Tactik Tube Doors Quick start guide

Tube Doors Installation & Use Instructions:
For '07 - '18 Wranglers (JK) Front or Rear
PARTS LIST (Front)
Nylon Door Check Straps (2)
Door Pin Bracket (4)
M8 Bolt 1.25 x 20MM (8)
M8 Nylock Nut (8)
M8 Flat Washer (8)
REQUIRED TOOLS
Safety Glasses
5MM Hex Key
10MM Wrench
13MM Wrench
T50 Torx Socket
T40 Torx Socket
Ratchet
TO REDUCE RISK OF SERIOUS
INJURY OR PROPERTY DAMAGE:
READ ALL SAFETY MESSAGES
AND UNDERSTAND ALL INSTRUCTIONS AND PROCEDURE NOTICES BEFORE
ATTEMPTING TO INSTALL OR USE THIS PRODUCT.
THESE DOORS ARE NOT
INTENDED TO PROTECT
OR CONTAIN THE VEHICLE
OCCUPANTS OR PREVENT INJURY OR DEATH IN THE EVENT OF AN
ACCIDENT.
WEAR SEAT BELTS AT
ALL TIMES.
PERIODICALLY CHECK AND
ADJUST ALL LATCHES AND
FASTENERS, FAILURE TO DO SO
COULD RESULT IN THE DOORS NOT LATCHING SECURELY.
RISK OF EYE INJURY! SAFETY
GLASSES MUST BE WORN
AT ALL TIMES WHILE
INSTALLING OR MAINTAINING THIS PRODUCT. DO NOT USE IF DAMAGED.
PARTS LIST (Rear)
Nylon Door Check Straps (2)
Door Pin Bracket upper (2)
Door Pin Bracket Lower (2)
M8 Bolt 1.25 x 20MM (8)
M8 Nylock Nut (8)
M8 Flat Washer (8)

INSTALLATION
2
STEP 2
Align two door hinge pins with the factory door hinges of your vehicle and gently lower the doors onto the hinges.
(Fig 2) Loosely install the factory door retention nuts with a T50 Torx but do not fully tighten at this time.
You may need to wiggle the door in order to align the hinge pins into the hinges. (Fig 3)
FIG 2 FIG 3
STEP 3
Open the door by lifting up on the latch knob on the inside of the door. (Fig 4) Gently swing the door open. Secure the
door check strap in the factory location. (Fig 5)
FIG 4 FIG 5
Locate the four holes for the door pin brackets on the
tube door. Place four M8 bolts through the holes from
the outside of the tube door. Place door pin bracket
with nylon check strap into the M8 bolts on the bottom
inside of the tube door and the door pin bracket on the
top. Place one M8 flat washer on the M8 bolt with an
M8 nylock nut and tighten using a 13mm socket and
wrench. (Fig 1) Repeat this step for all of the M8 bolts,
washers and nuts for the door pin brackets. NOTE: When
installing rear doors, top pin bracket will be slightly
raised.
STEP 1
FIG 1

INSTALLATION (Cont)
3
FIG 6 FIG 7
STEP 4
Gently close the door. While the door is still closed and the latch is engaged, tighten the hinge bolts with a T50 socket.
Lift up on the latch side of the door to make sure that the latch lines up. (Fig 6) It may be necessary to wiggle the rest
of the door in order to line it up. Push the door shut firmly until 2 clicks are heard. If the latch is not engaging properly
you may need to loosen the latch with 5mm hex key. Adjust the position of the latch as needed. (Fig 7)
When installing the rear TACTIK Tube Doors, remove the two door nuts using T50 socket. (Fig 8) While securely
holding the door locate the door limiting check strap wire plug protecting harness attached to the rear doors. (Fig 9)
STEP 5
FIG 9FIG 8
STEP 6
Locate the cover on the side panel. From the top of the cover, slightly push down to remove it. Notice that there are
two tabs on the bottom of the cover. (Fig 10) Press down on the tab to safely disattach the wire plug. (Fig 11) Repeat
steps one through four for the other door.
FIG 10 FIG 11
FIG 6

Your TACTIK®branded accessories are covered by the following Limited Warranty provided exclusively by TACTIK®
located at 1028 Saunders Lane, West Chester PA 19380.
This Limited Warranty is the only warranty made in connection with your purchase. TACTIK®neither assumes nor
authorizes any vendor, retailer or other person or entity to assume for it any other obligation or liability in connection
with this product or Limited Warranty.
What is Covered: Subject to the terms, exclusions and limitations herein and with respect only to TACTIK®branded
accessories rst sold in the United States, TACTIK®warrants to the initial retail purchaser only that your TACTIK®
accessory shall be free of defects in material and workmanship: for a period of one (1) year from date of retail
purchase.
This Limited Warranty is not assignable and shall terminate upon sale of the vehicle upon which the TACTIK®
accessory is installed or other transfer to third persons.
All other warranties are hereby disclaimed, except to the extent prohibited by applicable law in which case any implied
warranty of merchantability or tness for a particular purpose on this product is limited to 1 year from date of initial
retail sale. TACTIK®reserves the rights to: (a.) require invoice or other proof your accessory is within the terms of
this Limited Warranty as a condition of warranty service and, (b.) make future revisions to this product and Limited
Warranty without prior notice or obligation to upgrade your product.
What is Not Covered:
Your TACTIK®Limited Warranty does not cover products or parts TACTIK®determines to have been damaged by or
subjected to: (a.) installation damage, alteration, modication, combination with other parts, failure to maintain or
improper repair or service, (b.) normal wear & tear, cosmetic damage or damage from moisture or water immersion,
(c.) Acts of God, accidents, misuse, negligence, inadequate mounting or impact with vehicle(s), obstacles or other
aspects of the environment, (d.) theft, vandalism or other intentional damage.
Remedy Limited to Repair/Replacement: The exclusive remedy provided hereunder shall, upon TACTIK®inspection
and at TACTIK’s option, be either repair or replacement of product or parts (new or refurbished) covered under this
Limited Warranty. Customers requesting warranty consideration should rst contact TACTIK®to obtain a RGA number
via telephone at 800-603-4064, or initiate customer service by email at: [email protected]. All labor,
removal, shipping and installation costs are customer’s responsibility.
Other Limitations - Exclusion of Damages - Your Rights Under State Law:
In consideration of the purchase price paid, neither TACTIK®nor any independent TACTIK®distributor/licensee are
responsible for any time loss, rental costs, or for any incidental, consequential, punitive or other damages you may
have or incur in connection with any part or product purchased. Your exclusive remedy hereunder for covered parts is
repair/replacement as described above.
This Limited Warranty gives you specic rights. You may also have other rights that vary from state to state.
For example, some states do not allow limitations of how long an implied warranty lasts and /or do not allow the
exclusion or limitation of incidental or consequential damages, so the limitations and exclusions herein may not apply
to you.
©TACTIK®2022 All Rights Reserved. A4 Version 5/6/2022
Instructions Part Number: #12999-3249
Exclusive One Year Limited Warranty