Vaportek OPTIMUM 3000 User manual

Economical
Cartridge & filter lasts approximately
90 days.
Works 24/7
Treat areas where continual
deodorization and air cleaning is
needed.
Safe & Environmentally Preferable
Safe for use in occupied spaces. No
chemicals or harmful ozone.
Proudly made in the USA
The Optimum 3000 is an easy-to-use, virtually
silent, stationary system. Primarily intended for
constant deodorization and air cleaning by
removing particulates from the air. This unit is
safe to use in occupied spaces.
Optimum 3000™
A Dual Air Treatment System Ionizer
P: 800.237.6367 | F: 262.246.5065
www.vaportek.com | [email protected]
W226 N6339 Village Drive, Sussex, WI 53089 USA
#50-3000C Rev. 6/21
For service advice, contact your dealer or
USE AND OPERATING
INSTRUCTIONS FOR THE
OPTIMUM 3000™
CARTRIDGE USE
The Optimum 3000 is designed for use with Vaportek
approved replacement cartridges and filters only. Use of
non-approved replacement cartridges and filters will void
warranty coverage. For best results, store cartridges in a cool,
dry location and keep away from extreme heat. Replace cartridge
and filter after 90-days of use.
Reorder Information:
Optimum 3000 110/120v w/Neutral Cartridge/Filter (#80-2100N)
Optimum 3000 Neutral Cartridge/Filter (#80-2300)
Optimum 3000 Lemon Cartridge/Filter (#80-2310)
Optimum 3000 Potpourri Cartridge/Filter (#80-2320)
Five Year Limited Warranty
Vaportek warrants this unit to be free from defects in
workmanship and materials, under normal use and service,
for five years from date of purchase by the original
purchaser. If, at any time during the warranty period, the
product is found to be defective or malfunctions, Vaportek
will either repair or replace the defective part(s) at its
discretion. Warranty does not apply if it is shown by
Vaportek that the defect or malfunction was caused by
unauthorized modifications, neglect, or abuse by the
consumer. Further, any costs incurred by consumer due to
unauthorized changes made to the product will not be
covered by Vaportek. This warranty does not cover any
other charges incurred by the consumer. Vaportek’s sole
responsibility is to repair or replace product within the terms
stated above.
Vaportek shall not be liable for any consequential
damages resulting from any breach of warranty, expressed
or implied, applicable to this product. Some states do not
allow the exclusion or limitation of consequential damages,
so this limitation may not apply to you.
This warranty is in lieu of all other warranties, expressed
or implied. The warranties of merchant ability and fitness for
a particular purpose are hereby excluded beyond the five
year duration of this warranty. Some states do not allow
limitation on how long an implied warranty lasts, so the
above limitation may not apply to you. This warranty gives
you specific legal rights, and you may also have other rights
which can vary from state to state. This warranty applies
only to products sold and used in the United States and
Canada. Goods submitted for repair under this warranty
must be sent, freight prepaid, to Vaportek, Inc. Call first for
a return authorization number.

Fig. 3
IMPORTANT
Thank you for purchasing the Optimum 3000 by Vaportek. The unit
is an easy-to-use, virtually silent, stationary system. It treats areas up
to 12,000 ft3 to effectively eliminate odor contamination steadily and
safely, while removing particulates from the air. The unit is primarily
intended for delivering a long-lasting treatment solution. A
characteristic neutralizer fragrance will be noticeable during
operation as the essential oil dry vapor circulates throughout the
treatment area. Residual fragrance will dissipate in a matter of hours
after treatment ends. With proper care, your Optimum 3000 will
provide you years of trouble-free service. Please read these use and
operating instructions carefully before operating your new machine
and keep it for future reference.
Prior to initial start-up, open the unit. Press inwards on the locking
mechanism located on the top of the unit. The back top cover is
hinged, and will easily swing up. Put the lever down to its off (lowest)
position during servicing. Take out the filter and cartridge, unwrap
them. The black-framed filter is located in the front of the access area.
Replace filter by simply pulling up and out. Install new filter by
reverse action, ensuring that white side is facing the motor. Make
certain filter fits squarely in place to allow cover to close. To reinstall
cartridge, place cartridge in cradle ensuring that notch on bottom of
cartridge fits snuggly into square tab located directly in front of the
black filter. Plug unit into the correct outlet. Situate unit so air flow is
unobstructed, preferably in a relatively high location. Place on a firm,
stable surface. Deodorization and air filtration will occur
continuously. Adjust side lever for dry vapor output and intensity.
THANK YOU INSTRUCTIONS
On unit’s side is the air
treatment adjustment
lever. Move lever up to
increase dry vapor
output & down to
decrease/turn off this
function.
ODOR ELIMINATION
Unit can be used to eliminate odors using our Neutral formula. For
areas with any ongoing, organic odors, run the unit continuously to
eliminate odors.
IONIZER AIR FILTRATION
The Optimum 3000 offers multi-stage filtration containing three
different elements to remove smoke, dust, and pollens from the air.
The ionizer element helps clean the air by releasing millions of
negatively charged ions. Ions are attracted to oppositely charged
particulate (like smoke) and precipitate them out of the air. The
ionizer does not need servicing. The ionizer feature enhances filter
efficiency by constantly charging the filter media.
IDEAL FOR:
 Military Compounds
 Real Estate/Foreclosures
 Homeless Shelters
 Office Spaces
 Long-term Patient Facilities
 Athletic Facilities/Locker Rooms
 Vehicle/Boat/RV
 Medical Facilities
 Smoking Areas
 Musty Basement
 Daycare Centers
 Spas
SUGGESTED USES
As with any powered tool, certain precautions for safe and efficient
use apply. Please follow these rules and recommendations when
using the Optimum 3000:
1. Use Vaportek approved accessories only.
2. Do not allow oils to come in contact with finished surfaces.
Finished surfaces may be damaged by direct contact with oils.
However, if the oils should leak, wash affected skin, clothes,
and/or surfaces with soapy water.
3. For best results, store cartridges in a cool, dry location and keep
away from extreme heat.
4. Replace cartridges & filters after 90 days.
5. Dry vapor output will be affected by humidity, airflow, and
temperature. Ideal dry vapor release occurs at 50-80°F. Vapor
release significantly increases in excess of 90°F.
6. Do not immerse or use where contact with water may occur.
7. Do not alter the plug or change the electrical wiring.
8. The ionizer does not need servicing.
9. If unit appears to malfunction, unplug or turn it off immediately.
Contact your dealer or Vaportek for service advice.
10. Vaportek products use natural essential oils. If an allergic
reaction occurs, please discontinue use immediately.
11. To accelerate the dissipation period of the characteristic
Vaportek fragrance, open windows and turn on floor fans.
12. This system provides a safe, effective alternative to ozone. It is
not recommended for use with ozone generating equipment.
13. Designed for continuous, long-term operation.
14. Use standard disinfectant wipes to clean water safe surfaces.
On unit’s front is the
blower control switch.
Move this switch to the
right to engage low &
fast speeds. This switch
also activates the ionizer
air cleaner function.
Fig. 4
Fig. 1 Prior to initial start-up,
open the unit. Press
inwards on the locking
mechanisms located on
the side of the unit. The
back top cover is hinged,
and will easily swing up.
Fig. 2 Take out the filter and
cartridge, unwrap them,
and re-install by following
the Instructions section
above. See arrows on filter
for install guidance. Close
cover.
Adjustment
Lever
Locking
Mechanism
Ratings:
12W
60HZ
120V
Optimum 3000™