Airaid 861-341 User manual

INSTALLATION INSTRUCTIONS
#861-341 OEM Replacement Filter
’03-’07 Ford Superduty 6.0L Turbo Diesel
Thank you for purchasing the Airaid Premium Filter. Please read the instruction manual carefully before
proceeding with the installation. Contact Airaid @ [phone] 8:00 AM - 5:00 PM MST weekdays for
questions regarding fit or instructions that are not clear to you. Your Airaid Premium Filter was carefully inspected
and packaged. The air filter element is protected from direct exposure to water and debris; care should be taken not
to drive through deep water. WATER INGESTION IS THE DRIVERS RESPONSIBILITY!
Thank you for selecting Airaid.
1. Remove the factory filter housing from the intake assembly by separating the inlet and outlet
as shown above. Note: This step is performed in the vehicle. The vehicle is not shown in the
pictures for added clarity.
2. The air filter element is bonded to the housing on inlet side. Using a utility knife, carefully
separate the filter element from the air filter housing as shown above. The utility knife will
cut easily through the black glue that is used to bond the element to the housing. Use extra
care to avoid personal injury from the sharp tool.

4. Insert the Airaid Premium Filter into
the factory housing. The filter must be
fully inserted into the bottom of the
housing. Install the factory filter using
with the Airaid Premium Filter in the
reverse order. Double check your work
to insure that all connections are tight
there are no foreign objects in the
intake system.
3. Remove the element from the filter
housing and discard the element.
Remove all remaining glue from the
inside surface of the housing and clean
surface using a rag.
Synthamax Air Filters do not require oil. Service air filter as needed b
y
cleanin
g
with common non-petroleum all-purpose household cleaner and water. Simple
Green®, Formula 409® or equivalent works
g
reat. Appl
y
cleaner to outside of air
filter and allow to soak. Then flush filter clean from the inside out with a
g
arden
hose and repeat steps if necessary. Do not apply high pressure water or air to clean
filter. Allow filter to air dry and reinstall.
Airaid Filter Co. 2688 E Rose Garden Ln. Phoenix AZ 85050
(
800
)
498-6951 AiraidInfo
@
airaid.co
m
www.airaid.co
m