Sterilite Cobalt SC200-DWS11 User manual
Owner’s Manual
P/N 520114
SC200-DWS11, SCM200-DWS11
SC320-DWS12, SC320-DWS22,
SCM320-DWS12, SCM320-DWS22
Why buy original factory specified lamps...
Why are Sterilume®lamps the best available...
Recycle...
®
®®
®
the CSA
WILL NOTANY
®
®
NEW Environmentally Friendly
®
LongLife+™
®
* Note:
to www.lamprecycle.org
Congratulations
®Cobalt™
Table of Contents:
2
Operation
Dose Flow Chart
Symbols:
Caution Protective
Ground
Electrical
Warning Fragile
Eye Protection
WEEE (waste
electrical or
electronic
equipment)*
* This symbol indicates that you should not discard wasted electrical or electronic
equipment (WEEE) in the trash. For proper disposal, contact your local recycling/reuse
or hazardous waste center.
*CSA/UL certification with approved power cord and lamps only.
optional
flow
restrictor
Parts:
Controller
POWER - 100-240V/50-60HZ
Hard glass, coated Sterilume®-
HO UV lamps for long,
consistent life (9000 hours)
304 stainless steel
reactors with 600
grit polish (A249
pressure rated
tube)
IEC replacement power cords for
Cobalt™ ICE Controller (sold separately)
retaining clip
lamp connector
1
optional
temperature
management
valve (440179)
bracket
filter
filter
UV sensor
drain
plug
aluminum
gland nut
o-ring
214 fused quartz sleeves
with fire polished ends
Safety Instructions:
WARNING
READ AND FOLLOW ALL SAFETY INSTRUCTIONS.
CAUTION
DANGER
Warning:
Note:
2
Water Chemistry:
Proper
pre-treatment is essential for the UV disinfection system to operate as intended.
Installing your UV Disinfection System:
CAUTION
3
“DO NOT CONSUME THE WATER”
4
(Note: Installation drawings show Cobalt “PLUS” system with UV sensor for
representation purpose only)
optional 4-20Ma “Y” cable
5
PLEASE NOTE:
the water in the cell will become
Disinfection Procedure:
Note: Make sure the carbon filter is removed from the sump while
performing this function as the carbon filter will remove the bleach from the
system thus preventing the disinfection process.
PLEASE NOTE:
WILL
6
OPERATION
Operating & Maintenance Instructions:
Caution:
NOTE: RESET LAMP LIFE TIMER AFTER LAMP REPLACEMENT
(PG 10) –
the reactor chamber
Figure 2a
Figure 2b
Figure 2c
7
8
Figure 2D
Figure 3a
Figure 3b
Figure 3c
Figure 3D
9
Figure 4a Figure 4b
Figure 4c Figure 4D Figure 4e
10
Note:ALWAYS
10“ filter housings
20“ filter housings
DO NOT OVER TIGHTEN.
®
Figure 5a Figure 5b Figure 5c Figure 5D
Operation:
11
1. Lamp life remaining (days):
DEFERRAL
RESETTING LAMP LIFE:
2. Total days of operation:
3. Lamp failure (blank screen):
1. UV intensity (%):
Note:
to
to
to
<
DEFERRAL
DO NOT DISREGARD THE WARNING SIGNALS.
12
Possible causes for low UV alarm conditions:
Note: the monitoring system will not operate during power failures.
2. Lamp life remaining (days):
3. Total days of operation:
4. Lamp failure (blank screen):
Note:
5. Solenoid Output:
NOTE: DURING BYPASS, THE “DO NOT CONSUME THE WATER”
13
14
6. 4-20mA output (optional):
Figure 5a
Figure 5b Figure 5c
Troubleshooting:
TROUBLESHOOTING GUIDE
Symptom Possible Causes Solutions
Note:
Contamination in water
pre-filter
Common problem
use of water
temperature
water lines
reactor chamber
port connections
®
connector
connection
15
16
DISPLAY FAULT MODES
confirm that the controller is able to power lamp
parameter limits
Dose Flow Chart:
This manual suits for next models
6
Table of contents
Popular Water System manuals by other brands
Axiom
Axiom Puropal-Pro-25 Installation, operation and maintenance instructions
Intewa
Intewa AQUALOOP greywater recycling Series Maintenance manual
Haws
Haws 3670 Installation, operation & maintenance instructions
Canature
Canature 785 HIMTLC PLUS Series owner's manual
salmson
salmson THERMO'CLOCK Installation and starting instructions
Euronda
Euronda AQUADIST instruction manual
Kenmore
Kenmore 625.384450 owner's manual
TMC Aquarium
TMC Aquarium V2React 300 Compact Instructions for installation and use
deconta
deconta C 30 L instruction manual
iDM
iDM HYGIENIK 2.0 Installation instruction
Clear Comfort
Clear Comfort CCW300A Installation, operation & maintenance manual
Thermal Care
Thermal Care TWC Series Operation, installation, and maintenance manual
