Winston Disney Pixar Toy Story 3 Power Quad Datasheet

TABLE OF CONTENTS
20811
AElectric Car Specifications 2
BList of Parts 4
CAssembly 5
DBattery Charging 7
EHow to Use 9
FSafety Precautions 9
GSimple Repairs 10
HMaintaining your Vehicle 11
IAbout Thermal Fuses 11
Electric car specications
A
SUITABLE AGE 18-36 Months
CAPACITY under 45 lbs (20 kg)
SPEED 2.5km/H
CHARGER/INPUT 100-240V AC 0.16A 50/60HZ
CHARGING TIME 8-10 Hours
BATTERY 6V 4.5Ah, 1xBattery
SIZE OF CAR 70 x 42 x 47cm
CHARGING TIMES 300 times
OUTPUT DC 7.3V 500mA
THIS VEHICLE MUST BE ASSEMBLED BY AN ADULT.
PLEASE READ THE MANUAL CAREFULLY BEFORE OPERATION.
WARNING
CALIFORNIA PROPOSITION 65 WARNING
This product’s battery contains or emits chemicals known to the State of California to cause
cancer and birth defects or other reproductive harm.
If you have any questions, please call the Winston service phone number
1-877-901-8811 instead of returning to the retailer where purchased.
!
WARNINGS AND CAUTIONS

3
0811
TABLE OF CONTENTS
Electric car specications
WARNINGS AND CAUTIONS
WARNING
•Toreducetheriskofinjury,adultsupervisionisrequired.Neveruseinroadways,near
motorvehicles,onornearsteepinclinesorsteps,swimmingpoolsorotherbodiesof
water. Always wear shoes and a helmet.
•Neverallowmorethan1rider.
!
WARNING
TO PREVENT FIRE AND ELECTRIC SHOCK:
•Onlyusebatteryandchargerprovidedandspeciedbymanufacturer.
Useofthewrongtypeofbatteryforchargercouldcauseareorexplosion.
•DONOTusethebatteryorchargerforanyotherproduct.Overheating,reor
explosioncouldoccur.
•NEVERmodifytheelectriccircuitsystem.Alterationscouldcauseashock,reorexplosion.
•DONOTallowanytypeofliquidonthebatteryoritscomponents.Explosivegasesare
createdduringcharging.DONOTchargenearheatorammablematerials.Chargeina
wellventilatedareaONLY.
•ChargethebatteryinadryareaONLY.
•DONOTopenthebattery.Batterycontainsleadacidandothermaterialsthat
aretoxicandcorrosive.
•ONLYADULTSmayhandleorchargethebattery.NEVERallowchildtohandleorcharge
thebattery.Batteryisheavyandcontainsleadacid(electrolyte).
•DONOTdropthebattery.Permanentdamagetothebatterycouldoccuror
causeseriousinjury.
•Beforechargingthebattery,checkforwearanddamagetothebattery,chargerandthe
connectors.DONOTchargethebatteryifanydamagetopartshasoccurred.Replace
withmanufacturer’spartsONLY.
•DONOTallowthebatterytodraincompletely.Rechargethebatteryaftereachuseor
onceamonthifnotusedregularly.
•DONOTchargebatteryupsidedown.
•Alwayssecurethebatterywiththebracket.Batterycanfalloutandinjureachild
if vehicle tips over.
•Ifabatteryleakdevelops,avoidcontactwithskinoreyes.Flushwithcoolwaterforat
least15minutesandcallaphysician.
•Ifacidcomesincontactwithskinoreyes,ushwithcoolwaterforatleast15minutes
and call a physician.
•Ifacidisinternallyingested,givewater,milkofmagnesiaoreggwhiteimmediately.
Nevergiveemeticsorinducevomiting.Callaphysician.
!
ELECTRICAL HAZARD

4
LIST OF PARTSB
0811
Manual
ASSEMBLY
(1)MainBody
(2)Charger
(3)HandlebarAssembly
(4)Manual
(5)LockNutWrench
(1)
(2) (3)
(5)
(4)

LIST OF PARTS
C
0811
• Removethelocknutandwasheroffthehandlebar
steeringcolumn.
• Keepingvehicleuprightassemblehandlebarby
placingitdownintothelargeopeningonfront
of vehicle.
ASSEMBLY
5
1 2
• Turningvehicleover,ensuresteeringcolumnis
placedthroughthesteeringlinkage.
• Placethelocknut(roundedsideup)andwasher
ontotheendofthesteeringcolumn.Tightenthe
locknutrmlywithprovidedLockNutWrench.
SteeringLinkage
LockNut
SteeringColumn
RoundedSideUp LockNutWrench

ASSEMBLY
C
60811
Pull Up
• Connecthandlebarandmotorconnectors.
3 4
•Turnthevehicleupright.
•Pullthehandlebaruptobesurethesteering
column is secure.
BATTERY CHARGING

ASSEMBLY
D
7
0811
BATTERY CHARGING
IMPORTANT! Before first time use, charge the battery for at least 10 hours.
Never charge the battery longer than 15 hours.
• LocatetheDCchargingoutletonthebackofthe
quadundertheleftrearwheelfender.
1 2
• ConnectDCpinfromprovidedchargertoDC
chargingoutlet.
DC Charging Outlet

HOW TO USE
BATTERY CHARGINGD
80811
ChargerIndicatorlight.
• PlugDCchargerintowalloutlet.
NOTE:Aredlightonthechargerindicatesthe
batteryischarging.Quadwillnotworkwhilethe
batteryischarging!
3 4
• Theredlightonthechargerturnsgreen
whenthebatteryisfullycharged.
• DisconnecttheDCpinfromtheDC
chargingsocket.
Safety specications

HOW TO USE E
9
0811
BATTERY CHARGING
WARNING
•Thisquadisequippedwitha
self-resettingbuilt-inthermalfuse.
Pleaseseepage11formoredetails.
!
1
•Pressbuttontogo,releasebuttontostop.
!
Safety specications f
•Yournewbatterymustbechargedforatleast10hoursbeforeyouuseitinyourvehiclefor
thersttime.Werecommendthatyoustartchargingyourbatterybeforebeginningassembly
of your vehicle.
•Thechildmusthaveadultsupervisionatalltimes.
•Donotrideontheroad,footpaths,nearpools,orbodiesofwater.
•Donotallowchildrenunderthesuitableagetoridethevehicle;pleasereferto
theagegrading.
•Donotallowridergreaterthantherecommendedweightratingoroveragedchildrento
use the vehicle.
•To“stop“youmusttakeyourhandoffthebutton.
•Chargingshouldonlybedonebyanadult.
•Anadultmustteachthechildhowtooperatethevehicle.
•Donotrideonslopesgreaterthan15degrees,sand,orothersoft,wet,orslipperysurfaces.
•Donotuseadifferentsizebattery.
•Thevehicleisdesignedtoloadonlyoneperson.Overloadisprohibited.
•Thisproductshouldbeassembledandcheckedbyadultsbeforeuse.
•Don’twashthevehiclewithwater.Justcleanitwithacloth.
Press

10 0811 10 0811
PROBLEM POSSIBLE SOLUTION
Car won’t start Make sure all wires are connected.
Make sure the button on the handlebar is pressed
 downtotheONposition.
Speedistooslow Batteryneedstobecharged.
Batterywon’tcharge Makesureyouareusingone6-Voltbatteryin
the vehicle.
 Batterymayneedtobereplaced.
 Checktoseeifchargerisdamaged.
 Neveruseachargerwithtornwires.
•Yourbatteryisanon-spillablesealedlead-acidbattery.Itmustberecycledordisposedofin
an environmentally sound manner.
•Donotdisposeofalead-acidbatteryinare.Thebatterymayexplodeorleak.
•Donotdisposeofalead-acidbatteryinyourregular,householdtrash.Theincineration,
landllingormixingofsealedlead-acidbatterieswithhouseholdtrashisprohibitedbylaw
in most areas.
•Returnanexhaustedbatterytoafederalorstateapprovedlead-acidbatteryrecycler.
Contactyourlocalwastemanagementofcialsforotherinformationregardingthe
environmentallysoundcollection,recyclinganddisposaloflead-acidbatteries.Ifyoulivein
theStateofFloridaortheStateofMinnesota,itisprohibitedbylawforanyonetothrow
away lead-acid batteries in the municipal waste system.
SIMPLE REPAIRS
MAINTAINING YOUR VEHICLE
ABOUT THERMAL FUSES
G
Disposal of battery