Whirlpool CGM2941TQ0 User manual

c2008 WHIRLPOOL CORPORATION Part No. W10119633 Rev. B
COMMERCIAL
GAS DRYER
MODELS
CGM2941TQ0
CGM2941TQ1
07−08 Litho in U.S.A. (LT)(mek)

BULKHEAD PARTS
2
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)

BULKHEAD PARTS
3
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 Literature Parts
8563800 Instructions,
Installation
8576820 Label,
Wiring Diagram
W10119633 Repair Parts List
2 3388703 Washer, Support
3 348368 Lint Chute
Assembly
4 347139 Seal, Lint
Chute
5 90767 Screw, 8−18 x 3/8
6 3392519 Thermal Fuse
7 3387134 Thermostat,
Internal Bias
8 696302 Shield, Exhaust
9 8066086 Drum Hole
Plug
10 694089 Wheel, Blower
11 8577230 Housing, Blower
12 3398161 Clip
13 343641 Screw, 10−16 x 1/2
14 8530285 Box, Heater
15 3403140 Thermostat,
High Limit
205 F
(96 C)
16 3390647 Screw, 8−18 x 1/2
17 280010 Kit,
Thermal Cut−Off
(Includes
Illus. 15)
18 8066049 Funnel, Burner
19 3401707 Wire, Jumper
20 489463 Screw, 8−18 x 5/8
21 3406022 Bracket, Bulkhead
22 690997 Ring, Tri
23 3399506 Shaft, L.H.
24 3399507 Shaft, R.H.
25 3397590 Roller, Support (2)
26 348197 Washer,
Support (4)
27 3359452 Nut, 3/8−16 (2)
28 3403410 Bulkhead
29 338906 Sensor, Radiant
30 692526 Ring, Bearing
31
W10109200 Screw, 11−16 x 3/4
32 3406130 Seal, Rear Drum
33 695587 Drum Assembly
34 692490 Baffle, Drum
35 3403636 Baffle, Drum (1)
36 339956 Seal
37 3976434 Bracket, Support
Shaft
38 90296 Clip

TOP AND CONSOLE PARTS
4
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633

TOP AND CONSOLE PARTS
5
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 357213 Nut, Push−In (2)
2 8283378 Cover, Lint Screen
3 297535 Bumper, Lint Lid
4 8316437 Switch, Pushbutton
5 385421 Funnel, Coin
6 3949737 Cap, End (R.H.)
7 98445 Screw, 10−16 x 3/4
8 3402631 End Cap (L.H.)
9
W10127740 Panel, Control
10 349639 Screen, Lint
11 3387361 Bracket, Control
12 3978606 Hinge, L.H.
3978605 Hinge, R.H.
13 688983 Screw, 8−18 x 3/8
14 3387978 Panel, Rear
Console
15 97787 Screw,
11−16 x 5/8
16 8527847 Top
17 3403498 Connector,
3 Position
18 351297 Plug, Harness
19 8316433 Pushbutton
20 303921 Screw, 8−32 x 3/8
21 357572 Clip, Grounding
22 693995 Screw, 8−18 x 3/8
23 3401177 Light, Indicator
Assembly
24 3348109 Lens, Amber (3)
25 94614 Terminal
26 3978748 Case, Meter
27 3349065 Bolt,
5/16−24 x 1
28 339554 Screw,
10−16 x 1/32
29 3347825 Plate, Mounting
30 3954761 Adapter Plate
Chute Assembly
(Includes
Illus. 5)
31 8529862 Harness, Wiring
32 3401126 Harness, Timer
33 3351136 Door, Service
34 689559 Nut, Push In
35 3954812 Cushion, Meter
Case
36 690853 Wire, Ground
37
W10045440 Timer
(Includes
4−Pin Cam)
38 Timing Cam
3387974 3−Pin (60 Min)
339855 4−Pin (45 Min)
343777 6−Pin (30 Min)
Also Available
339854 9−Pin (20 Min)
339853 12−Pin (15 Min)
39 339805 Screw,
10−32 x 3/16
40 388326 Screw, Console
41 3954807 Kit, Vertical
8−Coin
(Includes
Illus. 51−53−54
57−58−59 & 60)
42 90406 Nut, Cage
43 3403499 Connector,
2 Position
44 351296 Receptacle
45 717252 Connector, 2−Way
46 3395683 Connector, Housing
47 717315 Receptacle (4−Way)
48 3936144 Connector
49 717253 Plug (2−Way)
50 3394427 Clip, Harness
Following Parts Supplied
On Whirlpool Coin
Equipped Models Only
51 8316526 Security Lock/Key
& Cam Assembly
52 8318517 Bolt, Slide
Mechanism
53 8316520 Slide Mechanism
(Vertical 8−Coin)
(Dollar Vend)
Inserts
(Not Shown)
8316264 Blank
8316265 25¢
54 8316525 Money Box W/Lock
55 Key (Money Box)
(When Ordering,
Specify Vendor
and Key Number)
56 Key (Service Door)
(When Ordering,
Specify Vendor
and Key Number)
57 8316523 Extension
58 8316524 Kit, Decal
59 8316532 Installation
Instructions
Coin Kit
60 3400086 Screw, 10−32 x 3/8
Coin mechanism parts may be
Ordered from whirlpool or
The vendor(s) listed below
ESD
270 New Jersey Dr.
Fort Washington, PA
19034
1−800−523−1510
@
info esdcoin.com

CABINET PARTS
6
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633

CABINET PARTS
7
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 3394975 Plug, Front
Panel
2 3954895 Bracket, Top
Lock
3 354730 Bolt,
5/16−18 x 2 3/4
4 90984 Nut
5 3404162 Clamp, Motor
(W/Shield)
6 3403630 Plug, Strike
7 343641 Screw, 10−16 x 1/2
8 697773 Screw, 6−20 x 7/8
9 3401401 Cord, Power
10 8541400 Bracket, Cabinet
11 697776 Screw, 10−32 x 5/8
(Grounding)
12 3404413 Plug, Hinge
Hole (4)
13 3405184 Handle, Door
14 3402335 Door, Front
15 3396795 Cover, Block
16 238088 Hinge, Top (2)
17 3394083 Clip, Front
Panel (2)
18 3396805 Panel, Rear
19 3401771 Burner Assembly
(60 Hz)
(Refer To Pages
8 & 9 For
Further Burner
Breakdown)
20 3402341 Door, Rear
21 98234 Clip, Ground (2)
22 3406129 Seal & Bearing
Assembly
23 693995 Screw, Hex
Washer Head
24 3403447 Front Panel
Assembly
25 3392100 Foot
279810 Foot − Optional
(Extended Length
Package Of 2)
(Not Included)
26 342055 Screw, 8−18 x 1/2
27 8281908 Valve, Gas
(Complete)
28 8530603 Cabinet
(Includes
Illus. 10)
29 3405514 Hinge & Pin
Assembly (2)
30 3406109 Switch, Door
31 3403431 Strike, Door
32 686590 Ignitor
33 690363 Lock, Front
Top (2)
34 685203 Clip, Felt Pad (2)
35 3393909 Screw, Washer
36 3405246 Seal, Door
37 3389441 Catch, Door
38 8066206 Motor Assembly
60 Hz.
39 348780 Base, Motor
40
W10131364 Belt, Drive
41 3400500 Bolt,
5/16−18 x 3/4
42 691366 Idler & Pulley
Assembly
43
W10121316 Clamp, Motor
44 8066184 Pulley, 60 Hz.

USE WITH TYPE 1 − NATURAL, TYPE 2 − MIXED, TYPE 3 − MANUFACTURED
AND TYPE 4 − LIQUEFIED PROPANE AND BUTANE GASES
3401771 BURNER ASSEMBLY
BA−128−A
8
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633

Illus. Part
No. No. DESCRIPTION
USE WITH TYPE 1 − NATURAL, TYPE 2 − MIXED, TYPE 3 − MANUFACTURED
AND TYPE 4 − LIQUEFIED PROPANE AND BUTANE GASES
1 3401771 Burner Assembly
60 Hz.
(Type 1, 2 & 3)
(White Rodgers)
2 688617 Tube, Burner
3 694298 Bracket, Ignitor
4 686590 Ignitor
5 3393909 Screw & Washer
(8−32 x 5/8)
6 343641 Screw, 10−16 x 1/2
7 693986 Base, Burner
8 3387057 Screw,
8−18 x 3/8 (2)
9 Orifice, Burner
234826 Type 1
15775 Type 2
15419 Type 3
229742 Type 4 (Butane)
234868 Type 4 (Propane)
10 3401775 Valve, 60 Hz.
11 694421 Screw,
8−32 x 1/2 (2)
12 694538 Bracket, Coil
13 694540 Coil, 60 Hz.
(2 Terminal)
(Main)
14 694539 Coil, 60 Hz.
(Split)
(3 Terminal)
(Pilot Position)
15 694424 Leak Limiter
16 694423 Screw, Regulator
Adjustment
17 694422 Spring, Regulator
20 239822 Plug, Pipe
21 233273 Pipe, Gas Supply
22 3393658 Valve & Union,
Shut−Off
23 3393767 Pipe, Tail
24 233076 Nut, Compression
25 341029 Clamp, Pipe
Following Parts Not Illustrated
694572 Conversion Kit
(Type 1, 2 & 3)
to Type (4) L.P.G.
BA−128−A
3401771 BURNER ASSEMBLY
9
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633

OPTIONAL PARTS (NOTINCLUDED)
10
For Model: CGM2941TQ0, CGM2941TQ1
(White) (White)
W10119633
Illus. Part
No. No. DESCRIPTION
ACCESSORY PARTS
279948 Kit,
Dryer Repair
8522199 Kit, Dryer
Vent Testing
PAINT, TOUCH−UP (1/2oz.)
72017 White
PAINT, PRESSURIZED SPRAY
(12 oz.)
350930 White
350938 Primer, Gray
PAINT, BULK (1 qt.)
799344 White (Uncut)