Alliance Laundry Systems CHD25G2-CA025L Owner's manual

Installation/Operation/Maintenance
Tumble Dryers
25 Pound (11 Kilogram) Capacity
30 Pound (13 Kilogram) Capacity
35 Pound (16 Kilogram) Capacity
Stacked 30 Pound (13/13 Kilogram) Capacity
Stacked 45 Pound (20/20 Kilogram) Capacity
55 Pound (24 Kilogram) Capacity
Starting Serial No. 0602004144
Refer to Page 9 for Model Identification
START
25C
HIGH
TEMP
MED
TEMP
LOW
TEMP
NO
HEAT
123
SELECT
TEMP
INSERT
COIN
PUSH
START
123
SELECT
TEMP
INSERT
COIN
PUSH
START
START
25C
HIGH
TEMP
MED
TEMP
LOW
TEMP
NO
HEAT
TMB1278C_SVG
Original Instructions
Keep These Instructions for Future Reference.
(If this machine changes ownership, this manual must accompany machine.)
www.alliancelaundry.com Part No. 70458301ENR10
September 2015

Installation must conform with local codes or, in the absence of local codes, with:
In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1/ NFPA 54 “National Fuel Gas
Code” and Standard ANSI/NFPA 70 “National Electric Code.”
In Canada, installation must comply with Standards CAN/CSA-B149.1 or Natural Gas and Propane Installation Code and CSA C22.1,
latest edition, Canadian Electric Code, Part I.
In Australia and New Zealand, installation must comply with the Gas Installations Standard AS/NZS 5601 Part 1: General Installa-
tions.
WARNING
FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion
or to prevent property damage, personal injury or death.
W033
WARNING
• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appli-
ance.
• WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Clear the room, building or area of all occupants.
• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the fire department.
• Installation and service must be performed by a qualified installer, service agency or the gas supplier.
W052
IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the user
smells gas. These instructions must be posted in a prominent location. Step-by-step instructions of the above
safety information must be posted in a prominent location near the tumble dryer for customer use.
IMPORTANT: The installer must fully test the tumble dryer after installation and demonstrate to the owner how to
operate the machine.
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
3 Part No. 70458301ENR10

WARNING
To reduce the risk of electric shock, fire, explosion, serious injury or death:
• Disconnect electric power to the tumble dryer before servicing.
• Close gas shut-off valve to gas tumble dryer before servicing.
• Close steam valve to steam tumble dryer before servicing.
• Never start the tumble dryer with any guards/panels removed.
• Whenever ground wires are removed during servicing, these ground wires must be reconnected to ensure
that the tumble dryer is properly grounded.
W002R1
WARNING
• Installation of unit must be performed by a qualified installer.
• Install tumble dryer according to manufacturer’s instructions and local codes.
• DO NOT install a tumble dryer with flexible plastic venting materials. If flexible metal (foil type) duct is instal-
led, it must be of a specific type identified by the appliance manufacturer as suitable for use with tumble
dryer. Refer to section on connecting exhaust system. Flexible venting materials are known to collapse, be
easily crushed, and trap lint. These conditions will obstruct tumble dryer airflow and increase the risk of
fire.
W752R1
The following information applies to the state of Massachusetts, USA.
• This appliance can only be installed by a Massachusetts licensed plumber or gas fitter.
• This appliance must be installed with a 36 inch [91 cm] long flexible gas connector.
• A “T-Handle” type gas shut-off valve must be installed in the gas supply line to this appliance.
• This appliance must not be installed in a bedroom or bathroom.
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
4 Part No. 70458301ENR10

Table of Contents
Introduction........................................................................................... 9
Model Identification........................................................................................9
Contact Information...................................................................................... 15
Safety Information................................................................................17
Explanation of Safety Messages..................................................................... 17
Important Safety Instructions......................................................................... 17
Specifications and Dimensions.............................................................. 19
Specifications and Dimensions.......................................................................19
Cabinet Dimensions – 025, 030, 035 and 055 Series.........................................23
Cabinet Dimensions – T30 and T45 Series...................................................... 24
Exhaust Outlet Locations – 025, 030, 035 and 055 Series................................. 25
Exhaust Outlet Locations – T30 and T45 Series............................................... 27
Gas Connection Locations – 025, 030, 035 and 055 Series................................28
Gas Connection Locations – T30 and T45 Series............................................. 29
Electrical Connection Locations – 025, 030, 035 and 055 Series........................30
Electrical Connection Locations – T30 and T45 Series..................................... 31
Steam Connection Locations – 025, 030 and 035 Series....................................32
Steam Connection Locations – T30 Series.......................................................33
Installation........................................................................................... 34
Pre-Installation Inspection............................................................................. 34
Location Requirements..................................................................................34
Position and Level the Tumble Dryer..............................................................35
Fifth Leveling Leg........................................................................................ 36
Fire Suppression System (Optional Equipment)............................................... 36
Check Local Codes and Permits..................................................................36
Water Requirements.................................................................................. 36
Water Connections.................................................................................... 37
Electrical Requirements............................................................................. 38
Auxiliary Alarm........................................................................................ 38
To Reverse the Loading Door (025, 030, 035 and 055 Series)........................... 38
Before Placing Tumble Dryer into Service...................................................... 40
Required for CE Models Only.................................................................... 42
Installing CE Gas Drying Tumble Dryer......................................................... 42
General Information.................................................................................. 42
CE Orifices...............................................................................................43
Properties of CE Gases.............................................................................. 47
Changing Gas Configuration...................................................................... 47
Specific Conversion Procedures..................................................................48
© Copyright 2015, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed
written consent of the publisher.
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
5 Part No. 70458301ENR10

Exhaust Requirements..........................................................................51
Exhaust Requirements................................................................................... 51
Layout......................................................................................................... 51
Make-Up Air................................................................................................51
Venting........................................................................................................51
Individual Venting.....................................................................................52
Manifold Venting...................................................................................... 53
Gas Requirements.................................................................................56
Gas Requirements.........................................................................................56
Gas Supply Pipe Sizing and Looping.............................................................. 58
Low Pressure Gas Pipe Sizes......................................................................58
High Pressure Gas Pipe Sizes..................................................................... 60
High Altitude Burner Orifice Sizing............................................................... 62
Electrical Requirements........................................................................70
Electrical Requirements.................................................................................70
Wiring Diagram............................................................................................70
Wiring for Central Pay.................................................................................. 70
Grounding Instructions.................................................................................. 72
For CE Models Only..................................................................................72
Service/Ground Location........................................................................... 73
To Connect Electrical Service To The Tumble Dryer....................................... 76
Configuring Your Tumble Dryer for Other Service Voltages.............................76
Electrical Connections for T30 and T45 Only.................................................. 77
Conversion Instructions................................................................................. 78
Ferrite Ring Installation (025, 030, 035 and 055 Series Only)............................79
Electrical Specifications................................................................................ 80
Steam Requirements.............................................................................92
Steam Requirements......................................................................................92
Piping Recommendations.............................................................................. 94
Installing Steam Trap and Making Condensate Return Connections...................94
Single Drop Timer................................................................................ 95
Power-Up Mode........................................................................................... 95
Ready Mode.................................................................................................95
Start Mode................................................................................................... 95
Run Mode.................................................................................................... 95
Door Open Mode.......................................................................................... 95
End of Cycle Mode....................................................................................... 95
Setting Dry Time Dipswitches........................................................................95
Models Through Serial No. 0908xxxxx....................................................... 95
Models Starting Serial No. 0909xxxxx........................................................ 95
Resetting Cycle Time to Zero.........................................................................95
Dipswitch Settings........................................................................................ 96
Topoffs........................................................................................................ 99
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
6 Part No. 70458301ENR10

Temperature Selector Switch......................................................................... 99
To Program a Short Test Cycle.......................................................................99
Error Codes..................................................................................................99
Operating Instructions........................................................................100
Operating Instructions................................................................................. 100
Emergency Stop Button On CE Models.........................................................100
Operating Instructions................................................................................. 100
Reversing Operation....................................................................................101
Control Instructions.....................................................................................101
Dual Digital Timer Control.......................................................................101
Electronic OPL Micro Control.................................................................. 103
Single Drop Control.................................................................................104
MDC Coin and Card Control.................................................................... 105
Quantum Control ....................................................................................105
Galaxy 600 Control .................................................................................106
LED OPL Control ...................................................................................107
UniLinc Control ..................................................................................... 108
DX4 Coin Control................................................................................... 109
DX4 OPL Control....................................................................................110
Diagnostic Microprocessor Control .......................................................... 110
DMP OPL Models...................................................................................112
DMP Coin.............................................................................................. 114
Ignition Control Operation and Troubleshooting for Models Starting 3/11/13... 116
Internal Control Failure............................................................................116
Troubleshooting...................................................................................... 116
Proper Electrode Location........................................................................ 117
Flame Current Measurement.....................................................................117
Ignition Control Operation for Non-CE Models Through 3/10/13.................... 117
Ignition Control Operation for CE Models Through 3/10/13............................118
System Tests........................................................................................... 119
Diagnostic LED (DGN LED)/Error Codes................................................. 119
Adjustments........................................................................................120
Adjustments............................................................................................... 120
Gas Burner Air Shutter................................................................................ 120
Airflow Switch .......................................................................................... 121
Loading Door Switch.................................................................................. 121
Door Strike.................................................................................................122
Maintenance....................................................................................... 123
Daily..........................................................................................................123
Monthly..................................................................................................... 124
Quarterly....................................................................................................124
Bi-Annually................................................................................................124
Annually.................................................................................................... 124
Fire Suppression System (Optional Equipment) Maintenance Test...................124
Before You Call for Service.................................................................126
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
7 Part No. 70458301ENR10

Removing Tumble Dryer from Service................................................ 127
Disposal of Unit...................................................................................128
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
8 Part No. 70458301ENR10

Introduction
Model Identification
Information in this manual is applicable to these models. Refer
to the machine serial plate for the model number.
Gas Steam Electric
025 Series
(11 Kg)
CHD25G2-
CA025L
CHD25G2-
CA025N
CHD25G2-
CT025L
CHD25G2-
CT025N
CHD25G2-
CU025L
CHD25G2-
CU025N
CK025N
CK025R
CT025R
CU025R
DR25G2-
BA025L
DR25G2-
BA025N
DR25G2-
BK025N
DR25G2-
BK025R
DR25G2-
BT025L
DR25G2-
BT025N
DR25G2-
BT025R
DR25G2-
BU025L
DR25G2-
BU025N
DR25G2-
BU025R
HA025L
HA025N
HK025N
HK025R
HT025L
HT025N
HT025R
HU025L
HU025N
HU025R
IPD25G2
IT025L
IT025N
IT025R
LA025L
LA025N
LK025N
LT025L
LT025N
LU025L
LU025N
MT025L
MT025N
MT025R
PA025L
PA025N
PK025N
PT025L
PT025N
PU025L
PU025N
SA025L
SA025N
SK025N
SK025R
ST025L
ST025N
ST025R
SU025L
SU025N
SU025R
UA025L
UA025N
UK025N
UK025R
UT025L
UT025N
UT025R
UU025L
UU025N
UU025R
YT025L
YT025N
YU025L
YU025N
CHD25S2-
CT025S
CHD25S2-
CU025S
DR25S2-
BT025S
DR25S2-
BU025S
HT025S
HU025S
IPD25S2
IT025S
LT025S
LU025S
MT025S
PT025S
PU025S
ST025S
SU025S
UT025S
UU025S
YT025S
YU025S
CHD25E2-
CT025E
CHD25E2-
CU025E
CT025F
CU025F
DR25E2-
BT025E
DR25E2-
BT025F
DR25E2-
BU025E
DR25E2-
BU025F
HT025E
HT025F
HU025E
HU025F
IPD25E2
IT025E
IT025F
LT025E
LU025E
MT025E
MT025F
PT025E
PU025E
ST025E
ST025F
SU025E
SU025F
UT025E
UT025F
UU025E
UU025F
YT025E
YU025E
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
9 Part No. 70458301ENR10

Gas Steam Electric
030 Series
(13 Kg)
CHD30G2-
CA030L
CHD30G2-
CA030N
CHD30G2-
CT030L
CHD30G2-
CT030N
CHD30G2-
CU030L
CHD30G2-
CU030N
CK030N
CK030R
CT030R
CU030R
DR30G2-
BA030L
DR30G2-
BA030N
DR30G2-
BK030N
DR30G2-
BK030R
DR30G2-
BT030D
DR30G2-
BT030L
DR30G2-
BT030N
DR30G2-
BT030R
DR30G2-
BU030L
DR30G2-
BU030N
DR30G2-
BU030R
HA030L
HA030N
HK030N
HK030R
HT030D
HT030L
HT030N
HT030R
HU030L
HU030N
HU030R
IPD30G2
IT030L
IT030N
IT030R
LA030L
LA030N
LK030N
LT030L
LT030N
LU030L
LU030N
MT030L
MT030N
MT030R
PA030L
PA030N
PK030N
PT030L
PT030N
PU030L
PU030N
SA030L
SA030N
SK030N
SK030R
ST030D
ST030L
ST030N
ST030R
SU030L
SU030N
SU030R
UA030L
UA030N
UK030N
UK030R
UT030L
UT030N
UT030R
UU030L
UU030N
UU030R
YT030L
YT030N
YU030L
YU030N
CHD30S2-
CT030S
CHD30S2-
CU030S
DR30S2-
BT030S
DR30S2-
BU030S
HT030S
HU030S
IPD30S2
IT030S
LT030S
LU030S
MT030S
PT030S
PU030S
ST030S
SU030S
UT030S
UU030S
YT030S
YU030S
CHD30E2-
CT030E
CHD30E2-
CU030E
CT030F
CU030F
DR30E2-
BT030E
DR30E2-
BT030F
DR30E2-
BU030E
DR30E2-
BU030F
HT030E
HT030F
HU030E
HU030F
IPD30E2
IT030E
IT030F
LT030E
LU030E
MT030E
MT030F
PT030E
PU030E
ST030E
ST030F
SU030E
SU030F
UT030E
UT030F
UU030E
UU030F
YT030E
YU030E
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
10 Part No. 70458301ENR10