Alva CCR111 User manual

/alvagas
/AlvaGas

IMPORTANT SAFETY INFORMATION
• Please read these instructions carefully before using your
butane cooker.
• The operator must understand all safety requirements as
detailed in this manual before using the unit.
• The operator is responsible for the safety of all third parties
while the butane cooker is in use.
• 7KHPDQXIDFWXUHU·VZDUUDQW\PD\EHYRLGHGE\LQFRUUHFW
use of this product.
• ,I\RXKDYHDQ\TXHULHVUHJDUGLQJWKHVHLQVWUXFWLRQVFRQWDFW
\RXUORFDOGHDOHUIRUFODULÀFDWLRQEHIRUH\RXXVH\RXUFRRNHU
• $OZD\VUHPRYHXQLWIURPDOOSDFNDJLQJPDWHULDOVSULRUWR
use.
• The unit must be thoroughly checked before use. Check
that the seals between the appliance and the gas cartridge
are in place and in good condition before connecting the
gas cartridge. DO NOT use this appliance if it has damaged
or worn seals. Tweezers can be used to pull the damaged/
worn seal out and replace it with a new seal or call 086 100
ALVA (2582)
• )DLOXUHWRIROORZWKHPDQXDO·VLQVWUXFWLRQVFRXOGUHVXOWLQ
damage or serious injury.
• 7KHXQLWPXVWRQO\EHXVHGRQDÁDWKRUL]RQWDOVWDEOH
non-slip and non-combustible surface.
• (QVXUHWKDWDOOEXWDQHÀWWLQJVDUHFRUUHFWO\DQGÀUPO\ÀWWHG
'RWKLVFKHFNHYHU\WLPHEHIRUHXVH
• '2127VWRUHÁDPPDEOHPDWHULDOVQHDUWKHFRRNHU
• DO NOT place or use aerosol sprays near the cooker.
• 8VHRQO\WKHJDVW\SHVSHFLÀHGRQWKHQDPHSODWHRIWKHXQLW
• '2127OHDYHWKHFRRNHUXQDWWHQGHGZKHQLWLVDOLJKW
• Onlookers should keep a safe distance away from the
butane cooker when it is in use.
• Keep children and animals well away while the butane
cooker is in use.
• Parts of the butane cooker will get extremely hot and could
FDXVHVHULRXVEXUQVWHVWHYHU\VXUIDFHEHIRUHWRXFKLQJLW
• %HYHU\FDUHIXOZKHQRSHUDWLQJWKHFRRNHU7KHRSHUDWRU
should pay constant attention to the food being cooked and
should remain at the appliance at all times when it is alight.
• Ensure that the butane cooker is turned OFF after use and
when left unattended.
• :KHQWXUQLQJRIIWKHEXWDQHFRRNHUWXUQWKHFRQWURONQREWR
WKH¶2·SRVLWLRQ
• Neither the Manufacturer nor their Agents can accept any
OLDELOLW\IRUWKHXQVXLWDELOLW\RIRUDQ\GDPDJHWRDQ\IRRG
cooked on this appliance.
Please read the
instructions carefully
before use.
Retain this manual for
future reference

• 7KHFRRNHUPXVWEHXVHGLQDZHOOYHQWLODWHGORFDWLRQ
• '2127XVHLQDZLQGEUHH]HRUGUDXJKW
• DO NOT use or place the cooker near other heat sources
VXFKDVKHDWHUVHOHFWULFDODSSOLDQFHVRUÁDPPDEOH
materials.
• '2127WRXFKWKHEXUQHUKHDG%%4JULOOIDWSDQ
pan support etc. immediately after or during use.
• Do not smoke while operating the appliance.
• 'RQRWFDUU\RUPRYHWKHFRRNHUZKLOHLQXVH
• Keep this appliance away from combustible materials
during operation. Keep minimum clearances of:
5HDUPP6LGHVPP7RSPP
• DO NOT use the cooker if you suspect that the unit is faulty.
• '2127XVHWKLVDSSOLDQFHLILWLVOHDNLQJGDPDJHGRUGRHV
not operate properly.
• (QVXUHWKHEXWDQHFDUWULGJHLVUHPRYHGIURPWKHFRRNHU
before storage.
• Carbon monoxide hazard:
This appliance can produce carbon monoxide which has no
RGRXU8VLQJLWLQDQHQFORVHGVSDFHHJFDUDYDQWHQWFDU
mobile home) may result in death.
• This appliance is to be used for cooking only. DO NOT use
WKHDSSOLDQFHDVDKHDWHUGU\LQJDSSDUDWXVRUWRVWDUWD
ZRRGÀUH
• DO NOT attempt any repairs yourself. This appliance must
RQO\EHVHUYLFHGE\DQDXWKRULVHGSURIHVVLRQDO
• $Q\PRGLÀFDWLRQWRWKHEXWDQHFRRNHUPD\FDXVHLQMXU\RU
SURSHUW\GDPDJHDQGDQ\PRGLÀFDWLRQWRWKHFRRNHUZLOO
LQYDOLGDWHWKHZDUUDQW\RQWKLVDSSOLDQFH
• Butane canister not included.
• The burner supplied with your cooker is considered to be a
FRQVXPDEOHVSDUH)UHTXHQF\RIXVHHQYLURQPHQWDOIDFWRUV
and failing to follow the cleaning and care instructions in this
manual may cause your cooker burner to corrode. This is
QRWFRQVLGHUHGDPDQXIDFWXULQJIDXOWEXWUDWKHUQRUPDOZHDU
DQGWHDUDQGLVQRWFRYHUHGXQGHURXUZDUUDQW\6KRXOG\RX
need to replace your burners please contact our customer
care department.

WARRANTY
3/($6(5(7$,1<2853522)2)385&+$6()25
:$55$17<&/$,06
ALVA warrants this appliance to be free of defects in material and
quality for a period of 12 months from date of original purchase.
7KLVZDUUDQW\FRYHUVWKHLQWHQGHGXVHRIWKLVDSSOLDQFH²ZLWKLQ
a domestic setting and not for commercial or industrial purposes.
$Q\GDPDJHFDXVHGE\ZLOOIXODEXVHWDPSHULQJPRGLÀFDWLRQRU
unauthorized repair will not be warranted.
3OHDVHUHWDLQDOOSDFNDJLQJPDWHULDODVLWHPVUHWXUQHGZLWKRXW
original packaging material may be subject to a withholding fee.
:KHUHWKLVDSSOLDQFHLVIRXQGWREHGHIHFWLYHGDPDJHGEURNHQ
RUGRHVQRWZRUNFRUUHFWO\IRUWKHLQWHQGHGSXUSRVH\RXPXVW
return the appliance to the retailer from where it was purchased.
7KHZDUUDQW\ZLOORQO\EHHIIHFWHGZLWKYDOLGSURRIRISXUFKDVH
)DLOXUHWRSURYLGHWKHSURRIRISXUFKDVHZLOOPRVWOLNHO\UHVXOWLQ
WKHUHSDLURUVHUYLFHUHTXLUHGEHLQJFKDUJHDEOH
,I\RXKDYHDQ\TXHVWLRQVZKLOHVHWWLQJXSRUXVLQJWKLVFRRNHU
SOHDVHYLVLWZZZDOYDFR]DRUFDOO$/9$RUHPDLO
[e-mail]
GENERAL INFORMATION
%HIRUHXVLQJWKLVFRRNHUSOHDVHUHDGWKURXJKWKLVPDQXDODQG
PDNHVXUH\RXXQGHUVWDQGHYHU\WKLQJ,I\RXDUHQRWVXUHFDOO
086 100 ALVA (2582) RUYLVLWZZZDOYDFR]DIRUKHOS
5HDGLQJDQGXQGHUVWDQGLQJWKLVPDQXDOVKRXOGJLYH\RXDJRRG
LQGLFDWLRQRIZKDWWRH[SHFWIURP\RXU$OYDJDVFRRNHU,IWKLV
SURGXFWLVQRWZKDW\RXZDQWRUQHHGSOHDVHKHOS$OYDDQGWKH
HQYLURQPHQWE\QRWGDPDJLQJRUGHVWUR\LQJDQ\SDUWRIWKH
SDFNDJLQJWKHPDQXDORUWKH6W\URIRDPLQVHUWV$OZD\VNHHS
your proof of purchase. Keep these instructions for future use.
,I\RXORVHWKLVFRS\\RXFDQREWDLQDQHZFRS\IURP\RXUGHDOHU
RURQOLQHDWZZZDOYDFR]D
Thank you for your
purchase of this
cooker. Please read
these instructions
carefully before use
and keep them in a
safe place,
for future reference.
Not using gas and/
or gas appliances
according to the
instructions is
extremely dangerous
and can lead to
property damage,
injury or death.
For outdoor use only.
For use with ALVA
Butane Canister only
Life s a Gas

2
2
3-4
5
5-6
7
7-8
9
9-10
10
11
12
12
INDEX
INDEX
)($785(6
3$576/,67
CAUTION
6(77,1*83<285%87$1(%%4&22.(5
,167$//,1*7+(%87$1(&$1,67(5
/($.7(67
86,1*<285%87$1(%%4&22.(5
7+($8726$)(7<'(9,&(
CARE AND MAINTENANCE
)/$6+%$&.6
7528%/(6+227,1**8,'(
63(&,),&$7,216
$)7(56$/(66(59,&(
KEY
Notes marked with the
following;
Contain important
information
Notes marked with the
following;
Contain cautions and
warnings.

Thank you for your
purchase of this gas
cooker.
Please read these
instructions carefully
before use and keep
them in a safe place
for future reference.
2
FEATURES
• BBQ grill with non-stick coating
• High heat output
• Automatic ignition
• Uses butane gas cartridges
• Safety locking mechanism
• Convenient carry case
• Lightweight design
• Stainless steel fat pan
• Heat shield plate
PARTS LIST
1. BBQ Grill
2. Stainless Steel Fat Pan
3. Fat Drop Hole
4. Pan Support Assembly
5. Pan Support
6. Burner
7. Heat Shield Plate
8. Electrode
9.Cartridge Locking Lever
10. Control/Ignition Knob
11. Cartridge Cover
12. Fat Drawer
13. Removal Drip Tray
Life s a Gas
11
13
12
10
9
8
7
6
5
4
2
3
1

Fig.1
Fig.2
Clothes Towel
ALVA butane gas
canisters are
available from
www.stingray.co.za
3
CAUTION
• DO NOT use any gas other
WKDQWKDWZKLFKLVVSHFLÀHGRQ
the label attached (Fig.1).
• Use for cooking only. Do not
GU\WRZHOVFORWKHVRUDQ\WKLQJ
HOVHRYHULW(Fig.2)
• '2127XVHLQDZLQGEUHH]H
or draught.
• Make sure that there are no
ÁDPPDEOHPDWHULDOVQHDUWKH
gas cooker. (Fig. 3)
• $IWHUXVHWXUQWKHLJQLWLRQNQRE
to the OFF position “OFF”,and
make sure the burners are
OFF. (Fig. 4)
• DO NOT touch the top housing
of the cooker as the surface
FDQJHWYHU\KRWGXULQJ
operation.
Fig.3
Curtain
Paper
Oil
Fig.4
OFF

• 2QO\XVHLQZHOOYHQWLODWHG
areas. Always ensure that
the windows are not fully shut
during the cooking session.
2EVHUYHÁDPHVWDELOLW\IURP
time to time while in use.
(Fig.5)
• When detecting a gas leak or if
\RXVPHOOJDVSHUIRUPD/HDN
test (Page.6).
• DO NOT test for a leak
XVLQJDQRSHQÁDPHRULJQLWLRQ
source.
• Always check that the seal is in place and in good condition.
Always ensure that the cartridge does not show any signs of
wear. If in doubt please consult your dealer.
Fig.5
Ventilation fan
Fig.6
Ventilation fan
Gas leak
Cigarette Match
4

Fig.8
25cm
120cm
25cm
25cm
Wall
Wall
Wall
Wall
Fig.7
5
FOR YOUR SAFETY
IF YOU SMELL GAS
OR HEAR A HISSING
SOUND:
• Turn the ignition
knob on the cooker
to “OFF”, to stop
WKHJDVÁRZDQG
turn the unit off.
• Ventilate the area.
• Check for leaks
(see LEAK TEST
page 7)
• If odour or
sound persists,
“UNLOCK” the
cartridge lock
lever to the upward
position and
remove and isolate
the gas cartridge
and contact your
dealer or local gas
supplier
immediately.
Fig.9
SETTING UP YOUR BUTANE BBQ COOKER
1. &RQÀUPWKDW\RXKDYHWKHULJKWPRGHOIRU\RXUW\SHRIJDV
supply.
2. :KHQXQSDFNLQJPDNHVXUHWKDWDOORIWKHSDUWVRIWKH
cooker are included. Assemble the parts: pan support
DVVHPEO\VWDLQOHVVVWHHOIDWSDQDQG%%4JULOODVLQ
VHTXHQFHRISDUWVOLVWRQSDJH7KHDVVHPEOHG%%4
cooker will appear as in Fig. 7
3. 3HUIRUPWKH/($.7(67
4. Position properly see (Fig.8)
INSTALLING THE BUTANE CANISTER
Only use 220g Butane cartridge
which complies with EN417.
1. 2SHQWKHFDUWULGJHFRYHU
2. Make sure ignition knob is in
“OFF” position and cartridge
OHYHULVLQ´81/2&.µSRVLWLRQ
(Fig.9). If the ignition knob is not
completely in “OFF”
SRVLWLRQWKHFDUWULGJHFDQQRWEH
engaged into “LOCK” position.
OFF

3. Place the cartridge into the compartment. Align the cartridge
properly by inserting the cartridge guide tab of the unit into
the cartridge slot on the rim of the canister. (Fig.10)
4. Lock in place by pushing the
FDUWULGJHOHYHUGRZQWR´/2&.µ
position and then close the
FDUWULGJHFRYHUFig.11)
5. Check that the cartridge is
SRVLWLRQHGSURSHUO\DQGWKH
FDUWULGJHOHYHULVLQWKH´/2&.µ
position.
 <RXFDQQRZWXUQRQWKH
unit. Turn the control knob
anti-clockwise until you hear a
¶&OLFN·5HSHDWLIQHFHVVDU\
after waiting 20 seconds.
(Fig.12)
CAUTION:
Incorrect positioning of the gas cartridge will cause the burner to
break and/or leak which will produce hissing sound and a smell
RIJDV,QWKLVFDVHSOHDVHIROORZWKH´/HDN7HVWµ
!
CAUTIONS
MAKE SURE THE
CARTRIDGE SLOT
IS POINTING UPWARD
Cartridge Slot
Cartridge Guide
Fig.10
6
Fig.11
Fig.12
LOAD
UNLOCK
LOCK
OFF

LEAK TEST
7KHOHDNWHVWPXVWEHFDUULHGRXWLQDZHOOYHQWLODWHGDUHDIUHH
IURPDQ\ÁDPHVRURWKHUVRXUFHVRILJQLWLRQ
• With the cartridge installed in
WKHFRRNHURSHQWKHLJQLWRU
knob.
• Brush the connections (cooker
to cartridge) with a solution of
equal parts soap and water
PDNHVXUHLW·VIRDP\
• A stream of bubbles forming
indicates a gas leak.
6HHFig.13)
• ,IEXEEOHVDSSHDUWXUQWKH
LJQLWLRQNQRE´2))µFORFN-
wise) and unlock the cartridge
ORFNOHYHUWRWKHXSZDUGSRVL-
WLRQDQGUHPRYHDQGLVRODWH
the gas cartridge.
• 5HLQVWDOOWKHJDVFDUWULGJH
making sure the cartridge slot
is pointing upward and retry
the leak test.
• If you are unsure or if you can-
not install the cartridge without
DOHDNRFFXUULQJSODFHWKH
butane cartridge outside in a
FRROZHOOYHQWLODWHGDUHDDQG
FRQWDFW$OYDRQ086 100 ALVA
(2582).
• A leak between the cooker
DQGFDQLVWHUFDQOHDGWRDÀUH
ZKLFKLVYHU\GDQJHURXVDQG
FDQUHVXOWLQH[WHQVLYHLQMXU\RU
HYHQGHDWK
USING YOUR BUTANE BBQ COOKER
+RZWRLJQLWH\RXUEXWDQH%%4FRRNHU
7XUQWKHLJQLWLRQNQREFRXQWHUFORFNZLVHXQWLO\RXKHDUD¶FOLFN·
sound.
• ,IWKHEXUQHUGRHVQRWOLJKWUHSHDWWKHLJQLWLRQSURFHGXUH
• Flaring may occur during the warm up period or if the
DSSOLDQFHLVPRYHGGXULQJXVH7KHÁDULQJZLOOVWRSZLWKLQ
RQHPLQXWHRUZKHQLWLVQRORQJHUEHLQJPRYHG
Fig.13
Foamy
bubbles
indicate a
leak
Connection
in assembly
Connections to be leak tested
Canister into Appliance
PRECAUTIONS
Leak test all
connections after each
canister installation.
NEVER check for
leaks with a match or
RSHQÁDPH
Any Butane cartridge
not connected for use
must not be stored in
the vicinity of this or
any other appliance.
7

&RQWUROOLQJWKHÁDPH
7KHVL]HRIWKHÁDPHFDQEH
regulated by turning the ignition
knob slowly toward “OFF”
position from (MAX) position.
(Fig.14)
([WLQJXLVKLQJWKHÁDPH
Turn the ignition knob clockwise
WR´2))µSRVLWLRQ7KHÁDPHLV
automatically cut off and no gas will
be supplied (Fig.15).
• 7KHÁDPHZLOOEHH[WLQJXLVKHG
before the ignition knob is
turned completely to “OFF”
position.
• &KHFNWRHQVXUHWKHÁDPHLV
extinguished
5HPRYLQJWKHEXWDQHFDUWULGJH
5DLVHWKHFDUWULGJHOHYHUXSWRWKH´81/2&.µSRVLWLRQ
2SHQWKHFDUWULGJHFRYHUDQGWKHQWDNHWKHFDUWULGJHRXW
Ensure the ignition knob is at “OFF” position. (Fig. 16)
Burning off remaining fuel
6RPHJDVPD\UHPDLQLQWKHJDV
cooker fuel the unit has been
WXUQHGRII)RU\RXUVDIHW\ZLWKWKH
FDUWULGJHOHYHULQ´81/2&.µ
SRVLWLRQWXUQLJQLWLRQNQREWR
(MAX) position to burn off any
remaining fuel. (Fig. 17)
DO NOT use metal
utensils on the
non-stick BBQ Grill,
as they will damage
the non-stick surface.
DO NOT store or use
gasoline or other
ÁDPPDEOHYDSRXUV
and liquids in the
vicinity of this or any
other appliance
8
Fig.14
Fig.15
Fig.16
Fig.17
OFF
OFF
OFF
OFF

9
THE AUTO SAFETY DEVICE
,QWKHFDVHRIORQJWHUPRUH[FHVVLYHKHDWQHDUWKHJDVFDU-
WULGJHSUHVVXUHZLOOEXLOGXSWRVHWRIIWKHVDIHW\GHYLFH7KHJDV
FDUWULGJHLVDXWRPDWLFDOO\HMHFWHGLQWKHHYHQWRIRYHUSUHVVXUHLQ
WKHJDVFDUWULGJHDQGWKHÁDPHZLOOEHH[WLQJXLVKHG7KHXQLWZLOO
not operate until the gas pressure of the cartridge returns to the
normal range.
+RZWRUHVHWWKHDXWRVDIHW\GHYLFH
1. Turn the control knob to the “OFF” position
2. 5HPRYHWKHJDVFDUWULGJH
3. Turn the ignition knob to the (MAX) position and wait for 5
minutes to release any excess gas inside the unit.
4. Return the ignition knob back to the “OFF” position.
5. 3XVKWKHFDUWULGJHOHYHUGRZQWRWKH´/2&.µSRVLWLRQDQG
then release it back to the “UNLOCK” position.
6. 'HWHUPLQHWKHFDXVHRIRYHUSUHVVXUHLHFRRNHUXVHGLQ
VWURQJGLUHFWVXQOLJKWLQVXIÀFLHQWYHQWLODWLRQHWF
7. 0DNHQHFHVVDU\DGMXVWPHQWVWRORFDWLRQSRWSDQXVHG
DQGLIQHFHVVDU\DOORZWKHJDVFDUWULGJHWRFRROEHIRUH
re-installing. Another option is to install a fresh cool gas
cartridge.
8. Follow the procedures for installing the gas cartridge and
LJQLWLRQWKHQUHLJQLWH
CARE AND MAINTENANCE
• %HIRUHFDULQJIRURUFOHDQLQJ\RXUEXWDQH%%4FRRNHU
make sure that the ignition knob is in the “OFF” position. If
WKHFRRNHULVVWLOOKRWZDLWIRULWWRFRROGRZQEHIRUH
cleaning.
• (QVXUHWKDWWKHUHDUHQRVLJQVRIEORFNDJHHJGHEULV
LQVHFWVHWFLQHLWKHUWKHEXUQHUSRUWKROHVWKHSULPDU\DLU
inlet or the neck of the iron burner. Use compressed air or
pipe cleaner wire to clear obstructions. A copper wire brush
FDQEHXVHGWRUHPRYHFRUURVLRQIURPWKHEXUQHUVXUIDFHV
%UXVKLWDIWHUZDUGVOLJKWO\ZLWKFRRNLQJRLOWRSUHYHQWWKH
formation of rust while storing.
:(5(&200(1'7+$77+,66+28/'%('21($)7(5
(9(5<&22.,1*6(66,21,1&2$67$/$5($6
Taking care of your cooker will prolong its lifespan.
Cleaning & maintenance
1. The unit must be cleaned after each use and maintained
DWOHDVWRQFHHYHU\VL[PRQWKV7KHXQLWPXVWRQO\EH
VHUYLFHGE\DOLFHQFHGVHUYLFHSURIHVVLRQDO

 )RUUHSDLUVVSDUHSDUWVRUVHUYLFHRIWKHDSSOLDQFHSOHDVH
contact 086 100 ALVA (2582).
 :KHQ\RXQRWLFHDVPDOOÁDPHRUQRÁDPHZKHQ\RXXVH
DQHZFDUWULGJHLWPD\EHWKDWWKHLQMHFWRULVWRRGLUW\RU
HYHQEORFNHG<RXFDQFOHDQWKHLQMHFWRUZLWKDQHHGOHWKLQ-
ner than 0.47mm or you can call the after-sales centre for
DGYLFH
%%4JULOO
7KH%%4*ULOOKDVDQRQVWLFNFRDWLQJ:DVKLQZDUPZDWHUZLWK
PLOGGHWHUJHQWDQGDVRIWFORWK'2127XVHDEUDVLYHVFRXUHUV
or cleaning agents as they will damage the non-stick surface.
Cooker body
 $IWHUXVLQJWKHXQLWLWPD\EHYHU\KRW3OHDVHZDLWIRUDW
OHDVWPLQXWHVEHIRUH\RXPRYHRUVWRUHLW
2. Ensure the unit is clean at all times. Only clean the unit after
WKHJDVFDUWULGJHLVUHPRYHGDQGWKHXQLWKDVFRROHG&OHDQ
the cooker body using a damp cloth. Use kitchen detergent
if necessary. Wipe dry.
Pan support and drip tray
5HPRYHWKHSDQVXSSRUWDQGGULSWUD\DQGFOHDQZLWKZDUPZDWHU
and kitchen detergent if necessary.
Burner head and surroundings
6RLOGLUWRLOGXVWJULPHHWFFDQFORJWKHEXUQHUDQGDIIHFWWKH
ÁDPH&OHDQWKHEXUQHUKHDGZLWKDPHWDOEUXVKDQGNHHSRXWRI
water.
Ignition plug
Keep clean and dry. Clean with a dry cloth.
6WRULQJRIWKHDSSOLDQFH
:KHQWKHDSSOLDQFHLVQRWLQXVHSOHDVHNHHSLWLQDVDIHSODFH
where:
 LWFDQ·WEHSUHVVHGE\RWKHUDSSOLDQFHV
 LWLVVDIHIURPGXVWDQGGLUW
 LWFDQEHNHSWGU\
4. it is safe from heat and direct sunlight.
FLASHBACKS
,QWKHHYHQWRIÁDVKEDFNZKLOVWWKHDSSOLDQFHLVLQXVHWXUQDOO
the controls to the “OFF” position.
Wait 5 minutes before attempting to relight the appliance. If the
SUREOHPSHUVLVWVFKHFNIRUEORFNDJHVDQGHQVXUHWKHFDUWULGJH
has been installed correctly. If problem persists do not try to rec-
tify the problem yourself as this could result in serious injury and/
RUSURSHUW\GDPDJH5HPRYHWKHFDUWULGJHIURPWKHDSSOLDQFH
and please contact our customer care department on 086 100
ALVA(2582)
DO NOT use steel
based products or
brushes - these
contaminate the cast
iron and can cause
rust.
DO NOT use pot
scourers or abrasive
cleaning products on
this cooker as these
will permanently
mark the cooker and
damge the non-stick
BBQ Grill
The burner supplied
with your cooker is
considered to be a
consumable spare.
Frequency of use,
environmental factors
and failing to follow
the cleaning and care
instructions in this
manual may cause
your cooker burner to
corrode.
This is not considered
a manufacturing fault,
but rather normal wear
and tear and is not
covered under our
warranty.
Should you need to
replace your burners
please contact our
customer care
department,
086 100 ALVA(2582)
10

TROUBLE SHOOTING GUIDE
Trouble and Causes
Ignition knob
is not turned to
“OFF” position
6DIHW\'HYLFH
$FWLYDWHG
Ignition Knob
malfunction
Clogged nozzle
Cartridge
incorrectly
installed
Clogged burner
holes
Bent or rusty
electrode
No gas
Trouble shooting
&$86(6 62/87,216
Ignition knob is not turned to
(MAX) position
Turn ignition knob completely to
“OFF” and reset cartridge
6DIHW\'HYLFH$FWLYDWHG Refer to explanation for Auto
6DIHW\'HYLFHPage.8)
Ignition Knob malfunction Contact 086 100 ALVA (2582)
Clogged nozzle Contact 086 100 ALVA (2582)
Cartridge incorrectly installed Fit cartridge guide into cartridge
slot
Clogged burner holes Clean with a metal brush
Bent or rusty electrode Clean electrode
No gas Replace Butane cartridge
Extinguished during operation No ignition/ faulty ignition 8QHYHQÁDPH /RZÁDPH 6PHOOJDV at “OFF” position
No gas supplied at (MAX) position Cartridge will not install
11
TROUBLE
&$86(6
Should you experience
problems with this
butane BBQ cooker,
carry out the neces-
sary checks as per
the Trouble Shooting
Guide.
If you are still unable
to correct the problem
with the information in
this guide, then you
need to contact your
nearest dealer or our
customer care
department,
086 100 ALVA (2582).

12
SPECIFICATIONS
Model CCR111 M
Description %%4FDQLVWHUFRRNHU
*DV Butane gas
Injector size 0.56mm
+HDWLQSXW 2.2kW
*DVFRQVXPSWLRQDW0D[ 160gr/hr
+HDWHIÀFLHQF\ 58%
$Q\PRGLÀFDWLRQWRWKH%%4FRRNHUPD\FDXVHLQMXU\
or property damage.
$Q\PRGLÀFDWLRQWRWKH%%4FRRNHUZLOOLQYDOLGDWHWKHZDUUDQW\
on this appliance.
AFTER SALES SERVICE
0$18)$&785(')25$1'',675,%87('%<$/9$
DGLYLVLRQRI6WLQJUD\$FFHVVRU\0DQXIDFWXUHUV3W\/WG
P.O. Box 30014
7RNDL
Tel: [phone]
E-mail: [e-mail]
ZZZDOYDFR]D
DOYDJDV
ZZZIDFHERRNFRP$OYD*DV
TOLL FREE NUMBER
086 100 ALVA (2582)