Xerox 4050 Technical manual

;HUR['RFX3ULQW,36
,QVWDOODWLRQ3ODQQLQJ*XLGH
9HUVLRQ
$XJXVW
3

;HUR[&RUSRUDWLRQ
6RXWK$YLDWLRQ%RXOHYDUG
(O6HJXQGR&$
¸ E\;HUR[&RUSRUDWLRQ$OOULJKWVUHVHUYHG
&RS\ULJKWSURWHFWLRQFODLPHGLQFOXGHVDOOIRUPVDQGPDWWHUVRI
FRS\ULJKWDEOHPDWHULDODQGLQIRUPDWLRQQRZDOORZHGE\VWDWXWRU\RU
MXGLFLDOODZRUKHUHLQDIWHUJUDQWHGLQFOXGLQJZLWKRXWOLPLWDWLRQ
PDWHULDOJHQHUDWHGIURPWKHVRIWZDUHSURJUDPVZKLFKDUHGLVSOD\HG
RQWKHVFUHHQVXFKDVLFRQVVFUHHQGLVSOD\VORRNVHWF
3ULQWHGLQWKH8QLWHG6WDWHVRI$PHULFD
3XEOLFDWLRQQXPEHU3
;HUR[ ·, 7KH'RFXPHQW&RPSDQ\WKHVW\OL]HG;DQGDOO;HUR[
SURGXFWQDPHVPHQWLRQHGLQWKLVSXEOLFDWLRQDUHWUDGHPDUNVRI;HUR[
&RUSRUDWLRQ3URGXFWVDQGWUDGHPDUNVRIRWKHUFRPSDQLHVDUHDOVR
DFNQRZOHGJHG
&KDQJHVDUHSHULRGLFDOO\PDGHWRWKLVGRFXPHQW&KDQJHVWHFKQLFDO
LQDFFXUDFLHVDQGW\SRJUDSKLFHUURUVZLOOEHFRUUHFWHGLQVXEVHTXHQW
HGLWLRQV

XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE iii
Laser safety
!Warning: Adjustments, use of controls, or performance of
procedures other than those specified herein may result in
hazardous light exposure.
The Xerox DocuPrint printers are certified to comply with the
performance standards of the U.S. Department of Health, Education,
and Welfare for Class 1 laser products. Class 1 laser products do not
emit hazardous radiation. The DocuPrint printers do not emit
hazardous radiation because the laser beam is completely enclosed
during all modes of customer operation.
The laser danger labels on the system are for Xerox service
representatives and are on or near panels or shields that must be
removed with a tool. DO NOT REMOVE LABELED PANELS OR
PANELS NEAR LABELS. ONLY XEROX SERVICE
REPRESENTATIVES HAVE ACCESS TO THESE PANELS.
Ozone information
This product produces ozone during normal operation. The amount
of ozone produced depends on copy volume. Ozone is heavier than
air. The environmental parameters specified in the Xerox installation
instructions ensure that concentration levels are within safe limits. If
you need additional information concerning ozone, call 1-800-828-
6571 to request the Xerox publication 600P83222, OZONE.
Operation safety
Your Xerox equipment and supplies have been designed and tested
to meet strict safety requirements. They have been approved by
safety agencies, and they comply with environmental standards.
Please observe the following precautions to ensure your continued
safety.
•Always connect equipment to a properly grounded electrical
outlet. If in doubt, have the outlet checked by a qualified
electrician.
!Warning: Improper connection of the equipment grounding
conductor may result in risk of electrical shock.
•Never use a ground adapter plug to connect equipment to an
electrical outlet that lacks a ground connection terminal.
•Always place equipment on a solid support surface with
adequate strength for its weight.



iv XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE
•Always use materials and supplies specifically designed for
your Xerox equipment. Use of unsuitable materials may result in
poor performance and may create a hazardous situation.
•Never move either the printer or the Printer Controller without
first contacting Xerox for approval.
•Never attempt any maintenance that is not specifically
described in this documentation.
•Never remove any covers or guards that are fastened with
screws. There are no operator-serviceable areas within these
covers.
•Never override electrical or mechanical interlocks.
•Never use supplies or cleaning materials for other than their
intended purposes. Keep all materials out of the reach of
children.
•Never operate the equipment if you notice unusual noises or
odors. Disconnect the power cord from the electrical outlet and
call service to correct the problem.
If you need any additional safety information concerning the
equipment or materials Xerox supplies, call Xerox Product Safety at
the following toll-free number in the United States:
1-800-828-6571
For customers outside the United States, contact your local Xerox
representative or operating company.

XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE v
Table of Contents
/DVHUVDIHW\ LLL
2]RQHLQIRUPDWLRQ LLL
2SHUDWLRQVDIHW\ LLL
,QWURGXFWLRQ L[
$ERXWWKLVJXLGH L[
&RQWHQWV L[
&RQYHQWLRQV [
1RWLFH [
 3URGXFWRYHUYLHZ 
6\VWHPRYHUYLHZ 
,36KDUGZDUHIHDWXUHV 
136,36'XDO0RGH 
6L[WK6HQVH 
%DVHV\VWHPFRPSRQHQWV 
 &RQWUROOHUFRPSRQHQWVDQGRSWLRQV 
&RQWUROOHUKDUGZDUH 
6XQ8OWUDZRUNVWDWLRQ 
6XQ8OWUDZRUNVWDWLRQ 
,36XVHULQWHUIDFHVFUHHQ 
+RVW&KDQQHO8QLW+&8²FKDQQHODWWDFKHGV\VWHPVRQO\ 
 3ULQWHUFRPSRQHQWVDQGRSWLRQV 
3ULQWHUFRPSRQHQWV 
3ULQWHUFRQWUROFRQVROH 
3ULQWHURSWLRQV 
+LJKFDSDFLW\IHHGHU 
'XDOVWDFNHU 
6WLWFKHUVWDFNHU 
 3UHSDULQJIRULQVWDOODWLRQ 
5HVSRQVLELOLWLHV 
;HUR[UHVSRQVLELOLWLHV 
&XVWRPHUUHVSRQVLELOLWLHV 
,QVWDOODWLRQSODQQLQJFKHFNOLVW 
&RQQHFWLYLW\UHTXLUHPHQWV 
(WKHUQHWVSHFLILFDWLRQV 

TABLE OF CONTENTS
vi XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE
7RNHQ5LQJVSHFLILFDWLRQV 
&KDQQHODWWDFKHGVSHFLILFDWLRQV 
 &RQWUROOHUVSHFLILFDWLRQVDQGUHTXLUHPHQWV 
3RZHUUHTXLUHPHQWV 
2XWOHWFRQILJXUDWLRQV 
(QYLURQPHQWDOVSHFLILFDWLRQV 
6SDFHUHTXLUHPHQWV 
3ULQWHUFRQWUROOHUSODFHPHQW 
&RQWUROOHUKDUGZDUHVSHFLILFDWLRQVDQGUHTXLUHPHQWVVXPPDU\ 
 3ULQWHUVSHFLILFDWLRQVDQGUHTXLUHPHQWV 
3RZHUUHTXLUHPHQWV 
2XWOHWFRQILJXUDWLRQV 
3ULQWHURXWOHWYROWDJHV²+] 
3ULQWHURXWOHWYROWDJHV²+] 
(QYLURQPHQWDOVSHFLILFDWLRQV 
6SDFHUHTXLUHPHQWV 
3ULQWHUSODFHPHQW 
6SDFHSODQQLQJJXLGHOLQHV 
&OHDUDQFHVSDFHUHTXLUHPHQWV 
6KDUHGVSDFH 
)ORRUOHYHOLQJ 
'HOLYHU\DFFHVVUHTXLUHPHQWV 
3ULQWHUKDUGZDUHVSHFLILFDWLRQVDQGUHTXLUHPHQWVVXPPDU\ 
6SDFHSODQQLQJWHPSODWHV 
 6\VWHPFRQQHFWLRQV 
&DEOHOHQJWKV 
&DEOHORFDWLRQV 
&KDQQHODWWDFKPHQWV 
 ,QVWDOODWLRQ 
,QVWDOODWLRQSURFHVV 
<RXUUHVSRQVLELOLWLHV 
'HILQLQJWKH,36SULQWHUWRWKHKRVW 
6RIWZDUHOLFHQVLQJ 
2QJRLQJPDLQWHQDQFH 
5RXWLQHPDLQWHQDQFH 
0HWHUUHDGLQJDQGUHSRUWLQJ 

TABLE OF CONTENTS
XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE vii
$ 6XSSOLHV $
3DSHUDQGRWKHUWKURXJKSXWVWRFNV $
6HOHFWLQJSDSHU $
3DSHUFDUH $
2WKHUVXSSOLHV $
'U\LQN $
)XVHUOXEULFDQW $
'HYHORSHU $
'LVNHWWHV $
&DUWULGJHWDSHV $
)RQWV $
&RQVXPDEOHVXSSOLHVWDEOHV $
3DSHUDQGVSHFLDOVWRFNVWDEOHV $
&RPSOHWHVXSSOLHVOLVW²SULQWHUV $
2UGHULQJVXSSOLHV $
% ;HUR[VXSSRUWVHUYLFHV %
;HUR[&XVWRPHU6HUYLFH6XSSRUW&HQWHU %
;HUR[3ULQWLQJ6\VWHPV&XVWRPHU6XSSRUW&HQWHU %
;HUR[&XVWRPHU'RFXPHQWDWLRQ&DWDORJ %
;HUR['RFXPHQWDWLRQDQG6RIWZDUH6HUYLFHV;'66 %
2SHUDWRUWUDLQLQJ %
;HUR[&XVWRPHU(GXFDWLRQ %
;HUR[)RQW&HQWHU %
& 5HODWHGSXEOLFDWLRQV &
' 'HILQLQJWKHFKDQQHODWWDFKHGSULQWHUWRWKHKRVW '
096SDUDPHWHUV '
26SURFHGXUHV '
$,;SURFHGXUHV '
90VDPSOHGHILQLWLRQV '
96(VDPSOHGHILQLWLRQV '
( 'HILQLQJWKHSULQWHUWRWKHKRVW7&3,3DWWDFKPHQW (
096RU26SDUDPHWHUV (
6RIWZDUHSUHUHTXLVLWHV±096 (
1HWZRUNFRQILJXUDWLRQV±096 (
&RQILJXUDWLRQVWHSV±096 (
&RQILJXUHWKH,36SULQWHUIRU7&3,3DWWKH*8, (
&RQILJXUHWKH096&&8IRUWKH096KRVWWR096 (
&RQILJXUHWKH36)SULQWHULQ-(6RU-(6 (
&RQILJXUHWKHSULQWHULQ36)096 (

TABLE OF CONTENTS
viii XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE
&RQILJXUH7&3,3IRU096IRUWKHSULQWHU (
7HVWWKHSULQWHUWRHQVXUHLWSULQWVIURPWKH096KRVW (
&RUUHFWLQJIRUSULQWHUSHUIRUPDQFHLVVXHV±096 (
5HIHUHQFHV (
$6SDUDPHWHUV (
6RIWZDUHSUHUHTXLVLWHV±$6 (
1HWZRUNFRQILJXUDWLRQV±$6 (
&RQILJXUDWLRQVWHSV±$6 (
&RQILJXUHWKH,36SULQWHUIRU7&3,3DWWKH*8, (
&UHDWHWKH36)FRQILJXUDWLRQ (
&UHDWHWKHSULQWHUGHYLFHGHVFULSWLRQ±$6 (
7HVWWKHSULQWHUFRQQHFWLRQ±$6 (
&RUUHFWLQJIRUSULQWHUSHUIRUPDQFHLVVXHV±$6 (
5HIHUHQFHV±$6 (
$,;SDUDPHWHUV (
6RIWZDUHSUHUHTXLVLWHV±$,; (
1HWZRUNFRQILJXUDWLRQV±$,; (
&RQILJXUDWLRQVWHSV²$,; (
5HIHUHQFHV (
26SDUDPHWHUV (
6RIWZDUHSUHUHTXLVLWHV±26 (
1HWZRUNFRQILJXUDWLRQV±26 (
&RQILJXUDWLRQVWHSV±26 (
&RQILJXUHWKHSULQWHUIRU7&3,3LQ26 (
3URYLGH7&3,3URXWLQJLQIRUPDWLRQLIQHFHVVDU\ (
'HILQHWKHSULQWHUWR36) (
'HILQHD36)SULQWTXHXHIRUWKHSULQWHURSWLRQDO (
7HVWWKHSULQWHUFRQQHFWLRQLQ26 (
&RUUHFWLQJIRUSULQWHUSHUIRUPDQFHLVVXHV±26 (
5HIHUHQFHV±26 (
*ORVVDU\ */266$5<
,QGH[ ,1'(;

XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE ix
Introduction
This Xerox Printing Systems Installation Planning Guide helps you
prepare for delivery and installation of your new Xerox DocuPrint
printing system.
About this guide
This guide is intended for the person responsible for coordinating the
installation of the DocuPrint printer at your site. It lists the tasks you
must complete before installation can begin, as well as your
responsibilities during the installation.
Before using this guide, become familiar with its contents and
conventions.
Contents
This guide contains the following:
•Chapter 1, "Product overview," provides an overview of the
DocuPrint 4050 and 4090 printing systems.
•Chapter 2, "Controller components and options," describes
system controller hardware, software, and options.
•Chapter 3, "Printer components and options," describes printer
components, configurations, and options.
•Chapter 4, "Preparing for installation," provides a checklist of
tasks that must be accomplished before the installation. It also
explains connectivity requirements for transporting documents
from the host or client to the DocuPrint printing system.
•Chapter 5, "Controller specifications and requirements,"
describes power, environmental, and space requirements for
the system controller.
•Chapter 6, "Printer specifications and requirements," describes
power, environmental, and space requirements for the printer.
Space planning guidelines and diagrams are provided to help
you set up the work area.
•Chapter 7, "System connections," provides cable requirements
for your DocuPrint 4050 and 4090 printing systems..
•Chapter 8, "Installation," describes the activities that occur
during installation. It also describes ongoing maintenance
activities.
•Appendix A, "Supplies," describes how to select, store, and use
supplies for the DocuPrint printing system. It also provides a list
of consumable supplies you can order.

INTRODUCTION
x XEROX DOCUPRINT 4050/4090 IPS INSTALLATION PLANNING GUIDE
•Appendix B, "Xerox support services," explains how to utilize
available Xerox support services.
•Appendix C, "Related publications," lists other Xerox
documents that are part of this publication set.
•Appendix D, "Defining the channel-attached printer to the host,"
provides explanations and sample printer parameters for
defining your channel-attached printer to your host.
•Appendix E, "Defining the printer to the host: TCP/IP
attachment," provides instructions, prerequisites, and sample
printer parameters for defining your TCP/IP-attached printer to
your host.
A glossary and index are provided at the back of the guide.
Conventions
This document uses the following conventions:
Italics—Document and library names are shown in italics (for
example, the Xerox DocuPrint IPS Series Messages Guide).
Note: Notes are hints that help you perform a task or understand
the text.
Caution: Cautions alert you to an action that could damage
hardware or software.
!Warning: Warnings alert you to conditions that may affect the
safety of people.
Notice
This publication may contain descriptions of concepts and features
not currently available for your Xerox printing system. Consult your
Xerox sales representative or your operating system software
program description for additional information.
