Vestax Typhoon User manual

SPECFICATIONS
VOLTAGE BUS Power 5V/500mA H.P TEST AC: 3KV / 10mA / 3 sec
SAFETY SPEC / CE UL USB COMPATIBITY Full-Speech Signal Quality
MEASUREMENT
ITEM
SPECIFICATION MEASUREMENT
SIGNAL
REMARKS
2dBV±0.3dBV Master Output 0dB, 1kHz Sine Wave from MAC OUTPUT LEVE
4.8dBV±0.5dBV Headphone 0dB, 1kHz Sine Wave from MAC
Less than -80dBV Master Output 0dB, 1kHz Sine Wave from MAC S/N NOISE LEVEL
Less than -80dBV Headphone 0dB, 1kHz Sine Wave from MAC
Less than 0.03% Master Output 0dB, 1kHz Sine Wave from MAC THD + N
Less than 0.03% Headphone 0dB, 1kHz Sine Wave from MAC
Less than -85dBV Master Output 0dB, 1kHz Sine Wave from MAC CROSSTALK
Less than -85dBV Headphone 0dB, 1kHz Sine Wave from MAC
CUSTOMER: vestax
MODEL : TYPHOON
SERVICE MANUAL

No. Materials SPECS Qt
y
Remar
k
....4 EC10616TS E. CAP 10UF/16V (7MM) 9 EC209, 301, 302, 601, 602, 604,
EC605, 608, 609
....4 EC10625TL (LOW LEAKAGE) E. CAP 10UF/25V 1 EC801
....4 EC10625TS E. CAP 10UF/25V 2 EC910, 913
....4 EC22725TS Capacitor 220UF/25V-RoHS 1 EC802
....4 EC47550TS E. CAP (SMALL) 4.7UF/50V 6 EC901~905, 907
....4 EC47625TS E. CAPACITOR 47UF/25V 7MM 2 EC908, 911
....4 AA822383X IC AIC1525CS (SOP8) 1 IC905
....4 AL2-51-0140 DIODE POWER SCHOTTKY MBRS140LT3 40V 1A 2ZD903, 904
....4 AL2-61-7223 IC REG VOLTAGE NJU7223DL1-33 3.3V TO-252 2IC902, 903
....4 AL2-71-0074 IC MC33079 QUAD-OP-AMP SOP-14 (TL074) 1 IC602
....4 AL2-75-4344 IC CONVERTER D/A CS4344 24BIT 192KHZ (12S) TSSOP10 2IC301, 601
....4 CS101J5003NPO CHIP CAPACITOR SMD 100P/50V ±5% 0603 NPO-RoHS 6C401, 606, 607, 613, 614, 910
....4 CS102K5003X7R CHIP CAP 1000PF/50V,X7R,+/-10%, SMD 0603 1 C402
....4 CS104K5003X7R CHIP CAP 0.1UF/50V,X7R,+/-10%, SMD 0603 26
C210~212, 301, 302, 405, 410~417,
C601, C602, 615, 616, 901~906,
C913, 914
....4 CS270J5003COG C.CAP 27PF/50V,COG,+/-5%,-55~+125°C,SMD 0603 2C408, 409
....4 CS300J5003NPO CHIP CAPACITOR 30PF, NPO, +/-5%, 50V 2 C403, 404
....4 CS332J5003X7R C.CAP 3300PF/50V,X7R,+/-5%,SMD 0603 2 C604, 605
....4 CS472K5003X7R chip Cap 4.7nF 50V 10% 0603 X7R 2 C406, 407
....4 DIEN1N4148WSM DIODE FAST SWICTHING 1N4848W SOD-123 3 D801~803
....4 DISR26 SCHOTTKY BARRIER RECTIFIER SMD 4 ZD901, 905, 907, 908
....4 IC74AHC1G125GW IC 74AHC1G125G SOT353 1 IC908
....4 IC74HCT00D IC 74HCT00D QUAD 2 INPUT NAND GATE 1 IC907
....4 ICBA05FP IC (BA05FP) 1 IC901
....4 ICG696L293T1UF IC RESET 1 IC403
....4 ICMC34063ADR IC MC34063ADR SOIC8 (ALTERNATIVE: AL2-61-3463) 1IC904
....4 ICPCM1808PWR IC PCM1808PWR 1 IC202
....4 ICTUSB3200 IC TUSB3200ACPAH TQFP 1 IC401
....4 ICYHFRS005 IC 24LC64TIMI+PROGRAM SOIC8 1 IC402
.....5 IC24LC64TIMI IC (64K SERIAL EEPROM) SOP 150MIL 1
....4 RS000004F06 CHIP RES. 0 O 1% SMD 1206 5 R906, 910, 924, 951, ZD902
....4 RS000010J03 CHIP RES. 0 !5% SMD 0603 4 R430, 432, 803, 804
....4 RS001010F03 CHIP RES. 10 !1% SMD 0603 1 R431
....4 RS010K10F03 CHIP RES. 10K !1% SMD 0603 4 R429, 805, 907, 950
....4 RS015010F03 CHIP RES. 150 !1% SMD 0603 1 R437
....4 RS01K510F03 CHIP RES. 1.5K !1% SMD 0603 1 R405
....4 RS04R704J06 CHIP RES. 4.7 OHM,1/4W,+/-5%,1206 1 R901
....4 RS0R2204F06 CHIP RES. 0.22 OHM,1/4W,+/-1%,1206 1 R911
....4 RS100K10F03 CHIP RES. 100K !1% SMD 0603 4 R918~920, 923
....4 RS10118F03 CHIP RES. 100 OHM, 1/8W, ±1%, 0603 19 R217~220, 301~304, 411, 412,
R434~436, 601~604, 620, 621
....4 RS10218F03 CHIP RES. 1K OHM,1/8W,±1%,0603 3 R622, 623, 913
....4 RS10K710F03 CHIP RES. 10.7K OHM,1/10W,±1%,0603 2 R610, 611
....4 RS180K10F03 CHIP RES. 180K OHM,1/10W,+/-1%,0603 1 R922
....4 RS27R410F03 CHIP RES. 27.4 !1% SMD 0603 2 R406, 407
....4 RS33218F03 CHIP RES. 3.3K OHM,1/10W,±1%,0603 1 R912
....4 RS3K0910F03 CHIP RES. 3.09K !1% SMD 0603 1 R401
....4 RS3K2410F03 CHIP RES. 3.24K !1% SMD 0603 2 R606, 607
....4 RS47318F03 CHIP RES. 47K OHM,1/8W,+/-1%,0603 9 R612~619, 921
....4 RS4K9910F03 CHIP RES. 4.99K !1% SMD 0603 2 R427, 428
....4 RS560K10F03 CHIP RES. 560K !1% SMD 0603 2 R801, 802
....4 RS5K3618F03 CHIP RES 5.36K OHM , 1/8W, 1% 0603 2 R608, 609
....4 TR2SA1037ASM TRANSISTOR 608 SMD 1 Q801
....4 TR2SD2114KSM TRANSISTOR NPN 2SD2114K SOT-23 (SMD) 2 Q602, 603
....4 TRDTA124ESM TRANSISTOR A124 (SMD) 1 Q802
....4 UH465516-351 INDUCTOR 7.0UH 70M OHM 1.0A SMD 4.6*1.6*5.5 1L1
....4 UHPIC1207-221M COIL SMD 220UH 1 L2
....4 UHPIH6D28-220M INDUCTOR 22UH 1.2A SMD-ROHS 2 L4, 5
....4 EC33725TLE E.CAPACITOR 330UF/25V 8X15MM (UHD1E331MPT) 1EC909
....4 FCN2S1001801 CONNECTOR , 2 WAY CONTACT, 180°, 1.0MM, 18P 1FCN1
....4 JK4690-DR30-04F USB2.0 B-TYPE 90 1 JK901
....4 JKDJ-0702B-020 DC SOCKET 2.0MM 1 JK902

TYPHOON (BOM)
No. Materials SPECS Qt
y
Remar
k
.1 CGSNC02313SNL03 INNER CARTON (TYPHOON) 1
.1 CTSNC02513SNL03 OUTER CARTON (TYPHOON) 0.25
.1 GE39TMV01 GUARANTEE CARD 1
.1 GE39TMV02 CUSTOMER INSTRUCTION CARD 1
.1 GE39TMV03 ENVELOPE (BIG) 1
.1 GE39TMV04 ENVELOPE (SMALL) 1
.1 LAC42SNL21 LABEL (TRAKTOR LE) 1
.1 LAC42SNL32 LABEL (TRAKTOR LE ENABLED) 1 14
.1 LAC52SNL28 LABEL SAFETY (TYPHOON) 1 18
.1 MT510440102 FIXED METAL (WHEEL) W/PRINTING 2 2
.1
N
P251SNL03
N
AME PLATE (REAR) 1 16
.1
N
P251SNL09
N
AME PLATE (UP) 1 8
.1
N
P251SNL10
N
AME PLATE (DOWN) 1 9
.1 OPSNC02SNL03 INSTRUCTION MANUAL (TYPHOON) 1
.1 OPSNC02SNL07 MANUAL (TRAKTOR LE QUICK GUIDE) 1
.1 PLSNC0201 POLY FOAM (LEFT) 1
.1 PLSNC0202 POLY FOAM (RIGHT) 1
.1 PT5104401 FIXED PLASTIC (PLATTER) 2 4
.1 PT511061801 KNOB VR 3 13
.1 PT511062301 SLIDER KNOB(LARGE) W/SPRAYING 3 10
.1 PT511062401 SLIDER KNOB(PITCH) W/SPRAYING 2 11
.1 PT511062501 SLIDER KNOB(EQ) W/SPRAYING 8 12
.1 PT511062601 KNOB VR W/SPRAYING 2 15
.1 PT5110701 ROTATE KNOB 2 5
.1 PU007007003 CONDUCTIVE FOAM 2 3
.1 RN109111 E RING(9MM) 2 7
.1 SC0308FBNI SCREW 6 1
.1 SC0310RBBI SCREW 14 17
.1 SD35055000RJP LAMIN BAG 1
.1 TSASIO401 ASIO4 TYPHOON DRIVER CD 1
.1 TSTRAKTOR01 CD (TRAKTOR LE) WITH LICENSE NUMBER 1
.1 TWSNC02SNL11 TYPHOON (DM) USB CONTROLLER ASS'Y 1
..2 CA040218002 USB CABLE (BLACK) + CORE 1
..2 FFC1810002001 18P FLAT WIRE 200MM FFC 1 43
..2 LAC22SNL11 LABEL SERIAL NO 1 23
..2 LAC62SNL40 LABEL BARCODE (INNER CARTON) 1
..2 LAC62SNL41 LABEL BARCODE (MASTER CARTON) 0.5
..2 MT5101801 GROUNDING PLATE 2 36
..2 MT5105502 METAL SHAFT 2 41
..2
N
M1106115 VELVET CARPET 2 20
..2
N
M1106118 VELVET CARPET 2 19
..2
N
M5106101 VELVET CARPET 8 39
..2
N
P351SNL07 ALUMINIUM FOIL 2 48
..2 PT511060103 PLASTIC KNOB (PLAY) W/PRINTING 2 29
..2 PT5110602 PLASTIC KNOB(KEY) 2 25
..2 PT511060404 PLASTIC KNOB (HEADPHONE)(LEFT) 1 26
..2 PT511060405 PLASTIC KNOB (HEADPHONE)(RIGHT) 1 27
..2 PT511060406 PLASTIC KNOB (CUE/CUP) 2 28
..2 PT5110605 PLASTIC KNOB (+) 1 24
..2 PT5110606 PLASTIC KNOB(AUTO MIX) 8 21
..2 PT5110607 PLASTIC KNOB (REC) 2 22
..2 PT513020201 CABINET (SPRAYING) 1 47
...3 PT5130202 CABINET 1
..2 PT5130301 BOTTOM BOARD 1 37
..2 PU007015005 CONDUCTIVE FOAM 3 46
..2 RU0730604 RUBBER FOOT 4 38
..2 SC0306PBBI SCREW 13 34
..2 SC0308RBNI SCREW 28 31
..2 TWPC09S00102 PCB ASS'Y (SOUND CARD) 1
...3 PC09S001 PCB SOUND CARD (DOUBLE LAYER FR4 300*95MM) 1
...3 TWPC09S001A02 PCB ASS'Y SOUND CARD 1 40

No. Materials SPECS Qt
y
Remar
k
....4 RJ2008HP-11F15A RCA JACK (2P) 1 JK601
....4 SWSSSF113NA1 SWITCH (ON/OFF) 3T 1 SW901
....4 TE10200602 6P CONNECTOR SOCKET 90° 1 TE11
....4 TE612000301 3P CONNETOR SOCKET 2 TE4, 5
....4 TE622000302 3P CONNECTOR SOCKET 1 TE21
....4 VRR50202009 VARIABLE RESISTOR 5K2B 20MM 2 VR101, 102
....4 XTM06000X3 CRYSTAL 6MHZ(49US)-ROHS 1 X401
...3 TWPC09S001B01 PCB ASS'Y MIC.JK 1 35
....4 EC10550TS E. CAPACITOR 1UF/50V(7MM) 1 EC702
....4 EC10616TS E. CAP 10UF/16V (7MM) 1 EC704
....4 EC10716TS E. CAP (SMALL) 100UF/16V 3 EC705~707
....4 EC47450TS E. CAP (SMALL) 0.47UF/50V 1 EC701
....4 CS100J5003NPO C. CAP. SMD 10 PF 50V 5% 0603 NPO 1 C703
....4 CS102K5003X7R CHIP CAP 1000PF/50V,X7R,+/-10%, SMD 0603 1 C701
....4 CS104K1603X7R CHIP CAP 0.1UF ±10% 16V 0603 1 C704
....4 CS470J5003NPO CHIP CAP.47PF ,SMD0603,+/-5 %, 50V, NPO 1 C702
....4 ICNJM2100M IC (NJM2100M) 1 IC701
....4 RS01K510F03 CHIP RES. 1.5K !1% SMD 0603 2 R708, 709
....4 RS04K710F03 CHIP RES. 4.7K !1% SMD 0603 1 R704
....4 RS05K610F03 CHIP RES. 5.6K !1% SMD 0603 1 R702
....4 RS10518F03 RESISTOR 1M 1% SMD 0603 -ROHS 1 R705
....4 RS220K10F03 CHIP RES. 220K !1% SMD 0603 1 R701
....4 RS22318F03 CHIP RES.22K OHM,1/8W,±1%,0603 1 R703
....4 RS47318F03 CHIP RES. 47K OHM,1/8W,+/-1%,0603 2 R706, 707
....4 JY6314-02-030 EARPHONEBASE W/NUT 1 JK701
....4 TE622000302 3P CONNECTOR SOCKET 1 TE22
....4 VRR50303007 VARIABLE RESISTOR 50KA-ROHS 1 VR701
...3 TWPC09S001C01 PCB ASS'Y HEADPHONE JK 1 42
....4 EC10616TS E. CAP 10UF/16V (7MM) 2 EC303, 304
....4 EC10716TS E. CAP (SMALL) 100UF/16V 2 EC305, 306
....4 CS101J5003NPO CHIP CAPACITOR SMD 100P/50V ±5% 0603 NPO-RoHS 2C307, 308
....4 CS104K5003X7R CHIP CAP 0.1UF/50V,X7R,+/-10%, SMD 0603 1 C309
....4 ICNJM4556AM IC (NJM4556AM) 1 IC302
....4 RS003310F03 CHIP RES. 33 !1% SMD 0603 2 R317, 318
....4 RS01K510F03 CHIP RES. 1.5K !1% SMD 0603 2 R311, 312
....4 RS100K10F03 CHIP RES. 100K !1% SMD 0603 2 R305, 306
....4 RS10218F03 CHIP RES. 1K OHM,1/8W,±1%,0603 2 R319, 320
....4 RS6K6518F03 CHIP RES 6.65K OHM , 1/8W, 1% 0603 2 R313, 314
....4 TR2SD2114KSM TRANSISTOR NPN 2SD2114K SOT-23 (SMD) 2 Q301, 302
....4 JY6314-02-030 EARPHONEBASE W/NUT 1 JK301
....4 TE10200602 6P CONNECTOR SOCKET 90° 1 TE12
....4 VRR50301502 VARIABLE RESISTOR ROTARY 50KA*2 15MM 1VR301
..2 TWPC09S00202 PCB ASS'Y (CONTROL) 1
...3 PC09S002 PCB CONTROL )DOUBLE LAYER FR4 350*230MM) 1
...3 TWPC09S002A02 PCB ASS'Y CONTROL 1 30
....4 SWEVQ11L05R TACT SWITCH (5MM) ROUND TERMINAL 30 SW1~30
....4 AL2-51-4401 TRANS NPN 2N4401 40V 1A SOT-23 6 Q7~12
....4 AL2-51-4403 TRANSISTOR PNP 2N4403 40V 800MA SOT-23 6 Q1~6
....4 AL2-61-7223 IC REG VOLTAGE NJU7223DL1-33 3.3V TO-252 1IC901
....4 AL2-72-0339 IC LM339 ANALOG COMP SOP-14 4 IC601~604
....4 CS101J5003NPO CHIP CAPACITOR SMD 100P/50V ±5% 0603 NPO-RoHS 4C305, 306, 311, 312
....4 CS102K5003X7R CHIP CAP 1000PF/50V,X7R,+/-10%, SMD 0603 4 C303, 304, 309, 310
....4 CS103K5003X7R C.CAP 0.010UF 50V X7R,±10% SMD 0603 4 C301, 302, 307, 308
....4 CS104K5003X7R CHIP CAP 0.1UF/50V,X7R,+/-10%, SMD 0603 38 C1, 100~103, 108, 112~124, 130,
C145, 600~609, 801~805, 902,
....4 CS200J5003NPO C. CAP. SMD 20 pF 50V 5% 0603 NPO 2 C104, 105
....4 DI1SS302SM DIODE 1SS302 SC-70 2 D803, 804
....4 DI1SS352SM DIODE 1SS352 HE1A 2 D801, 802
....4 DIEN1N4148WSM DIODE FAST SWICTHING 1N4848W SOD-123 35 D1~30, 101, 600~603
....4 FCN2R1001801 FFC connector dual side conn 90° 1.0mm 18P 1 FCN1
....4 IC74AHC1G125GW IC 74AHC1G125G SOT353 1 IC103
....4 IC74HCT04D IC 74HCT04D SO14 1 IC1
....4 ICBA4558F IC (4558) SMD 1 IC600

No. Materials SPECS Qt
y
Remar
k
....4 ICLM358M IC LM358M DUAL OPA SOP-8 1 IC801
....4 ICTC4051BFN IC TC4051BFN SOP16 2 IC101, 102
....4 ICTC7W14F IC 2 IC301, 302
....4 ICYH98S02 IC WITH PROGRAME 1 IC100
.....5 ICPIC18F66J10 IC (PIC18F66J10-I/PT) 1
....4 RS006810F03 CHIP RES. 68 !1% SMD 0603 2 R623, 624
....4 RS010K10F03 CHIP RES. 10K !1% SMD 0603 10 R102, 110~114, 307, 308, 315, 316
....4 RS015010F03 CHIP RES. 150 !1% SMD 0603 38
R1~5, 8~19, 22~27, 29~32, 34, 35,
R600, 61, 62, 71, 72, 201, 202, 211,
R212
....4 RS01K510F03 CHIP RES. 1.5K !1% SMD 0603 2 R801, 802
....4 RS01K810F03 CHIP RES. 1.8K !1% SMD 0603 2 R621, 622
....4 RS022K10F03 CHIP RES. 22K !1% SMD 0603 4 R305, 306, 313, 314
....4 RS033010F03 CHIP RES. 330 !1% SMD 0603 8 R28, 33, 303, 304, 311, 312, 628,
629
....4 RS039010F03 CHIP RES. 390 !1% SMD 0603 2 R609, 610
....4 RS043K10F03 CHIP RES. 43K O 1% SMD 0803 2 R601, 602
....4 RS051010F03 CHIP RES. 510 !1% SMD 0603 2 R613, 614
....4 RS056010F03 CHIP RES. 560 !1% SMD 0603 6 R301, 302, 309, 310, 611, 612
....4 RS062010F03 CHIP RES. 620 !1% SMD 0603 2 R615, 616
....4 RS068010F03 CHIP RES. 680 !1% SMD 0603 2 R607, 608
....4 RS068K10F03 CHIP RES 68K OHM 1% 1/10W 0603 1 R627
....4 RS082010F03 CHIP RES. 820 !1% SMD 0603 2 R617, 618
....4 RS100K10F03 CHIP RES. 100K !1% SMD 0603 2 R603, 604
....4 RS10118F03 CHIP RES. 100 OHM, 1/8W, ±1%, 0603 4 R625, 626, 807, 808
....4 RS10218F03 CHIP RES. 1K OHM,1/8W,±1%,0603 17 R101, 115~126, 605, 606, 619, 620
....4 RS10518F03 RESISTOR 1M 1% SMD 0603 -ROHS 5 R100, 803~806
....4 TR2SC2412KSM TRANSISTOR 536 SMD 4 Q301~304
....4 TRBC857B TRANSISTOR BC857B 5 Q600~604
....4 XTM10000X6 CRYSTAL 10MHZ - 49US SMD 1 X100
....4 CN0620001006 CONNECTOR WIRE 6P/2.0/100MM 180° 2 CN1, 2
....4 DIRPI-352 DIODE 4 S301~304
....4 EC10550TS E. CAPACITOR 1UF/50V(7MM) 2 EC601, 602
....4 EC10625TLE E.CAP LOW ESR 10UF/25V 5*11M 1 EC100
....4 EC47525TS E.CAPACITOR 4.7UF/25V (7MM) 1 EC904
....4 EC47616TS E. CAP (SMALL) 47UF/16V 1 EC901
....4 TE622000302 3P CONNECTOR SOCKET 2 TE4, 5
....4 TE812000411 4P HEADER SIL 2MM MALE SHRD 2 (CN1, 2)
....4 TWLD-005HLV04 LED RED ASS’Y (SNC02) 10 LD3, 71, 72, 10, 12, 18, LD201,
202, LD22, 35
.....5 BALE48201-5A PLASTIC BOSS (LED) 1.5MM 1
.....5 LD-005HLVC LED RED (CUT LEAD) 1
....4 TWLD-005K6CS01 LED BLUE ASS’Y (SNC02) 12 LD1, 4, 61, 62, 8, 9, 14, LD16, 17,
LD211, 212, 24
.....5 BALE48201-5A PLASTIC BOSS (LED) 1.5MM 1
.....5 LD-005K6CSC LED BLUE (CUT LEAD) 1
....4 TWLD-305SYV04 LED (AMBER) ASS’Y (SNC02) 3 LD11, 13, 15
.....5 BALE48201-5A PLASTIC BOSS (LED) 1.5MM 1
.....5 LD-305SYVC LED AMBER (CUT LEAD) 1
....4 TWLD-511E4YG01 LED YELLOW/GREEN ASS’Y (SNC02) 4 LD2, 5, 19, 23
.....5 BALE48201-5A PLASTIC BOSS (LED) 1.5MM 1
.....5 LD-511E4YGC LED YELLOW/GREEN (CUT LEAD) 1
....4 TWLD5R1O1G301 LED BAR 5PCS ROUND HEAD LED 2 LDB1, 2
.....5 LD3G4HDA LED YELLOW/GREEN f3 ROUND HEAD DIP 3
.....5 LD3O4HWA LED ORANGE DIFUSE ROUND HEAD DIP 1
.....5 LDIFR324HDC LED 3MM RED (CUT LEAD) 1
.....5 PT5104405 LED PLASTIC FIX 1
....4 TWLD7R2O1G4X201 LED BAR 7 SQUARE TYPE HORIZANTAL 2X 1 LDB601
.....5 LD2G74HDN LED YELLOW/GREEN 7*4.95MM FLAT HEAD DIP 8
.....5 LD2O74HWN LED ORANGE DIFUSE FLAT HEAD DIP 2
.....5 LD2R74HDN LED RED 7*4.95MM FLAT HEAD DIP 4
.....5 PT5104404 LED PLASTIC FIX 2X 1
....4 TWLDIFR324HD-04 LED 3MM (RED) ASS’Y (SNC02) 1 LD600
.....5 BALE48201-5A PLASTIC BOSS (LED) 1.5MM 1