Weber Summit E-420 User manual

E/S-420/450
#89559
YOU MUST READ THIS OWNER'S GUIDE I
I
BEFORE OPERATING YOUR GAS GRILL
A_DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
A_WARNING:
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
A_ WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
A_ WARNING: Do not try to light this I
appliance without reading the "Lighting I
Instructions" section of this manual.
89559 US 03/03/08 LP
US ENGLISH

A_DANGER I
Failure to follow the Dangers, Warnings and Cautions contained in this Owner's Manual may result in serious bodily injury or
death, or in a fire or an explosion causing damage to property.
AkWARNINGS
Ak Do not store aspare or disconnected liquid propane cylinder under or near this barbecue.
/k Improper assembly may be dangerous. Please follow the assembly instructions carefully.
Ak After a period of storage, and/or nonuse, the Weber _ gas barbecue should be checked for gas leaks and burner obstructions
before use. See instructions in this manual for correct procedures.
Ak Do not operate the WebeP gas barbecue if there is a gas leak present.
/k Do not use a flame to check for gas leaks.
Ak Combustible materials should never be within 24 inches (61 cm) of the back or sides of your Weber _ gas barbecue.
Ak Do not put a barbecue cover or anything flammable on, or in the storage area under the barbecue.
Ak Your WebeP gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young
children away while it is in use.
Ak You should exercise reasonable care when operating your WebeP gas barbecue. It will be hot during cooking or cleaning and
should never be left unattended, or moved while in operation.
Ak Should the burners go out while in operation, turn all gas valves off. Open the lid and wait five minutes before attempting to
relight, using the lighting instructions.
Ak Do not use charcoal or lava rock in your Weber _ gas barbecue.
Ak Never lean over open grill or place hands or fingers on the front edge of the cooking box.
Ak Should a grease fire occur, turn off all burners and leave lid closed until fire is out.
/k Do not enlarge valve orifices or burner ports when cleaning the valves or burners.
Ak The WebeP gas barbecue should be thoroughly cleaned on a regular basis.
Ak Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid propane
gas in anatural gas unit is dangerous and will void your warranty.
/k Do not attempt to disconnect any gas fitting while your barbecue is in operation.
Ak Use heat-resistant barbecue mitts or gloves when operating barbecue.
Ak Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
Ak Combustion byproducts produced when using this product contain chemicals known to the state of California to cause cancer,
birth defects, or other reproductive harm.
Ak Do not use this barbecue unless all parts are in place. The unit must be properly assembled according to the assembly
instructions.
Ak Do not build this model of grill in any built-in or slide in construction. Ignoring this Warning could cause a fire or an explosion
that can damage property and cause serious bodily injury or death.
Ak Proposition 65 Warning: Handling the brass material on this product exposes you to lead, a chemical known to the state of
California to cause cancer, birth defects or other reproductive harm.
(Wash hands after handling this product.)
LIQUID PROPANE GAS UNITS ONLY:
A_ Use the pressure regulator and hose assembly that is supplied with your Weber _ gas barbecue.
A_ Do not attempt to disconnect the gas regulator and hose assembly or any gas fitting while your barbecue is in operation.
Ak A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not
use a liquid propane cylinder with a damaged valve.
A_ Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be
transported and stored accordingly.
Ak If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:
1. Move away from liquid propane cylinder.
2. Do not attempt to correct the problem yourself.
3. Call your fire department.

Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Webe_
gas griJl that it wiff be free of defects in material and workmanship from the date of purchase as foffows:
NumLnum r_st_ogs
StaLn]ess steel Shroud,
porc@_Jmeoame_ert shrOUd,
Cookbox A_embhJ
S tair,less steel bufr_ers tubes,
Stai_ess stee_ COoking g_tes,
Stainless steel F_voflze_ ba_,
pofce_air_.e_ame]e_ c_-_rot_
COoking grates,
Po_ce_ir_.e_amo]ed
COokLng grates,
Po_ce_ e_ameled
F_vo_ze_ ba_s,
infrared Rot_sser_ Bume_
A]I remaining pat ts,
25-year s (2 y#&rs on pa_{_t excludes ratting)
25-ye&rs;
25-yeats
104/eals (2 yea/o_ p_i_ e×CdudeS fading}
104/eals
5kyeals no lust through or bum through
5-ye_s no _u_ through or bum though
5-ye_ no _ust thro_h or bt_r_ through
3_Je_s no _ust throug_ or bum through
2-ye_s no _us_though or bum though
24/ea_
2-ye_s
When assembled and operated in accordance, w_th the pdnted instructions accompanying it.
Weber may requi_ reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN
YOUR SALES SLIP OR iNVOICE.
This Limited Warranty shall be I#_ited to the repair or _placement of parts that prove defective under
normal use arid service and which on examir_atior_ shall indicate, to Webe_s satisfaction, they are
defective. _fore returning a_y p_ts, ¢ontac_ the Customer Service Representative ir_your are_
using the contact information on our website. If Weber corlfim/s the defe_ and approves the claim,
Weber will ele_ to replace such parts without charge. If you are _qui_d to return defective parts,
trarlsportation charges must be prepaid. Weber will return parts to the purchaser, f_ight or postage
prepaid.
This Limited Warranty does r_ot cover any feilures or operating difficulties due to accident, abuse,
misuse, alteration, ri/[sapp]ication, vandalism, improper installation or improper maintenance or
service, or failure to pe#orm normal and routine maintenance, includ[rlg but not limited to damage
caused by inse¢ts within the burner tubes, as set out in this owr_er's manual.
Weber-Stephen Products Co., (Weber) mediante la presente le garant[za el COMPRADOR ORIGINAL
de esta barbacoa de gas Weber _ que ]a misma estar& libre de defectos en cuanto a materiales y
fabi[caci6n a part[r de la fecha de cor_/pra seg_3n ]o siguJente:
P_ezas co_adas de a[umir#o 25.a¢_os (2 a6os paTa la p_ntu[a exc]t_yendo p_decolofadC_f_}
C_b_eda de ac_o ir_ox_e, 25.afios
C_b_e_t a _orce]a n_zada, 25._fios
C_mara para asa_ 10-a_os (2 a¢_os papa I_ p_ntu_a exc]t_/endo _ deOO_ofad¢_}
TubOs de _¢e_o It_ox_d_tb[÷
de los qt_em_res, 10.afios
pa_rqas de cocoon do
ace_o _t_o×_d_31e, 5kar/os s_n perto_a_0_ po_ fuego _ ox_c]dn
Bar,as F_avo_]zer de
acefo ]r_ox_]e, 5.a_os s_n perto_aq_ po_ fuego uoxrdac_n
paranoias de coccr6_ de hrerro
o_ po_e]an_z_do, 5kaYos s_n pertofar4,3_ p_ _uego _ ox_dac]dn
p ar#_as de cocc_0r_ po_ce_]a_rzadas 3-anos s_n _3ertofarJd_ p_ _ue.qo _ ox_dac]On
Barras Flavoflzer porce_t aLzada s, 2 a_os s_n perto_a_l_/_ po_ fuego u oxrdac_n
@umeador _nflar_o/o de_
TO_s la demos partes, 2-athos
cuando se ensambla y opera de acuerdo a las inst rucc[ones impresas que la acompahan.
Weber pudiese requer[r p#Jeba razonable de la fecha de con/pra. POR LO TANTO, DEBER._
GUARDAR SU REC]BO O FACTURA DE VENTA.
Esta garantla lim[tada estA I[mitada a la reparac[6n o reemplazo de p[ezas que resultasen defectuosas
bajo uso y se_[c[o normal y las cuales al examinarse indiquen, a plena satisfacc[6n de Weber, que
efectivamente son pbzas defectuosas. Antes de devolver cualqu[er parte, contacte al Representante
de Atencion al C_[ente en slJ area, cuya informad6rl de ¢ontacto _aen¢ontrarA erl nuest ro s[t[o web. S[
Weber confirma el defecto y aprueba el reclamo, esta e]eg[ra reparar o reemplazar tel pieza sin cargo
alguno. Si usted t[ene que retomamos las partes defectuosas, los gastos de transporte deben set
prepagados. Weber _etornara las partes al comprador con transpose o franqueo prepagado.
Deterioration or damage due to severe weather cond_[ons such as ha[], hurricanes, earthquakes
or tomedoes, discoloration due to exposu re to chemicals either d[re_ly or in the atmosphere, is not
covered by this Limited Warranty.
There ere no other express warrants except as set forth herein and any _pffcab]e Jmpffed warranties
of me_han_ability and fitness are limited in duration to the period of coverage of this express written
Limited Warranty. Some legions do not allow limitation on how long an implied warranty lasts, so this
liri/[tation may not apply to you.
Weber is not liable for any special, [ndi_e_ or cons_quent[al damages. Some regions do not allow the
exclusion or limitation of incidental or consequential damages, so this liri/[tation or exclusion may not
apply to yo_J.
Weber does not authorize any person or company to assume for it any other obffgat[on or Iiab[lityin
connection with the saJe, instaff_[tion, use, rer_ovaJ, return, or repJacement of its equipmen_; and no
such representations are binding on Weber.
This Warranty applies only to prod_Jcts sold at retail
WEBER-STEPHEN PRODUCTS CO.
Customer Service Center
1890 Roselle Road, Suite 308
Schaumburg, IL 60195
USA
For replacement parts carl:
1-800-446-107t
www.weber.com e
Esta Garantia Lim[tada no cubre ninguna falla o problema de operad6is a causa de accJdentes,
abuso, real uso, alteraei6n, uso en aplicaciones indebidas, vanda]ismo, instalac[6n [napropiada o
r_antenimiento o serv[¢io in®ropiados, o pot no _[evar ,3 c_bo e] r_antenimiento norn_l y rut[nado,
entre ion que se [ne]uyen, pero sir_ limit aei_n, _os da_os eau_ados pot insectos dentro de ]on tubos
quemadores, segt]n se deta]la en este manual del propi_ar[o.
Esta Garant [a Lim[tada no cubre e] de4er[oro o damon a causa de condJciones de tien_po [_clemente
ta_es 6omo granizo, huracanes, terremotos o toreros n[ tampooo _a deeoJoraci6n pot ex,3osJ6i6n a
susta_c[_s quim[oas bien sea pot contacto di_ecto o pot que [as m[smas ¢ontenidas en ]a at m,Ss{era.
No existe n_nguna otra garant_a expresa que no sean las las aca indicadas y cuabsquier garant_as
[mp]_itas de comerc_abHidad y apUtud de uso e_an Iimitadas en duraci6n al Uempo de ¢obert ura de
esta expresa Garantia Umit_da pot esor[to. AIgunas tog[ones no permiten IJmitacJ6nalgurla en el
Uempo que una garant_ [mplicita pueda durar, pot ]o que esta I#_itaci6n pudiera no aplieade a usted.
Weber no se ha6e responsabJe de c_Jalesqu[er da_os espec_a_es, indirectos o eme_gentes. A]gunas
tog[ones no permiten la exclus[6n o lim[tae[6n de da_os [ncidentales o emergentes, pot Io que esta
limitaci6n o exdusi6n pudierarl no apl[cade a usted.
Weber _soautodza a persona o empresa alguna a asumir en su nombre nhsguna obligac[6n o
responsabi][dad en relaci6n con la venta, insta]ac[6n, uso, ret[ro, devolue[6n o reemplazo de sus
equipos, y nilsguna tal representaci6n sera v[£¢ulaRte para Weber.
Esta Garant[a aplica solo a aque]]os productos vend[dos a] pot menor.
WEBER-STEPHEN PRODUCTS CO.
Customer Service Center
1890 Roselle Road, Suite 308
Schaumburg, IL 60195
USA
Para pattes de repuesto Ilame a:
1-800-446-1071
www.weber.com e'
Para compras hechas en Mexico
WEBER-STEPHEN PRODUCTS S,A, de C.V.
Marcella No 338_
Oo]oRia Americana
44160 M_xi¢o, C,P,
M_xico
Para partes de repuesto Ilame a:
(52) (33) 3615-0736
www, weber,com®
Weber-Stephen Products Co. (Weber) garantit par le pr_serlt document & I'ACHETEUR D'OR]GINE de
ce grill _ gaz Webe_ e que ce[uFci ne ¢on/portera aucun d_faut de piece ni de main d'oeuvre _ comp_r
de la date d'achat 6or_n_e suit :
Fol_te d'al_minium 25 arts (2 ar_s pour lapaint_l# _ F#x_eptlon d_ lotff{= d_colofatior_}
5ffuctu_e en _cJef _noxydt_]e, 25 ann
Structure _m_q]l_e, 25ann
Cure, 10 arts (2 _as pour I_ pe_rr_ _ rexceptlo_ de toute _colof_tior_)
Tubes du br_]eur en _c_ef InoX_/d_]e, 10 an_
GrJl]es de cu_son en _c_ ]noxyd_e, 5 arts sa_ trou _ovoqu_ par ]a rour_]e ou pa_ une brS]ure
Bar_es F[avo_Lzer en _cJe_ inoxyd_e, 5 arts sa_s trou _ovoqu_ par ]a rour_]e ou pa_ une brS]ure
Gflllos de cu_sso_ en fonte for _ma_l]_e, 5 arts sa_ trou _fovoqu_ par ]a rou_]e ou p_ une br_]ure
Grqles de cursson _m _l]_es, 3 arts s_s trou p_voqu_ par la rot_[_e o_ pa_ une brs]_re
Bar_ F[avo_Lzer _m _11_es, 2 an8 s_as trou p_ovoqu_ par la rot_]e o_ pa_ une br81t_re
Bf_eu_ de _ar_t_so_re _ I_ouge, 2 ann
Toutes _e_ _u_res p_c÷s, 2an8
A conditiols qu'fl air 6t6 assemble et utilise ¢onformement aux instructions impfimees qui
I'accomp_gnent.
Weber pout e×iger une preuve raisonnable de votre date d'achat. VOUS DEVRIEZ DONC
CONSERVER VOTRE TICKET DE CAISSE OU VOTRE FACTURE.
La p_sente Garantie limit_} est limitee &]a _parat[on ou au remplacement des p[_ces qui s'averent
defeotueuses darts ]e cadre d'une uti]isat[on normaJe et d'u_ ent retien normal et dor_t E'examer_ ind[que,
la satisfaction de Weber, qu'e]]es sont defe_ueuses. Avar_t de retoumer route piece, veu[I]ez
er_trer en contact ave€ le Representar_t du Service dient_Je le plus proehe gr&ce au× 6co,dorm.s
votre disposition sur notre site Intemet. S[ Weber confirme le defaut _ _prouve ]a demande,
Weber ehoisira de _mplacer cos pi_ces sans frais. S'il vous est demande de retourner los pi_ces
defectueuses, ]es frais de transpolt devront _tre prepayes. Weber retoumera los pieces a I'acheteur,
franeo de port.
La p_sente Garantie limit_e ne _x_uvre pas tou_ defai]lance ou d[f6culte d'utffisation provoquee par un
a6oident, une Litil[_ation abusive, une mauva[se ut[]isatior_, une a_t_tion, une mauvaise app_ication, un
a6te de vandalisme, une installation [n6orrecte ou une maintenance ou un ent ret[en incorrec_s, ou ]e
defaut d'erltretien normal _ regulier, y oompfis mais pus seu]ement los dommages provoques par des
[nseotes & I'int_deur des tubes du br_Jleur, tel que d_¢rit duns le present mode d'emp]oi.
Toute d_ter[oraUon ou tout dommage resuJtant de o3ndit[ons met_oroJogiques graves comme de Ja
gi_le, des ouragans, des s_ismes ou des toraades, route decoloration r_sultant d'une exposition & des
agents ohin_iques directement ou darts ]'atmosphere, n'est pa8 eouver[e dans Jecadre de la p_sente
Galantie _[rait_e.
I] n'existe aueune autre garantie expresse horm[s ceJles exposees duns _e present dooumer_t et route
ga_ntie de comme_cia]isation et de bon eta_ induite est limit_e en du_e & _apedode de oo_verture de
la p_sente Gar_ntie _in/it_e eorite expresse. Certaines regions n'autodsent pus de Iimita_ion de dur_
de la garant[e indui_ ; il est done posible que cette _imitation ne s'applique pus & vous.
Weber ne pout _tre tenu pour responsable de tout dommage particulier, induit ou se produisant par
voie de consequence. Certaines re_gions n'auto_sent pus J'excJusionou ]a ]imitation des don_m_ges
indirects ou se p_oduisant par vole de ¢onst_quence ; il est done possible que cette limitation ou
e×clusion ne s'appJique pan _ vous.
Weber n'autorise aucune pe_sonne ou sooi_te a pr_sur_er en son nora de route autFe obJigation
ou responsabi]ite en relation avec ]a vente, _'instaflation, ]'uti]isation, le rot fair, le retour ou _e
rempJac-sment de sos _quipements ; e_ aucune de cos representations ne JieWeber.
La pr#_sente Garantie s'applique un[quement aux produits vendus au d(_taH.
WEBER-STEPHEN PRODUCTS CO.
Product Registration
P.O. Box 40530
Burlington, ON L7P4Wl
Pour des pi_ces de rechange, appelez le :
1-800-265-2t 50
www.weber.com e

CatchPan Holder
Sostenedor del plato recolector
Support de I'0goutioir
Catch Pan
Plato recolector
Egouttoir
Cooking Grate
Pardlla de cocci6n
Grille de cuisson
Warming Rack
Rejilla para calentar
Grille de maintien au chaud
Rotisserie Fork
Horquilla del asador giratorio
Fourche de la rOtissoire
Rotisserie Spit
Espet6n del asador giratorio
BrOche de la r6tissoire
Rotisserie Motor
Motor del asador giratorio
Moteur de la rOtissoire
Rotisserie Bracket
Soporte del asador giratodo
Support de la rOtissoire
4:::
Drip Tray
Bandeja de goteo
Plateau de recueil des gouttes
Flavorizer _ Bar
Barras FlavorizeP
Barre Flavodzel e
Smoker Bar
Barra del ahumador
Barre du fumoir
Smoker Box
Caja del ahumador
Bottler du fumoir
Side Burner Table
Mesa del quemador lateral
Tabletie du br01eur lateral
Side Table
Mesa lateral
Tablette lat_rale
Wrench
Llave
Cl_
Nylon Washer
Arandela de nil6n
Rondelle de nylon
Truss Head Screw (_A*20 x1Inch)
Tornillo de cabeza segmentada (Tornillo _4-20 x 1 pulgadas)
Vis &t6te bomb_e large de (A-20 x 1 pouces)
Keps Nut (_A*20 keps nut)
Tuerca keps(Tuerca keps t¢-20)
Ecrou & rondelle dentee (ecrou & rondelle dentee de ,_-20)
1inch Bolt (V4-20 x1inch Bolt)
Perno 1 pulgada (Perno _4-20 x 1 pulgadas)
Ecrou de 1 pouce (ecrou de ,:_-20 x 1 pouce)
Screw
Tornillo
Vis
Plastic Plug
Tap6n plAstico
Bouchon en plastique

I
2
3
4
VISION ECLATEE, DIAGRAHA DE DESPIECE $420 LP US
6
?
8
9
I0
2?
11
12
13
17
19
21
22
30
31
32
33
34
35
36
37
38
39
4O
43
t* i, i, k*i:l:] :l:l_e]. U

f=
2=
LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION I_CLATI_E
Shroud Hardware
Accesorios de la cubierta
Structure de protection
Shroud
Cubierta
TSle de protection
18. Disposable Drip Pan
Bandeja de goteo desechable
Egouttoir jetable
19. Drip Tray
Bandeja de goteo
Plateau-_gouttoir
35,
36,
Side Burner Hose
Manguera del quernador lateral
Tuyau du brt31eurlateral
Right Tool Holder
Portaherramientas derecho
Support d'ustensiles de droite
3. Thermometer
Term6metro
Thermornetre
20. Catch Pan
Plato recolector
Egouttoir
37. Frame Support
Soporte del bastidor
Support du cadre
4. Thermometer Bezel
Moldura decorativa del terrnornetro
Plaque indicatrice du thermometre
5. Handle
Asa
Poign_e
6. Grill Out TM Handle Light
Luz de asa Grill Out TM
Lampe de poignee Grill Ouff M
7. Warming Rack
Rejilla de calentamiento
Grille de rechauffage
8, Cooking Grates
Parrillas de cocci6n
Grilles de cuisson
9. Flavorizer e Bars
Barras Flavorizer _
Barres Flavorizer _
10, Burner Tubes
Tubos quemadores
Tubes des breleurs
11, Side Table
Mesa lateral
Tablette laterale
12. Left Tool Holder
Portaherramientas izquierdo
Support d'ustensiles de gauche
13. Manifold
MUltiple
Collecteur
14. Control Panel
Tablero de control
Panneau de commandes
15. Knob Bezel
Moldura decorativa de la perilla
Plaque indicatrice du bouton
16. Knob
Perilla
Bouton
1Z Water Baffle /Heat Shield
Reflector de agua /Pantalla termica
Protection contre I'eau/Cloison anti-chaleur
21. Catch Pan Holder
Soporte del plato recolector
Support d'egouttoir
22. Left Door
Puerta izquierda
Porte gauche
23, Door Handles
Asas de las puertas
Poignees de portes
24. Right Door
Puerta derecha
Porte droite
25. Left Frame Panel
Panel izquierdo del bastidor
Panneau du cadre gauche
26. Bottom Panel
Panel inferior
Panneau inf#rieur
2Z Cooking Grate
Rejilla de cocci6n
Grille de cuisson
28. Side Burner
Quemador lateral
Breleur lateral
29. Cookbox
Caja de coccion
Boltier de cuisson
30. Bulkhead
Tabique divisorio
Cloison
31, Manifold Hose
Manguera del multiple
Tuyau du collecteur
32. Hose /Regulator
Manguera /Regulador
Tuyau/Regulateur
33. Side Burner Lid
Tapa del quernador lateral
Couvercle du breleur lateral
34. Side Burner Table
Mesa del quemador lateral
Tablette du brQleur lateral
38, Back Panel
anel trasero,
_anneau arrlere
39, Right Frame Panel
Panel derecho del bastidor
Panneau du cadre droit
40, Tank Scale
B_scula del tanque
Plateau de la bouteille
41. Tank Glides
Deslizaderas del tanque
Glissi_res de la bouteille
42, Matchstick Holder
Portacerillos
Porte-allumette
43,
44,
Caster
Rueda giratoria
Roulette
Locking Caster
Rueda giratoria con bloqueo
Roulette autobloquante

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
VISION I_CLATC:E,DIAGRAMA DE DESPIECE S450LPUS
31
32
__ 33
35
36
3?
38
39
16
17
19
20
21
22 r-
23-
24-
25
26-
28
29
30
O
42
,¢ 43
4/,.
4.5
46
4.8
49
50
51
52
53
$54
56
57

LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION I_CLATEE
1. Shroud Hardware
Accesorios de la cubierta
Structure de protection
21. Water Baffle/Heat Shield 41. Side Burner
Reflector de agua /Pantalla termica Quernador lateral
Protection contre I'eau/Cloison anti-chaleur BrQleur lateral
2. Shroud 22. Disposable Drip Pan 42. Cookbox
Cubierta Bandeja de goteo desechable Caja de cocci6n
T61ede protection Egouttoir jetable BoWer de cuisson
3. Thermometer 23. DripTray 43. Bulkhead
Term6metro Bandeja de goteo Tabique divisorio
Therrnometre Plateau-egouttoir Cloison
Thermometer Bezel
Moldura decorativa del term6metro
Plaque indicatrice du thermom6tre
Handle
Asa
Poignee
Grill Out TM Handle Light
Luz de asa Grill OutTM
Lampe de poign_e Grill OutTM
Rotisserie Motor
Motor del asador
Moteur de la r6tissoire
4,
5.
6.
Z
8. Rotisserie Bracket
Soporte del asador giratorio
Support de la r6tissoire
9. Warming Rack
ReillaJ de calentarniento
Grille de rechauffage
24. Catch Pan 44. Manifold Hose
Plato recolector Manguera del rnQItiple
Egouttoir Tuyau du collecteur
25. Catch Pan Holder
Soporte del plato recolector
Support d'egouttoir
45. Hose /Regulator
Manguera /Regulador
Tuyau/Regulateur
26. Left Door 46. Side Burner Lid
Puerta izquierda Tapa del quemador lateral
Porte gauche Couvercle du br01eur lateral
27. Door Handles
Asas de las puertas
Poign_es de portes
47. Side BurnerTable
Mesa del quemador lateral
Tablette du brQleur lateral
28. Right Door 48. RightTool Holder
Puerta derecha Portaherramientas derecho
Porte droite Support d'ustensiles de droite
29. Left Frame Panel
Panel izquierdo del bastidor
Panneau du cadre gauche
49. Side Burner Hose
Manguera del quemador lateral
Tuyau du breleur lateral
10. Cooking Grates 30. Bottom Panel 50. Frame Support
Parrillas de coccion Panel inferior Soporte del bastidor
Grilles de cuisson Panneau inferieur Support du cadre
11. Flavorizer e Bars 31. IR Burner Cover 51. Back Panel
Barras Flavorizer _ Tapa del quemador IR Panel trasero
Barres Flavorizer _ Cache du brWeur IR Panneau arri_re
32. Infrared Burner
Quemador infrarrojo
BrQleur & infrarouge
12. Burner Tubes
Tubos quemadores
Tubes des breleurs
52. Right Frame Panel
Panel derecho del bastidor
Panneau du cadre droit
13. SideTable 33. IR Burner Box 53. Tank Scale
Mesa lateral Caja del quemador infrarrojo B4scula del tanque
Tablette laterale Boftier du br01eur IR Plateau de la bouteille
14. LeffTool Holder
Portaherrarnientas izquierdo
Support d'ustensiles de gauche
34. IR Burner IgniterWire
Cable de encendido del quernador IR
C&ble de I'allumeur du brQleur IR
54. Tank Glides
Deslizadera del tanque
Glissi_res de la bouteille
35. Thermocouple 55. Matchstick Holder
Termopar Portacerillos
Thermocouple Porte-allumette
36. IR Burner Hose 56. Caster
Manguera del quemador IR Rueda giratoria
Tuyau du brQleur IR Roulette
37. Rotisserie Spit Assembly 57. Locking Caster
Ensamble del espet6n del asador giratorio Rueda giratoria con bloqueo
Ensemble de la broche de la r6tissoire Roulette autobloquante
38. Smoker Box
Caja del ahumador
BoWer du fumoir
15. Manifold
Multiple
Collecteur
16. Control Panel
Tablero de control
Panneau de commandes
17. Small Knob Bezel
Moldura decorativa de la perilla pequefia
Plaque indicatrice du petit bouton
18. Small Knob
Perilla pequefia
Petit bouton
19. Large Knob
Perilla grande
Grand bouton
39. Smoker Bar
Barra del ahumador
Barre du fumoir
20. Large Knob Bezel 40. Smoker Burner
Moldura decorativa de la perilla grande Quemador del ahumador
Plaque indicatrice du grand bouton BrQleur du fumoir

Adjust doors, if necessary
Si fuese necesario, ajuste la puerta
Ajustez la porte si n_cessaire zzzzzz
2
kj _,_A_ Aji=J:] =J:ll,le] _,_ll

a| JAJAJA_t=l:l=l:l_l]_

12
The Weber Grill Out" Handle Light has a "fiit Sensor": Lid up - ON /Lid Closed - OFF. The power
button (a) activates or deactivates the "Tilt Sensor." For daytime use, deactivate the sensor by
pressing power button (a).
La LAmpara de Asa Weber Grill Out" tiene un "sensor de inclinacion": tapa abierta -ENCENDIDA
/tapa cerrada -APAGADA. El boron de encendido (a) actlva o desactlva a[ "sensor de lnclinacion".
Para uso durante el dia, desactive a[ sensor pulsando el bot6n de encendido (a).
La Lampe de poign_e Weber Grill Out TM est pourvu d'un "Detecteur Tilt" : Couvercle releve -MARCHE
/Couvercle ferme -ARRET (OFF). Le bouton d'alimentation electrique (a) active ou desactive [e
"D_tecteur Tilt." Pour une uti]isation pendant la journee, veuiilez d_sactiver le detecteur en appuyant
sur le bouton d'alimentation electrique (a).
ai JAJAJg_ t=[:J=[:l_l]u_i

Your Weber _ gas barbecue is a portable outdoor cooking appliance. With the Webe_
gas barbecue you can grill barbecue, roast and bake with results that are difficult to
duplicate with indoor kitchen appliances. The closed lid and Flavofize¢ _ Bars produce
that "outdoo¢' flavor in the food.
The Webe! e gas barbecue is portable so you can easily change its location in your yard
or on your patio. Portability means you can take your Weber _ gas barbecue with, if you
move.
Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than
charcoal fuel.
These instructions will give you the minimum requirements for assembling your
WebeP gas barbecue. Please read the instructions carefully before using your
Weber _ gas barbecue. Improper assembly can be dangerous.
Not for use by children.
If there are local codes that apply to portable gas grills, you will have to conform to
them. Installation must conform with local codes or, in the absence of local codes,
with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and
Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and
CSA Z240 RV Series, Recreational Vehicle Code, as appficabie.
The pressure reguiafor supplied with the Weber _ gas barbecue must be used.
This regulator is set for 11 inches of waler column (pressure).
This WebeP gas barbecue is designed for use with liquid propane (LP) gas only.
Do not use with natural (piped in cily) gas. The valves, orifices, hose and regulator
are for LP gas only.
Do not use with charcoal fuel.
Check that the area under the control panel and the bottom tray are free from
debris thai might obstruct the flow of combustion or venlilalion air.
The areas around the LP cylinder must be free and clear from debris.
Replacement pressure regulators and hose assemblies must be those specified
by Weber-Stephen Products Co.
FOR INSTALLATION IN CANADA
These instructions, while generally acceptable, do not necessarily comply with the
Canadian Installation codes, parficulariy with piping above and below ground. In
Canada the installation of this appliance must comply with local codes and/or Standard
CSA-B149.2 (Propane Storage and Handling Code).
OPERATING
/k WARNING: Only use this barbecue outdoors in a well-
ventilated area. Do not use in a garage, building, breezeway
or any other enclosed area.
/k WARNING: Keep ventilation openings for cylinder enclosure
free and clear from debris.
STORAGE AND/OR NONUSE
The gas must be turned off at the liquid propane cylinder when the Webe_ gas
barbecue is not in use.
When the Weber _ gas barbecue is stored indoors, the gas supply must be
DISCONNECTED and the LP cylinder stored outdoors in a well-ventilated space.
LP cylinder must be stored outdoors in a well -ventilated area out of reach of
children. Disconnected LP cylinder must not be stored in a building, garage or any
other enclosed area.
When the LP cylinder is not disconnected from the Weber _ gas barbecue, the
appliance and LP tank must be kept outdoors in a well-ventilated space.
The Weber _ gas barbecue should be checked for gas leaks and any obstructions
in the burner tubes before using. (See Section: "Maintenance/Annual
Maintenance).
Check that the areas under the control panel and the slide out bottom tray are free
from debris that might obstruct the flow of combustion or ventilation air.
The Spider/Insect Screens should also be checked for any obstructions.
(See Section: "Maintenance/Annual Maintenance").
/k WARNING: Your Weber egas barbecue shall not be used
under overhead combustible construction.
.,!,,WARNING: Your Weber egas barbecue is not intended to be
installed in or on recreational vehicles and/or boats.
/k WARNING: Do not use the barbecue within 24 inches of
combustible materials to the back or sides of the grill.
.,!,,WARNING: The entire cooking box gets hot when in use. Do
not leave unattended.
/k WARNING: Keep any electrical supply cord and the fuel
supply hose away from any heated surface.
.,!,,WARNING: Keep the cooking area clear of flammable vapors
and liquids such as gasoline, alcohol, etc., and combustible
materials.
/k WARNING: Never store an extra (spare) LP cylinder under or
near the Weber _gas barbecue.
AkWARNING: The LP cylinder used with your barbecue must
be with a listed OPD (Overfilling Prevention Device) and
a QCCf or Type 1 (CGA810) cylinder connection. The
cylinder connection must be compatible with the barbecue
connection.
GRILLING METHODS
Note: ff grill loses heat while cooking refer to the troubleshooffng section of this manual
Ak WARNING: Do not move the Weber egas barbecue when
operating or while barbecue is hot.
You can adjust the individual main burners as desired. The control settings are START/
HI, MEDIUM, LOW, or OFF.
Note: The temperature inside your cooking box for the first few uses, while surfaces
are still very reflective, may be hotter than those shown in your cookbook¸ Cooking
conditions, such as wind and weathe_ may require the adjustment of the burner
oontrols to obtain the oorrect cooking temperatures.
If burners go out during cooking, open lid, turn off all burners and wait five
minutes before relightlng.
Preheating - Your Weber _ gas barbecue is an energy-efficient appliance. It operates at
an economical low BTU rate. To preheat: after lighting, close lid and turn all burners to
"START/HI". Preheating to between 500° and 550 ° F (260 ° and 2900 C) will take 10 to
15 minutes depending on conditions such as air temperature and wind.
Drippings and grease -The Flavorizer_ bars are designed to "smoke" thecorrect
amount of drippings for flavorful cooking. Excess drippings and grease will accumulate
inthecatch pan under theslide outbottom tray.Disposablefoil drippans are available
that fit the catch pan.
A', WARNING: Check the bottom tray for grease build-up before
each use. Remove excess grease to avoid a grease fire in
the slide out bottom tray.
CLEANING
A,, WARNING: Turn your Weber egas barbecue off and wait for it
to cool before cleaning.
A', CAUTION: Do not clean your Flavorizer c'_bars or cooking
grates in a self-cleaning oven.
For availability of replacement cooking grates and Flavorizer ebars contact the
Customer Service Representative in your area using the contact information on
our website. Log onto www.weber.com ®
Outside surfaces - Use a warm soapy water solution to clean, thenrinse with water.
A', CAUTION: Do not use oven cleaner, abrasive cleansers
(kitchen cleansers), cleaners that contain citrus products, or
abrasive cleaning pads on barbecue or cart surfaces.

Slide out Bottom tray -Remove excess grease, then wash with warm soapy wafer,
then rinse.
Flavorlzer ebars and Cooking grates - Clean with a suitable brass bdstle brush. As
needed, remove from grill and wash with warm soapy wafer, then rinse with water.
Catch pan - Disposable foil frays are available, or you can line the catch pan with
aluminum foil. To clean the catch pan, wash with warm soapy water, then rinse.
Thermometer - Wipe with warm soapy water; clean with plastic scrub ball.
Inside cooking module - Brush any debris off of burner tubes. DO NOT ENLARGE
BURNER PORTS (OPENINGS). Wash inside of cooking box with warm soapy water
and a water rinse.
Inside Lid -While lid is warm, wipe inside with paper towel to prevent grease build-up.
Flaking built-up grease resembles paint flakes.
Stainless steel surfaces -Wash with a soft cloth and a soap and water solution. Be
careful to scrub with the grain direction of the stainless steel.
Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after
cleaning.
Preserve Your Stainless Steel -Your grill or its cabinet, lid, control panel and shelves
may be made from stainless steel. To keep the stainless steel looking its best is a
simple matter. Clean g with soap and water, rinse with clear wafer and wipe dry. For
stubborn padicles, the use of a non-metallic brush can be used.
A_ IMPORTANT: Do not use awire brush or abrasive cleaners
on the stainless steel surfaces of your grill as this will cause
scratches.
,4',IMPORTANT: When cleaning surfaces be sure to rub/wipe
in the direction of the grain to preserve the look of your
stainless steel.
IMPORTANT LP CYLINDER INFORMATION
Failure to follow these DANGER statements exactly may result in a tire causing deathor
seriousinjury.
Ak DANGER
A_ NEVER store a spare LP Cylinder under or near this
barbecue,
A_ NEVER fill the tank beyond 80% full.
Your Weberegas grill is equipped for a cylinder supply system designed for
vapor withdrawal.
,4', WARNING: Only use this grill outdoors in a well-ventilated
area. Do not use in agarage, building, breezeway or any
other enclosed area.
The proper filling methods for the filling of your cylinder are by weight or volume, as
described in NFPA 58. Please make sure your filling station fills your LP cylinder by
weight or volume. Ask your filling station to read purging and tilling instructions on the
LP cylinder before attempting to fill.
LEAK CHECK PREPARATION
CHECK THAT ALL BURNER VALVES ARE OFF
Valves are shipped in the "OFF" position, but you should check to be sure that they are
turned off. Check by pushing down and turning clockwise. It they do not turn, they are
off. Proceed to the next step. If they do turn continue turning them clockwise until they
stop, then they are off. Proceed to the next step.
CONNECTING THE LIQUID PROPANE CYLINDER
All Webe¢ liquid propane gas grill regulators are equipped with a UL-Listed tank
connection as per the latest edition of ANSI Z21.58. This will require a liquid propane
tank that is similarly equipped with a Type 1 connection in the tank valve. This Type 1
coupling allows you to make a fast and totally safe hookup between your gas grill and
your liquid propane tank. It eliminates the chance of leaks due to a POL fitting that is
not properly tightened. Gas will not flow from the tank unless the Type 1 coupling is fully
engaged into the coupling.
,4',WARNING: Make sure that the LP cylinder valve is closed.
Close by turning valve clockwise.
/k DANGER
Do not use an open flame to check for gas leaks. Be sure
there are no sparks or open flames in the area while you
check for leaks. Sparks or flames will result in a fire or
explosion which can cause serious bodily injury or death,
and damage to property.
1
2
3
4
5
2
Type 1 Valve
Hand Wheel
External Thread
Thermally Sensitive Nut
Propane Regulator

TO CONNECT THE HOSE TO THE CYLINDER:
1) Locatehoseretentionclip (a)on regulator hose.Securehltoslot(b) on underside
oftankscale.
A,, WARNING: The hose must be secured to the tank scale
with the Hose Retention Clip. Failure to do so could cause
damage to the hose resulting in a fire or explosion which
can cause serious bodily injury or death, and damage to
property.
Some LP tanks have differing top collar assembles. (The top collar is the metal
protective ring around the valve.) One series of tanks mount with the valve facing
front (a). The other tanks mount with the valve facing away from the fuel scale
(b). Weber recommends the use of cylinder manutactureCs Manchester and
Wodhington, with a 47.6 Ib water capacity. Other cylinders may be acceptable for
use with the appliance provided they are compatible with the appliance retention
means (see illustrations).
The LP cylinder is installed inside the base cabinet, on the tank scale (right side).
(a)
2) Open base cabinet doors.
3) Turn the LP cylinder so the opening of the valve is either to
the front, side or rear of the Webe¢ _ gas barbecue. Lift and
hook the cylinder onto the fuel gauge.
4) Lift tank up into position on the tank scale.
5) Loosen the cylinder lock wing nut. Swing the cylinder lock
down. Tighten the wing nut.
TO CONNECT THE HOSE TO THE CYLINDER:
6) Remove theplastic dust cover from the valve.
7) Screwthe regulator coupling onto the tank valve,
clockwise, or to theright. Hand-tighten only.
Note: Thisconnection tightens clockwise and will notallow gas
toflow unless theconnection is ffghL Theconnection requires
tightening by hand only
A_ WARNING: Do not use a wrench to tighten
the connection, Using a wrench could
damage the regulator coupling and could
cause a leak.
You will need: LP cylinder, a soap and water solution and a rag
or brush to apply it.
8) Mix soap and water.
9) Turn on the cylinder valve.
10) Check for leaks by wetting the fitting with the soap and
water solution and watching for bubbles. If bubbles form, or
if a bubble grows, there is a leak.
If there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and
recheck with the soap and water solution.
If leak does not stop do not use the barbecue. Contact the customer service
representative in your area using the contact information on our web site. Log
onto www.webet.cora ®.
11 ) When leak checking is complete, turn gas supply off at the source and rinse
connections with water.
© ©
yr Tr Tr yr •
kJ_,_A_ AJJ=J:]=J:ll[e] _,U

CHECK FOR GAS LEAKS
A', WARNING: The gas connections of your Summit egas grill
have been factory tested. We do however recommend that
you leak check all gas connections before operating your
Summit egas grill.
REMOVE CONTROL PANEL
Tool required: PtlillJps Screwdriver.
1) Remove the burner control knobs.
2) Remove the two screws that secure the control panel to the frame.
3) Remove the control panel. Tilt panel forward and lift up and away from grill.
Completely remove the control panel (3) from the cooking box assembly exposing
the valves, burners, igniter, and manifold.
CHECK FOR GAS LEAKS
A', DANGER
Do not use an open flame to check for gas leaks. Be sure
there are no sparks or open flames in the area while you
check for leaks. Sparks or open flames will result in a fire or
explosion, which can cause serious bodily injury or death
and damage to property.
A', WARNING: You should check for gas leaks every time you
disconnect and reconnect a gas fitting.
Note: Aft factory-made connections have been thoroughly checked for gas leaks The
burners have been flame-tested. As a safety precaution however; you should recheck
all fittings for leaks befot_ using your Weber' Gas Barbecue Shipping and handling
may loosen or damage a gas fitting
A', WARNING: Perform these leak checks even if your
barbecue was dealer or store assembled.
You will need: a soap and water solution, and a rag or brush to apply it.
Note: Since some leak test solutions, including soap and water, may be slightly
corrosive, all connections should be rinsed with water after checking tot leaks
If your grill has a side burner make sure the side burner Jsoff.
To perform leak checks: open cylinder valve by turning the cylinder valve hand-
wheel counterclockwise.
,,I", WARNING: Do not ignite burners when leak checking.
Check for leaks by wetting the connections with the soap and water solution and
watching for bubbles. If bubbles form or if a bubble grows, there is a leak.

CHECK:
1) Bulkhead and gas supply hose connection.
2) Main gas line to manifold connections.
/k WARNING: If there is a leak at connection (1, or 2), retighten
the fitting with a wrench and recheck for leaks with soap and
water solution,
If a leak persists after re-tightening the fitting, turn off the gas.
DO NOT OPERATE THE GRILL. Contact the Customer Service
Representative in your area using the contact information on
our web site. Log onto www.weber.com ®,
3) Side burner hose to bulkhead connection.
4) Side burner hose to Quick disconnect connection, side burner valve and orifice
connections.
5) Regulator to cylinder connection.
6) Hose to regulator connection.
7) Valves to manifold connections.
Ak WARNING: If there is a leak at connections (3, 4, 5, 6 or 7),
turn oft the gas. DO NOT OPERATE THE GRILL. Contact
the Customer Service Representative in your area using the
contact information on our web site.
Log onto www.weber,com ®.
When leak checks are complete, turn gas supply oit at the source and rinse connections
with water.
®
*The grill illustrated may have
slight differences than the
model purchased.
kj _,_A_ AjJ=J:]=J:ll,le] _,U

CHECK:
1) Main gas line to manifold connection.
2) RotisseMe(I.R. Burner) gas lineconnection.
3) Bulkhead and gas supply hose connection.
A,, WARNING: If there is aleak at connection (1, 2, or 3),
retighten the fitting with a wrench and recheck for leaks with
soap and water solution.
If a leak persists after re-tightening the fitting, turn off the gas.
DO NOT OPERATE THE GRILL. Contact the Customer Service
Representative in your area using the contact information on
our web site. Log onto www.weber.com ®.
4) Side burner hose to bulkhead connection.
5) Side burner hose to quick disconnect connection, side burner valve and orifice
conneolions.
6) Hose to regulator connection.
7) Regulator to cylinder connection.
8) Valves to manifold connections.
Ak WARNING: If there is aleak at connections (4, 5, 6, 7, or 8),
turn off the gas. DO NOT OPERATE THE GRILL. Contact
the Customer Service Representative in your area using the
contact information on our web site.
Log onto www.weber.com e,
When leak checks are complete, turn gas supply off at the source and rinse connections
with water.
REINSTALLCONTROLPANEL
Parts required: control panel screws and burner control knobs.
Hook the top edge of the control panel onto the control panel brackets on either side ot
the front of the cooking box.
Line up screws with screw holes on both the control panel bracket and the frame.
Tighten screws.
Place corresponding control knobs onto the valve stems.
*The grill illustrated may have
slight differences than the model
purchased.
® ®

REFILLING THE LIQUID PROPANE CYLINDER
We recommend that you refill the LPcylinder before it Jscompletely empty.
Removalof the LPcylinder
1) Closecylinder valve (turn clockwise).
2) Unscrew regulator coupling by turning counterclockwise, by hand only.
3) Loosen cylinder lock wing nutand turncylinder lock upout ofthe way.
4) Lift cylinder oft.
To till,take theLP cylinder to agas propanedealer, or look up"gas-propane" Jnthe
phone book for other sources of LP gas.
Ak WARNING: We recommend that your LP cylinder be filled
at an authorized LP gas dealer, by a qualified attendant,
who fills the cylinder by weight. IMPROPER FILLING IS
DANGEROUS.
Ak CAUTION: Place dust cap on cylinder valve outlet whenever
the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder
valve. Other types of caps or plugs may result in leakage of
propane.
CHECKING THE FUEL LEVEL IN YOUR TANK
Check the fuel level by viewing the color indicator level line on the side of the tank scale.
1) Empty
2) Medium
3) Full
(3)
(t) (2) (3)
SAFE HANDLING TIPS FOR LIQUID PROPANE GAS
CYLINDERS
Liquid Propane (LP) gas isa petroleum product as are gasoline and natural gas.
hPgas isa gas atregular temperatures and pressures. Under moderatepressure,
inside a cylinder, LP gas Jsa liquid.As thepressure is released,the liquid readily
vaporizes and becomes gas.
LPgas has anodor similarto natural gas. Youshould be aware of thisodor.
LP gas is heavier than air. Leaking LP gas may collect in low areas and prevent
dispersion.
To fill,take theLP cylinder to agas propanedealer, or look up"gas-propane" Jn
the phone book for other sources of LP gas.
,4", WARNING: We recommend that your LP cylinder be filled
at an authorized LP gas dealer, by a qualified attendant,
who fills the tank by weight. IMPROPER FILLING IS
DANGEROUS.
Air must be removed from a new LP cylinder before the initial filling. Your LP
dealer is equipped to do this.
The LP cylinder must be installed, transported and stored in an upright position.
LP cylinders should not be dropped or handled roughly.
Never store or transport the LP cylinder where temperatures can reach 125' F
(too hot to hold by hand - for example: do not leave the LP cylinder Jn a car on a
hot day).
Note: A refill will last about 18-20 hours of cookfog time at normal use The tud scale
will indfoate the propane supply so you can refill before running OUL YOUdo not have
to run out before you refill
Treat "empty" LP cylinders with the same care as when lull. Even when the LP
tank Jsempty of liquid there still may be gas pressure in the cylinder. Always
close the cylinder valve before disconnecting.
,4",CAUTION: Place dust cap on cylinder valve outlet whenever
the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder
valve. Other types of caps or plugs may result in leakage of
propane.
Do not use a damaged LP cylinder. Dented or rusty LP cylinders or LP cylinders
with a damaged valve may be hazardous and should be replaced with a new one
immediately.
Liquid Propane (LP) Cylinder(s)
The joint where the hose connects to the LP cylinder must be leak tested each
time the LP cylinder Jsreconnected. For example, test each time the LP cylinder is
refilled.
Be sure the regulator is mounted with the small vent hole pointed downward so
that it will not collect water. This vent should be tree of dirt, grease, bugs etc.
The gas connections supplied with your Weber _ gas barbecue have been
designed and tested to meet 100% CSA and ANSI requirements.
.4,,WARNING: Replacement LP tanks must match the regulator
connection supplied with this barbecue.
LIQUID PROPANE CYLINDER REQUIREMENTS
Check to be sure cylinders have a D.O.T. certification (1), and date tested (2) is
within five years. Your LP gas supplier can do this tot you.
All LP tank supply systems must include a collar to protecl the cylinder valve.
The LP cylinder must be a 20db. size approximately (18!4 inches high, 12V4
inches Jndiameter).
The cylinder must be constructed and marked in accordance with the
Specifications for LP - Gas Cylinders of the U.S. Department of Transportation
(D.O.T.) or the National Standard of Canada, CAN/CSA-B339, Cylinders,
Spheres and Tubes or Transportation of Dangerous Goods; and Commission, as
applicable.
IN CANADA
LIQUID PROPANE CYLINDER REQUIREMENTS
Note: Your retailer can help you match a replacement tank to your barbecue
The LP cylinder must be constructed and marked in accordance with the
specifications for LP gas cylinders, T.C.

GRILLING METHODS
Note: If grill looses heat while cooktr'tg refer to the troubleshootirtg section of this
manual
You can adjust the individual burners as desired. The control settings are STARTtHI,
MEDIUM, LOW, or OFF.
If burners go out during cooking, turn off all burners and wait 5 minutes before relighflng.
A', WARNING: Check the bottom tray and catch pan for grease
build-up before each use. Remove excess grease to avoid a
grease fire in the bottom tray.
PREHEATING
Preheating the grill before grilling is impodant. Light your SummiP gas gd[I according
to the instructions in this Owner's Manual Turn all of the main burners to Start!
Hi, close the lid, and preheat grill with the lid down unfit grill thermometer reaches
550_F (260 -288 C).This is the recommended broiling temperature. This will take
approximately 10 to 15 minutes, depending on outside temperatures.
COVERED COOKING
All grilling is done with the lid down to provide uniform, evenly circulated heat. With the
lid closed, the Summit e gas grill cooks much like a convection oven. The thermometer
in the lid indicates the cooking temperature inside the grill. All preheating and grilling is
done with the lid down. No peeking -- heat is lost every time you lift the lid.
ARRETE
OFF O O mmii,,(
APAGADO
FLAVORIZER _ SYSTEM
When meat juices drip from the food onto the specially angled Flavorizer "_bars,
they create smoke that gives foods an irresistible barbecued flavor. Thanks to the
unique design of the burners, Flavorizefl "_bars and the flexible temperature controls,
uncontrolled flare-ups are virtuaNy eliminated, because YOU control the flames.
Because of the special design of the Flavorizer _ bars and burners, excess fats are
directed through the funnel-shaped bottom tray into the grease catch pan.
The most important thing to know about grilling is which cooking method to use for a
specific food, Direct or Indirect. The difference is simple: place the food directly over the
fire, or arrange the tire on either side of it. Using the right method is the shodesl route to
great results--and the best way to ensure doneness safety.
DIRECT COOKING
The Direct Method, similar to broiling, means the food is cooked directly over lhe heat
source. For even cooking, food should be turned once halfway through the grilling time.
Use the Direct method for foods that take less than 25 minutes to cook: steaks, chops,
kabobs, sausages, vegelables, and more.
Direct cooking is also necessary to sear meats. Searing creates that wonderful crisp,
caramelized texture where the food hits the grate. It also adds great color and flavor to
the entire surface. Steaks, chops, chicken breasts, and larger cuts of meat all benefit
from searing.
To sear meats, place them over Direct High heat for 2 to 5 minutes per side. Smaller
pieces require less searing time. Usually after searing you finish cooking the food at a
lower temperature. You can finish cooking fasbcooking foods by the Direct method: use
the Indirect method for longer-cooking foods.
To sel up your gas grill for Direct cooking, preheat the grill with all burners on "HI". Place
food on the cooking grate, and then adjust all burners to the temperature noted in the
recipe. Close the lid of the grill and lift it only to turn food or to test for doneness at the
end of lhe recommended cooking time.
INDIRECT COOKING
The Indirect Method is similar to roasting, but with the added benefits of that grilled
texture, flavor, and appearance you can't get from an oven. To set up for Indirect
cooking, gas burners are lit on either side of the food but not directly beneath ih Heat
rises, reflects off the lid and inside surfaces of the grill, and circulates 1o slowly cook the
food evenly on all sides, much like a convection oven, so there's no need to turn the
food.
Use the Indirect method for foods that require 25 minutes or more of gdliing time or that
are so deNcate that direct exposure to the flame would dry them out or scorch them.
Examples include roasts, ribs, whole chickens, turkeys, and other large cuts of meat, as
well as delicate fish fillets.
To sel up your gas grill for Indirect cooking, preheat lhe grill with all burners on "HI".
Then adjust the burners on each side of the food to the temperature noted in the recipe
and turn off the burner(s) directly below the food. For best results, place roasts, poultry,
or large cuts of meat on a roasting rack set inside a disposable heavy-gauge foil pan.
For longer cooking times, add water to the foil pan to keep drippings from burning. The
drippings can be used 1o make gravies or sauces.
4 burner
1234
H H H H
Direct Method
Food is placed on the area of the cooking
grates directly over the lit burners.
4 burner
© ©
14
M M
indirect Method
Food is placed on the area of the cooking
grates between the lit burners.