Square Scrub EBG-20 User manual




















EBG‐20SurfacePreparationMachine
OwnersManual














CONTENTS
IntroductiontotheEBG‐20..………………………………………………………………
OperatorInstructions……..…………………………………………………..…………….
MachinespecificationsandSet‐Up…………………………………………………….
OperationInstructions……………………………………………………………………….
TroubleshootingGuide………………………………………………………………………
PartsBreakdown………………………………………………………………………………
WarrantyInformation……………………………………………………………………...


IntroductiontotheEBG20
YouarenowtheproudownerofanEBG20.ThismachineisaproductofSquareScrubInc.Itismade
offinematerialsandwillgiveyoumanyyearsofsatisfactoryserviceifmaintainedandusedaccording
totheguidelinesinthisowner’smanual.
SAFETY
DANGER:Indicatesanimminentlyhazardoussituationwhich,ifnotavoided,mayresultindeathor
seriousinjury.
WARNING:Indicatesapotentiallyhazardoussituation,which,ifnotavoided,mayresultindeathor
seriousinjury.
CAUTION:Indicatesthatmachineorpropertydamagecouldresultifinstructionsarenotfollowed.
NOTE:Provideshelpfulinformation.
OPERATORINSTUCTIONS
DANGERS:
Severebodilyinjuryordeathcanoccurtoyouorotherpersonnelifwarningsfoundonthismachineor
inthisowner’smanualareignored.Readandobserveallstatementandinstructionsfoundonthe
machineandintheowner’smanual.
Neverleavethemachineunattendedwhilepowercordisconnected.
Alwayswearsafetygogglesanddustmaskandwhenoperatingthismachine.
Neverinhaledustcreatedbytheuseofthismachine.
Anymodificationstothismachinemayresultindamagetothemachineorinjurytotheoperatoror
othersnearby.Alterationstothemachinewillalsovoidanyandallwarrantyandliabilities.
Donotoperatethismachinearoundfuels,solvents,flammablefloorfinishes,thinners,wooddustor
anyflammablematerials.Cigarettelighters,pilotlights,electricalsparksandallothersourcesofigni‐
tionshouldbeextinguishedoravoided.Workareasshouldbewellventilated.
Keepthepowercordclearofthepad.Alwaysliftthecordoverthemachine.Donotpullonthepower
cordinanattempttomovethemachine.Thiscouldresultinelectrocution.
Donotusemachineifithasbeensprayedwithwaterorleftoutintherain.Thiscouldresultina
shockinjury.
Keepfeet,hands,andlooseclothingawayfromanymovingpartsonthemachinetoavoidinjury.Dis‐
connectpowercordbeforechangingthepadorwhenservicing.


Caution:
Damagecanoccurtothemachineortootherpropertyifinstructionsintheowner’smanualarenot
followed.
WARNINGS:
Donotoperatethismachinewhileundertheinfluenceofalcoholorotherdrugs.
Neverallowchildrenunderagae18tooperatethismachine.
Unplugmachinefrompowersourcebeforeadjustingheightofhandleorchangingpad.
Neverattempttomovethemachinebypullingthepowercord.

TRANSPORTOFMACHINE
Totransportthismachine,thefollowingprocedureisadvised:
Unplugmachinefrompowersource
Alwaysleaveapadonthemachinetoprotectthegripfacefromdamageintransportandstorage.
Wrapcordusingcordwrapandhandleaspictureillustrates.


Raisehandleandlockinuprightposition.
Tiltmachineontowheelsandtransportslowly.
Whenliftingmachine,itisadvisablefortwouserstoparticipate.Withoneuseroneachsideof
themachine,gripliftingbarsatthebaseofmachinewithonehand.Gripthehandlewiththe
otherhandandlift.
Securemachinewhentransportinginavehicletopreventmovement.


Caution:Thismachineweighs117pounds.Getassistancewhenlifting.Donotattempttoliftalone.

OPERATINGINSTRUCTIONS
1)Movemachinetoworklocation.Nevertransportorstorethemachinewithoutapadtoprotect
thegripface.
2)Checkthepad.Ifithasbecomereducedtoathicknessoflessthan1/2”replacethepad.
3)Toinstallorreplacepad,followtheseinstructions:
Makecertainpowersourceisdisconnected.
Lockhandleinuprightposition
Tiltmachinebackuntilthehandlerestsonthefloor.
Removeexistingpadandreplacewithnewpad.Centerpadwhenplacingongripface.
Presspadfirmlyintogripface.
Returnmachinetouprightposition.
**WhenusingaSPPabrasivepad,placethepadonthefloorandslowlylowermachineontopad,
makingcertaintheSPPpadiscenteredonthemachineandredpad.
4)Connectcordtopowersource.
5)Releaseandlowerhandletoacomfortableposition.Lockhandleintoposition.Thebestoperating
positionisatarmslengthtohelpwithcontrolofmachineandtoimproveoperatorcomfort.Main‐
tainthemachineflatonthefloorforeaseofoperation.Raisingorloweringthehandlecancausethe
machinetopulltotherightorleft.Aneutralhandlepositionwillprovideaneutraloperation.
6)Squeezethepowerbarwithbothhandstostartmachine.Releasepowerbartostopmachine.
Note:Releasingpowerbarwillimmediatelystopthemachine.
TROUBLESHOOTINGGUIDE
ProblemCauseAction
MachinewillnotstartNotconnectedtopowersourceCheckpowersourceconnection 
DefectiveswitchContactSquareScrubdealer



runserratically  LowvoltagefromexcessivelengthUse12gaugeextensioncord
orundersizedextensioncord notmorethan25’long
Defectivestartswitch  ContactSquareScrubdealer
Defectivemotorlowvoltage ContactSquareScrubdealer
Fuse/CircuitBreakertripsLowvoltageAllowthemotortocool.The
circuitbreakerisaredbutton
onthesideofthemotorthat
willresetwhenpressed.
 Eliminateextensioncord.

Locatepowercordclosertoworksite.Havevoltagecheckedbyelectrician.

MachinepullshardtoonesideRubberisolatorswornout Replaceisolators.
NOTE:TherubberisolatorsontheEBG‐20FloorPreparationMachineareconsideredwearitems.Itis
recommendedtoreplacetheentiresetofallfourisolatorsatleastevery100hoursofmachineopera‐
tiontopreventfailureanddamagetothemachine.
Machineisnoticeablylouderthanitwaswhennew  Replaceisolators.

SquareScrub,Inc.
www.squarescrub.com
Tollfree800‐577‐6822











NOTES:
___________________________________________________________________

___________________________________________________________________

___________________________________________________________________

___________________________________________________________________

___________________________________________________________________

___________________________________________________________________

MachineSerialNumber:________________
DatePurchased:_______________________




SquareScrubLimitedWarranty
ThisSquareScrubproductiswarrantedtobefreefromdefectsinmaterialsandworkmanshipunder
normaluseandserviceforaperiodoftwoyearsfromthedateofpurchase,whenoperatedandmain‐
tainedinaccordancewithSquareScrubMaintenanceandOperationsInstructions.Damagedueto
misuseorimpropercarewillnotberepairedunderwarranty.
Thiswarrantyisextendedonlytotheoriginalpurchaserforuseoftheproduct.Itdoesnotcovernor‐
malwearandtearpartssuchaselectricalcable,rubberparts,paddriver,andmotorbrushes.Note:
Therubberisolatorsareconsideredwearableparts.Itisrecommendedthattheentiresetoffouriso‐
latorsbereplacedevery20hoursofmachineoperation.
Ifadifficultydevelopswiththeproduct,contactyourlocalSquareScrubdealerorcallSquareScrubat
800‐557‐6822or870‐932‐0748.OnlySquareScrubcanauthorizerepairsunderwarranty.Transporta‐
tionchargestoandfromtherepairlocationmustbeprepaidbythepurchaser.SquareScrubwillre‐
pairtheproductand/orreplaceanydefectivepartswithoutchargewithinareasonabletimeafterre‐
ceiptoftheproduct.
SquareScrub’sliabilityunderthiswarrantyislimitedtorepairoftheproductand/orreplacementof
partsandisgiventopurchaserislieuofallotherremedies,includingINCIDENTALANDCONSEQUEN‐
TIALDAMAGES.
THEREARENOEXPRESSWARRANTIESOTHERTHANTHOSESPECIFIEDHEREIN.THEREARENOWAR‐
RANTIESWHICHEXTENDBEYONDTHEDESCRIPTIONOFTHEFACEHEREOF.NOWARRANTIES,INCLUD‐
INGBUTNOTLIMITEDTOWARRANTYOFMERCHANTABILITY,SHALLBEIMPLIED.Pleaseregisteryour
machineonourwebsitewithinthirtydaysofpurchasetoassistSquareScrubinprovidingtheper‐
formanceyouexpectfromyournewfloormachine.







800-557-6822
www.squarescrub.com