Wen DF1100 User manual

For replacement parts visit
WENPRODUCTS.COM CARB COMPLIANT
EPA CERTIFIED
Your new tool has been engineered and manufactured to WEN’s highest standards for dependability, ease
of operation, and operator safety. When properly cared for, this product will supply you years of rugged,
trouble-free performance. Pay close attention to the rules for safe operation, warnings, and cautions. If
you use your tool properly and for its intended purpose, you will enjoy years of safe, reliable service.
IMPORTANT:
11000 WATT
DUAL FUEL GENERATOR
NEED HELP? CONTACT US!
800-232-1195 (M-F 8am-5pm CST)
[email protected]
WENPRODUCTS.COM
Have product questions? Need technical support?
Please feel free to contact us at:
NOTICE: Please refer to wenproducts.com for the most up-to-date instruction manual.
bit.ly/wenvideo

TABLE OF CONTENTS
Introduction ....................................................................................2
Safety Information ...........................................................................4
Generator Safety Warnings ..............................................................5
Know Your Generator .......................................................................8
Unpacking & Assembly ..................................................................10
Generator Preparation ...................................................................12
Starting the Generator ...................................................................19
Using the Generator ......................................................................21
Shutting Off the Generator .............................................................24
Maintenance .................................................................................25
Transportation & Storage ...............................................................32
Specifications ...............................................................................33
Exploded View & Parts List ............................................................34
Wiring Diagram .............................................................................38
Troubleshooting Guide ...................................................................39
Warranty Statement ......................................................................40
KEY SPECIFICATIONS
Model Number DF1100, DF1100T
Rated Wattage Gasoline: 8300 Watts, LPG: 7500 Watts
Surge Wattage Gasoline: 11000 Watts, LPG: 9500 Watts
Frequency 60Hz
Rated Voltage AC: 120V/240V, DC: 12V
Rated Amperage AC: 70A/35A, DC: 8A
Engine OHV, 4 stroke, single cylinder, 457cc
Fuel Tank Capacity 6.6 US gallons (25 L), 87 octane minimum
Oil Capacity 37.2 fl. oz. (1.1 L)
Half-Load Run Time Gasoline: 8.5 hours
LPG (with 20 lb tank): 3 hours
Product Dimensions 27.3 x 20.6 x 21.9 in. (L x W x H)
Product Net Weight 213.8 lbs (97 kg)
2
Your generator is compatible with the WEN 55201 Magnetic Oil Dipstick,
available at wenproducts.com

SERIAL NUMBER
INTRODUCTION
THANKS FOR PURCHASING THE WEN GENERATOR!
Refer to the illustration below for the location of the serial number. Record the generator information in the
spaces provided below. If assistance for information or service is required, please contact the Customer
Service Help Line by calling 800-232-1195, M-F 8-5 CST; you will be asked to provide the following gen-
erator information when calling.
GENERATOR MODEL NUMBER: WEN DF1100, WEN DF1100T
DATE OF PURCHASE: __________________________________________
PURCHASED FROM: ___________________________________________
SERIAL NUMBER: _____________________________________________
SERVICE RECORD
Record the service dates of your generator in the chart below. Please perform maintenance checks and
operations according to the “MAINTENANCE” section of the manual.
Service Record Date Date Date Date Date Date
Change Oil
Change Spark Plug
Clean Air Cleaner
Clean Spark Arrestor
Clean Fuel Tank
TO MAXIMIZE THE LIFESPAN OF YOUR GENERATOR:
We recommend running your generator at least ONCE A MONTH for 20 to 30 minutes. Start the genera-
tor according to the instructions and plug a small load in to make sure the outlet is producing electricity.
3

DANGER: indicates a hazard, which, if not avoided, will result in death or serious injury.
WARNING: indicates a hazard, which, if not avoided, could result in death or serious injury.
CAUTION: indicates a hazard, which, if not avoided, might result in minor or moderate injury.
CAUTION: when used without the alert symbol, indicates a situation that could result in damage to
the machine.
QUESTIONS? PROBLEMS?
In order to answer questions and solve problems in the most efficient and speedy manner, contact Cus-
tomer Service at [phone], M-F 8-5 CST or email [email protected].
SAFETY SYMBOLS
The purpose of following safety symbols is to attract your attention to possible dangers. The safety sym-
bols, and their explanations, deserve your careful attention and understanding. The safety warnings do not
by themselves eliminate any danger. The instructions or warnings they give are not substitutes for proper
accident prevention measures.
SAFETY INTRODUCTION
Safety is a combination of common sense, staying alert, and knowing how your tool works. This manual
contains important information regarding the generator’s potential safety concerns, as well as preparation,
operation, and maintenance instructions. Before operating this generator, be sure to read and observe all
warnings and instructions both on the generator labels and in this instruction manual. Failure to follow all
instructions listed below may result in personal injury.
NOTE: The following safety information is not meant to cover all possible conditions and situations that may
occur. WEN reserves the right to change this product and specifications at any time without prior notice.
SAVE THESE INSTRUCTIONS - Please keep this manual available to all users during the entire life of
the tool. Review it frequently to maximize safety for both yourself and others.
SAFETY INFORMATION
WARNING: Before operating the generator, make sure to read all safety warnings and all instruc-
tions. Failure to follow the warnings and instructions may result in electric shock, fire or serious injury.
NOTICE REGARDING EMISSIONS
Engines that are certified to comply with U.S. EPA emission regulations for SORE (Small Off Road Equip-
ment), are certified to operate on regular unleaded gasoline, and may include the following emission control
systems: (EM) Engine Modifications and (TWC) Three-Way Catalyst (if so equipped).
4

California Proposition 65 WARNING: This product contains chemicals and produces exhaust
known to the State of California to cause cancer, birth defects and other reproductive harm.
WARNING: If this generator is used as a supply for a BUILDING’S WIRING SYSTEM, the generator
MUST be installed by a qualified electrician and connected to a transfer switch as a separately derived
system in accordance with all applicable laws and electrical codes and the National Electrical Code,
NFPA 70. The generator shall be connected to a transfer switch that switches all conductors exclud-
ing the equipment grounding conductor. The frame of the generator shall be connected to an approved
grounding electrode.
WARNING: RISK OF EXPLOSION. HIGHLY FLAMMABLE: This generator may emit highly flam-
mable and explosive gasoline vapors, which can cause severe burns or even death, if ignited. A nearby
open flame can lead to explosion even if not directly in contact with gasoline.
• Do not operate near open flame.
• Do not smoke near generator.
• Always operate on a firm, level surface.
• Always turn generator off before refueling. Allow generator to cool for at least 2 minutes before re-
moving fuel cap. Loosen cap slowly to relieve pressure in tank.
• Do not overfill fuel tank. Gasoline may expand during operation. Do not fill to the top of the tank. Allow
for expansion.
• Always check for spilled fuel before operating.
• Empty fuel tank before storing or transporting the generator.
• Before transporting, turn fuel valve to OFF and disconnect spark plug wire.
GENERATOR SAFETY WARNINGS
DANGER: CARBON MONOXIDE
Using a generator indoors CAN KILL YOU IN MINUTES. Generator exhaust contains carbon monox-
ide (CO). This is a poison gas you cannot see or smell. If you can smell the generator exhaust, you are
breathing CO. But even if you cannot smell the exhaust, you could be breathing CO.
NEVER use a generator inside homes, garages, crawl spaces, or other partially enclosed areas. Deadly
levels of carbon monoxide can build up in these areas. Using a fan or opening windows and doors does
NOT supply enough fresh air. ONLY use a generator OUTSIDE and far away from windows, doors, and
vents. These openings can pull in generator exhaust.
Even if you use a generator correctly, CO may leak into the home. ALWAYS use a battery-powered or
battery-backup CO alarm in the home. If you start to feel sick, dizzy, or weak after the generator has
been running, move to fresh air RIGHT AWAY. See a doctor. You may have carbon monoxide poisoning.
5

GENERATOR SAFETY WARNINGS
OPERATING ENVIRONMENT
1. Using a generator indoors can KILL YOU IN MINUTES. Only use a generator outside and far away from win-
dows, doors and vents.
2. Do not operate near open flame or flammable materials. This generator may emit highly flammable and
explosive gasoline vapors, which can cause severe burns or even death if ignited. A nearby open flame can
lead to an explosion even if it isn’t directly in contact with gasoline.
3. Do not smoke near the generator.
4. Do not use the generator in rainy or wet conditions; doing so significantly increases the risk of electrical
shock.
5. Always operate the generator on a dry, firm, level surface.
6. Do not allow children or non-qualified persons to operate the generator.
7. Do not use or store LPG cylinder in a building, garage or enclosed area. Failure to do so will result in death
or serious injury. Liquid Petroleum Gas (LPG) is highly flammable and explosive. Flammable gas under pres-
sure can cause a fire or explosion if ignited. Always keep the LPG cylinder in an upright position. The LPG
cylinder valve should be turned OFF (closed) when generator is not in use; failure to do so could result in death
or serious injury.
GENERATOR PREPARATION
1. Always ground the generator before using it to maximize safety (see “GROUND THE GENERATOR” section
on page 18).
2. Always make sure generator is turned OFF before filling the fuel tank. Do not overfill fuel tank, as gaso-
line may expand during operation. Do not fill to the very top of the tank. Leave room for gasoline expansion.
Always check for spilled fuel before operating.
3. Do not use receptacles or cords that show signs of damage, such as broken or cracked insulation. If
any part of the generator or electrical device is broken, damaged, or defective, make sure it is repaired or
replaced before operation. Service should only be performed by a qualified technician.
4. Use a ground fault circuit interrupter (GFCI) in highly conductive areas such as metal decking or steel
work. Extension cords with in-line GFCIs are recommended for these operations to maximize safety.
5. NEVER connect the generator to a building’s electrical system without consulting a qualified electrician.
Such connections must comply with local electrical laws and codes. Failure to comply can create a back-
feed, which may result in serious injury or death to utility workers.
WARNING: Do not let comfort or familiarity with the product replace strict adherence to product
safety rules. Failure to follow the safety instructions may result in serious personal injury.
6

GENERATOR SAFETY WARNINGS
GENERATOR OPERATION
1. Only use the generator for its intended purposes. Modifying or using the generator for operations for
which it was not designed may cause hazards and personal injury.
2. Do not touch bare wires or receptacles (outlets).
3. Do not exceed the wattage capacity of the generator by plugging in more electrical devices than the unit
can handle.
4. Allow generator to run for several minutes before connecting electrical devices.
5. Do not exceed the wattage capacity of the generator by plugging in more electrical devices than the unit
can handle (see “OPERATION” section).
6. Do not turn on electrical devices until after they are connected to the generator.
7. Generators vibrate in normal use. During and after the use of the generator, inspect both the generator
as well as extension and power supply cords for damage resulting from vibration.
8. Do not touch HOT PARTS. This generator produces heat when running. Temperatures near exhaust can
exceed 150º F (65º C). Allow generator to cool down after use before touching engine or areas of the gen-
erator that become hot during use.
9. Turn off all connected electrical devices before stopping the generator.
10. Always turn generator off before refueling. Allow generator to cool for at least 2 minutes before remov-
ing fuel cap. Loosen cap slowly to relieve pressure in tank.
11. Turn the engine switch to “OFF” position when the engine is not running.
12. Empty fuel tank before storing or transporting the generator. Do not store generator or gasoline near
furnaces, water heaters, or any other appliances that produce heat or have automatic ignitions. Store the
generator and fuel away from sparks, open flames, pilot lights, heat and other sources of ignition.
CAUTION: Misuse of this generator can damage it or shorten its lifespan.
TO MAXIMIZE THE LIFESPAN OF YOUR GENERATOR:
We recommend running your generator at least once a month for 20 to 30 minutes. Start the generator
according to the instructions and plug a small load in to make sure the outlet is producing electricity.
If you do not run it often, it will greatly shorten the generator’s lifespan and void the warranty.
7

KNOW YOUR GENERATOR
8
1. Gasoline Fuel Cap
Access to the fuel tank for adding gasoline
2. Fuel Gauge
Indicates amount of fuel inside the fuel tank
E indicates Empty, F indicates Full
3. Pressure Relief Valve
4. Choke Lever
Adjusts the amount of air let into the engine
during startup
5. Fuel Valve
Allows fuel to enter engine from the fuel tank
6. Air Filter
A case with a sponge-like element that filters
the air entering the engine
7. Recoil Starter
Pull cord for manually starting the engine
1
2
3
4
5
6
7
8
9
8. 457cc OHV Engine
9. Transportation Handles
For easy transport of the generator
(installed by user)
10. Fuel Tank
11. Control Panel
Refer to the next page for descriptions
12. Battery
Connect the battery before starting the generator
13. Oil Fill and Dipstick
For filling and checking oil
14. LPG Hose Connector
Connects to LPG hose and LPG cylinder
12
11
10
13
Use the illustration below to become familiar with all the components and controls of this generator. If any
part is damaged or missing, please contact our customer service at [phone], M-F 8-5 CST or email
us at [email protected].
14

KNOW YOUR GENERATOR
9
1. Fuel Selector Dial
Turn the dial to select between gasoline
or LPG before operation
2. Electric Start Switch
Turn the starter key to start, run and stop the
engine
3. Multi-meter
Displays the following information:
- Output voltage
- Output frequency
- Total runtime
- Session runtime
4. DC 12V Receptacle
Cigarette lighter style receptacle, 12V DC, 8A
5. DC Circuit Breaker
Thermal protector that protects the DC circuit
from overload
6. NEMA 5-20R GFCI Duplex Receptacle
Connect electrical devices that run on 120V,
60 Hz, single phase, AC current
KNOW YOUR CONTROL PANEL
1 2 3 4
5
6
7
8
9
7
1210
7. AC 20A Circuit Breakers (for 5-20R)
Thermal protector that protects the 5-20
receptacles from overload
8. AC 30A Circuit Breaker (for L5-30R)
Thermal protector that protects the L5-30
receptacle from overload
9. NEMA L5-30R 120V 30A Twistlock Receptacle
Connect electrical devices that run on 120V, 60 Hz,
single phase, AC current
10. NEMA L14-50R 120V/240V 50A Receptacle
Connect electrical devices that run on 120V/240V,
60 Hz, single phase, AC current
11. 35A Main Circuit Breakers
Thermal protectors that protect the generator’s
main circuit from overload
12. Grounding Nut
Connect grounding wire here to properly ground
the generator

UNPACKING & ASSEMBLY
No. Accessory Qty.
43 Foot Support Assembly 2
44 Foot Support Isolator 2
32 M6X25 Bolt 2
45 M6 Nut 2
64 M8 Nut 4
48 Wheel Axle 2
42 Wheel 2
16 Flat Washer 2
25 Cotter Pin 2
19 Handle 2
73 Handle Isolator 2
30 Handle Plug 2
67 Handle Bushing 4
31 M8X45 Bolt 2
77 M8 Lock Nut 2
N/A Spark Plug Wrench 1
N/A First Stage Regulator 1
N/A Oil Bottle 1
PACKING LIST
UNPACKING THE GENERATOR AND ACCESSORIES
Open the packaging and take out all loose parts from the box. With the help of a good friend or trustworthy
foe, carefully lift the generator from the packaging and place it on a sturdy, level surface.
Make sure all the accessories are accounted for and fully assemble the generator before discarding the pack-
aging. If any part is missing or broken, please contact our customer service at [phone], M-F 8-5 CST
or email us at [email protected].
10
IMPORTANT: Two red shipping brackets have been added
to the bottom of your generator to protect the generator
during shipping. Please make sure to remove BOTH ship-
ping brackets before operation.
IMPORTANT: The LPG hose is packed underneath the fuel
tank, sitting above the engine. Remove to hose and set it
aside before assembling or operating the generator.