Sunjoy A106010900 User manual

10x8ArchedPergola
ITEM#：A106010900
SKU:1406710
Questions,problems,missingparts?
PleasecallSunjoyGroupat1(866)578‐6569anytime24hours/7daysaweekorvisit
www.sunjoyonline.comformoreinformationorassistance.
GENERALBESTPRACTICESFORASSEMBLY
•Pleasereadandunderstandthisentiremanualbeforeattemptingtoassembleorinstalltheproduct.
•Beforebeginningassemblyofproduct,makesureallpartsarepresent.Comparepartswithpackage
contentslistandhardwarecontentslist.Ifanypartismissingordamaged,donotattempttoassemblethe
product.
•Theassembledpergolashouldbelocatedatleast6feetfromanyobstructionsuchasfence,garage,
house,overhangingbranches,laundrylinesorelectricalwires.
•Somepartsmaycontainsharpedges.Wearprotectiveglovesifnecessary duringassembly.
•Checkallnutsandboltsperiodicallyfortightnessand,whenrequired,tightenthemagain.
•Payattentiontothepartsorientation.

∙
MAINTENANCE
•Steelcomponentsforthispergolaaretreatedwithrustinhibitingpaintthatprotectsitfromrusting.
However,duetothenatureofsteel,surfaceoxidation(rusting)willoccuriftheseprotectivecoatingsare
scratched.Thisisnotadefectandthusnotcoveredbythewarranty.
•Tominimizethiscondition,itisrecommendedtousecarewhenassemblingandhandlingtheproductto
preventscratchingthepaint.Shouldanyscratchingordamageoccur,itisrecommendedtocoverthe
scratchimmediatelywithrustinhibitingpaint(notincluded).
•SurfacerustcanalsobeeasilyremovedwithaverylightapplicationofregularcookingoilorWD‐40.If
surfaceoxidation(rusting)occursandifnomeasureistakentopreventthis,theoxidationmaystart
drippingontodeckorpatioandcauseddamagingstains,whichmaybedifficulttoremove.Thiscanbe
preventediftheabove‐mentionedmeasuresaretakentokeeptheproductfromoxidizing.
•Keepinstructionmanualforfuturereference.
•Keeptheoriginalpackagingtostorethepergola.
•Periodicallycheckandensurethatallboltsarewell‐tightenduringuse.
WARNINGS
•Installthepergolaonlevelground.Stakesareprovidedtosecurethepergolatotheground.
•Donotassemblethepergolaonsandy,muddyorloosesoil,asstakesdonothaveenoughanchoragein
thesetypesofsoil.
•Ifyouwishtosecurethepegolatoawooddeckorconcretesurface,useanchors(not included) suitedto
thesesurfaces.
•Snowmustbeclearedoffregularlyduringsnowydays.
•Donotleavethepergolawherethereisariskofhighwind,aspossibledamagewilloccurtothestructure.
•Anyassemblyormaintenanceoftheproductmustbecarriedoutbyadultsonly.
•Pleasecheckyourstateandlocalregulationspriortopurchasing.Somejurisdictionsmayrequirepermits
forinstallationanduse.Somespecialproceduresmaybevalidinyourarea.
•Ifanyscratchpaint,pleasetouchuptopreventrusting.
•Foroutdooruseonly.
•Keep all flame and heat sources away from the tent fabric. This tent is made with fabric that meets
CPAI-84 specifications for flame resistance. It is not fire proof. The fabric will burn if right in continuous
contact with any flame source. The application of any foreign substance to the tent fabric may render the
flame resistant properties ineffective.
•Do not use bleach, acid, or other abrasive cleaners on the roof or frame parts.
Tooles Recommended
Included

∙
EXPLODEDDRAWING

∙
PartsList
Label PartNumber Description Qty PartImage
A1P00060074102Top Beam 1 7
A2P00060073902Top Beam 2 7
B1P000601815Top Arc Beam 12
B2P000601738Top Arc Beam 22
B3P000501016Top Arc Beam Connector 2
C1P00040141901Cross Beam 12
C2P00040142001Cross Beam 22
DP005600076Crossbeam Decoration4
D4P00560012402Post Tail4
P000200535Post 12
E
P000200536Post 22
F
P00010015203Post Base4
G
P00610009203Base Cover4
H
P005000550Support Bar 12
I1
P005000551Support Bar 22
I2
P005000552Support Bar 32
J1
P005000553Support Bar 42
J2
P000501518Rail Rod Connector 8
L

P00570089301Fabric Rod 12
M
P00570089401Fabric Rod 22
N
P005700790Rail Tube4
O
P00110070701Canopy1
HardwarePack
Label PartNumber Description Qty Spare PartImage
AA H010020011BoltM6*15 885
BB H050030001FlatWasherM6 1287
CC H010030030BoltM6*15181
DD H010020016Bolt M6*4522 2
EE H010030022Bolt M6*7081
FF H070010001Stake Φ6*23080
Z1 H090010017 WrenchM6 2 0
P
Z2H090030002 Allen key M6 10

∙

∙

∙

∙

∙

∙

∙

∙

∙

∙

∙

∙

∙
Country of Origin: China Production Number: 2022BPCN10
13