SPEC-D Tuning LHP-JET99JM-8-TM User manual

*If you experience any difficulties that the instruction did not cover, Please seek local auto shop for advise.
*
Please wear protection before you work on your vehicle.
*An assistant is helpful when removing the front bumper.
*Please be careful while working with the bumper or body part to avoid scratching.
*
Do not make direct contact with the halogen bulb or the wire assembly until the unit has cooled down after use
.
WWW.SPECDTUNING.COM
1999-2004VOLKSWAGENJETTAPROJECTORHEADLIGHTS
LHP-JET99JM-8-TM
LHP-JET99-8-TM
INSTALLATION INSTRUCTIONS
3/8” Drive Ratchet
¼” Drive Ratchet
T30 Socket
T25 Socket
6” Long 3/8” Drive Extension
6” Long ¼” Drive Extension
Phillips Screwdriver
Flathead Screwdriver
TOOLS AND SUPPLIES REQUIRED

5. After you pull the grille up, it should look the same as the
picture shown above
9. There are two bolts underneath the fender that needs to
be removed also
6. There are two clips that needs to be removed
7. Remove the top clip 8. Then remove the bottom clip
10. Remove the bolts from the fog light opening
WWW.SPECDTUNING.COM
p2

11. Gently pull out the bumper slightly, just enough to see
the bottom of the headlight
12. After you pull the bumper slightly, it should look the same
as the picture shown above
13. Use a flat tip screwdriver to disconnect the connector from
headlight and vehcile
bolts
14. Remove the two bolts on top of the headlight
16. After removing the headlight, it should look the same as
the picture shown above
15. Gently pull out the headlight
WWW.SPECDTUNING.COM
p3

17. Connect the connector with thr headlight
18. Gently install the projector headlight to its original spot
and install the bolts to fasten the headlight
19. Install the bolts below the headlight between the bumper 20. Gently put the bumper to its original position
22. Install the bolts underneath the fender21. Install the bolts to the fog light opening
please see the “Halo and L.E.D. installation instructions”
If your headlights don’t have HALO or L.E.D. You can skip the
installation instructions.
WWW.SPECDTUNING.COM
p4