AQUARION AQ111 User manual

Doc. No.: 01999986
Revision: D 1 of 4
Issue Date: 08/15/21
INSTALLATION
•
OPERATION
•
MAINTENANCE MANUAL
SELF-CONTAINED EYEWASH STATION
AQUARION® AQ111 FILL KIT
INSTALLATION INSTRUCTIONS
Instructions for filling the eyewash cartridges
1. Open the AQ111 box. Inside you will find two expiration date labels, a funnel, and two eye wash cartridges with a few
ounces of Hydrosep® in each bag.
Figure 1: Fill Kit packed in Box.
2. On one of the box flaps you will see a perforated cut. Press firmly on the perforated area to remove the cardboard.
Figure 2: Perforation cut out.
3. With the bag laid out on a flat, stable surface, insert the valve of the Aquarion® bag through the hole and slide it back
into the thinner slot to keep the bag in place.

Doc. No.: 01999986
Revision: D 2 of 4
Issue Date: 08/15/21
Figure 3: Aquarion® valve slid into slot.
4. Removed the tamper evidence seal, compress the white push button and then remove the plug/cap.
Figure 4: Seal removed, button compressed and cap removed.
5. Place the funnel in the open valve and press down gently to secure it in place.
6. Fill the bag with 4.0-4.2 gallons of deionized potable water (15.1-15.9 L).
Note: Filling the cartridge with the correct amount of water is critical to the system meeting the ANSI Z358.1
Standard.

Doc. No.: 01999986
Revision: D 3 of 4
Issue Date: 08/15/21
Figure 5: Funnel installed for filling.
7. Gently lift the bag by the fill port to allow any air bubbles to escape.
8. Replace the cap in the port; it will be secure when the cap clicks into place.
9. Write the date filled on the Aquarion® label provided and place it on the bag.
Note: If at any time the system is activated, the entire cartridge must be replaced as this is a onetime use cartridge.
(Fig. 6) Aquarion® expiration label.
10. See Installation, Operation, Maintenance Manual 01999972 for instructions on installing the cartridges.

Doc. No.: 01999986
Revision: D 4 of 4
Issue Date: 08/15/21
PROPOSITION 65
WARNING: This product can expose you to BPA, which is known to the State of California to cause birth defects or other
reproductive harm. For more information go to www.P65Warnings.ca.gov.
WARRANTY STATEMENT
ENCON HEREBY DISCLAIMS ALL WARRANTIES EXPRESSED OR IMPLIED INCLUDING BUT NOT LIMITED TO
WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, AND NON-INFRINGEMENT OF THIRD-
PARTY RIGHTS, EXCEPT AS HEREINAFTER PROVIDED.
Encon Safety Products warrants that for one year from the date of purchase of any Encon products, the product will be free of
defects in materials and workmanship if properly used and cared for or cleaned under normal conditions in accordance with
Encon’s use and care instructions and properly installed, if applicable, in accordance with Encon’s installation instructions. With
respect to the product, Encon’s only obligation and purchaser’s exclusive remedy under this warranty is to repair or replace such
product; provided that:
1. Encon is notified of the defect within one year of shipment, and
2. the product is determined by Encon to be defective.
Encon requires proof of original ownership as proof of warranty coverage, and Encon must receive any claim under this Limited
Warranty within one year of purchase of the product.
NOTWITHSTANDING ANYTHING TO THE CONTRARY CONTAINED HEREIN, ENCON SHALL NOT BE LIABLE FOR LOSS,
DAMAGE, OR EXPENSE ARISING DIRECTLY OR INDIRECTLY AS A CONSEQUENCE OF USE OF THE EQUIPMENT WITH
OTHER PRODUCTS OR FROM ANY OTHER CAUSE, INCLUDING ANY CONSEQUENTIAL, INCIDENTAL, SPECIAL OR
EXEMPLARY DAMAGES, EXCEPT FOR ENCON’S OBLIGATION TO REPAIR OR REPLACE DEFECTIVE PRODUCTS AS
EXPRESSLY PROVIDED IN THIS STATEMENT.
Replacement parts purchased from Encon are warranted for one year following the shipment of such replacement part, or until
the expiration of the warranty period for the product, whichever is less. No warranty is given in connection with products that are
altered without Encon’s expressed written consent. The same warranty limitations and the obligations of Encon as set out herein
above shall apply to replacement parts.
Encon’s total liability arising out of this warranty (including, but not limited to, warranty claims) regardless of forum and regardless
of whether such action or claim is based on tort, contract or otherwise will not exceed the total purchase price of the product.
6825 W. Sam Houston Pkwy. N
Houston, TX 77041
1-800-AT-ENCON / 1-800-283-6266
[email protected]
http://www.enconsafety.com