Tanaka T277487 Setup guide

IllustrIllustr

Illustraa

ated Pted P

ted Pted P

ted Parar

arar

arts Mants Man

ts Mants Man

ts Manualual

ualual

ual

Model Number:

TED-210C

GAS DRILL (Limited Canadian Production)

P/N N/A

Rev 000

Date 1-15-08

Serial Numbers (T277487 - T284900)

AND

Serial Numbers (U205952 - U268935)

Nikko Tanaka Engineering U.S.A.,Ltd.• 1028 4th Street SW, Bldg B • Auburn, WA98001 • Phone: (253) 333-1200 • Fax: (253) 333-1212

www.tanakapowerequipment.com [email protected]

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 1

TED-210C

CYLINDER, PISTON, CRANKSHAFT, IGNTION • FIGURE 1

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

1-1 1570650091 CAP,SPARK PLUG ASS'Y 1

1-2 0180654021 PLUG,SPARK 1

1-3 0010650090 SET,CYLINDER 1 Includes cylinder gasket

1-4 99416050201 SCREW,5X20/WS 2

1-7 0170650020 GASKET,CYLINDER 1

1-8 04100601210 RING,PISTON 1

1-9 0300650090 SET,PISTON 1 Includes rings and circlips

1-10 03706500200 PIN,PISTON 1

1-11 03901620200 CIRCLIP,PISTON PIN 2

1-12 04606500801 CRANKSHAFT 1

1-13 99962081225 BEARING,NEEDLE,F-810 1

1-27 1532153390 COIL,IGNITION 1

1-28 99416040226 SCREW,WS,4X22 2

1-36 25006500200 TUBE,INSULATOR 1

1-37 1780650080 CORD,STOP COMPLETE 1

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 2

TED-210C

CRANKCASE, MAGNETO • FIGURE 2

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

2-21 07206502900 CRANKCASE,ASS'Y 1 Crankcase Ass'y includes bearings, seals

2-22 09006500200 GASKET,CRANKCASE 1 and gasket

2-23 99966122206 SEAL,OIL,#TC12227 2

2-24 99961600100 BEARING,BALL,#6001 2

2-25 33000200210 SHIM,12.2X19X.10 1 Shims are "as needed" to obtain

2-25 33000200220 SHIM,12.2X19X.15 1 correct side clearance

2-25 33000200230 SHIM,12.2X19X.20 1

2-25 33000200240 SHIM,12.2X19X.30 1

2-26 59900601200 CUSHION 1

2-30 99414050301 SCREW,5X30/S 3

2-31 1552152380 ROTOR, MAGNETO 1

2-32 99201080011 WASHER,8 1

2-33 99210080012 WASHER,S,8 1

2-34 99101080011 NUT,8 1

2-35 10012000200 STUD,6X26 2

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 3

TED-210C

MUFFLER COVER, MUFFLER, RECOIL STARTER • FIGURE 3

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

3-3 7380650020 PROTECTOR,MUFFLER 1

3-4 73706500200 GASKET,MUFFLER 1

3-5 13306500200 SHIELD,HEAT 1

3-6 7040650090 SET,MUFFLER 1

3-7 99201050011 WASHER,5 2

3-8 99051050503 BOLT,HEX,5X50 2

3-11 1120650A80 CASE,FAN 1

3-12 78006097200 SPRING,RECOIL 1

3-13 77406097200 PULLEY,STARTER 1

3-15 8390201020 SCREW,SET 1

3-16 79806500900 PULLEY,STARTER,ASS'Y 1

3-17 2030604A202 GROMMET 1

3-18 78306097200 ROPE,STARTER 1

3-19 78506410200 HANDLE,STARTER 1

3-20 99415040162 SCREW,PS,4X16 3

3-21 75106500200 GASKET,MUFFLER 1

3-22 7210650490 SET, TAIL PIPE 1

3-24 99414040081 SCREW,4X8 2

3-47 2770634F900 CLUTCH,ASS'Y 1

3-61 99072045164 SCREW,TAPPING,4.5X16 1

3-62 99425040128 BOLT,PS,4X12 2

3-65 79006097200 SPRING,STARTER PAWL 1

3-66 7880650020 PAWL,STARTER 1

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 4

TED-210C

AIR CLEANER, FUEL SYSTEM • FIGURE 4

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

4-25 40306500200 GASKET,INTAKE 1

4-26 4040650090 SET,CARB INSULATOR 1

4-27 99416050252 SCREW,5X25WS 2

4-30 40206500200 GASKET,CARBURETOR 1

4-33 99967015000 O-RING,P15 1

4-35 4230650081 BODY,CLEANER 1

4-36 47006500200 COLLAR 2

4-37 52806500200 VALVE,CHOKE 1

4-38 99204080030 WASHER,8 1

4-39 47601700200 BOARD,BLOW OVER CHECK 1

4-40 99210050012 WASHER,S,5 2

4-41 99011050602 SCREW,5X60 2

4-43 4460650020 ELEMENT,CLEANER 1

4-44 4520650091 COVER,CLEANER,W/BOLT 1

4-45 3800637C200 BOLT,CLEANER COVER 1

4-46 4550651E90 CARBURETOR,TED-210C 1

4-50 2230650090 PIPE,FUEL,ASS'Y 1

4-51 68000731201 CLIP 6.3 1

4-52 6750404280 FILTER,FUEL 1

4-53 5910650000 TANK,FUEL PIPE,ASS'Y 1

4-55 65900801200 COLLAR 2

4-58 99463050185 BOLT,HEX 5X18PS 2

4-63 5950423Q90 CAP,TANK 1

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 5

TED-210C

CARBURETOR • FIGURE 5

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

5-0 4550651E90 CARBURETOR,TED-210C 1

5-1 54825140200 SCREW,THROTTLE SET 2

5-5 53925120200 SWIVEL 1 Carburetor Repair Kit - 650-25140-900

5-7 48925100200 RING,STOP 1 Gasket / Diaphragm Kit - 652-25140-900

5-8 48825145800 VALVE,THROTTLE 1

5-10 55025100200 O-RING 1

5-11 599200AW41 JET,MAIN 41.5 1

5-13 ~ ~ ~ GASKET,PUMP 1 ~ Contained in Carb Kits

5-14 ~ ~ ~ DIAPHRAGM,PUMP 1

5-17 57825007200 SCREEN,INLET 1

5-18 5752515280 BODY,PUMP 1

5-19 ~ ~ ~ GASKET,DIAPHRAGM 1

5-20 ~ ~ ~ DIAPHRAGM,METERING 1

5-21 47625004200 COVER,DIAPHRAGM 1

5-22 54825101200 SCREW,SET 4

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 6

TED-210C

GEAR CASE • FIGURE 6

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

6-1 0023218280 CASE,GEAR A 1

6-2 0063210A80 CASE,GEAR,B 1

6-3 2263210A800 HOUSING,CLUTCH 1

6-4 01232120200 GEAR,#2 1

6-5 01632120201 GEAR,#3 1

6-6 06800300200 KEY,WOODRUFF,3X10X3.7 1

6-11 99961600102 BEARING,BALL,#6001Z 1

6-12 99961600100 BEARING,BALL,#6001 1

6-13 99350012002 RING,STOP,C-12 EX 1

6-14 01832120200 GEAR,#4 1

6-15 99961720221 BEARING,BALL,#7202B 1

6-16 04032120201 WASHER,BEARING 1

6-17 99961620202 BEARING,BALL,#6202Z 1

6-18 99351035002 RING,IN,C-35,STOP 1

6-19 06801006200 KEY,WOODRUFF,3X13X5 1

6-20 02232120201 SHAFT,DRIVE 1

6-22 99023060301 BOLT,P,6X30 2

6-23 99101060011 NUT,6 2

6-24 99210060012 WASHER,S,6 4

6-26 99414050181 SCREW,S,5X18 4

6-43 99209350030 WASHER,WAVE,B.B,35 1

6-44 23132175200 COLLAR,GEAR SHAFT B 1

6-45 30032250801 FITTING,GREASE 1

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 7

TED-210C

HANDLES, THROTTLE, STOP SWITCH • FIGURE 7

ITEM PART NUMBER DESCRIPTION QTY COMMENTS

7-28 2583210A82 HANDLE,A 1

7-29 1653313020 HANDLE,GRIP,A 1

7-30 10132120201 LEVER,THROTTLE 1

7-34 99011050251 SCREW,5X25 1

7-35 99101050011 NUT,5 1

7-36 19833130200 CLAMP,CORD 2

7-37 99023060161 BOLT,6X16 PLUS 1

7-38 99210060012 WASHER,S,6 1

7-39 25932120810 HANDLE,B 1

7-41 99210100012 WASHER,S,10 1

7-46 1563210A801 SWITCH,STOP 1

7-47 9253317620 DECAL,STOP BUTTON 1

7-48 2581165020 BUTTON,STOP 1

7-49 99011030101 SCREW,3X10 1

7-51 88506502801 WIRE,THROTTLE 1

7-52 16407029000 TUBE,PROTECTION 1

7-53 1553210A200 HOLDER, CHUCK KEY 1

www.tanakapowerequipment.com

PARTSINFORMATION

[email protected]

Page 8

TED-210C

CHUCK & KEY, WRENCH, DECALS • FIGURE 8

ITEM PART NUMBE

DESCRIPTION QTY COMMENTS

8-0 05932120911 CHUCK & KEY SET 1/2" 1

8-1 06032120911 CHUCK,1/2" 1

8-2 06132120811 CHUCK KEY 1/2" 1

8-3 8292000080 SPANNER,COMBI,13X19 1

8-4 9203217220 DECAL,CAUTION 1

8-5 9213217220 MARK, CAUTION 1

8-6 91106500200 DECAL,SRS 1

8-7 9060650520 PLATE, NAME, TED-210 1

8-8 27218 KEYLESS CHUCK 1/2" 1 OPTIONAL

This manual suits for next models

Table of contents

Other Tanaka Drill manuals

Tanaka

Tanaka TED-210 User manual

Tanaka

Tanaka TED-232 Instruction Manual

Tanaka

Tanaka TED-210 User manual

Tanaka

Tanaka TED-260 Instruction Manual

Tanaka

Tanaka TED-270PFL, TED-270PFLS, TED-270PFR, TED-270PFRS, TED-270PFHS, TED-270PFDH,... User manual

Tanaka

Tanaka TED-262L Setup guide

Tanaka

Tanaka TED-262DH User manual

Tanaka

Tanaka TED-262HS Setup guide

Tanaka

Tanaka TED-270PFL User manual

Popular Drill manuals by other brands

Stanley

Stanley FatMax FME140 Original instructions

Black & Decker

Black & Decker MATRIX BDCDMT120C instruction manual

DeWalt

DeWalt D25134 manual

Skil

Skil 2431 Original instructions

Bort

Bort 93728410 user manual

GreenWorks

GreenWorks DDG407 Operator's manual

Panasonic

Panasonic EY7460 - DRILL DRIVER 21.6V operating instructions

Mueller

Mueller E-5 operating instructions

Bosch

Bosch GSB Professional 18-2 RE Original instructions

Clarke

Clarke CON18LI Operation & maintenance instructions

Makita

Makita 8280D technical information

Stanley

Stanley SCH20 user manual

Makita

Makita BDF456 instruction manual

Makita

Makita LXFD01 instruction manual

Black & Decker

Black & Decker LDX220 instruction manual

GMC

GMC HD1400K instruction manual

POWERBOR

POWERBOR PB1000E owner's manual

Festool

Festool T18+3 instructions