K 5% 1/4W
RY601 1-515-920-11 RELAY (24V)
R731: 1-247-887-00 CARBON 220K 5% 1/4W RY701 1-515-920-11 RELAY (24V)
(D450Z/DE505) RY801 1-515-894-11 RELAY (US)
R734 = 1-249-429-11 CARBON 10K 5% 1/4W RY851 1-515-918-11 RELAY (CND)
(D450Z/DE505) RY852 1-515-918-11 RELAY (CND)
A, R740 ~~ 1-249-393-11 CARBON 10 5% 1/4W F
A, R741 ~—s-1-249-393-11. CARBON 10 5% 1/4W F < TERMINAL >
R742 1-249-417-11 CARBON 1K 5% 1/4W
TM1 1-537-240-51 TERMINAL BOARD (CHECKER PIN) (ANTENNA)
R743 = 1-249-417-11 CARBON 1K 5% 1/4W TM601 1-537-510-11 TERMINAL BOARD (SPEAKER) (6P)
R744 ~—-1-249-425-11 CARBON 4.7K 5% 1/4W (SURROUND SPEAKER)
R745 = 1-249-435-11 CARBON 33K 5% 1/4W TM701 1-537-376-11 TERMINAL BOARD (SP) (FRONT SPEAKER)
The components identified by mark
A\ or dotted line with mark A\ are
critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque A\ sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.