Yamaha TW200 User manual

PRINTED IN JAPAN
2002·5–0.1×1(E) !5FY-28199-EX
OWNER’S MANUAL
TW200
PRINTED ON RECYCLED PAPER
YAMAHA MOTOR CO., LTD.

INTRODUCTION
1
2
4
5
6
7
8
9
EAU00000
Congratulations on your purchase of the Yamaha TW200. This model is the result of Yamaha’s
vast experience in the production of fine sporting, touring, and pacesetting racing machines. It
represents the high degree of craftsmanship and reliability that have made Yamaha a leader in
these fields.
This manual will give you an understanding of the operation, inspection, and basic mainte-
nance of this motorcycle. If you have any questions about the operation or maintenance of
your motorcycle, please consult a Yamaha dealer.
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 1

IMPORTANT MANUAL INFORMATION
1
2
3
4
5
6
7
8
9
EAU00005
Particularly important information is distinguished in this manual by the following notations:
The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY
IS INVOLVED!
Failure to follow WARNING instructions could result in severe injury or death to the
motorcycle operator, a bystander or a person inspecting or repairing the motorcycle.
A CAUTION indicates special precautions that must be taken to avoid damage to
the motorcycle.
A NOTE provides key information to make procedures easier or clearer.
Q
w
cC
NOTE:
NOTE:
8This manual should be considered a permanent part of this motorcycle and should
remain with it even if the motorcycle is subsequently sold.
8Yamaha continually seeks advancements in product design and quality. Therefore,
while this manual contains the most current product information available at the time
of printing, there may be minor discrepancies between your motorcycle and this manu-
al. If there is any question concerning this manual, please consult your Yamaha dealer.
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 2

IMPORTANT MANUAL INFORMATION
1
2
4
5
6
7
8
9
EW000002
w
PLEASE READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE OPERATING THIS
MOTORCYCLE.
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 3

1
2
3
4
5
6
7
8
9
TW200
OWNER’S MANUAL
©1997 by Yamaha Motor Co., Ltd.
1st Edition, November 1997
All rights reserved. Any reprinting or
unauthorized use without the written
permission of Yamaha Motor Co., Ltd.
is expressly prohibited.
Printed in Japan
EAU00008
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 4

EAU00009 TABLE OF CONTENTS
1
2
3
4
5
6
7
8
9
GIVE SAFETY THE RIGHT OF WAY ..................1-1
DESCRIPTION .....................................................2-1
Left view............................................................2-1
Right view.........................................................2-2
Controls/Instruments .......................................2-3
INSTRUMENT AND CONTROL
FUNCTIONS........................................................3-1
Main switch/Steering lock ...............................3-1
Indicator lights..................................................3-2
Speedometer....................................................3-2
Handlebar switches..........................................3-3
Clutch lever.......................................................3-4
Shift pedal.........................................................3-4
Front brake lever ..............................................3-5
Rear brake pedal ..............................................3-5
Fuel tank cap.....................................................3-5
Fuel....................................................................3-6
Fuel cock ...........................................................3-7
Starter (choke) “1”.........................................3-8
Kick starter........................................................3-8
Seat ...................................................................3-9
Helmet holder...................................................3-9
Rear shock absorber ......................................3-10
Rear carrier .....................................................3-10
Sidestand........................................................3-10
Sidestand/clutch switch operation check.....3-11
PRE-OPERATION CHECKS.................................4-1
Pre-operation check list ...................................4-1
OPERATION AND IMPORTANT RIDING
POINTS................................................................5-1
Starting and warming up a cold engine.........5-1
Starting a warm engine...................................5-4
Shifting..............................................................5-4
Engine break-in ................................................5-5
Parking ..............................................................5-6
PERIODIC MAINTENANCE AND MINOR
REPAIR ................................................................6-1
Tool kit ..............................................................6-1
Periodic maintenance and lubrication............6-3
Cowling and panel removal and
installation ........................................................6-6
Cowling A .........................................................6-6
Panel A..............................................................6-7
Panel B ..............................................................6-7
Spark plug inspection......................................6-7
Engine oil..........................................................6-8
Air filter ...........................................................6-12
1
2
3
4
5
6
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 5

Carburetor adjustment ..................................6-13
Idle speed adjustment ...................................6-13
Throttle cable free play inspection ...............6-14
Cam chain adjustment...................................6-14
Valve clearance adjustment ..........................6-14
Tires.................................................................6-15
Wheels ............................................................6-17
Clutch lever free play adjustment.................6-18
Front brake lever free play adjustment ........6-18
Rear brake pedal height and free play
adjustment......................................................6-19
Brake light switch adjustment.......................6-20
Checking the brake shoes..............................6-21
Drive chain slack check..................................6-21
Drive chain slack adjustment ........................6-22
Drive chain lubrication...................................6-23
Cable inspection and lubrication ..................6-24
Throttle cable and grip lubrication ...............6-24
Brake and shift pedal lubrication..................6-24
Brake and clutch lever lubrication ................6-25
Sidestand lubrication.....................................6-25
Rear suspension lubrication..........................6-25
Front fork inspection......................................6-26
Steering inspection........................................6-26
Wheel bearings ..............................................6-27
Battery.............................................................6-27
Fuse replacement...........................................6-29
Headlight bulb replacement..........................6-30
Supporting the motorcycle ...........................6-31
Front wheel removal......................................6-31
Front wheel installation.................................6-32
Rear wheel removal.......................................6-33
Rear wheel installation ..................................6-33
Troubleshooting.............................................6-34
Troubleshooting chart ...................................6-35
CLEANING AND STORAGE ...............................7-1
Cleaning............................................................7-1
Storage..............................................................7-2
SPECIFICATIONS................................................8-1
How to use the conversion table ....................8-4
CONSUMER INFORMATION .............................9-1
Identification numbers record.........................9-1
Key identification number ...............................9-1
Vehicle identification number .........................9-1
Model label.......................................................9-2
TABLE OF CONTENTS
1
2
3
4
5
6
7
8
9
7
8
9
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 6

1-1
EAU00021 QGIVE SAFETY THE RIGHT OF WAY
1
2
3
4
5
6
7
8
9
Motorcycles are fascinating vehicles, which can give you an unsurpassed feeling of power and
freedom. However, they also impose certain limits, which you must accept; even the best
motorcycle does not ignore the laws of physics.
Regular care and maintenance are essential for preserving your motorcycle’s value and operat-
ing condition. Moreover, what is true for the motorcycle is also true for the rider: good perfor-
mance depends on being in good shape. Riding under the influence of medication, drugs and
alcohol is, of course, out of the question. Motorcycle riders more than car drivers must always
be at their mental and physical best. Under the influence of even small amounts of alcohol,
there is a tendency to take dangerous risks.
Protective clothing is as essential for the motorcycle rider as seat belts are for car drivers and
passengers. Always wear a complete motorcycle suit (whether made of leather or tear-resistant
synthetic materials with protectors), sturdy boots, motorcycle gloves and a properly fitting hel-
met. Optimum protective wear, however, should not encourage carelessness. Though full-cov-
erage helmets and suits, in particular, create an illusion of total safety and protection, motorcy-
clists will always be vulnerable. Riders who lack critical self-control run the risk of going too
fast and are apt to take chances. This is even more dangerous in wet weather. The good motor-
cyclist rides safely, predictably and defensively avoiding all dangers, including those caused by
others.
Enjoy your ride!
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 7

EAU00026
DESCRIPTION
1
2
3
4
5
6
7
8
9
2-1
1. Headlight (page 6-30)
2. Fuel cock (page 3-7)
3. Starter(choke) “1“ (page 3-8)
4. Air filter (page 6-12)
5. Battery (page 6-27)
6. Helmet holder (page 3-9)
7. Rear carrier (page 3-10)
8. Shift pedal (page 3-4)
1234 56 7
8
Left view
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 8

DESCRIPTION
1
2
3
4
5
6
7
8
9
2-2
9. Fuse (page 3-6)
10. Kick starter (page 3-8)
11. Rear brake pedal (page 3-5)
12. Tool kit (page 6-1)
910
11
12
Right view
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 9

1
2
3
4
5
6
7
8
9
DESCRIPTION
2-3
13. Clutch lever (page 3-4, 6-18)
14. Left handlebar switches (page 3-3)
15. Speedometer (page 3-2)
16. Right handlebar switches (page 3-3)
17. Front brake lever (page 3-5, 6-18)
18. Throttle grip (page 6-14, 6-24)
19. Fuel tank cap (page 3-5)
20. Main switch (page 3-1)
13 14 15 16 17
18
19
20
Controls/Instruments
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 10

3-1
LOCK
OFF ON
EAU00029
Main switch/Steering lock
The main switch controls the igni-
tion and lighting systems. Its oper-
ation is described below.
EAU00032
ON:
All electrical circuits are switched
on, and the headlight, meter light,
taillight and front position lights
come on. The engine can be start-
ed. The key cannot be removed in
this position.
EAU00038
OFF:
All electrical circuits are switched
off. The key can be removed in this
position.
EAU00042
LOCK:
The steering is locked in this posi-
tion and all electrical circuits are
switched off.
The key can be removed in this
position.
To lock the steering, turn the han-
dlebars all the way to the left. With
the key at “OFF”, push it into the
main switch and release it, turn it
counterclockwise to “LOCK”and
remove it.
To release the lock, turn the key to
“OFF”.
EW000016
w
Never turn the key to “OFF” or
“LOCK” when the motorcycle is
moving. The electrical circuits will
be switched off which may result
in loss of control or an accident. Be
sure the motorcycle is stopped
before turning the key to “OFF” or
“LOCK”.
EAU00027 INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 11

3-2
123
EAU00056
Indicator lights
EAU00059
Turn indicator light “TURN”
This indicator flashes when the
turn switch is moved to the left or
right.
EAU00062
Neutral indicator light “NEUTRAL”
This indicator comes on when the
transmission is in neutral.
1. Turn indicator light “TURN”
2. High beam indicator light
“HIGH BEAM”
3. Neutral indicator light “NEUTRAL”
EAU00064
High beam indicator light “HIGH
BEAM”
This indicator comes on when the
headlight high beam is used.
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
1
2
EAU00098
Speedometer
The speedometer shows riding
speed.
This speedometer is equipped with
an odometer.
1. Speedometer
2. Odometer
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 12

3-3
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
1
23
EAU00118
Handlebar switches
EAU00122
Dimmer switch “LIGHTS”
Turn the switch to “HI”for the high
beam and to “LO”for the low
beam.
EAU00128
Turn signal switch “TURN”
This is a three-position switch. The
center position is off.
Turn to “L”to turn on the left
flasher, and to “R”for the right
flasher. Be sure to turn the switch
off after completing a turn.
1. Dimmer switch “LIGHTS”
2. Turn signal switch “TURN”
3. Horn switch “HORN”
EAU00130
Horn switch “HORN”
Press the switch to sound the horn.
1
2
EAU00137
Engine stop switch “ENGINE
STOP”
The engine stop switch is a safety
device for use in an emergency
such as when the motorcycle over-
turns or if trouble occurs in the
throttle system. Turn the switch to
“RUN”to start the engine. In case
of emergency, turn the switch to
“OFF”to stop the engine.
1. Engine stop switch “ENGINE STOP”
2. Start switch “START”
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 13

3-4
EAU00141
Start switch “START”
The starter motor cranks the
engine when pushing the start
switch.
EC000005
cC
See starting instructions prior to
starting the engine.
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
EAU00152
Clutch lever
The clutch lever is located on the
left handlebar, and the ignition cir-
cuit cut-off system is incorporated
in the clutch lever holder. Pull the
clutch lever to the handlebar to dis-
engage the clutch, and release the
lever to engage the clutch. The
lever should be pulled rapidly and
released slowly for smooth clutch
operation. (Refer to the engine
starting procedures for a descrip-
tion of the ignition circuit cut-off
system.)
1
N
5
4
3
2
1
EAU00157
Shift pedal
This motorcycle is equipped with a
constant-mesh 5-speed transmis-
sion.
The shift pedal is located on the
left side of the engine and is used
in combination with the clutch
when shifting.
N. Neutral
1. Shift pedal
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 14

3-5
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
1
2
EAU00158
Front brake lever
The front brake lever is located on
the right handlebar. Pull it toward
the handlebar to apply the front
brake.
1. Unlock
2. Open
EAU00162
Rear brake pedal
The rear brake pedal is on the right
side of the motorcycle. Press down
on the brake pedal to apply the
rear brake.
EAU00177
Fuel tank cap
TO OPEN:
Insert the key and turn it 1/4 turn
counterclockwise. Turn the cap 1/3
turn counterclockwise and remove
it from the tank.
TO CLOSE:
Put the cap in the filler neck and
turn it 1/3 turn clockwise. Lock the
cap by turning the key 1/4 turn
clockwise, and remove the key.
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 15

1
2
EAU01183
Fuel
Make sure there is sufficient fuel in
the tank. Fill the fuel tank to the
bottom of the filler tube as shown
in the illustration.
EW000130
w
Do not overfill the fuel tank. Avoid
spilling fuel on the hot engine. Do
not fill the fuel tank above the bot-
tom of the filler tube or it may
overflow when the fuel heats up
later and expands.
EAU00185
cC
Always wipe off spilled fuel imme-
diately with a dry and clean soft
cloth. Fuel may deteriorate painted
surfaces or plastic parts.
1. Filler tube
2. Fuel level
NOTE:
The tank cap cannot be reinstalled
unless it is unlocked. The key must
remain in the cap until the cap is
properly installed and locked onto
the fuel tank.
EW000023
w
Be sure the cap is properly
installed and locked in place
before riding the motorcycle.
3-6
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 16

3-7
EAU00187
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
Recommended fuel:
Regular gasoline
Fuel tank capacity:
Total:
7.0 L
Reserve:
1.0 L
ON FUEL
RES
OFF
1
ON
1. Arrow mark
EAU01121
Fuel cock
The fuel cock supplies fuel from
the tank to the carburetor while fil-
tering it also.
The fuel cock has three positions,
which should be set as shown in
the illustrations.
OFF: With the fuel cock in this
position, fuel will not flow.
Always set the fuel cock to
this position when the engine
is not running.
ON: With the fuel cock in this
position, fuel flows to the car-
buretor. Set the fuel cock to
this position when starting
the engine and while riding.
RES
ON FUEL
OFF
1
1. Arrow mark
OFF ON
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 17

3-8
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
a
b
1
EAU00210
Starter(choke) “1”
Starting a cold engine requires a
richer air-fuel mixture. A separate
starter circuit supplies this mixture.
Move in direction ato turn on the
starter(choke).
Move in direction bto turn off the
starter(choke).
1. Starter (choke) “1”
RES: This indicates reserve. If you
run out of fuel while riding,
set the fuel cock to this posi-
tion.
Fill the tank at the first oppor-
tunity. Be sure to set the fuel
cock back to “ON”after refu-
eling!
OFF
ON FUEL
RES
1
RES
1. Arrow mark
RES
EAU00212
Kick starter
Rotate the kick starter away from
the engine. Push the starter down
lightly with your foot until the
gears engage, then kick smoothly
and forcefully to start the engine.
This model has a primary-coupled
kick starter so the engine can be
started in any gear if the clutch is
disengaged. However, shifting to
neutral before starting is recom-
mended.
1
1. Kick starter
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 18

3-9
INSTRUMENT AND CONTROL FUNCTIONS
1
2
3
4
5
6
7
8
9
EAU01092
Seat
To remove the seat, remove the
bolts.
1
1. Bolt (×2)
To install the seat, insert the pro-
jection on the front of the seat into
the holder and push down on the
seat, then tighten the bolts.
NOTE:
Make sure that the seat is securely
fitted.
1
2
EAU00260
Helmet holder
To open the helmet holder, insert
the key in the lock and turn it as
shown. To lock the helmet holder,
replace the holder in its original
position.
EW000030
w
Never ride with a helmet in the
helmet holder. The helmet may hit
objects, causing loss of control
and possibly an accident.
1. Open
2. Helmet holder
5FY-28199-EX (TW200) 4/16/02 5:38 PM Page 19