Aidcall Astra 6000 User manual

DocNo.FM5610issueBPage1

Touchsafe®Pro

WirelessNursecallSystem

_________________________________________________________________________________________________



Astra6000PagerTransmitter

InstallationGuide



Aidcalloperatesapolicyofcontinualproductimprovementand

reservestherighttomodifythespecificationofitsproducts.



Ifanyvariationtothedetailsinthisdocumentaresuspectedplease

contactAidcall’sTechnicalSupport.



 



Aidcall,abusinessunitofLegrandElectricLtd

CowleyRoad,BlythRiversideBusinessPark,Blyth,Northumberland,NE245TF.

T:+44(0)1670357431www.aidcall.co.uk

________________________________________________________________

DocNo.FM5610issueBPage2



CONTENTS



SectionTopicPage

  

1ProductOverview2

2ImportantSafetyInstructions3

3RegulatoryInformation 4

4Maintenance&Care4

5TransmitterKitFeatures5

6Installation6

7PanelSetup 9

8ReplacingthePSUBattery11

9Specification12



CONTENTS

1. PRODUCTOVERVIEW



TheAstra6000PagerTransmitterkit(AidcallP/No.E40104)includesthetransmitterandantennacomplete

witha12VDCbatterybackedpowersupplyunit.Pagersareboughtseparately,there’snolimithowmany

canbeusedpersystem.



Note:theJ25wasreplacedbytheScopemodelinJuly2016–botharecompatiblewithAstraPagers.



TheTransmitterrequiresconnectiontothePSUandthePagerPortonaTouchsafeProNursecallPanel.

StaffwillthenbealertedtoacallnomatterwheretheyareviatheirportablePagers.



ThesystemcanbesetupsoallcallsarereportedtoallPagersatalltimes,orday/nightgroupscanbesetso

differentPagerscanbealerteddependingonthetimeofday.Thetypesofcallthatarereportedtothe

Pagerscanbesetalongwiththebeeppatterntoidentifydifferentcalltypes.FurthermorePagerscanbe

configuredintozonessocallsareonlynotifiedtothestaffresponsibleforspecificareas.



RefertotheJ25PagerUserGuide(AidcallDocNo.FM5615)orScopePagerUserGuide(Aidcall

DocNo.FM5620)fordetailsonsetupandhowthePagersoperate.

J25Pager

(AidcallPartNo.W07280)

ScopePager

(AidcallPartNo.W07600)

DocNo.FM5610issueBPage3



2. IMPORTANTSAFETYINSTRUCTIONS



Readandunderstandtheseinstructionsbeforeuse.Keeptheseinstructionsforfuturereference.

Takecarewhenworkingonstepladdersduringinstallationorservice.



IsolatethemainssupplybeforeremovingthePSUcover.

Donotdisassemblethetransmitter/PSUorattempttorepairityourself.

Nouserserviceablepartsinside.Referallservicingtoqualifiedservicepersonnel.



ThePSUshouldonlybeconnectedtoa220‐240VAC50/60Hzmainssupply.Ifyouareunsureofthetype

ofpowersupplyconsultyourlocalpowercompany.



DangerofexplosionifthePSUrechargeablebatteryisincorrectlyreplaced.Useonlymanufacturer

approvedbatteryasidentifiedinsection8ofthismanual.



Onlyusemanufacturerapprovedcableduringinstallation.Seesection6ofthismanualfordetailsof

cabletype,recommendedcolourcodeandcablelengthrestrictions.



Thisproductshouldbelocatedatleast2metresawayfromanyotherelectronicequipment.

Failuretoprovidethisseparationmayresultinreducedradiorange.



Donotlocatethisproductabovearadiatororotherheatsource.



Donotexposetodirectsunlight.



Donotsubmergeinwateranddonotuseindamporhumidconditions.



Donotexposethisproducttodrippingorsplashingwater.

Liquidscancauseafailureand/orafirehazard.



Cleanwithadampclothandanon‐abrasivecleaningproduct.Polishwithadryduster.DONOTusea

wetcloth.



Avoidusingharsh,abrasiveorcorrosivecleaningagentsordetergents(e.g.scouringpowders,bleaches,

polishes,etc.)whencleaningthisproduct.



Attheendofitslifethisproductshouldbedisposedofandrecycledinaccordancewiththe

environmentalregulations.SeetheRegulatoryInformationinsection3below.



DocNo.FM5610issueBPage4



3. REGULATORYINFORMATION



ThissymbolontheproductindicatesitcomplieswithallrelevantEUDirectivesasrequiredbylaw.

DTIApproval;MPT1305

LowVoltage;2006/95/EC

ElectroMagneticCompatibility;EMC2004/96/EC

RestrictionofHazardousSubstances;RoHS2011/65/EU



ThissymbolontheproductindicatesitisclassedasElectricalorElectronicEquipmentandshouldnotbe

disposedofwithothercommercialwasteattheendofitsworkinglife.



TheWasteofElectricalandElectronicEquipment(WEEE)Directive(2012/19/EU)hasbeenputinplace

torecycleproductsusingthebestavailablerecoveryandrecyclingtechniquestominimiseimpactonthe

environment,treathazardoussubstancesandavoidincreasinglandfill.



Forproductdisposalpleasecontactyoursupplierandcheckthetermsandconditionsofthepurchase

contractandensurethisproductisnotmixedwithothercommercialwastefordisposal.



Thissymbolonbatteriesindicatesseparatecollection.Batteriescontainchemicalsthatcanbe

hazardoustohealthandtheenvironmentandshouldnotbedisposedofinthewastebin.



TheEUDirective(2006/6/EC)hasbeenputinplacetoensurethesafedisposalandrecyclingof

batteries.



Returnusedbatteriestoyoursupplierordrop‐offatyourlocalmunicipalwasterecyclingdepot.



NTENTS

4. MAINTENANCE&CARE



ForpeaceofmindandtoensureyoursystemismaintainedtothehigheststandardAidcallrecommendan

annualmaintenancecontract.Thiswillprovidevitalassistanceintimesofneedfromanationwideteamof

trainedServiceEngineerswhospecialiseinwirelessNursecallsystems.



Apreventativemaintenancevisit(PMV)isalsoavailablefromAidcall,thiscoversthereplacementofall

batteries,afullsystemtest,softwareupdates(whereapplicable)andaServiceCertificate.



FormoreinformationonMaintenanceContractPackagesandPMV’spleasecontactourcustomerservices

teamon01670357431orvisitourwebsite;www.aidcall.co.uk/healthcare/support/maintenance



MONTHLYMAINTENANCE



AstraPagerTransmittersdonotrequireanyregularmaintenance,ifaunitshowssignsofexternaldamage

itshouldbereplacedimmediatelybyaServiceEngineer.Productsneedingrepaircanbereturnedviathe

website;www.aidcall.co.uk/healthcare/support/repair



ANNUALMAINTENANCE



TherechargeablebatteryinthePSUshouldbetestedeveryyearbyaServiceEngineerandreplacedevery5

years.Seesection8fordetailsofbatterytype.



DocNo.FM5610issueBPage5



5. TRANSMITTERKITFEATURES



TheAstra6000Transmitterkit(AidcallPartNo.E40104)includesthetransmitter&antenna,a12V/1A

boxedpowersupply,a2metremainsleadanda12V/1.2Ahrechargeablebattery.



TRANSMITTERLED’s



TheREDPOWERLEDshouldbepermanentlyilluminatedwhenthe12VPSUisconnected.

TheGREENTRANSMITTINGLEDwillonlyilluminatewhenasignalistransmittedtothePagers.



POWERSUPPLYLED’s



TheGREENPOWERLEDshouldbepermanentlyilluminatedwhentheMainssupplyishealthy.

TheREDFAULTLEDwillilluminateifthe12Voutputorbatteryfusehasblown.



HelicalAntenna

(165mmhigh)

Red PowerLED

WallMountedEnclosure

210x144x39mm(HxWxD)Green TransmittingLED

BNCConnector

RemovableLid(4ScrewFixings)

CableEntry

WallMountedEnclosure

200x230x80mm(HxWxD)

12V1.2AhRechargeableBattery

2mMainsLead&13AUKPlug

GreenPowerLED

Red FaultLED

Transmitter&Antenna

12V/1APowerSupply

HingedLid(1ScrewFixing)

DocNo.FM5610issueBPage6



6. INSTALLATION



Thetransmittermustbesitedinadrysecurearea;itisNOTsuitableforoutdoorlocations.

Thetransmittermustbewithin20metrescablerunofaTouchsafeProDisplayPanel.

Note:Iftherearemultiplepanelsconnecttotheonewhichismostcentrallylocatedonthesite.

Thetransmittershouldbepositionedashighaspossiblewiththeantennaaminimumof300mmfromthe

ceilingandatleast2metresawayfromanyotherelectronicequipment.



IMPORTANT:AVOIDLOCATINGTHETRANSMITTER…



WITHIN2METRESOF

OTHERELECTRONIC

EQUIPMENT

DIRECTLYABOVEA

HEATER

INDIRECTSUNLIGHT NEARTOSPLASHING

WATER



RADIORANGE



Constructionmaterialssuchasfoilbackedplasterboard,reinforcedconcreteorstonewallswillreduce

range.Environmentalconditionssuchashighlevelsoftransmissionatnearbyfrequenciesoremissions

fromotherelectricalequipmentmayfurtherreducerange.Clearline‐of‐sightwillgiveamaximumradio

rangeof1kilometreradiusfromthetransmitter.



DocNo.FM5610issueBPage7



6.INSTALLATION



Thetransmitterrequiresapoweranddataconnection;poweristakenfromthe12V/1AbatterybackedPSU

anddatacomesfromthePagerPortonanyTouchsafeProDisplayPanel.



POWERSUPPLYUNIT



Undothesinglelidfixingscrewandopenthelid.

Note:ifthelidisremovedensuretheSafetyEarthisre‐connected.



PositionthePSUwithin2metresofanun‐switched13Amainssocket.

Fixthepowersupplyunittothewallusingthe3holes“A”asshownbelow.



Connectthemainsleadprovidedtothepowersupplyunitmainsterminals

usingthecolourcodeinthetablealongside.



Note:theplugisfittedwitha240VAC5ABS1362fuse.



ThePSUshouldonlybeopenedduringinstallationandservice–thelidmustbescrewed

shutatallothertimestopreventtheriskofelectricshock.NeverleavealivePSU

unattendedwiththelidopen.



TRANSMITTER



Undothe4screwsandremovethelidfromthetransmitter.

Seethepreviouspageforinformationonsitingthetransmitter.

Fixthetransmittertothewallusingthe4holes“A”asshownbelow.



MainsConnection

ColourTerminal

BrownL

BlueN

Green/YellowE

IMPORTANT

MountTransmitter

withAntennaVertical

120mm

122mm

Cable

Entry

AA

160mm

65mm

145mm

A

AA

PSU

(NOTTOSCALE)

12V/1A Boxed PSU

ASTRA

TRANSMITTER

E

L

O/P

+‐

DocNo.FM5610issueBPage8



6.INSTALLATION



SITEWIRING



CONNECTIONDETAILS



CABLESPEC&COLOURCODE



ThetransmittershouldbewiredusingLSF(LowSmokeandFume)screenedTCCA8corealarmcable.

Usethecolourcodesshownbelow…



CableColourPSUAstraPanel



PowerRedO/P++N/C

BlackO/P‐ ‐ N/C

DataYellowN/CRXDTX

Black N/C ‐0V



ThiscableisavailablefromAidcallbythemetre;PartNo.YW1730.

NTS

E40104

AstraTransmitterKit

IMPORTANT

LooptheCableonce

throughtheFerriteSleeve

rovidedwiththePanel

DisplayPanel

PagerConnections

Astra6000Pager

Transmitter

PSU

Output+/‐

Max20mcablelengthbetweenPanelandPager

DocNo.FM5610issueBPage9



7. PANELSETUP



GototheTouchsafeProMasterPanel(ID1),LogonasanEngineerandselectthePanelDetailsoption…



StillonTouchsafeProMasterPanel(ID1),selecttheCommonPagersoption…



Alternatively,PagerscanbesettooperatebyZone‐seenextpage…

S

NotesonPagerID’s



J25Pagerscanbeprogrammedwithupto6differentID’s

ScopePagerscanbeprogrammedwithupto8differentID’s

TheseID’sare7digitslongbutthefirst4digitsmustbe0012fortheAstraPager

Onlyenterthelast3digitsoftheID’sintheboxesabove

RefertotheJ25PagerUserGuide(AidcallDocNo.FM5615)formoreinformation

RefertotheScopePagerUserGuide(AidcallDocNo.FM5620)formoreinformation



Selectwhich PanelIDtheAstraPager

Transmitterisbeingconnectedtofrom

thePagingPanelpull‐downbox.

Note:thisonlyneedstobesetonthe

MasterPanel(ID1).



PresstheSavebuttonthenClosetoexit.



Enterthe3digitPagerID’sintheboxes

alongsideeachcalltypegroup(Cardiac,

Emergency,etc.)foronesyouwanttobe

notifiedduringtheDay,Night1andNight2

modes.



Thekeypadwillbedisplayedwhenyouclick

onaboxtoenterapagerID‐youmayneed

topressthe123#?buttontoselectthe

numerickeypad.



PresstheSavebuttonthenClosetoexit.

DocNo.FM5610issueBPage10



7.PANELSETUP



StillonTouchsafeProMasterPanel(ID1),selecttheZonedPagersoption…



GototheTouchsafeProPanelwiththeAstraPagerTransmitterconnected,LogonasanEngineerandselect

thePagingSetupoption…



BEEPCODETABLE



AstraBeepCodeJ25PagerBeepPattern Scope PagerBeepPattern



0,1,3,4,5,6,7,86doublebeeps8doublebeeps

28triplebeeps8triplebeeps

9high/lowbeeps+vibrate8fourbeeps



EntertheBeepCodetochoosethebeeppatternthePagerwillsoundforeachcalltype.



SettheProtocoloptiontoAstra/Bluebell.



SelecttheBeepCodesyouwantthePager

tosoundfromthepull‐downboxes

alongsideeachcalltype.

Note:only3differentbeeppatternsare

availablewiththeAstraoption‐seethe

BeepCodetablebelow.



SettheRe‐PagingDelayfromthe

pull‐downbox;ifanalarmcallisnot

acceptedwhenthisperiodexpiresthe

Pagerswillbenotifiedagain.



PresstheSavebuttonthenClosetoexit.

SelectaZonefromthepull‐downboxthen

enterthe3digitPagerID’syouwanttobe

notifiedduringtheDay,Night1andNight2

modesintheboxesalongsideeachcalltype

group(Cardiac,Emergency,etc.).

See“NotesonPagerID’s”onpage9.



Thekeypadwillbedisplayedwhenyouclick

onaboxtoenterapagerID‐youmayneed

topressthe123#?buttontoselectthe

numerickeypad.



PresstheSavebuttonthenClosetoexit.

This manual suits for next models

Table of contents

Other Aidcall Transmitter manuals

Aidcall

Aidcall Touchsafe Pro Door Monitor V3.00a User manual

Popular Transmitter manuals by other brands

Seneca

Seneca K120RTD installation manual

Nautel

Nautel GV40 installation manual

HumanTechnik

HumanTechnik cm-light operating instructions

INOR

INOR APAQ C130 TC User instructions

Linear

Linear DXS-64 operating instructions

FeinTech

FeinTech ABT00102 instruction manual

Geo

Geo Web Pack quick start guide

Inovonics

Inovonics EchoStream EN1210W installation instructions

IKONNIK

IKONNIK KA-6 quick start guide

Rohde & Schwarz

Rohde & Schwarz SR8000 Series System manual

Audio Technica

Audio Technica UniPak ATW-T93 Installation and operation

NIVELCO

NIVELCO EasyTREK SCA-300 Series Programming manual

Honeywell

Honeywell 5816WMBR installation instructions

Kamstrup

Kamstrup READy MTU Installation and operation guide

Omega

Omega ZW Series user guide

ABB

ABB Field 264H Instructions for installation

Dejero

Dejero EnGo 3x manual

Rosemount

Rosemount 4600 Reference manual