Vario Hearables Novo Enhanced User manual

User Guide
novoenhanced

21
Your Vario novos
Your Vario Novo modules will be marked
with a unique serial number on the audio
spout and Vario logo on the main body.
Audio spout
Battery door
Vario logo
Filter
Eartip
Index
Power on/off
Batteries
Battery life
Replacing the batteries
Cleaning and maintenance
Storage
Eartips
Selecting an eartip
Inserting the module into the eartip
Inserting into your ears
Removing from your ears
Optional lanyard
Attenuation information
Warnings
Warranty
3
3
3
4
5
7
7
8
8
9
10
10
11
13
14

power on/off
Once a fully aerated battery is in place (see page 4), your Vario
Novos will power on when you close the battery door and power
off when the battery door is fully open.
Your Novos are an effective hearing protection device without a
battery, but you will lose ambient awareness.
Batteries
Your Vario Novos use size 10 zinc air hearing aid batteries. These
are available online and on the high street, or can be purchased
at www.variohearables.com.
Battery life
Each battery, if correctly aerated, should exceed 80 hours of
continuous use.
Zinc air batteries degrade over time, regardless of use, and so will
be active for no more than 45 days after removal of the protective
tab.
Leaking batteries can irreversibly damage your Novos and
invalidate your warranty.
Batteries deteriorate faster at low temperatures. 43
Replacing the batteries
Remove the protective tab from the battery.
Allow the battery to breathe (aerate) for two minutes before
going any further. This is very important!
Holding the module, flip the battery door open.
Insert the battery into the battery door with the flat side (+) of the
battery facing out.

6
Cleaning and maintenance
Your Vario Novos should be cleaned after every use. Wipe the
Novo module body with a damp cloth and sanitiser or
antibacterial wipe. Do not immerse in water.
Remove any debris or wax. Clean the eartips with a damp cloth
and pat dry.
If the filter in the audio spout becomes blocked, sound quality
will diminish. Remove the filter with the tool provided and
replace, positioning a new filter in the audio spout and pressing
against a hard, flat surface (see diagrams below). Do not use the
tool to push the filter into place as it will pierce the membrane.
Do not use your Novos without filters in place.
Additional filters can be purchased from
www.variohearables.com.
5
Item
Replacement filters VAC209
Part Number

8
Selecting an eartip
Tips that are too big can cause discomfort and be difficult to
insert, whereas tips that are too small may not provide a proper
seal and not provide adequate protection
To find the best fit for you, start with the largest tip and work
down, using the insertion instructions below. Silicone tips tend to
be slightly more comfortable, while foam provides a slightly
better seal.
Try both and see which one suits you best.
Inserting the module into the eartip
Align the edge of the audio spout with the edge of the hole in
the top of the eartip.
Firmly press the audio spout into the eartip, rotating as you do so.
It is a tight fit to aid retention.
7
Storage
Always store your Vario Novos in the storage case provided at a
temperature between -10°C and 50°C. If storing for longer than
30 days please remove the batteries from the Novos to prevent
damage. Leaking batteries can irreversibly damage your Novos
and invalidate your warranty. Batteries deteriorate faster at low
temperatures.
Eartips
Ear canals are sensitive and each one is unique so we've provided
a selection of sizes and materials for you to choose from. It will be
necessary to change the eartips from time to time. Never use a
damaged eartip.
Replacements can be
purchased from
www.variohearables.com.
Foam Tips Size (mm) Part Number
Blue 13.7 VAC201/Blue
Black 12.4 VAC201/Black
Red 10.9 VAC201/Red
Silicone Tips Size (mm) Part Number
Large 13.8 VAC202/Large
Medium 12.6 VAC202/Medium
Small 10.8 VAC202/Small

Removing from your ears
Grasp your Vario Novo and slowly pull away from the ear canal,
twisting gently to break the seal.
Optional lanyard
To attach the lanyard to your Vario Novos, simply slip the silicone
ring over the body of each Novo module. Replacements are
available at www.variohearables.com.
Item Part Number
Black lanyard VAC203/Sd
Blue lanyard VAC203/Fs
Orange lanyard VAC203/In
White lanyard VAC203/Wt
Inserting into your ears
If using foam eartips, roll and squeeze the eartip between your
forefinger and thumb to compress.
Pull your ear up and backwards if necessary. The easiest way to
do this is with the opposite hand, reaching over the top of your
head.
Gently push the Novo (eartip first) into your ear, rotating until you
find the natural direction of your ear canal and the most
comfortable fit.
Allow at least ten seconds for foam eartips to re-expand and form
to the shape of your ear canal.
NB: Never insert the Novo modules into the ear canal without
eartips, or vice versa. They must always be used in unison.
109

Active Attenuation - Criterion Levels
EN352-7 Minimum Requirements
Measured Results
H L
97dB(A) 94dB(A)
110dB(A) 95.4dB(A)
M
96dB(A)
104dB(A)
Passive Attenuation - Foam Eartip
SD (dB) 5.2 4.5 3.6 4.1 3.9 3.3 6.6
F (Hz) 63 250 500 1000 2000 4000 8000125
MA (dB) 17.4 20.4 20.0 23.8 31.8 37.8 37.321.3
3.7
APV (dB) 12.2 15.9 16.4 19.7 27.9 34.4 30.717.5
Passive Attenuation - Silicone Eartip
SD (dB) 4.9 4.9 5.1 3.9 5.4 5.4 7.1
F (Hz) 63 250 500 1000 2000 4000 8000125
MA (dB) 22.8 23.1 21.8 26.1 27.6 27.8 29.625.8
5.5
APV (dB) 17.8 18.2 16.6 22.2 22.2 22.3 22.520.2
Foam Eartips
H
M
L
27dB
SNR
20dB
18dB
24dB
Silicone Eartips
22dB
20dB
19dB
23dB
F = Frequency
MA = Mean Attenuation
SD = Standard deviation
APV = Assumed protection level
H = High frequency attenuation
M = Medium frequency attenuation
L = Low frequency attenuation
SNR = Single Number Rating attenuation
Attenuation information
Vario Hearables Ltd declares that the hearing protection is in
compliance with PPE regulation EU 2016/425.
The full text of the EU declaration of conformity can be found at
www.variohearables.com.
The tests according to EN 352-2:2002 and EN352-7:2002 and
certification to the regulation EU 2016/425 and the production
control module D (CE2777) were performed by Satra Technology
Centre, Kettering, Northants, UK, #2777.
1211

one year limited warranty
Vario Hearables Ltd warrants these Novo modules against defects in materials and
workmanship for a period of one year from the date of original retail purchase.
If a defect exists, and this limited warranty is valid, at its option Vario Hearables Ltd
will repair the product at no charge where possible or replace the product. A repaired
or replaced product assumes the remaining warranty of the original product. When
a product or part is replaced, any replacement item becomes your property and the
replaced item becomes Vario Hearables Ltd’s property.
Obtaining warranty service
For limited warranty service, email [e-mail] or call [phone]
00. When you contact our customer service team you will be asked to provide your
name, address, telephone number and to provide proof of the original purchase
(receipt) containing a description of the product(s) and purchase date. Before you
send your product for limited warranty service please make sure you copy all relevant
documents for your files (receipts, etc.). Shipping and processing fees may be
incurred.
Exclusions and limitations
This Novo One Year Limited Warranty applies only to Novo modules distributed by or
for Vario Hearables Ltd that can be identified by the Vario Hearables Ltd logo. Vario
Hearables Ltd’s One Year Limited Warranty does not apply to any other products that
may appear to be authentic but were not distributed/sold by Vario Hearables Ltd.
This limited warranty extends only to the original consumer purchaser and is not
transferable. In addition, proof of purchase must be demonstrated.
This limited warranty does not apply to damage caused by accident, abuse, misuse
or misapplication; to damage caused by improper maintenance (including
unauthorised parts service); to a product or part that has been modified in any way
and or if any Vario Hearables Ltd serial number or logo has been removed or defaced.
No Vario Hearables Ltd reseller, agent, or employee is authorised to make any
modification to this warranty.
Warnings
Product life and the protection it provides may be dramatically reduced if these
instructions and warnings are not adhered to.
Always wear hearing protection in noisy environments.
Choking hazard. Keep away from small children.
Always ensure that the module is securely located in the eartip, and that an airtight
seal is achieved within the ear canal.
Improper fitting will result in severely reduced attenuation.
Sudden or fast removal of your Vario Novos may damage the eardrum.
You should not use the optional lanyard where there is a risk that the lanyard could
be caught up during use.
Do not remove your Vario Novos by pulling on the lanyard.
Regularly inspect your Vario Novo modules, eartips and filters for serviceability.
Replace or repair to maintain maximum protection.
Should any defect in materials or workmanship be found, contact Vario Hearables
immediately. See Warranty for details.
Do not expose your Vario Novos or eartips to alcohol or chemicals. Do not expose to
extreme temperatures or humidity.
Dispose of batteries, silicone moulds and modules responsibly according to local
regulations, or return to Vario Hearables Ltd.
Vario Novos are not designed or made to be used as hearing aids.
1413

For additional information visit
www.variohearables.com
Vario Hearables Ltd
16 Waterer Rise, Wallington,
SM6 9DN, UK
[e-mail]
01737 45 22 00
Designed and manufactured in the UK
Recycle Vario Novo modules, eartips and batteries
in accordance with national regulations.
Packaging widely recycled.
v4.9 04/2021