Walker Bay 8 User manual

WalkerBay™
Performance Sail Kit
Assembly Instructions
Walker Bay 8
IMPORTANT SAFETY INFORMATION
•READ OWNERS MANUAL. IMPROPER USE MAY CAUSE INJURY OR DEATH.
•EACH PASSENGER MUST HAVE AN APPROVED PERSONAL FLOTATION DEVICE.
•CARRY AN OAR AND BAILER ON BOARD WHILE SAILING.
•USE A BUDDY SYSTEM, SAIL WHERE PEOPLE CAN SEE AND HELP YOU IF
NECESSARY.
•DO NOT USE A MOTOR OR SAIL UNLESS YOU USE THE EQUIPMENT IN THE MANNER
INTENDED AND/OR AS DESCRIBED IN THE MANUAL.
•DO NOT USE THIS BOAT UNDER THE INFLUENCE OF DRUGS OR ALCOHOL.
•DO NOT USE THIS BOAT IF YOU SUSPECT A CRACK OR A HOLE. IT MAY BE UNSAFE.
•USE CAUTION WHEN ENTERING OR EXITING THE BOAT.
•KEEP YOUR WEIGHT CENTERED AND DISTRIBUTE THE WEIGHT OF GEAR AND
PASSENGERS EVENLY.
•DO NOT USE THIS BOAT AS A TOW CRAFT.
•THIS BOAT IS NOT A TOY. ADULT SUPERVISION ADVISED.
•PARTS AND SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE.
•FOR SAFETY INFORMATION OR PARTS, CALL WALKER BAY BOATS AT:
(888) 44-WALKER OR [phone].
GB F E D I NL S

2
6
8
34
11
910
7
513
2
1
16
15
12
14
b
a
c
d
ef
SRWB8001
1. Wooden Dowel ........................................................................ 1 ea.
2. Mast Support Tube .................................................................. 1 ea.
3. Mast Support Clamp ............................................................... 1 ea.
4. Seat Block Clamp.................................................................... 1 ea.
5. Ratchet Block ...........................................................................1 ea.
6. Seat Plug................................................................................. 1 ea.
7. Open Keel Plate Cover............................................................ 1 ea.
8. Lower Mast Half (with gooseneck ring) ................................... 1 ea.
9. Upper Mast Half ...................................................................... 1 ea.
10. Boom ....................................................................................... 1 ea.
11. Daggerboard............................................................................ 1 ea.
12. Rudder (Three Position Kick-Up Style) ................................... 1 ea.
13. Tiller Handle ............................................................................ 1 ea.
14. Performance Sail ..................................................................... 1 ea.
15. Line Kit
a. Mainsheet Line
160 in. (4.07 m) Green ....................................................... 1 ea.
b. Outhaul Line
50 in. (1.27 m) Yellow ......................................................... 1 ea.
c. Clew Line
12 in. (0.30 m) Yellow ......................................................... 1 ea.
d. Cunningham Line
32 in. (0.81 m) Red............................................................. 1 ea.
e. Vang Line
60 in. (1.53 m) Blue............................................................ 1 ea.
f. Shock Cord (Bungee Cord)
78 in. (1.98 m) Green ......................................................... 1 ea.
16. Flotation Bag ........................................................................... 1 ea.
Checklist of Components
Liste de contrôle des composants
Lista de comprobación
de los componentes
Bauteil-Checkliste
Lista del componenti
Stuklijst
GB Checklist of Components (Specifications and contents subject to change without notice)
F
1. Cheville en bois ................................................................................1
2. Tube de support du mât.....................................................................1
3. Collier de support du mât .................................................................1
4. Collier du siege .................................................................................1
5. Bloc d’encliquetage ...........................................................................1
6. Bouchon pour siège ..........................................................................1
7. Couverture de quille ouverte ............................................................1
8. Moitié inférieure du mât (avec bague à col de cygne) .....................1
9. Moitié supérieure du mât ..................................................................1
10. Bôme..................................................................................................1
11. Dérive.................................................................................................1
12. Gouvernail (type relevable à trois positions) ....................................1
13. Poignée de barre ..............................................................................1
14. Voile ..................................................................................................1
15. Kit de cordages
a. Ecoute de grand voile
Cordage vert de 4,07 m................................................................1
b. Hale-dehors
Cordage jaune de 1,27 m.............................................................1
c. Point d’écoute
Cordage jaune de 0,30 m
d. Cunningham
Cordage rouge de 0,81 m.............................................................1
e. Hale-bas
Cordage bleu de 1,53 mètres.......................................................1
f. Corde élastique
Cordage vert de 1,98 m................................................................1
16. Sac d matériel....................................................................................1
Liste de contrôle des composants (spécifications et contenus sujets à modifications sans préavis)
E
1. Clavija de madera ............................................................................1
2. Tubo de soporte del mástil................................................................1
3. Mordaza de soporte del mástil..........................................................1
4. Mordaza del asiento..........................................................................1
5. Bloque de trinquete ...........................................................................1
6. Tapa del asiento ................................................................................1
7. Tapa de placa de quilla abierta .........................................................1
8. Mitad inferior del mástil (con anilla en ‘S’) ........................................1
9. Mitad superior del mástil ...................................................................1
10. Botavara ............................................................................................1
11. Orza alzable ......................................................................................1
12. Timón (tres posiciones, tipo replegable) ...........................................1
13. Caña del timón ..................................................................................1
14. Vela de altas prestaciones ................................................................1
15. Cordaje
a. Línea de escota mayor
160" (4,07 m) – Línea verde .........................................................1
b. Línea de driza de fuera
50" (1,27 m) – Línea amarilla .......................................................1
c. Línea de puño
12" (0,30 m) – Línea amarilla .......................................................1
d. Línea Cunningham
32" (0,81 m) – Línea roja ..............................................................1
e. Línea de osta
60" (1,53 m) – Línea azul..............................................................1
f. Cuerda antisacudidas (cuerda bungee)
78" (1,98 m) – Cuerda verde ........................................................1
16. Bolsa de aparejo
Lista de comprobación de los componentes (Las especificaciones y el contenido podrán alterarse sin previo aviso)

3
Bauteil-Checkliste (Spezifikationsänderungen bleiben vorbehalten)
1. Caviglia di legno ...............................................................................1
2. Supporto albero .................................................................................1
3. Collare supporto albero .....................................................................1
4. Stopper per la cima ...........................................................................1
5. Blocchetto di arresto..........................................................................1
6. Chiusura scassa di deriva..................................................................1
7. Protezione lamiera di chiglia..............................................................1
8. Parte inferiore dell’albero (con anello di
articolazione del boma) .....................................................................1
9. Parte superiore dell’albero ................................................................1
10. Boma..................................................................................................1
11. Deriva.................................................................................................1
12. Timone (tipo a tre posizioni) .............................................................1
13. Barra del timone ...............................................................................1
14. Vela ....................................................................................................1
15. Corredo di cime
a. Scotta con anello per cima di scorrimento
160 poll. (4,07 m) colore verde ....................................................1
b. Alafuori
50 poll. (1,27 m) colore giallo.......................................................1
c. Cima d'angolo
12 poll. (0,30 m) colore giallo.......................................................1
d. Cima Cunningham
32 poll. (0,81 m) colore rosso ......................................................1
e. Ostino
60 poll. (1,53 m) colore azzurro ...................................................1
f. Fune antidanneggiamento deriva (fune Bungee)
78 poll. (1,98 m) colore verde ......................................................1
16. Sacco per manovre............................................................................1
1. Holzdübel ......................................................................................je 1
2. Mastaufnahmerohr.........................................................................je 1
3. Mastklammer .................................................................................je 1
4. Sitzklemme ....................................................................................je 1
5. Ratschenblock ...............................................................................je 1
6. Sitzverschluß .................................................................................je 1
7. Kieldeckplatte.................................................................................je 1
8. Mastunterteil (mit Segelhalsbeschlag) ..........................................je 1
9. Mastoberteil ...................................................................................je 1
10. Baum..............................................................................................je 1
11. Schwert..........................................................................................je 1
12. Ruder (drei Positionen, hochklappbar) ..........................................je 1
13. Pinnenausleger..............................................................................je 1
14. Leistungssegel...............................................................................je 1
15. Seilsatz
a. Großschottau mit Traveller-Beschlag
160 Zoll (4,07 m) grün..............................................................je 1
b. Ausholleine
50 Zoll (1,27 m) gelb ................................................................je 1
c. Schothornleine
12 Zoll (0,30 m) gelb ................................................................je 1
d. Cunningham-Leine
32 Zoll (0,81 m) rot...................................................................je 1
e. Vang-Leine
60 Zoll (1,53 m) blau ................................................................je 1
f. Dämpfungsschnur (Bungee-Schnur)
78 Zoll (1,98 m) grün................................................................je 1
16. Zeugtasche ....................................................................................je 1
Lista del componenti (Specifiche e dati soggetti a variazione senza preavviso)
1. Houten nagel ................................................................................1 st.
2. Maststeunbuis...............................................................................1 st.
3. Maststeunklem..............................................................................1 st.
4. Bankjeklamp .................................................................................1 st.
5. Ratelblok .......................................................................................1 st.
6. Afdichtprop....................................................................................1 st.
7. Afdekking van open kielplaat........................................................1 st.
8. Onderste masthelft (met halsdoekring) ........................................1 st.
9. Bovenste masthelft .......................................................................1 st.
10. Giek...............................................................................................1 st.
11. Zwaard ..........................................................................................1 st.
12. Roer (met drie standen,
van het op klaptype) .....................................................................1 st.
13. Helmstok .......................................................................................1 st.
14. Performance-zeil ...........................................................................1 st.
15. Tuigage
a. Grootschootlijn met overloopring
4,07 m groen lijn......................................................................1 st.
b. Schoothoornlijn
1,27 m gele lijn........................................................................1 st.
c. Geitouw
0,30 m wit/gele lijn...................................................................1 st.
d. Cunningham-lijn
0,81 m rood/witte lijn ...............................................................1 st.
e. Pardoenlijn
1,53 m wit/blauwe lijn..............................................................1 st.
f. Amortiseurkoord
1,98 m wit/groen koord............................................................1 st.
16. Tas met tuig ..................................................................................1 st.
Stuklijst (Specificaties en inhoudsopgave vatbaar voor wijzigingen zonder voorafgaande kennisgeving)
1. Plastlås..............................................................................................1
2. Mastfot...............................................................................................1
3. Mastfotsfäste .....................................................................................1
4. Blockfäste för toften...........................................................................1
5. Spärrblock .........................................................................................1
6. Övre delen av masten.......................................................................1
7. Nedre delen av masten m. svanhalsring...........................................1
8. Bom ...................................................................................................1
9. Rorkult ...............................................................................................1
10. Uppfällbart roder ...............................................................................1
11. Centerbord ........................................................................................1
12. W810 högprestandasegel (m. latta) ..................................................1
13. Extra flytkudde...................................................................................1
14. Kickslagskryssbult .............................................................................1
15. Komplett linsats
a. Uthalslina
1,57m gul .....................................................................................1
b. Kick
1,8m blå .......................................................................................1
c. Cunninghamslina
1,27m röd .....................................................................................1
d. Storsegelskot
4,8m grön .....................................................................................1
e.
f.
16.
Standardutrustning (Specifikationer och innehåll kan ändras utan varsel)
D
I
NL
S
SWEDISH TEXT TO
COME

4
GB
Step A. Opening Daggerboard Well
Step B. Installing Mast Support Tube
Step C. Attaching the Seat Block Clamp and Ratchet
Block
Step D. Raising the Sail
Step E. Attaching the Sail to the Boom
Step F. Securing the Vang Line, Cunningham Line and
Shock Cord
Step G. Securing the Mainsheet Line to the Ratchet
Block
Step H. Inserting the Daggerboard and Rudder
Step I. Installing and Operating the Rudder
Step J. Installing the Flotation Bag
Etape A. Ouverture du puits de dérive
Etape B. Installation du tube de support du mât
Etape C. Installation du collier de siège et du bloc
d’encliquetage
Etape D. Hissage de la voile
Etape E. Fixation de la voile à la bôme
Etape F: Fixation du hale-bas, cunningham et la corde
élastique
Etape G: Fixation de l’écoute de grand voile au bloc d’en-
cliquetage
Etape H. Mise en place de la dérive et du gouvernail
Etape I. Fixation et fonctionnement du gouvernail
Etape J. Gonflage du sac de flottaison
E
Paso A. Apertura de la cavidad para la orza alzable
Paso B. Instalación del tubo de soporte del mástil
Paso C. Instalación de la mordaza del asiento y bloque de
trinquete
Paso D. Izada de la vela
Paso E. Sujeción de la vela a la botavara
Paso F. Sujeción de la línea de osta, la línea
Cunningham y la cuerda antisacudidas
Paso G. Sujeción de la línea de escota mayor al bloque
de trinquete
Paso H. Inserción de la orza alzable y del timón
Paso I. Instalación y operación del timón
Paso J. Inflado de la Bolsa de Flotación
D
Schritt A. Öffnen des
Schwertgehäuses
Schritt B. Montage des
Mastaufnahmerohrs
Schritt C. Befestigen der Sitzklemme
und des Ratschenblocks
Schritt D. Aufziehen des Segels
Schritt E. Befestigen des Segels am
Baum
Schritt F. Befestigen der Vang-Leine,
der Cunningham-Leine und
Dämpfungsschnur
Schritt G. Befestigen des
Großschotttaus am
Ratschenblock
Schritt H. Einschieben des Schwertes
und des Ruders
Schritt I. Montage und Betätigung
des Ruders
Schritt J. Installation des
Schwimmsackes
Fase A. Apertura della scassa di
deriva
Fase B. Montaggio supporto albero
Fase C. Fissaggio dello stopper per la
cima e del
blocchetto di arresto
Fase D. Innalzamento della vela
Fase E. Attacco della vela al boma
Fase F. Fissaggio dell’ostino, della
cima Cunningham e fune
antidanneggiamento
Fase G. Fissaggio della cima di scor-
rimento scocca al blocchetto
di arresto
Fase H. Inserimento della deriva e del
timone
Fase I. Montaggio e funzionamento
del timone
Fase J. Gonfiaggio del cuscino di
galleggiamento
Stap A. Openen van de zwaardkast
Stap B. Installeren van de
maststeunbuis
Stap C. Bevestigen van de
bankje-klamp en het
ratelblok
Stap D. Hijsen van het zeil
Stap E. Bevestigen van het zeil aan
de giek
Stap F. Vastzetten van de pardoenlijn,
de Cunningham-lijn en het
amortiseurkoord
Stap G. Vastzetten van de
grootschootlijn aan het ratel-
blok
Stap H. Insteken van het zwaard en
het roer
Stap I. Aanbrengen en bedienen van
het roer
Stap J. Opblazen van de
drijfzak
Steg A. Öppna centerbord-
strumman och ta bort
skyddsplattan i botten
Steg B. Installera mastfoten
Steg C. Fäst blockfästet och
spärrblocket på toften
Steg D. Hissa segel
Steg E. Fäst bommen och
linans uthalslina
Steg F. Fäst kicklina och fäst
Cunningham
Steg G. Installation och
användning av rodret
Steg H. Fäst lina för storskot
på spärrblocket
Steg I. Installera extra
flytkudde vid behov
INL S
F
D
B
E
A
G
C
I
H
J
Preparation
Follow Steps A through J
Préparation
Suivre les étapes de A à J
Preparativos
Siga los pasos A a J
Vorbereitung
Schritte A bis J ausführen
Preparazione
Eseguire nell’ordine le
operazioni da A a J
Voorbereidingen
Volg stap A t/m J
Seglingsförberedelse
Följ steg A till J
F
SWEDISH
TEXT TO
COME

5
!
of sharp edges!
Be carefull
A
B
C
SRWB8003
3
4
7
5
2
1

Bowline Knot
Figure 8 Knot
Square Knot
15c
D
E
F
15b
15e
15d
15f
Square Knot
Figure 8 Knot
Bowline Knot
H
8
9
10
14
SRWB8004
6

7
Bowline Knot
15a
11
13
16
12
Figure 8 Knot
I
H
J
G

✔✔
✔✔
✖
✖
1 2 3
4 5 6
8
Operations: 607 West Ahtanum Road, Union Gap, WA 98903, USA Tel: 888-44WALKER (449-2553) Fax: [phone]
Admin: WBB Marine Management, 770 -1066 West Hastings St., Vancouver, BC V6E 3X1 Tel: [phone] Fax: [phone]
email: [e-mail] web: www.walkerbay.com
Part Number PSKAI8 Rev. 1 Ken Cook Co.