Alliance Laundry Systems CHD25G2-CT025L Operating instructions

Programming
Tumble Dryer
OPL Electronic Control
Refer to Page 7 for Model Identification
Original Instructions
Keep These Instructions for Future Reference.
(If this machine changes ownership, this manual must accompany machine.)
www.alliancelaundry.com Part No. 70444901ENR10
February 2016

Front Matter
WARNING
Machine installations must comply with minimum
specifications and requirements stated in the appli-
cable Installation Manual, any applicable municipal
building codes, water supply requirements, electrical
wiring regulations and any other relevant statutory
regulations. Due to varied requirements and applica-
ble local codes, this machine must be installed, ad-
justed, and serviced by qualified maintenance per-
sonnel familiar with applicable local codes and the
construction and operation of this type of machinery.
They must also be familiar with the potential hazards
involved. Failure to observe this warning may result
in personal injury, property damage, and/or equip-
ment damage, and will void the warranty.
W820
NOTE: The WARNINGS and IMPORTANT SAFETY IN-
STRUCTIONS appearing in this manual are not meant
to cover all possible conditions and situations that may
occur. Common sense, caution, and care must be exer-
cised when installing, maintaining, or operating the
machine.
Any problems or conditions not understood should be reported to
the dealer, distributor, service agent or the manufacturer.
Front Matter
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
3 Part No. 70444901ENR10

Table of Contents
Front Matter.......................................................................................... 3
Introduction........................................................................................... 7
Model Identification........................................................................................7
Nameplate Location...................................................................................... 17
Preliminary Information.......................................................................18
About the Control......................................................................................... 18
DIP Switch Configuration..............................................................................18
Power Failure Recovery................................................................................ 18
Communications...........................................................................................18
Audit Information......................................................................................... 18
Restore to Factory Defaults............................................................................18
Entering Program Mode................................................................................ 19
Control Identification........................................................................... 20
Operational Keypad...................................................................................... 20
Operation Modes.......................................................................................... 21
General Modes of Operation.......................................................................21
Power-up Mode.........................................................................................21
Idle Mode................................................................................................. 22
Run Mode.................................................................................................22
Rapid Advance Mode................................................................................ 23
Pause Mode.............................................................................................. 23
Error Mode............................................................................................... 23
Communication Mode............................................................................... 23
Cool Down Mode......................................................................................23
End of Cycle Mode....................................................................................23
Extended Tumble Mode............................................................................. 23
Reversing Mode (reversing models only).....................................................23
Entering Diagnostic Mode From Idle Mode................................................. 23
Displaying Temperature Mode....................................................................23
Machine Cycle Definition and Operation.............................................. 24
Machine Cycle Operation.............................................................................. 24
Time Dry Cycle.........................................................................................24
Auto-Dry Cycle.........................................................................................24
Moisture Dry Cycle (if equipped)................................................................24
Rotation Sensor Equipped Machines...............................................................24
To Start a Cycle............................................................................................ 24
© Copyright 2016, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed
written consent of the publisher.
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
4 Part No. 70444901ENR10

Entering the Manual Mode................................................................... 25
How to Enter the Manual Mode......................................................................25
Programming Control...........................................................................27
What Can Be Programmed?........................................................................... 27
How to Program a Cycle................................................................................27
Programmable Options Available................................................................... 27
Collecting Audit Information................................................................ 38
How to Enter Audit Feature........................................................................... 38
How to Read Audit Data................................................................................38
How to Exit Audit Feature............................................................................. 38
Manual Reset........................................................................................39
Custom Save.........................................................................................40
Testing Machine and Electronic Control Functions............................... 41
How to Enter Testing Feature.........................................................................41
How to Start Tests.........................................................................................41
How to Exit Testing Feature...........................................................................41
Diagnostic Test Descriptions..........................................................................44
Control Software Version Number Test........................................................44
Loading Door Test.....................................................................................44
Lint Door Test...........................................................................................44
Heater Interlock Test..................................................................................44
Dip Switch Status......................................................................................44
ICM Alarm Status..................................................................................... 45
ICM Reset Test......................................................................................... 45
External Alarm Test...................................................................................45
Tumble Dryer On Temperature Test............................................................ 45
Thermistor Temperature Test...................................................................... 45
Machine Configuration Display #2 Test.......................................................45
Machine Configuration Display #3 Test.......................................................46
Airflow Switch Test...................................................................................46
Fan Motor Test..........................................................................................46
Damper Motor Test....................................................................................46
Reverse Motor Test....................................................................................47
Rotation Sensor Test.................................................................................. 47
Moisture Sensor Test (Shorted Test Jumper).................................................47
Moisture Sensor Test (Resistance Test Jumper)............................................ 47
Production Test Cycle....................................................................................47
To Enter Production Test Cycle...................................................................47
To Exit Production Test Cycle.................................................................... 48
Machine Errors.................................................................................... 49
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
5 Part No. 70444901ENR10

PDA Communications Error.......................................................................... 49
Open Thermistor Error.................................................................................. 49
Shorted Thermistor Error...............................................................................49
Stove and Cabinet Limit Errors...................................................................... 49
Auto Ignition Retry (Gas Models Only).......................................................... 49
Air Flow Switch Errors..................................................................................49
Airflow Switch Sensed Closed While Not In Run Mode................................49
Airflow Switch Does Not Close After Cycle Started..................................... 49
Airflow Switch Bounces During A Running Cycle....................................... 49
Rotation Sensor Error....................................................................................50
Fan Motor Contactor Error.............................................................................50
Fan Motor Centrifugal Switch Error............................................................... 50
DIP Switch/Harness Index Mismatch Error..................................................... 50
Moisture Sensor Error................................................................................... 50
Error Codes..........................................................................................51
Communication Mode...........................................................................53
Infra-red Communications............................................................................. 53
How to Begin Communications with An External Device................................. 53
Cycle Charts.........................................................................................54
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
6 Part No. 70444901ENR10

Introduction
Model Identification
Information in this manual is applicable to these tumble dryer
models:
Gas Steam/Thermal Oil Electric
25 Pound CHD25G2-
CA025L
CHD25G2-
CA025N
CHD25G2-
CT025L
CHD25G2-
CT025N
CHD25G2-
CU025L
CHD25G2-
CU025N
CK025N
CK025R
CT025R
CU025R
DR25G2-
BA025L
DR25G2-
BA025N
DR25G2-
BK025N
DR25G2-
BK025R
DR25G2-
BT025L
DR25G2-
BT025N
DR25G2-
BT025R
DR25G2-
BU025L
DR25G2-
BU025N
DR25G2-
BU025R
HA025L
HA025N
HK025N
HK025R
HT025L
HT025N
HT025R
HU025L
HU025N
HU025R
IPD25G2
IT025L
IT025N
IT025R
LA025L
LA025N
LK025N
LT025L
LT025N
LU025L
LU025N
NT025L
NT025N
NU025L
NU025N
PA025L
PA025N
PK025N
PT025L
PT025N
PU025L
PU025N
SA025L
SA025N
SK025N
SK025R
ST025L
ST025N
ST025R
SU025L
SU025N
SU025R
UA025L
UA025N
UK025N
UK025R
UT025L
UT025N
UT025R
UU025L
UU025N
UU025R
CHD25S2-
CT025S
CHD25S2-
CU025S
DR25S2-
BT025S
DR25S2-
BU025S
HT025S
HU025S
IPD25S2
IT025S
LT025S
LU025S
NT025S
NU025S
PT025S
PU025S
ST025S
SU025S
UT025S
UU025S
CHD25E2-
CT025E
CHD25E2-
CU025E
CT025F
CU025F
DR25E2-
BT025E
DR25E2-
BT025F
DR25E2-
BU025E
DR25E2-
BU025F
HT025E
HT025F
HU025E
HU025F
IPD25E2
IT025E
IT025F
LT025E
LU025E
NT025E
NU025E
PT025E
PU025E
ST025E
ST025F
SU025E
SU025F
UT025E
UT025F
UU025E
UU025F
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
7 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
30 Pound CHD30G2-
CA030L
CHD30G2-
CA030N
CHD30G2-
CT030L
CHD30G2-
CT030N
CHD30G2-
CU030L
CHD30G2-
CU030N
CK030N
CK030R
CT030R
CU030R
DR30G2-
BA030L
DR30G2-
BA030N
DR30G2-
BK030N
DR30G2-
BK030R
DR30G2-
BT030D
DR30G2-
BT030L
DR30G2-
BT030N
DR30G2-
BT030R
DR30G2-
BU030L
DR30G2-
BU030N
DR30G2-
BU030R
HA030L
HA030N
HK030N
HK030R
HT030D
HT030L
HT030N
HT030R
HU030L
HU030N
HU030R
IPD30G2
IT030L
IT030N
IT030R
LA030L
LA030N
LK030N
LT030L
LT030N
LU030L
LU030N
NT030L
NT030N
NU030L
NU030N
PA030L
PA030N
PK030N
PT030L
PT030N
PU030L
PU030N
SA030L
SA030N
SK030N
SK030R
ST030D
ST030L
ST030N
ST030R
SU030L
SU030N
SU030R
UA030L
UA030N
UK030N
UK030R
UT030L
UT030N
UT030R
UU030L
UU030N
UU030R
CHD30S2-
CT030S
CHD30S2-
CU030S
DR30S2-
BT030S
DR30S2-
BU030S
HT030S
HU030S
IPD30S2
IT030S
LT030S
LU030S
NT030S
NU030S
PT030S
PU030S
ST030S
SU030S
UT030S
UU030S
CHD30E2-
CT030E
CHD30E2-
CU030E
CT030F
CU030F
DR30E2-
BT030E
DR30E2-
BT030F
DR30E2-
BU030E
DR30E2-
BU030F
HT030E
HT030F
HU030E
HU030F
IPD30E2
IT030E
IT030F
LT030E
LU030E
NT030E
NU030E
PT030E
PU030E
ST030E
ST030F
SU030E
SU030F
UT030E
UT030F
UU030E
UU030F
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
8 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
30 Pound
Stacked
CHD30STG
2-CAT30L
CHD30STG
2-CAT30N
CHD30STG
2-CTT30L
CHD30STG
2-CTT30N
CHD30STG
2-CUT30L
CHD30STG
2-CUT30N
CKT30N
CKT30R
CTT30R
CUT30R
DR335
DR335G2-
BKT30N
DR335G2-
BKT30R
DR335G2-
BTT30R
DR335G2-
BUT30R
DRST30G2-
BAT30L
DRST30G2-
BAT30N
DRST30G2-
BTT30D
DRST30G2-
BTT30L
DRST30G2-
BTT30N
DRST30G2-
BUT30L
DRST30G2-
BUT30N
HAT30L
HAT30N
HKT30N
HKT30R
HTT30D
HTT30L
HTT30N
HTT30R
HUT30L
HUT30N
HUT30R
IPD30STG2
ITT30L
ITT30N
ITT30R
LAT30L
LAT30N
LKT30N
LTT30L
LTT30N
LUT30L
LUT30N
NTT30L
NTT30N
NUT30L
NUT30N
PAT30L
PAT30N
PKT30N
PTT30L
PTT30N
PUT30L
PUT30N
SAT30L
SAT30N
SKT30N
SKT30R
STT30D
STT30L
STT30N
STT30R
SUT30L
SUT30N
SUT30R
UAT30L
UAT30N
UKT30N
UKT30R
UTT30L
UTT30N
UTT30R
UUT30L
UUT30N
UUT30R
CHD30STS2
-CTT30S
CHD30STS2
-CUT30S
DRST30S2-
BTT30S
DRST30S2-
BUT30S
HTT30S
HUT30S
IPD30STS2
ITT30S
LTT30S
LUT30S
NTT30S
NUT30S
PTT30S
PUT30S
STT30S
SUT30S
UTT30S
UUT30S
CHD30STE2
-CTT30E
CHD30STE2
-CUT30E
CTT30F
CUT30F
DR335G2-
BTT30F
DR335G2-
BUT30F
DRST30E2-
BTT30E
DRST30E2-
BUT30E
HTT30E
HTT30F
HUT30E
HUT30F
IPD30STE2
ITT30E
ITT30F
LTT30E
LUT30E
NTT30E
NUT30E
PTT30E
PUT30E
STT30E
STT30F
SUT30E
SUT30F
UTT30E
UTT30F
UUT30E
UUT30F
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
9 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
35 Pound CHD35G2-
CA035L
CHD35G2-
CA035N
CHD35G2-
CT035L
CHD35G2-
CT035N
CHD35G2-
CU035L
CHD35G2-
CU035N
CK035N
CK035R
CT035R
CU035R
DR35G2-
BA035L
DR35G2-
BA035N
DR35G2-
BK035N
DR35G2-
BK035R
DR35G2-
BT035L
DR35G2-
BT035N
DR35G2-
BT035R
DR35G2-
BU035L
DR35G2-
BU035N
DR35G2-
BU035R
HA035L
HA035N
HK035N
HK035R
HT035L
HT035N
HT035R
HU035L
HU035N
HU035R
IPD35G2
IT035L
IT035N
IT035R
LA035L
LA035N
LK035N
LT035L
LT035N
LU035L
LU035N
NT035L
NT035N
NU035L
NU035N
PA035L
PA035N
PK035N
PT035L
PT035N
PU035L
PU035N
SA035L
SA035N
SK035N
SK030R
ST035L
ST035N
ST035R
SU035L
SU035N
SU035R
UA035L
UA035N
UK035N
UK035R
UT035L
UT035N
UT035R
UU035L
UU035N
UU035R
CHD35S2-
CT035S
CHD35S2-
CU035S
DR35S2-
BT035S
DR35S2-
BU035S
HT035S
HU035S
IPD35S2
IT035S
LT035S
LU035S
NT035S
NU035S
PT035S
PU035S
ST035S
SU035S
UT035S
UU035S
CHD35E2-
CT035E
CHD35E2-
CU035E
CT035F
CU035F
DR35E2-
BT035E
DR35E2-
BT035F
DR35E2-
BU035E
DR35E2-
BU035F
HT035E
HT035F
HU035E
HU035F
IPD35E2
IT035E
IT035F
LT035E
LU035E
NT035E
NU035E
PT035E
PU035E
ST035E
ST035F
SU035E
SU035F
UT035E
UT035F
UU035E
UU035F
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
10 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
45 Pound
Stacked
CKT45N
CKT45R
CTT45L
CTT45N
CTT45R
DR445G2-
BAT45L
DR445G2-
BAT45N
DR445G2-
BKT45N
DR445G2-
BKT45R
DR445G2-
BTT45D
DR445G2-
BTT45L
DR445G2-
BTT45N
DR445G2-
BTT45R
DR445G2-
BUT45L
DR445G2-
BUT45N
DR445G2-
BUT45R
DRST45G2-
BAT45L
DRST45G2-
BAT45N
DRST45G2-
BTT45D
DRST45G2-
BTT45L
DRST45G2-
BTT45N
DRST45G2-
BUT45L
DRST45G2-
BUT45N
HAT45L
HAT45N
HKT45N
HKT45R
HTT45D
HTT45L
HTT45N
HTT45R
HUT45L
HUT45N
HUT45R
IPD45STG2
ITT45L
ITT45N
ITT45R
LAT45L
LAT45N
LKT45N
LTT45L
LTT45N
LUT45L
LUT45N
NTT45L
NTT45N
NUT45L
NUT45N
PAT45L
PAT45N
PKT45N
PTT45L
PTT45N
PUT45L
PUT45N
SAT45L
SAT45N
SKT45N
SKT45R
STT45D
STT45L
STT45N
STT45R
SUT45L
SUT45N
SUT45R
UAT45L
UAT45N
UKT45N
UKT45R
UTT45L
UTT45N
UTT45R
UUT45L
UUT45N
UUT45R
Not Applicable Not Applicable
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
11 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
50 Pound CA050L
CA050N
CK050N
CT050L
CT050N
CU050L
CU050N
DR50G2-
BA050L
DR50G2-
BA050N
DR50G2-
BK050N
DR50G2-
BT050D
DR50G2-
BT050L
DR50G2-
BT050N
DR50G2-
BU050L
DR50G2-
BU050N
DR55G2-
BA050L
DR55G2-
BA050N
DR55G2-
BT050D
DR55G2-
BT050L
DR55G2-
BT050N
DR55G2-
BU050L
DR55G2-
BU050N
HA050L
HA050N
HK050N
HT050D
HT050L
HT050N
HU050L
HU050N
IPD50G2
IT050L
IT050N
LA050L
LA050N
LK050N
LT050L
LT050N
LU050L
LU050N
NT050L
NT050N
NU050L
NU050N
PA050L
PA050N
PK050N
PT050L
PT050N
PU050L
PU050N
SA050L
SA050N
SK050N
ST050D
ST050L
ST050N
SU050L
SU050N
UA050L
UA050N
UK050N
UT050L
UT050N
UU050L
UU050N
CT050S
CT050T
CU050S
CU050T
DR50S2-
BT050S
DR50S2-
BT050T
DR50S2-
BU050S
DR50S2-
BU050T
DR55S2-
BT050S
DR55S2-
BT050T
DR55S2-
BU050S
DR55S2-
BU050T
HT050S
HT050T
HU050S
HU050T
IPD50S2
IT050S
IT050T
LT050S
LT050T
LU050S
LU050T
NT050S
NU050S
PT050S
PT050T
PU050S
PU050T
ST050S
ST050T
SU050S
SU050T
UT050S
UT050T
UU050S
UU050T
CT050E
CU050E
DR50E2-
BT050E
DR50E2-
BU050E
DR55E2-
BT050E
DR55E2-
BU050E
HT050E
HU050E
IPD50E2
IT050E
LT050E
LU050E
NT050E
NU050E
PT050E
PU050E
ST050E
SU050E
UT050E
UU050E
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
12 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
55 Pound CA055L
CA055N
CK055N
CK055R
CT055L
CT055N
CT055R
CU055L
CU055N
CU055R
DR55SG2-
BA055L
DR55SG2-
BA055N
DR55SG2-
BK055N
DR55SG2-
BK055R
DR55SG2-
BT055D
DR55SG2-
BT055L
DR55SG2-
BT055N
DR55SG2-
BT055R
DR55SG2-
BU055L
DR55SG2-
BU055N
DR55SG2-
BU055R
HA055L
HA055N
HK055N
HK055R
HT055D
HT055L
HT055N
HT055R
HU055L
HU055N
HU055R
IPD55G2
IT055L
IT055N
IT055R
LA055L
LA055N
LK055N
LT055L
LT055N
LU055L
LU055N
NT055L
NT055N
NU055L
NU055N
PA055L
PA055N
PK055N
PT055L
PT055N
PU055L
PU055N
SA055L
SA055N
SK055N
SK055R
ST055D
ST055L
ST055N
ST055R
SU055L
SU055N
SU055R
UA055L
UA055N
UK055N
UK055R
UT055L
UT055N
UT055R
UU055L
UU055N
UU055R
Not Applicable CT055E
CT055F
CU055E
CU055F
DR55SE2-
BT055E
DR55SE2-
BT055F
DR55SE2-
BU055E
DR55SE2-
BU055F
HT055E
HT055F
HU055E
HU055F
IPD55E2
IT055E
IT055F
LT055E
LU055E
NT055E
NU055E
PT055E
PU055E
ST055E
ST055F
SU055E
SU055F
UT055E
UT055F
UU055E
UU055F
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
13 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
75 Pound CA075L
CA075N
CK075N
CK075R
CT075L
CT075N
CT075R
CU075L
CU075N
CU075R
DR75G2-
BA075L
DR75G2-
BA075N
DR75G2-
BK075N
DR75G2-
BK075R
DR75G2-
BT075D
DR75G2-
BT075L
DR75G2-
BT075N
DR75G2-
BT075R
DR75G2-
BU075L
DR75G2-
BU075N
DR75G2-
BU075R
DR80G2-
BA075L
DR80G2-
BA075N
DR80G2-
BT075D
DR80G2-
BT075L
DR80G2-
BT075N
DR80G2-
BU075L
DR80G2-
BU075N
HA075L
HA075N
HK075N
HK075R
HT075D
HT075L
HT075N
HT075R
HU075L
HU075N
HU075R
IPD75G2
IT075L
IT075N
IT075R
LA075L
LA075N
LK075N
LT075L
LT075N
LU075L
LU075N
NT075L
NT075N
NU075L
NU075N
PA075L
PA075N
PK075N
PT075L
PT075N
PU075L
PU075N
SA075L
SA075N
SK075N
SK075R
ST075D
ST075L
ST075N
ST075R
STF75L
STF75N
SU075L
SU075N
SU075R
UA075L
UA075N
UK075N
UK075R
UT075L
UT075N
UT075R
UTF75L
UTF75N
UU075L
UU075N
UU075R
CT075S
CT075T
CU075S
CU075T
DR75S2-
BT075S
DR75S2-
BT075T
DR75S2-
BU075S
DR75S2-
BU075T
DR80S2-
BT075S
DR80S2-
BT075T
DR80S2-
BU075S
DR80S2-
BU075T
HT075S
HT075T
HU075S
HU075T
IPD75S2
IT075S
IT075T
LT075S
LT075T
LU075S
LU075T
NT075S
NU075S
PT075S
PT075T
PU075S
PU075T
ST075S
ST075T
SU075S
SU075T
UT075S
UT075T
UU075S
UU075T
CT075E
CT075F
CU075E
CU075F
DR75E2-
BT075E
DR75E2-
BT075F
DR75E2-
BU075E
DR75E2-
BU075F
DR80E2-
BT075E
DR80E2-
BU075E
HT075E
HT075F
HU075E
HU075F
IPD75E2
IT075E
IT075F
LT075E
LU075E
NT075E
NU075E
PT075E
PU075E
ST075E
ST075F
SU075E
SU075F
UT075E
UT075F
UU075E
UU075F
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
14 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
120 Pound CA120L
CA120N
CK120N
CT120L
CT120N
CU120L
CU120N
DR120G2-
BA120L
DR120G2-
BA120N
DR120G2-
BK120N
DR120G2-
BT120L
DR120G2-
BT120N
DR120G2-
BU120L
DR120G2-
BU120N
HA120L
HA120N
HK120N
HT120L
HT120N
HU120L
HU120N
IPD120G2
IT120L
IT120N
LA120L
LA120N
LK120N
LT120L
LT120N
LU120L
LU120N
NT120L
NT120N
NU120L
NU120N
PA120L
PA120N
PK120N
PT120L
PT120N
PU120L
PU120N
SA120L
SA120N
SK120N
ST120L
ST120N
SU120L
SU120N
UA120L
UA120N
UK120N
UT120L
UT120N
UU120L
UU120N
CT120S
CT120T
CU120S
CU120T
DR120S2-
BT120S
DR120S2-
BT120T
DR120S2-
BU120S
DR120S2-
BU120T
HT120S
HT120T
HU120S
HU120T
IPD120S2
IT120S
IT120T
LT120S
LT120T
LU120S
LU120T
NT120S
NU120S
PT120S
PT120T
PU120S
PU120T
ST120S
ST120T
SU120S
SU120T
UT120S
UT120T
UU120S
UU120T
CT120E
CU120E
DR120E2-
BT120E
DR120E2-
BU120E
HT120E
HU120E
IT120E
LT120E
LU120E
NT120E
NU120E
PT120E
PU120E
ST120E
SU120E
UT120E
UU120E
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
15 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
170 Pound CA170L
CA170N
CK170N
CT170L
CT170N
CU170L
CU170N
DR170G2-
BA170L
DR170G2-
BA170N
DR170G2-
BK170N
DR170G2-
BT170L
DR170G2-
BT170N
DR170G2-
BU170L
DR170G2-
BU170N
HA170L
HA170N
HK170N
HT170L
HT170N
HU170L
HU170N
IPD170G2
IT170L
IT170N
LA170L
LA170N
LK170N
LT170L
LT170N
LU170L
LU170N
NT170L
NT170N
NU170L
NU170N
PA170L
PA170N
PK170N
PT170L
PT170N
PU170L
PU170N
SA170L
SA170N
SK170N
ST170L
ST170N
SU170L
SU170N
UA170L
UA170N
UK170N
UT170L
UT170N
UU170L
UU170N
CT170S
CT170T
CU170S
CU170T
DR170S2-
BT170S
DR170S2-
BT170T
DR170S2-
BU170S
DR170S2-
BU170T
HT170S
HT170T
HU170S
HU170T
IPD170S2
IT170S
IT170T
LT170S
LT170T
LU170S
LU170T
NT170S
NU170S
PT170S
PT170T
PU170S
PU170T
ST170S
ST170T
SU170S
SU170T
UT170S
UT170T
UU170S
UU170T
Not Applicable
Table continues...
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
16 Part No. 70444901ENR10

Gas Steam/Thermal Oil Electric
200 Pound CA200L
CA200N
CT200L
CT200N
CU200L
CU200N
DR200G2-
BA200L
DR200G2-
BA200N
DR200G2-
BT200L
DR200G2-
BT200N
DR200G2-
BU200L
DR200G2-
BU200N
HA200L
HA200N
HT200L
HT200N
HU200L
HU200N
IT200L
IT200N
LA200L
LA200N
LT200L
LT200N
LU200L
LU200N
NT200L
NT200N
NU200L
NU200N
PA200L
PA200N
PT200L
PT200N
PU200L
PU200N
SA200L
SA200N
ST200L
ST200N
SU200L
SU200N
UA200L
UA200N
UT200L
UT200N
UU200L
UU200N
CT200S
CT200T
CU200S
CU200T
DR200S2-
BT200S
DR200S2-
BT200T
DR200S2-
BU200S
DR200S2-
BU200T
HT200S
HT200T
HU200S
HU200T
IT200S
IT200T
LT200S
LT200T
LU200S
LU200T
NT200S
NU200S
PT200S
PT200T
PU200S
PU200T
ST200S
ST200T
SU200S
SU200T
UT200S
UT200T
UU200S
UU200T
Not Applicable
Includes models with the following control suffixes:
EO – OPL electronic
RE – reversing OPL electronic
Nameplate Location
The nameplate is located on the back of the machine and is pro-
grammed in the control.
Introduction
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
17 Part No. 70444901ENR10

Preliminary Information
About the Control
This control is an advanced, programmable computer that lets the
owner control most machine features by pressing a sequence of
keypads.
The control allows the owner to program custom cycles, run di-
agnostic cycles, and retrieve audit and error information.
Tumble Dryers shipped from the factory have default cycles and
other settings built in. The owner can change the default cycle or
any cycle.
IMPORTANT: It is extremely important that the tumble
dryer has a positive ground and that all mechanical
and electrical connections are made before applying
power to or operating the tumble dryer.
DIP Switch Configuration
Make sure DIP switches are configured properly for the machine.
Refer to Figure 1 .
TMB1445R_SVG
Figure 1
Power Failure Recovery
If a cycle is in progress when the power fails, and if the power
outage lasts three or more seconds, the cycle is lost and cannot be
resumed when power recovers. If the power outage lasts less than
three seconds, the control will resume the cycle when the power
recovers.
Communications
The control has the ability to communicate with a PDA and a lap-
top with an IrDA device running the control software. Devices
such as PDAs and laptops that are IrDA capable (able to transmit
information to machine) that have been tested and approved for
use with the software can be used as a tool for managing the ma-
chine.
Audit Information
The control collects and stores audit information, which can be
accessed with a PDA or PC. Refer to the following list for some
of the available audit information. Refer to PC and PDA Appli-
cation User Instructions.
• End of Cycle to Loading Door Open Time
• End of Cycle to Start of Next Cycle Time
• Total Number of Machine Cycles
• Total Number of Operating Minutes
• Power Failure Audit Data
The PDA or PC can receive audit and program data from the con-
trol, and send programming data and diagnostic commands to the
control. Refer to PC and PDA Application User Instructions
for additional information.
Some of the above listed audit data is available manually. Refer
to How to Enter Audit Feature section.
Restore to Factory Defaults
When the user resets to factory default, the control resets all of
the default values. The control also resets Machine Cycles #1
through #30. The control will also reset the following to factory-
defaults:
Default Global Settings
Ignition Retries = 3
Temperature Units = Fahrenheit (°F)
High (H) Temperature = 190 (°F)
Medium (M) Temperature = 160 (°F)
Low (L) Temperature = 140 (°F)
Very Low (VL) Temperature = 120 (°F)
Cool Down Temperature = 100 (°F)
Cool Down Time = 2 (minutes)
Rapid Advance = Disabled
Multi-Segment Cycles = Disabled
Daylight Saving = Enabled
Key Pad Audio = Enabled
End of Cycle Audio = Enabled (5 seconds)
Preliminary Information
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
18 Part No. 70444901ENR10

End of Cycle External Signal = Enabled (5 seconds)
Clean Lint Screen Reminder = Off
Display Limit Errors = Disabled
Manual Diagnostics = Enabled
*Manual Programming = Enabled
**Reverse Cylinder Rotate Time = 30 (seconds)
**Reverse Cylinder Stop Time = 6 (seconds)
**Advanced Reversing = Disabled
***Advanced Options for Moisture Dry = Disabled
***Display Moisture Sensor Error = Disabled
*If manual programming is disabled, programming changes to
the control can only be made with an external communication de-
vice. Refer to PC and PDA Application User Instructions.
**Only available on units equipped with reversing feature.
***Only available on units equipped with moisture sensing fea-
ture.
Refer to Factory Defaults, Menu section for information on Re-
storing Factory Defaults.
Entering Program Mode
Press and hold Stop, then Back, then Up to enter the program-
ming options.
Preliminary Information
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
19 Part No. 70444901ENR10

Control Identification
Operational Keypad
The control includes five keypads. These functions are available
to the operator and are intended to control and manage operation
of the tumble dryer. Refer to Figure 2 , Figure 3 , Figure 4 , Fig-
ure 5 , Figure 6 , Figure 7 , Figure 8 and Table 1 .
S Models
TMB1345R_SVG
Figure 2
H Models
TMB1346R_SVG
Figure 3
U Models
TMB1371R_SVG
Figure 4
B, C and I Models
TMB1375R_SVG
Figure 5
P Models Through 5/31/15
START
BACK
STOP
TMB2369N_SVG
Figure 6
L Models Through 5/31/15; N Models
TMB2370N_SVG
START
STOP
BACK
Figure 7
Control Identification
© Copyright, Alliance Laundry Systems LLC -
DO NOT COPY or TRANSMIT
20 Part No. 70444901ENR10