SpaDealers Pioneer Wood User manual

















































PIONEER 25 kW WOOD HEATER
MANUAL
Marketing:
SpaDealers
Korsnäs - FINLAND
[phone]
[email protected]
www.spadealers.eu
WARNING

Donottouchhotparts(chimneypipe,fireboxandhatch).Carefullyread
throughthemanualfortheheater.

Ignitionandusage:

Heatermustbeundersupervisionwhenitisinuse.Keepchildrenawayfrom
heater.
Placedrypapersuchasnewspaperonthebottom.
Usedrywood,40‐43cmlongandsplittoabout4x4cmthickness.
Don’tburnplasticoritemscontainingsulphurorsalt.
Donotleanagainstthepartwherethewarmwaterentersthetub
Readthetechnicaldescriptionsbeforeinstallingtheheater
Readthemanualbeforestartingtheheater
Improperuseoftheheatercanbedangerous
Theheaterschimneypipesandfiredoorcanbecomeveryhotduringuse.
Neverusedampwoodasitdrasticallyreducesefficiency.
Donotdrainthehottubandheaterbeforeallthewoodhasburnedoutand
theembershavefaded.
Followproductinstructionswhenusingchemicals.

USEDRYWOOD!
Thestoveisoptimizedtoprovideagoodenergyyieldwhendrywoodisusedasfuel.Itwillalsodecrease
fuelconsumption.Fortheheatertoworkefficiently,thewoodmustbedry.Thisisalsomentionedinthe
manual.Woodcontaininghighlevelsofmoisturecausespoordraftandcombustion.Moisturecanalso
begintoleakoutfromthestove’sfrontedge.

Evenasinglesessionwithsuchwoodcanresultinacoatingontheinnersurfacewhichextendsheating
time.Unlessthesurfaceiscleaned,thecoatingwillincreaseandfurtherreducetheheatersefficiencyand
prolongtheheatingtimesignificantly.Thepicturesshowwhatitcanstarttolooklike.Itcaneasilyextend
theheatingtimebyhalforevenlonger.

Theimagesshowadifferentstovemodel,buttheresultisthesame.


PioneerWood(HWPPE120)
PioneerWoodisfiredwithwoodandconnectedtoahottubon
theoutside.Fortheheaterchimneypipesandchimneytopfor
effectiveremovalofsparkscanbeboughtseparately.Needvaries
basedonlocation.

Wood‐burningwaterheater

Thisisaprecisionbuiltwaterheater,especiallydesignedforhot
tubs.Thewaterisself‐circulatingthroughthe"thermosiphon
principle"(hotwaterrisesandcreateslowpressure,whichsucks
waterfrombelow).

Iteliminatestheneedforacirculatingpumpandelectricity,
makingitpossibletoheatthewaterinahottubwiththeheater
placedexternally.Abigadvantageisthattherewillbemorespace
inthetub,whichinturnmeansasmallermodelcanbeselected.

ThematerialisaluminumAL5052whichhasverygoodcorrosionresistance,especiallyinmarineconditions.Italso
hasexcellentthermalconductivity.Rust(3)andgaps(2.6)ismadeofstainlesssteel.Thisensuresyearsoftrouble
freeuse.Thestovemustbeemptiedofwateraftereachuse.

Theheatfromthefireisefficientlytransferredtothewaterthroughauniqueandsophisticateddesignthatmakes
thewholefireboxaheattransferringsurface.Thenominalheatoutputisapprox.25kW.



INSTALLATION
PioneerWoodisconnectedtoahottubusinga
connectionkit(includedincompletehottub
packages).Thekitisnotsuppliedwiththe
purchaseofonlythestovebutcanbeordered
separately.Installaccordingtoinstructionsbelow
iftheconnectionpipeisofSpaDelers
manufacture.
Thestoveisplacedonasurfacemadefromwood,
brickorcement.Letitstandalittlehigheratthe
reartopreventairpocketformationthatcan
disruptthecirculationandcausedamagetothe
stove.
1. Fortheupperconnectionpipe(outlet),
drilla60mmholeinthesideofthehot
tub,approx.6cmhigherthantheupper
outletofthestove.Inthebottomofthe
oppositesideofthehottub,makea
similarholefortheinletwatertothe
stove.(NOTE:Foranassembledhottubkit
thisstepandstep2arealreadymade)
2. Theskewedbushingisthenscrewedintotheside.Thecurvedbushingisscrewedintothebottom.
3. Therubberpipesareattachedbetweenthestoveandpipesfromthehottub.Ifthetubesarelubricated(for
instance,cookingoil),itiseasiertoassemble.Fastenwiththeincludedclamps.
4. Inordertoobtaingoodwatercirculationthetoppipeshouldslopeupwardsapprox.15°.
WINTERUSAGE
Ifthereisariskoffreezingdamagethentheheatermustbedrainedofwaterafteruse.Self‐circulationwillcease
whenthewoodhasburntoutandthesmallamountofwaterremainingintheheatercaneasilyfreezeandcause
damagetotheheater.Tokeepthewaterinthehottubthereisarubberplugcompletewithaccessories.Seeimages
below.Ifelectricityisavailablethenafreezingguardcanbeinstalledintheheatersfireboxtoavoidfreezing
damageswhenit’snotinuse.Upperandlowerconnectionpipesmustthenbeinsulated.










Function
PioneerWoodfunctionsasaconventionalwoodstove.Thefireboxis43cmlongand3cmindiameter.Maximum
effectisachievedbyusingdrywood(lessthan15%moisture),40‐42cmlongandsplitintosmallerparts.Aload
burnsforapprox.20‐30minutes.Neveruseacidicwoodasitreducestheeffectivenessconsiderablyandmaycause
heavydepositsonthestove'sheattransfersurface.Alsoavoidalderwood.Controllingthedraftandheatingeffectis
donebyregulatingthelowerdraftdoor.Forfastheating,openabout10cmandkeepitclosedtomaintain
temperatureoncethewaterishot.


Construction
Thestoveisdesignedtositonafirmandlevelsurface.Neverplaceitinsandoronsoftgroundasitcausesair
pocketsthatpreventcirculationanddamagetothestovewillresult.Ifthestoveisinstalledwithapump(egpool),
theconnectionmustbeequippedwithanadjustabletaponthe"suctionside"thatmakesitpossibletoregulatethe
waterflowandpressure.Highflowandpressurecandamagethestove.Settheregulatorsothatthehotwaterfrom
thestoveisbetween60‐70degreescelcius.

Properties

•Weatherproofdesign
•StoveinaluminumAl5052
•Gratesandhatchesinstainlesssteel
•Largeeffect
•Largefirebox


1. Aluminum
2. Ashtray
3. Grate
4. Hatch


Specifications

•Dimensions:60cm(height)x58cm(length)
x37cm(width)
•Weight:24kg
•Firebox:42x27x28cm
•Heatingsurface:1m²

Heating
Theheatingeffectvariesdependingonthequalityofthefire
woodandhowoftentheheaterisrefilled.ThenominaloutputofPioneerWoodis25kW.


ModelWateramount Startingtemperature Approximateheatingtimeto35°C
HT150 1200L 5°C About3hours


TIP!Theheaterhasalargeexteriorsurfacethat'sindirectcontactwiththeair,thereforeitcouldbegoodtoinsulate
theoutsideorplaceitinaninsulatedbox.Theheatingtimeinthewintercanthenbesignificantlyreduced.
















2
3
1
1. Chimneytop
2. Chimneypipe
3. Pioneer25kw