Volvo XC90 - ANNEXE 951 Quick start guide

WIRING DIAGRAM 2009
VOLVO XC90
TP 39131202

© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Data link connector in the passenger compartment.
Changes implemented up to and including May 2008.
Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Order number TP 39131202
Replaces previous publication 39131201 of Electronic Wiring Diagram Electronic Wiring
Diagram (EWD) which can be ordered from Technical Information Shop (TIS)
at www.volvocarstechinfo.ford.com/vss
We reserve the right to make modifications.

TP 39131202 XC90 2009 3
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain) ......................................................... 2
Explanations .................................................................. 6
Abbreviations................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Fuses
Engine compartment 11A/1-5 ....................................... 11
Engine compartment 11B/1-11 ..................................... 12
Engine compartment 11B/12-14................................... 13
Engine compartment 11B/15 ........................................ 14
Engine compartment 11B/16-21................................... 15
Passenger compartment 11C/1-4................................. 16
Passenger compartment 11C/5-7................................. 17
Passenger compartment 11C/8-10............................... 18
Passenger compartment 11C/11-14............................. 19
Passenger compartment 11O/1-2................................. 20
Cargo compartment 11E/1-7 ........................................ 21
Cargo compartment 11L/1 ............................................ 22
Cargo compartment 11O/6-12 ...................................... 23
Central electronic module (CEM) F1-F11 ..................... 24
Central electronic module (CEM) F15-F34 ................... 25
Rear electronic module (REM) F1-F7........................... 26
Rear electronic module (REM) F8-F28......................... 27
Rear electronic module (REM) F29-F38....................... 28
Relays
Ignition switch and relays............................................. 29
Engine compartment FMA1 - FST3............................. 30
Cargo compartment..................................................... 31
Other relays ................................................................. 32
Ground connections
Overview...................................................................... 33
31/1 - 31/46 ................................................................. 34
31/47 - 31/72 ............................................................... 35
31/73 - 31/84 ............................................................... 36
31/88 - 31/93 ............................................................... 37
31/94 - 31/121 ............................................................. 38
Control modules
Overview of locations................................................... 39
Overview designations................................................. 40
Central Electronic Module (CEM) 1:2 .......................... 41
Rear Electronic Module (REM) 1:2 .............................. 43
Data communication High speed CAN ........................ 45
Data communication Low speed CAN ......................... 46
Data communication LIN 1:2........................................ 47
Data communication MOST......................................... 49
Group 23 Fuel system
Engine management system, Diesel 1:3 ..................... 50
Engine management system, 5-Cyl. Turbo 1:2............ 53
Engine management system, 6-Cyl. 1:2 ...................... 55
Engine management system, 8-Cyl. 1:2 ...................... 57
Emission control, 5-Cyl. Turbo..................................... 59
Emission control, 6-Cyl. ............................................... 60
Emission control, 8-Cyl. ............................................... 61
Group 26 Cooling system
Cooling fan, 5-Cyl. ....................................................... 62
Cooling fan, Diesel, 6-Cyl. & 8-Cyl............................... 63
Group 27 Engine control
Cruise control, 5-Cyl. ...................................................64
Cruise control, Diesel, 6-Cyl. & 8-Cyl............................65
Group 32 Alternator and voltage regulator
Power supply ............................................................... 66
Group 33 Starting system
Starting system, 5-Cyl.................................................. 67
Starting system, Diesel, 6-Cyl. & 8-Cyl........................ 68
Table of Contents 1:3

TP 39131202 XC90 2009 4
Group 35 Lighting
High and low beam/(Bi-Xenon®) &
Daytime running lamps ............................................... 69
Active headlights (ABL) ............................................... 70
Fog lights ..................................................................... 71
Brake lights.................................................................. 72
Reversing lights ........................................................... 73
Follow-me-home lighting.............................................. 74
Running lights/ Parking lights, Tail lights &
License plate lighting ................................................... 75
Interior lighting ............................................................. 76
Beam length adjustment.............................................. 77
Auxiliary lights.............................................................. 78
Group 36 Additional electrical equipment
Rain sensor.................................................................. 79
Direction indicator and Hazard warning flashers ......... 80
Wiper/washer Windshield ............................................ 81
High pressure headlight washer .................................. 82
Wiper/washer Rear window......................................... 83
Horn ........................................................................ 84
Electronic immobilizer.................................................. 85
Anti-theft alarm ............................................................ 86
Parking assistance....................................................... 87
Alcohol lock.................................................................. 88
Accessory Electronic Module (AEM) 1:2 ..................... 89
Group 37 Wiring and fuses
Diagnostics system...................................................... 91
12V outlet .................................................................... 92
Tow hitch cable harness, 4/7-pin ................................. 93
Tow hitch cable harness, 7-pin .................................... 94
Tow hitch cable harness, 13-pin ................................. 95
Accessory USB unit (AUU) .......................................... 96
Group 38 Instruments
Seat belt reminder ....................................................... 97
Driver information module, 5-Cyl. ................................ 98
Driver information module Diesel................................. 99
Driver information module, 6-Cyl. .............................. 100
Driver information module, 8-Cyl. .............................. 101
Group 39 Other
Audio with external amplifier...................................... 102
Audio with internal amplifier ....................................... 103
Portable navigation system........................................ 104
Road Traffic Information module (RTI) ...................... 105
Satellite radio ............................................................. 106
Rear seat entertainment ............................................ 107
Rear seat entertainment, accessory .......................... 108
Infotainment ............................................................... 109
Rear seat entertainment, roof mounted ..................... 110
Parking camera.......................................................... 111
Parking camera & AEM.............................................. 112
Bluetooth handsfree, external amplifier ..................... 113
Bluetooth handsfree, internal amplifier ...................... 114
Bluetooth handsfree with AEM,
internal amplifier, LHD ............................................... 115
Bluetooth handsfree with AEM,
internal amplifier, RHD............................................... 116
Bluetooth handsfree with AEM,
external amplifier, LHD .............................................. 117
Bluetooth handsfree with AEM,
external amplifier, RHD.............................................. 118
Group 43 Transmission
Automatic transmission AW51AWD........................... 119
Automatic transmission TF-80SC AWD 8-Cyl. .......... 120
Automatic transmission TF-80SC/TF-80SC AWD
6-Cyl. & Diesel ........................................................... 121
Geartronic AW51 AWD.............................................. 122
Shift lock AW51 & Manual ......................................... 123
Differential Electronic Module (DEM)......................... 124
Table of Contents 2:3

TP 39131202 XC90 2009 5
Group 59 Brake system
Brake control system ................................................. 125
Group 64 Steering
Electronic power steering .......................................... 126
Group 83 Doors and openings
Central locking........................................................... 127
Power windows.......................................................... 128
Power sunroof............................................................ 129
Group 84 Exterior decorative elements, etc.
Power exterior rearview mirrors................................. 130
Blind spot information system.................................... 131
Heated exterior rearview mirrors ............................... 132
Heated rear window................................................... 133
Group 85 Interior equipment
Power driver’s seat .................................................... 134
Power passenger seat ............................................... 135
Heated seats.............................................................. 136
Massage seats with ventilation .................................. 137
Heated seats second row of seats............................. 138
Group 87 Climate control system
Climate control system, 5-Cyl. 1:2............................. 139
Climate control system, Diesel, 6-Cyl. & 8-Cyl. 1:2 ... 141
Climate control system rear ....................................... 143
Parking heater, auxiliary heater ................................. 144
Relay, electric engine heater ..................................... 145
Group 88 Internal equipment
Remote garage door opener...................................... 146
Supplemental Restraint System (SRS)...................... 147
Connectors................................................148
Branching points .....................................173
Cable harness routine in vehicle
Engine harness Gasoline 5-Cyl. .................................183
Engine harness Gasoline 6-Cyl. .................................184
Engine harness 8-Cyl..................................................185
Engine harness Diesel ................................................186
Engine compartment harness LHD.............................187
Engine compartment harness RHD ............................188
Passenger compartment harness LHD.......................189
Passenger compartment harness RHD ......................190
Cargo compartment harness ......................................191
Roof harness ..............................................................192
Tailgate harness .........................................................192
Door harness ..............................................................193
Executive harnesses...................................................194
Component illustrations ..........................195
Index 1:2 ....................................................248
List of components 1:7 ............................250
Table of Contents 3:3

TP 39131202 XC90 2009 6
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E=Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N=Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ABL = Active Bi-Xenon® Light
ACC = Accessories
Ag = Silver plated
Au = Gold plated
AUDIO = Audio system
AUTO = Automatic transmission
Bi-X = Bi-Xenon®
BLIS = Blind spot information system
CEM = Central Electronic Module
DIESEL = D5244 T4/T5/T6/T7
DRL = Daytime Running Lights
DSTC = Dynamic Stability Traction Control
ECC = Electronic climate control system
ECPS = Electronic power steering
EXC = Exclusive
EXT. D = Extended electrical distribution
HISPEED = High speed data bus
LH = Left-hand side
LHD = Left-hand drive
LOSPEED = Low speed data bus
MAN = Manual transmission
MCC = Manual Climate Control
PCL = Power Child Lock
PETROL = Gasoline
REM = Rear Electronic Module
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SRS = Airbag
T = Turbocharged engine
W/O = Without
5CYL = 5-cylinder engine
6CYL = 6-cylinder engine
8CYL = 8-cylinder engine
Colors
BL = Blue
BN = Brown
GN = Green
GR = Gray
NL = Natural
LBL = Light Blue
LGN = Light Green
OR = Orange
P=Pink
R=Red
SB = Black
VO = Violet
W=White
Y = Yellow

TP 39131202 XC90 2009 7
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
26 Converter
27 Optics
31 Ground connection
53 Branching point
54 Connector
B. Branching points
The wiring diagrams contain numbered junction
points, e.g. 53/352.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the "Connectors" sec-
tion.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars are equipped with CAN, LIN & MOST
networks that transmit information. Connections to
these networks are not shown in their entirety on the
respective wiring diagram. Complete information on
Data communication can be found in the section
entitled "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Component location
There is a section at the end of the manual in which
the appearance and location of components is
described in numerical order.

TP 39131202 XC90 2009 8
How to use the wiring diagrams 2:2
AF EDCB
G
10/1-2
BN
20
53/503
7/149
BN
W
3
2
1
5
3
UEM
D:49
13
8
GN
BN
54/16
1
2
3VO-W
1
2
11C/7
30+
1
2
11C/6
D:34
D:35
D:50
CEM
4/56
21 54/13
SWM
3/254
LIN
R R
31/98
4/70
1
11
R
R
BN
44
VO-W
W-BL W
53/505 VO-W
D:11 54/13
14
W
BL-W
321
4
H
SB
31/93
BN
53/331
L
6/1
RSM
20 BN
BN
31/83
CAN
LIN
C:31
BN
53/397
CAN
LIN
LIN
7
GN-W
D:58
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution
box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component
LIN
CAN
1
1

TP 39131202 XC90 2009 9
R-W
R-W
R-SB
GN-Y
R-W
R-W
R
R
R
R-W
GN-OR
BL-R
BL-R
BL-R
BL
GN-OR
BL-R
R
SB
R
R
R
Y
Y
BL
R
RR
123
11A/1
54/1C
2
1
11A/2
2
1
11A/3
2
1
B
11A/4
2
1
11A/5
2
1
11B/1
2
1
11B/2
2
1
11B/3
2
1
11B/4
2
1
11B/5
2
1
11B/6
2
1
11B/7
2
1
11B/8
2
1
11B/9
2
1
11B/10
2
1
11B/11
2
1
11B/12
2
1
11B/13
2
1
11B/14
2
1
11B/15
2
1
11B/16
2
1
11B/17
2
1
11B/18
2
1
11B/19
2
1
11B/20
2
1
11B/21
2
1
5(87)2(85)
3(30)1(86)
FMA2
15/31
A1 A1 A1
5(87)2(85)
4
1
2
35
3(30)1(86)
FST1
2/90
6/1
4(87a) 5(87)2(85)
4
1
2
35
3(30)1(86)
FST2
2/91
4(87a) 5(87)2(85)
4
1
1
2
2
35
3(30)1(86)
FST3
2/182
4(87a)
5(87)2(85)
4
1
2
3
3(30)1(86)
FMA3
2/32
5(87)2(85)
4
1
2
3
3(30)1(86)
FMA1
BL-GN
2/35
5(87)2(85)
4
1
2
3
3(30)1(86)
FMI2
2/22
17/17
4/46B:29
5
GR 54/1B:6
GN-R 54/1B:8
BL-OR 4/46B:44
GN-W
R-W
6CYL / 8CYL
PETROL
PETROL
DIESEL
DIESEL
DIESEL
DIESEL
DIESEL
8 CYL
8 CYL
8 CYL
4/46B:32
GR-SB
GR
4/56C:25
53/331
4/56C:4
GN-SB
6/104:1
Y
Y
6/1
Y
4/56C:3
Y-W
GN-OR
BL-OR
Y-W
4/46B:42 4/46B:16 4/46B:51
4/46
B:9
4/46B:11
4/46B:53
Y-W
4/46B:27
DC FGE
53/305
6 CYL
BL-OR
GN-Y
GN-Y
1
4(87a)
BL-GN
6 CYL
4/46B:10
DIESEL
DIESEL
6 CYL
4/109:11
A
R
R
11L/1
54/146 1
R4/71:2
GN-GR
BL-R 4/56B:1
6/114:1
R-W
SB 8/84:1
5(87)2(85)
4
1
2
3
3(30)1(86)
FMI1
2/133
5
4(87a)
Electrical distribution 1:2
Overview

TP 39131202 XC90 2009 10
2
R
R
R
BL-R
4/9B:27/55
53/408
4
3/1
R-SB
X
30
5
S
37
50
6
15
8
1
15 15I 16/65:1
BL-R
53/443 BL-R 4/9B:28/56
3/157:2
1
11E
67
2
45
22
23
22
1
F1-38
D:16
B:2
B:24
B:3
B:16
D:15
D:60
4/56
CEM
D:8
CAN
1/1
12V
+
SB
SB
-
31/53
VO
VO
BL-R
2
C:13
C:14
REM
54/40D
2
VO VO
C:13
D:50
D:35
LIN
BL-R
Y
Y-W
C:14
3/157:1
1
E:A
E:B
A:23
R
R
R
R
R
Y-R
K:1
A:13
ABCDEF G
BL
BL
R-W
BL-R
R
A:29
54/40C 12
F3, 5-10,
17-23,
31-32 ,34
F1-2, 1
F29
1,
13-16,
26-30, 33
CAN
LIN
R
R
R
11C/1111C/1
1 1
11C/2
2 2
11C/4
11
11C/3
1
11C/5
222
11C/8
1
11C/6
11
11C/7
2 22
1
11C/9
11
11C/10
2 22
11C/1311C/12
1 1
2 2
53/415
R
R
R
53/403
11C/14
1
2
R R R
DIESEL
53/3009
R
R
RR
R
ACM
A:1
6/26
B+
31
G
LIN
1
6/25
31
M
30
8CYL
8CYL
4/58
Electrical distribution 2:2
Overview

TP 39131202 XC90 2009 11
11A Fuses in the engine compartment
No. Fuse function via A
1 4/109 Glow plug control unit (GCU)
20/22-26 Glow plug
-
4/109
60
2 6/29 Cooling fan motor, Diesel 4/71 60
3- --
4- --
5- --
5
4
3
2
1
Fuses
Engine compartment 11A/1-5

TP 39131202 XC90 2009 12
11B Fuses in the engine compartment
No. Fuse function via A
1 4/16 Brake Control Module (BCM) - 30
2 4/16 Brake Control Module (BCM) - 30
3 6/104 High pressure headlight washer motor 2/182 35
4 6/35 Fuel pump, auxiliary heater
6/73 Coolant pump, auxiliary heater
9/30 Auxiliary heater
4/7
4/7
4/7
25
5 54/8 Connector, cable harness, auxiliary lights, 30-feed - 20
6 6/25 Starter motor 2/35 35
7 2/90 Relay, windshield wiper, low/high speed
2/91 Relay, intermittent wiping
6/1 Windshield wiper motor
2/91
-
2/90, 2/91
25
8 4/83 Control module fuel pump
6/33 Fuel pump
4/56
4/56
15
9 4/28 Transmission Control Module (TCM), TF-80SC/TF-80SC AWD - 15
10 4/46 Engine Control Module (ECM), Diesel
20/3-8 Spark plug and ignition coil, not 8-Cyl.
20/14 Condenser, ignition coils, 8-Cyl.
20/46-53 Spark plug with ignition coil, 8-Cyl.
-
-
-
-
20
11 6/44 Cooling fan, electrics box, engine compartment
7/51 Accelerator pedal sensor
8/3 Electromagnetic clutch, climate control system
-
-
2/22
10
continues
1
2
3
4
5
6
7
8
9
21
20
19
18
17
16
15
14
13
12
11
10
Fuses
Engine compartment 11B/1-11

TP 39131202 XC90 2009 13
11B Fuses in the engine compartment
No. Fuse function via A
12 7/17 Mass air flow sensor (MAF), Diesel - 5
4/46 Engine Control Module (ECM), Gasoline not 8-Cyl.
7/17 Mass air flow sensor (MAF), Gasoline not 8-Cyl.
8/6-11 Injection valves, Gasoline not 8-Cyl.
8/146-
8/153 Injection valves, 8-Cyl.
-
-
-
-
15
13 4/46 Engine Control Module (ECM), 8-Cyl.
6/120 Throttle body motor, 8-Cyl.
-
4/46
10
4/46 Engine Control Module (ECM), Diesel
6/118 Swirl throttle control motor, Diesel
6/120 Throttle body motor, Diesel
6/139 Upper actuating motor, intake manifold
6/140 Lower actuating motor, intake manifold
8/98 Fuel pressure control valve, Diesel
8/111 Fuel flow control valve
-
4/46
4/46
-
-
4/46
4/46
15
14 7/15 Heated oxygen sensor, Diesel - 10
7/15 Heated oxygen sensor
7/82 Heated oxygen sensor, diagnosis 1
7/103 Heated oxygen sensor 3
-
-
-
20
7/15 Front heated oxygen sensor, bank 2, 8-Cyl.
7/82 Front heated oxygen sensor, bank 1, 8-Cyl.
7/103 Rear heated oxygen sensor, bank 2, 8-Cyl.
7/104 Rear heated oxygen sensor, bank 1, 8-Cyl.
-
-
-
-
20
continues
1
2
3
4
5
6
7
8
9
21
20
19
18
17
16
15
14
13
12
11
10
Fuses
Engine compartment 11B/12-14

TP 39131202 XC90 2009 14
11B Fuses in the engine compartment
No. Fuse function via A
15 6/67 Pump, fuel leakage control
8/18 EVAP valve
8/19 Solenoid, variable valve timing, intake
8/28 Turbocharger control valve
8/81 Solenoid, variable valve timing outlet
9/32 PTC resistor, crankcase ventilation
-
-
-
-
-
10
8/125 Variable valve lifter, front plane, 6-Cyl.
8/126 Variable valve lifter, rear plane, 6-Cyl.
-
-
15
4/46 Engine Control Module (ECM), 8-Cyl.
6/67 Pump, fuel leakage control, 8-Cyl.
7/17 Mass air flow sensor (MAF), 8-Cyl.
8/3 Electromagnetic clutch, climate control system, 8-Cyl.
8/18 EVAP valve, 8-Cyl.
8/19 Solenoid, variable valve timing, intake, bank 2, 8-Cyl.
8/81 Solenoid, variable valve timing, exhaust, bank 2, 8-Cyl.
8/107 Valve, variable intake, 8-Cyl.
8/117 Solenoid, variable valve timing, intake, bank 1, 8-Cyl.
8/118 Solenoid, variable valve timing, exhaust, bank 1, 8-Cyl.
-
-
-
-
-
-
-
-
-
-
4/109 Glow plug control unit (GCU)
6/143 Turbo control motor, Diesel
8/64 Solenoid valve, engine pad, Diesel
8/113 Bypass valve, EGR cooling, Diesel
8/120 EGR valve, Diesel
-
-
-
-
-
continues
1
2
3
4
5
6
7
8
9
21
20
19
18
17
16
15
14
13
12
11
10
Fuses
Engine compartment 11B/15

TP 39131202 XC90 2009 15
Fuses
Engine compartment 11B/16-21
11B Fuses in the engine compartment
No. Fuse function via A
16 10/1 Left front lamp housing, daytime running lights
10/70 Low beam, left
4/56
4/56
20
17 10/2 Right front lamp housing, daytime running lights
10/66 Low beam, right
4/56
4/56
20
19 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM)
-
-
5
20 10/11 Running/parking light, front left
10/12 Running/parking light, front right
10/71 Side running light, front left
10/73 Side running light, front right
4/56
4/56
4/56
4/56
15
21 6/114 Vacuum pump 2/133 20
1
2
3
4
5
6
7
8
9
21
20
19
18
17
16
15
14
13
12
11
10

TP 39131202 XC90 2009 16
11C Fuses in the passenger compartment
No. Fuse function via A
1 6/28 Motor, passenger compartment fan 4/31 30
2 16/105 Audio Module (AUD) - 30
3 4/52 Power Seat Module (PSM)
6/16 Motor driver’s seat, backrest angle
6/17 Motor driver’s seat, up/down front edge
6/18 Motor driver’s seat, up/down rear edge
6/19 Motor driver’s seat, fore/aft
-
4/52
4/52
4/52
4/52
25
4 6/20 Motor passenger seat, fore/aft
6/64 Motor passenger seat, backrest angle
6/65 Motor passenger seat, up/down front edge
6/66 Motor passenger seat, up/down rear edge
3/27
3/27
3/27
3/27
25
continues
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
Fuses
Passenger compartment 11C/1-4

TP 39131202 XC90 2009 17
Fuses
Passenger compartment 11C/5-7
11C Fuses in the passenger compartment
No. Fuse function via A
5 3/74 Left-hand front door lock unit
3/126 Driver/Passenger Door Module (DDM)/(PDM)
6/58 Motor, front left power window
6/62 Left power exterior rearview mirror
9/33 Left heated exterior rearview mirror
10/148 Left exterior rearview mirror lighting
3/126
-
3/126
3/126
3/126
3/126
25
6 3/75 Right-hand front door lock unit
3/127 Passenger/Driver Door Module (PDM)/(DDM)
6/60 Motor, front right power window
6/63 Right power exterior rearview mirror
9/34 Right heated exterior rearview mirror
10/149 Right exterior rearview mirror lighting
3/127
-
3/127
3/127
3/127
3/127
25
7- --
continues
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38

TP 39131202 XC90 2009 18
11C Fuses in the passenger compartment
No. Fuse function via A
8 16/1 Integrated Audio Module (IAM)
16/109 DVD player/control module
-
-
15
9 4/124 Accessory USB unit (AUU)
16/46 Multimedia display
16/108 Multimedia Module (MMM)
16/109 DVD player/control module
16/139 Global Positioning System Module (GPS)
16/145 Remote Digital Audio Receiver (RDAR)
54/112 Connector, cable harness, infotainment, 30-feed
-
-
-
-
-
-
-
10
10 3/111 Light Switch Module (LSM)
3/254 Steering Wheel Module (SWM)
4/68 Steering Wheel Angle Sensor Module (SAS)
17/13 Data link connector
-
-
3/254
-
5
continues
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
Fuses
Passenger compartment 11C/8-10

TP 39131202 XC90 2009 19
Fuses
Passenger compartment 11C/11-14
11C Fuses in the passenger compartment
No. Fuse function via A
11 3/157 Switch, passenger side airbag
4/9 Supplemental Restraint System module (SRS)
4/28 Transmission Control Module (TCM)
4/46 Engine Control Module (ECM)
4/56 Central Electronic Module (CEM)
4/58 Rear Electronic Module (REM)
11O/1 Fuses in spare fuse holder, passenger compartment
11O/2 Fuses in spare fuse holder, passenger compartment
16/65 Antenna ring/ignition switch illumination
3/1
3/1
3/1, 4/56
3/1, 4/56
3/1
3/1
-
3/1
3/1
7.5
12 3/117 Switch unit, ceiling light
4/33 Sun Roof Module (SRM)
4/70 Upper Electronic Module (UEM)
4/76 Remote control unit for garage door opener
7/149 Rain Sensor Module (RSM)
10/114 Vanity mirror lighting, left
10/115 Vanity mirror lighting, right
10/150 Rear reading light
10/172 Reading light, third row of seats
4/70
4/70
-
4/70
4/70
4/70
4/70
4/70
4/70
10
13 4/70 Upper Electronic Module (UEM)
6/15 Sunroof motor
-
4/33
15
-
14 16/60 Phone Module (PHM) - 5
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38

TP 39131202 XC90 2009 20
Fuses
Passenger compartment 11O/1-2
11O/1-2 Fuses in spare fuse holder, passenger compartment
No. Fuse function via A
1 Alcohol lock
Alcohol lock
-
2/241
5
2 Alcohol lock -5
11O/1-2