A.O. Smith CAWH 8-455-6 Troubleshooting guide

0336078 / R1.0
Enevator Store
Heat pump water heater
Voorraadhoudende warmtepomp
Pompe à chaleur de stockage
Pufferspeicher-Wärmepump
CAWH 8-455-6/9/12
Installation, User and Service Manual
Installatie-, Gebruikers- en Servicehandleiding
Manuel d'installation, d'utilisation et d'entretien
Installations-, Bedienungs- und
Wartungsanleitung
0923 / EN-NL-FR-DE

T : [phone]
[email protected]
www.aosmithinternational.com
A.O. Smith Europe
De Run 5305
PO Box 70
5500 AB Veldhoven
The Netherlands
Data is subject to change / Gegevens onderhevig aan verandering / Données sujettes à révision / Änderungen vorbehalten

English
Preface........................................................................................3
About this manual....................................................................... 7
User part............................................................13
1 Introduction.............................................................................. 15
2 Safety........................................................................................17
3 Interface................................................................................... 19
4 Use............................................................................................25
Installation, Maintenance and Service part........29
5 Introduction.............................................................................. 31
6 Safety........................................................................................33
7 Water heater............................................................................. 39
8 Installation............................................................................... 41
9 Settings.....................................................................................49
10 Maintenance..............................................................................61
11 Troubleshooting........................................................................ 65
12 Warranty................................................................................... 69
Index........................................................................................ 71
Nederlands
Voorwoord................................................................................ 73
Informatie over deze handleiding..............................................77
Gedeelte voor de gebruiker................................83
1 Inleiding....................................................................................85
2 Veiligheid.................................................................................. 87
3 Bedieningspaneel...................................................................... 89
4 Gebruik..................................................................................... 95
Gedeelte over de installatie en het onderhoud...99
5 Inleiding..................................................................................101
6 Veiligheid................................................................................ 103
7 Boiler...................................................................................... 111
8 Installatie................................................................................113
9 Instellingen.............................................................................121
10 Onderhoud.............................................................................. 133
11 Storingen................................................................................ 137
12 Garantie.................................................................................. 141
Index...................................................................................... 143
Français
Préface.................................................................................... 145
À propos de ce manuel............................................................ 149
Partie Utilisateur..............................................155
0336078_CAWH_ENNLFRDE_V1.0, 28-02-2023 1

1 Introduction............................................................................ 157
2 Sécurité...................................................................................159
3 Interface................................................................................. 161
4 Utilisation................................................................................167
Partie Installation et entretien........................ 171
5 Introduction............................................................................ 173
6 Sécurité...................................................................................175
7 Chauffe-eau.............................................................................181
8 Installation..............................................................................183
9 Paramètres..............................................................................193
10 Entretien................................................................................. 205
11 Pannes.................................................................................... 209
12 Garantie.................................................................................. 213
Index...................................................................................... 215
Deutsch
Vorwort................................................................................... 217
Zu diesem Handbuch............................................................... 221
Abschnitt für den Benutzer.............................. 227
1 Einleitung................................................................................ 229
2 Sicherheit................................................................................231
3 Bedienoberfläche.................................................................... 233
4 Verwendung............................................................................ 239
Abschnitt für die Installation, Wartung und
Instandhaltung................................................ 243
5 Einleitung................................................................................ 245
6 Sicherheit................................................................................247
7 Warmwasserheizer..................................................................253
8 Installation..............................................................................255
9 Einstellungen.......................................................................... 263
10 Wartung.................................................................................. 275
11 Störungen............................................................................... 279
12 Gewährleistung....................................................................... 283
Index...................................................................................... 285
Appendices/Bijlagen/Annexes/Anhänge
A Appendices/Bijlagen/Annexes/Anhänge..................................... i
2

Preface
Copyright
Copyright © 2023 A.O. Smith Water Products Company
All rights reserved.
Nothing from this publication may be copied, reproduced and/or published by means of
printing, photocopying or by whatsoever means, without the prior written approval of A.O.
Smith Water Products Company.
A.O. Smith Water Products Company reserves the right to modify specifications in this
manual.
Trademarks
Brand names in this manual are registered trademarks of their respective owners.
Warranty
Refer to the appendix Warranty (see 12) for the warranty provisions.
Liability
User
A.O. Smith accepts no liability when the water heater is not used correctly and requires
the user to:
•Read this manual carefully and obey the instructions.
•Ask your installation engineer for advise about the use of the water heater.
•Make sure that the service and maintenance activities are done by a qualified
engineer.
•Store the manual, in good condition, near the water heater.
Installation engineer
A.O. Smith accepts no liability when the water heater is not used correctly and requires
the installation engineer to:
•Read this manual carefully and obey the instructions.
•Make sure that the entire water heater installation complies with the applicable
regulations (on page 5).
•Make sure that the water heater is tested before the installation is taken into use.
•Explain the correct use to the user.
•Notify the user when service and maintenance activities are necessary.
•Make sure that you hand over all applicable manuals.
0336078_CAWH_ENNLFRDE_V1.0, 28-02-2023 3
EN

Supplier
The CAWH water heater is designed in accordance with the applicable regulations. The
water heater is delivered with compliancy–marking and all necessary documentation to
obey these regulations. See the compliance section.
A.O. Smith accepts no liability for claims from third parties when:
•The instructions for the correct installation of the water heater are not obeyed.
•The instructions for the correct use of the water heater are not obeyed.
•The water heater did not have maintenance on the correct maintenance interval.
For more information, refer to the General Terms of Sales. These are available on request,
free of charge.
We believe that this manual provides you with accurate and complete descriptions of all
relevant components. If you, nonetheless find errors or inaccuracies in this manual, please
inform A.O. Smith. This helps us to further improve our documentation.
4 Preface
EN

Compliance
To safely produce domestic hot water, the design and construction of the CAWH water
heaters is in accordance with:
•CE
- the European Directive 2014/35/EU on low voltage appliances (LVD)
- the European Directive 2014/30/EU on Electromagnetic Compatibility (EMC)
- the European Directives 2011/65/EU and 2015/863/EU on RoHS II and RoHS
III
- the European Directive 2009/125/EC on Ecological Design (ErP)
•UKCA
- the Electrical Equipment (Safety) Regulations 2016 (UK SI 2016 No. 1101)
- the Electromagnetic Compatibility Regulations 2016 (UK SI 2016 No. 1091)
- the RoHS regulations 2012 (UK SI 2012 No. 3032)
- the Ecodesign for Energy-Releated Products Regulation 2010 (UK SI 2010 No.
2617)
Refer to the appendix Declaration of conformity.
Regulations
The installation of the equipment MUST be in accordance with the relevant requirements of
the Building Regulations, I.E.E. Regulations and the bylaws of the local water board.
In addition, the installation should follow the relevant guidance offered in the following
documents. It is not practical to list all relevant information due to continuous changes but
emphasis is placed on the following documents, as failure to comply with the guidance
given will almost certainly result in an unsatisfactory installation:
•British Standards (BS), especially:
- BS 6700: 1997 - Design, installation, testing and maintenance of services
supplying water for domestic use with buildings and their curtilages
- BS 67074: 1989 Part 1 and 2 - Application, selection and installation of
expansion vessels and ancillary equipment for sealed systems
- BS 7671: 2008 - Requirements for electrical installations, I.E.E. wiring
regulations seventeenth edition
- CP 342: Part 2 1974 - Code of practice for centralized hot water supply-
buildings other than dwellings
•CIBSE Guides
•Clean Air Act
•H.S.E Guidance
Note
Manufacturer's notes must not be taken in any way as overriding statutory obligations.
Contact information
If you have any comments or questions, please contact:
A.O. Smith Water Products Company
Adress: PO Box 70
5500 AB Veldhoven
The Netherlands
Telephone: [phone]
E-mail: [email protected]
Website: www.aosmithinternational.com
In the event of problems with your electricity or water supply connections, please contact
your (energy/water) supplier.
n
0336078_CAWH_ENNLFRDE_V1.0, 28-02-2023 5
EN

6 Preface
EN

About this manual
Scope
This manual gives information about safe and correct use of the water heater and how
installation, maintenance and service activities have to be done correctly. You must obey
the instructions in this manual.
Caution
Read this manual carefully before you start the water heater. It can cause personal injury
and damage to the water heater when you do not read the manual and/or do not obey
the instructions.
The purpose of this manual is to:
•describe the working principles and layout of the water heater
•explain the safety devices
•highlight possible hazards
•describe the use of the water heater
•describe the installation, service and maintenance of the water heater
This manual has two parts:
•An User part that describes the correct usage of the water heater.
•An Installation, Maintenance and Service part, that describes the correct installation
and maintenance procedures.
Target group
The information in this manual applies to three target groups:
•users
•installation engineers
•service and maintenance engineers
The User part is intended for the (end) users. The Installation, Maintenance and Service
part is intended for the installation engineers and the service and maintenance engineers.
Notation conventions
This manual uses the following text conventions:
•Numbers between parentheses e.g. (1), refer to elements in a figure that are
described by the text.
•Cross-references to sections, tables, figures etc. are underlined and written as (see
"..."). In the digital version, the cross-references function as hyperlinks that can be
used to navigate through the manual by clicking on them. Example: Safety (see 2).
This manual contains the following text styles/symbols for situations that may endanger
users/engineers, cause damage to equipment or need special attention:
Note
A note gives more information on a topic.
c
n
0336078_CAWH_ENNLFRDE_V1.0, 28-02-2023 7
EN

Caution
Obey the caution instructions to prevent damage of the water heater.
Warning
Obey the warning instructions to prevent danger of personal injury, and serious damage
to the water heater.
Document identification
Article number Language Version
0336078 EN 1.0
c
w
8 About this manual
EN