Arrow Revolution User manual

For Technical Assistance contact contact ARROW LOCK
sWWWARROWLOCKCOM
INSTALLER NOTE:
&AILURETOFOLLOWTHESEINSTRUCTIONSCOULDRESULTIN
DAMAGETOTHELOCKANDVOIDTHEFACTORYWARRANTY
¥!22/7,OCK$OOR(ARDWAREs2EV#
Touchpad Access Cylindrical Lock
Installation Instructions
4HISDOCUMENTISAVAILABLEONOURWEBSITEINPRINTED3PANISHAND&RENCH'OTOWWWARROWLOCKCOM
#LICK,ITERNATURE2EQ
%STEDOCUMENTOESTÉDISPONIBLEENESPA×OLENNUESTRAPÉGINADEINTERNET6AYAAWWWARROWLOCKCOM
0RESIONE)NFORMACIØNDEL0RODUCTOY$OCUMENTACIØN
#EDOCUMENTESTDISPONIBLESURNOTRESITE7EBDANSLEFRANAISIMPRIMÏ!LLEZÌWWWARROWLOCKCOM
#LIQUEZSURLE)NFORMATIONSURLEPRODUITET$OCUMENTATION

2
¥!22/7,OCK$OOR(ARDWAREs2EV#
#!54)/.#HANGESORMODIlCATIONSTOTHISUNITNOTEXPRESSLYAPPROVEDBYTHEPARTY
RESPONSIBLEFORCOMPLIANCECOULDVOIDTHEUSERSAUTHORITYTOOPERATETHEEQUIPMENT
)-0/24!.44HEACCURACYOFTHEDOORPREPARATIONISCRITICALFORTHEPROPERFUNCTIONING
ANDSECURITYOFTHISCYLINDRICALPRODUCT-ISALIGNMENTCANCAUSEPREMATUREWEARANDA
LESSENINGOFSECURITY
&INISH#ARE4HISLOCKSETISDESIGNEDTOPROVIDETHEHIGHESTSTANDARDOFPRODUCTQUALITY
ANDPERFORMANCE#ARESHOULDBETAKENTOINSUREALONGLASTINGlNISH7HENCLEANING
ISREQUIREDUSEASOFTDAMPCLOTH5SINGLACQUERTHINNERCAUSTICSOAPSABRASIVECLEANERS
ORPOLISHESCOULDDAMAGETHECOATINGANDRESULTINTARNISHING
TABLE OF CONTENTS
7!2.).'3
).42/$5#4)/.
!RROW2EVOLUTION3TANDALONE4OUCHSCREEN!CCESS,OCKCOMBINESROBUSTCYLINDRICAL
LOCKSETSWITHACONTEMPORARYELECTRONICAESTHETIC
5SERSBENElTFROMANINTERACTIVETOUCHSCREENTHATMAKESDAYTODAYACCESSEFFORTLESSAND
OFFERSVOICEGUIDEDPROGRAMMINGFORSIMPLEUPDATESTOUSERINFORMATIONINTHEEVENTOF
STAFlNGCHANGESORSECURITYBREACHES
2EVOLUTION ISENGINEEREDFORQUICKANDEASYINSTALLATIONANDlTSINTOTHESTANDARD!.3)
"(-!!CYLINDRICALLOCKSWITHLEVERDOORPREPWITHONLYONEADDITIONALHOLE
ANDSCREWSINCLUDINGLATCHBOLTANDSTRIKE
2EVOLUTION FEATURESTHECHOICEOF%ASYOR!DVANCEDOPERATINGMODES,OCKSARE
SHIPPEDASADEFAULTFROMTHEFACTORYIN%ASYMODE4HEDESIREDOPERATINGMODESHOULD
BEDETERMINEDBEFORETHECOMPLETIONOFLOCKINSTALLATIONBUTCANBECHANGEDATALATERTIME
IFREQUIRED
7ARNINGS2
)NTRODUCTION2
Installation
#OMPONENTSAND4OOLS
$OOR0REPARATION
0REPARE,OCKFOR)NSTALLATION 5-6
)NSTALL,OCK 
(ARDWARE4ROUBLESHOOTING8
0ROGRAMMING
0ROGRAMMING&EATURES-ENUS+EYS$ElNITIONS 9-11
/PERATING-ODES 12-16
%ASY-ODE 
!DVANCED-ODE 
-ISCELLANEOUS)NFORMATION
0ROGRAMMING4ROUBLESHOOTING18
3AMPLE0IN#ODE-ANAGEMENT3HEETS19


¥!22/7,OCK$OOR(ARDWAREs2EV#
Lock Installation
PHILLIPSSCREWDRIVER
,EVERREMOVALTOOLSUPPLIED
ORDRILL
!LLENWRENCHSUPPLIED
Door Prep
MMHOLESAW
MMBORINGBIT
MMDRILLBIT
MMDRILLBIT
#HISELANDHAMMER
Parts Illustrations
Tools
1UICK3TART)NSTRUCTIONS
Installation Instructions
$OOR-ARKER
/UTSIDE4OUCHSCREEN!SSEMBLY
)NSIDE%SCUTCHEON!SSEMBLY
s )NSIDE3UPPORT!SSEMBLY
s )NSIDE%SCUTCHEON
s )NSIDE,EVER(ANDLE
s "ATTERY#OVER
!!!LKALINE"ATTERIES
,ATCHBOLT
3TRIKE
!LLEN7RENCHMM
,EVER2EMOVAL4OOL
3CREW0ACKSCREWS
+EYS)FCYLINDERINCLUDED
In the box, you should find. . .
#/-0/.%.43!.$4//,3
Outside
Touchscreen
Assembly
Inside
Support
Assembly
Inside
Escutcheon
Inside
Lever
Handle
Battery Cover
4 AA Alkaline
Batteries
Latchbolt
Strike


¥!22/7,OCK$OOR(ARDWAREs2EV#
6ERIFYBACKSETBEFOREMARKINGANDDRILLINGDOOR
! -ARKHORIZONTALLINEACROSSEDGEOFDOOR
MMFROMmOOR
" &OLDDOORMARKEROVERTHEEDGEOFTHEDOORCENTERING
ONTHEHORIZONALLINE
# -ARKCENTERSOFHOLESATPROPERBACKSET&ORBEVELED
ANDSQUAREEDGEDOORSMARKBOTHSIDESOFTHEDOOR
$IAMETER

"ACKSETOR
! $RILLMMDIAHOLETHROUGHTHEDOOR
#UTNOTCHESASSHOWNONTEMPLATE
Note: To avoid splintering wood doors, drill holes (A) and
(D) from both sides of the door.
" $RILLMMDIAMETERHOLETHROUGHTHEDOORACCORDING
TODOORMARKER
# $RILLMMDIAMETERHOLEINEDGEOFDOOR-ORTISEFOR
LATCHBOLTFRONTMMWIDEXMMHIGH
BYDEEP
$ $RILLTWOMMDIAMETERHOLESTHROUGHDOOR
SEENOTEABOVE
% $RILLPILOTHOLESFORLATCHBOLTSCREWSMM
A
C
E
D
! #LOSETHEDOORANDMARKAHORIZONTALLINEFROMTHECENTER
OFTHETEMPLATETOTHEFRAMEOFTHEDOOR
" -EASUREHALFTHETHICKNESSOFTHEDOOR-ARKTHISSAME
DISTANCEWITHAVERTICALLINESTARTINGFROMTHESTOPSIDE
OFTHEFRAME7HEREBOTHLINESCROSSMAKEAMM
DIAMETERHOLEMMINDEPTH
# !LIGNTHEHOLESOFTHESTRIKEWITHTHEVERTICALLINE
4RACETHEOUTLINEOFTHESTRIKEANDMORTISEWITH
AMMDEPTH!TTACHTHESTRIKEWITH
TWOSCREWSPROVIDED
$//202%0!2!4)/.
B
Mark Door
Drill Door
Prepare and Install Strike (Wood Frames Only)
Strikes
6
/PTIONAL3TRIKE
"OX6
!TTACHING3CREWS
81-2012-0620
X
6
3TANDARD
3TRIKE"OX
!TTACHING3CREWS

X
B
C
A

5
¥!22/7,OCK$OOR(ARDWAREs2EV#
4HELOCKISPACKEDREPRESENTATIVEOFHOWITWILLINSTALLONTHEDOOR
Before installation:
!$ISASSEMBLETHEINSIDEESCUTCHEON
2EMOVETHEINSIDELEVERWITHTHELEVERREMOVALTOOLPROVIDED
3EPARATETHEINSIDESUPPORTASSEMBLYFROMTHEINSIDEESCUTCHEON
"2EMOVETHEBATTERYCOVER
5NSCREWTHEHEXSCREWUSINGTHE!LLENWRENCHPROVIDED4HEHEXSCREWDOES
NOTCOMECOMPLETELYOUT
3LIDETHEBATTERYCOVEROFF
4HEOUTSIDEASSEMBLYSTAYSASSEMBLED
&ACETHEDOORFROMTHESECURESIDETODETERMINEITSHAND4HESECURESIDEISTHETOUCHSCREEN
SIDEOFANENTRANCEDOORORTHECORRIDORSIDEOFAROOMDOOR
.OTE2EVOLUTIONLOCKSARENONHANDEDTHELEVERCANBEmIPPEDAROUNDTOTHEDESIREDHAND-
ING
Left Hand Reverse
(INGESONLEFT
/PENSOUTWARD
&ORHANDEDLOCKS
SPECIFY,(2
Left Hand
(INGESONLEFT
/PENSINWARD
&ORHANDEDLOCKS
SPECIFY,(
Right Hand
(INGESONRIGHT
/PENSINWARD
FORHANDEDLOCKS
SPECIFY2(
Right Hand Reverse
(INGESONRIGHT
/PENSOUTWARD
&ORHANDEDLOCKS
SPECIFY2(2
PREPARE LOCK FOR INSTALLATION
Unpack the Lock
Determine Hand of the Door
Inside
Support
Assembly
Inside
Escutcheon Inside
Lever
Handle
Battery
Cover
Support
Assembly
Screws

6
¥!22/7,OCK$OOR(ARDWAREs2EV#
,OCKISPACKEDPREADJUSTEDFORMMDOORS
4OADJUSTFORTHINNERDOOR
!2EMOVESCREWSFROMOUTSIDE
SUPPORTASSEMBLY
"3LIDEOUTSIDEASSEMBLYAWAY
FROMTHELOCKBODY
#$ISENGAGEPLATEFROMASSEMBLY
BYSLIDINGTOTHESIDEANDREMOVING
$2ESEATPLATEONOUTSIDEASSEMBLY
0LATEHOLEISSLIGHTLYOFFCENTER
GRAYAREA3LIDEPLATEOVER
ASSEMBLYANDSLIDETOTHECENTER
UNTILSEATEDINONEOFTHETWOGROOVES
%!DJUSTFORDOORTHICKNESSBY
SEATINGPLATEINGROOVESON
ASSEMBLYTOMATCHDOORTHICKNESS
&2ESEATPLATEONASSEMBLY
'&ASTENPLATEANDOUTSIDEASSEMBLYTOLOCKBODYWITHSCREWS
Adjust Lock for Door Thickness (If Necessary)
2EMOVECYLINDERHANDLE
!)NSERTKEYANDROTATEDEGREESCOUNTERCLOCKWISE
")NSERTLEVERRETAINERTOOLANDPUSH
#3LIDELEVEROFFLOCK
2EMOVETHEPLASTICSLEEVEFROMTHEOLDCYLINDER
3LIDENEWCYLINDERINTOSLEEVE
)NSERTKEYINTOCYLINDER
)MPORTANT-AKESURETHEKEYCUTSIDEOFKEYLINES
UPFACINGTOWARDSTHEENDOFTHELEVER)FTHEKEYIS
INSERTEDINCORRECTLYTHELOCKWILLREASSEMBLEAND
MIGHTAPPEARTOPROPERLYWORKHOWEVERWHENTHE
KEYISREMOVEDTHELATCHBOLTWILLREMAINRETRACTED
2OTATEKEYDEGREESCOUNTERCLOCKWISE
$EPRESSRETAINERPLATEPUSHTHEHANDLEONTOTHESHANKUNTILFULLYSEATED
0ULLONHANDLETOINSUREPROPERLYSEATED
&ORPINCYLINDERSTHICKDOORS
&ORPINCYLINDERSTHICKDOORS/.,9
&ORPINCYLINDERSTHICKDOORS
&ORPINCYLINDERSTHICKDOORS/.,9
CAUTION: The cylinders furnished with Revolution lock for use in 1-3/8" doors have a tailpiece
that is 1/4" shorter than the standard cylinders that are furnished for 1-3/4" doors. Trying to
install a standard cylinder in 1-3/8" will DAMAGE the lock body.
How to Replace, Re-Key or Install Cylinder
0OSITIONFOR
THICKDOORS
0OSITIONFOR
THINDOORS
C
A
E
B
3LIDE0LATETORESEATINGROOVES
$
A
C
B
+EYCUT
F
'


¥!22/7,OCK$OOR(ARDWAREs2EV#
Outside Assembly
Touchscreen
Cable
Escutcheon Screw
X0AN(EAD
With Star Washer ScreW
3
3b
4
5
9
10
11
12
13
Motor Cable
Support Assembly Screws
X&LAT
(EAD-ACHINE3CreWS
Inside Assembly
3a
1
INSTALL LOCK
)NSTALLLATCHBOLTINDOOR"ESURETHATBEVEL
EDGEOFBOLTFACESSTRIKE!TTACHWITHTWO
SCREWSSUPPLIED
)NSTALLSTRIKEONTHEDOORFRAME
)NSERTOUTSIDEASSEMBLYTHROUGHDOOR
MAKINGSURETHATTHELOCKBODYFRAME
HOOKSLATCHCASEANDRETRACTORENGAGES
BOLTTAILS$/./4&/2#%3EE$ETAIL!
ABOVE)FLOCKBODYDOESNOTENGAGELATCH
EASILYCHECKDOORPREPARATIONFORERRORS
A'UIDEMOTORCABLEREDANDBLACKWIRES
THROUGHDIAMETERHOLE
B'UIDETOUCHSCREENCABLETHROUGH
DIAMETERUPPERHOLE
'UIDEMOTORCABLETHROUGHRECTANGULAR
HOLEONINSIDESUPPORTASSEMBLY
3LIDEINSIDESUPPORTASSEMBLYOVEROUTSIDE
ASSEMBLYLININGUPTOPANDBOTTOMSCREW
GUIDESWITHHOLESINDOOR3ECUREBOTH
ASSEMBLIESWITHXmATHEAD
MACHINESCREWS$ONOTOVERTIGHTEN
!TTACHMOTORCABLECONNECTORTOTHE
INSIDEESCUTCHEON0#BOARDHEADER
MARKEDh-/4/2v
!TTACHTHETOUCHSCREENCABLECONNECTORTO
THEINSIDEESCUTCHEON0#BOARDHEADER
ASILLUSTRATED
3ELECTEASY or ADVANCED Mode USINGTHE
SWITCHONTHEBACKOFTHE0#BOARD
Directions
EASY
EXT-PWR / REMOTE / MOTOR
Easy /
Advanced
Mode
ADVANCED
Touchscreen
Cable
Connector
EXT-PWR / REMOTE / MOTOR
6
8 7
9b Touchscreen Cable
Routing
"Z" Fold
2
1
(2) 8-32 x 3/4"
Flat Head
Combination Screws
(2) 8-32 x 3/4"
Flat Head
Combination Screws
Retractor
%NGAGES
"OLT4AILS
,OCK"ODY
&RAME
%NGAGES
Latchcase
Latch
Detail A

8
¥!22/7,OCK$OOR(ARDWAREs2EV#
#YCLETHELOCKINBOTHTHELOCKEDANDTHEUNLOCKEDPOSITIONS)FPROBLEMSAREFOUND
(!2$7!2%42/5",%3(//4).'
3LIDEINSIDEESCUTCHEONOVERINSIDE
SUPPORTASSEMBLY
CAUTION:
A0OSITIONMOTORCABLEAGAINSTINSIDE
SUPPORTASSEMBLY!VOIDPINCHINGWIRES
AGAINSTTHESTEELSHANKOFTHEASSEMBLY
Bh:vFOLDTOUCHSCREENWIRECABLEANDLAY
AGAINSTTHEBACKRECESSEDAREAOF
THEESCUTCHEONASSEMBLY0OSITIONAND
BENDWIRESTOPREVENTBINDINGWHEN
INSTALLINGTHEESCUTCHEONOVERTHE
SUPPORTASSEMBLY
)NSTALLANDSECURETHEXPAN
HEADSCREWTHROUGHTHECENTEROFTHE
BATTERYHOUSINGINTOTHEBARRELNUTOF
THEOUTSIDEASSEMBLY
3LIDEONINSIDELEVERANDPUSHINTOATTACH
)NSERTFOUR!!ALKALINEBATTERIES4HE
LOCKRESPONDShWelcome to the Arrow
Digital Worldv
Note: Refer to programming instructions prior to
completion of step 13.
)NSTALLBATTERYCOVERANDTIGHTENHEXHEAD
SCREWWITH!LLENWRENCHPROVIDEDWITHLOCK
Directions, Continued
Symptom Suggested Action
Door is binding a.Check that door and frame are properly aligned and door is free swinging.
b. Check hinges: They should not be loose or have excessive wear on knuckles.
Latchbolt will not deadlock a. Either strike is out of alignment or the gap between the door and jamb is too great.
Realign strike or shim strike out towards flat area of latchbolt.
Latchbolt does not retract or extend properly Latchbolt tail and retractor are not properly positioned:
a. Remove lockset. Look though 2-1/8" hole and verify latchbolt tail is centered
between top and bottom of hole.
b. Remove latchbolt and insert lockset. Look though latchbolt hole and verify retractor
mouth centered in hole. If not, adjust outside rose plate.
c. If necessary, rebore holes to line up retractor and tail.
Test the Operation of the Lockset

9
¥!22/7,OCK$OOR(ARDWAREs2EV#
PROGRAMMING
02/'2!--).'&%!452%3-%.53+%93$%&).)4)/.3
6OLT"ATTERIES0URCHASED3EPARATELY
(%83CREW
I"UTTON
!!
!LKALINE
Batteries
3PEAKER
3TATUS,%$
"ATTERY#OVER
Outside Inside
6OLT
%MERGENCY0OWER
3UPPLY4ERMINAL
0ASSAGE-ODE
#YLINDER
Lockout
-ODE
,OW
"ATTERY
Touchscreen
.UMBERS 0+EY
2EURNTO0REVIOUS
0ROGRAMMING&EATURES-ENUS+EYS$ElNITIONS 9-11
/PERATING-ODES 12-16
%ASY-ODE 
!DVANCED-ODE 
-ISCELLANEOUS)NFORMATION
0ROGRAMMING4ROUBLESHOOTING18
3AMPLE0IN#ODE-ANAGEMENT3HEETS19

10
¥!22/7,OCK$OOR(ARDWAREs2EV#
Menu and Icons
Touch the screen with palm of hand or
fingers to begin and end actions.
Enter Master PIN code (6 digits in length).
Advanced Mode only. Factory default: 123456.
Click the indicated number. Enter Supervisor PIN code. Can be 4-12 digits
in length. Factory default: 1234567890.
Press the Star key on the touchscreen to
Enter or Accept entry.
Enter User PIN. Can be 4-12 digits in length.
Press the Pound key on the touchscreen to
enter Menu mode.
Supervisor Serial Number (00 - 19).
Advanced Mode only.
Press this key to return to the previous
step or menu setting.
User Serial Number (01 - 49).
Advanced mode only.
Repeat operation using settings indicated. Enter value 1 - 10 (times or seconds).
The I-Button is located under the battery
cover. Remove battery cover for access.
Enter value 1 - 255 (seconds).
Slide the batter cover up and off. Voice guide.
S
M
U
~
Passage Mode
2
Low Battery
1Lockout Mode
3Lock and Unlock - Audio and Visual
5
Return to Previous Step
4
Advanced Mode3EE!DVANCED-ODEONPAGE
All Code Lockout!DVANCEDMODEONLY4HISFEATUREISENABLEDONLYBYTHE-ASTERCODE
7HENENABLEDITRESTRICTSALLUSER0).CODEACCESS7HENTHEUNITISIN,OCKOUTTHE
REDLOCKEDPADLOCKWILLAPPEARONTHESCREEN
Easy Mode3EE%ASY-ODEONPAGE
Emergency Power Supply6BATTERYCONNECTIONSARELOCATEDUNDERTHEFRONTOFTHE
OUTSIDEESCUTCHEON)NTHECASETHATTHE!!ALKALINEBATTERIESARECOMPLETELYDIS-
CHARGEDA6BATTERYCANBEUSEDTOSUPPLYPOWERTOTHELOCK7HILECONNECTINGTHE
6BATTERYTHELOCKCANBEOPERATEDASNORMALTHUSGRANTINGACCESSSOTHE!!
ALKALINEBATTERIESCANBEREPLACED
Group Lockout!DVANCEDMODEONLY4HISFEATURECANBEENABLEDBYEITHERTHE-ASTER
CODEORTHE3UPERVISORCODE)F'ROUP,OCKOUTISENABLEDTHROUGHTHE-ASTERCODE
SPECIlC3UPERVISORSANDTHEIRENTIREGROUPOF5SERSWILLBELOCKEDOUT)F'ROUP,OCK-
OUTISENABLEDTHROUGHTHE3UPERVISORCODEONLY5SERSCORRESPONDINGTOTHAT3UPER-
VISORARELOCKEDOUT
Definitions

11
¥!22/7,OCK$OOR(ARDWAREs2EV#
I-Button%ASYMODEONLY,OCATEDUNDERTHEBATTERYCOVERTHEhIvBUTTONISUSEDFOR
CHANGINGTHEDEFAULT3UPERVISORCODEANDCANBEUSEDFORPROGRAMMING
Low Battery7HENBATTERYPOWERISLOWTHELOWBATTERYICONWILLBEGINBLINKING)FBATTERY
POWERISCOMPLETELYLOSTTHEEMERGENCYPOWERSUPPLYCANBEUSED
Operating Modes2EVOLUTIONFEATURESTHECHOICEOF%ASYOR!DVANCEDOPERATINGMODES
4HEDESIREDOPERATINGMODESHOULDBEDETERMINEDBEFORETHECOMPLETIONOFLOCKINSTAL-
LATIONBUTCANBECHANGEDATALATERTIMEIFREQUIRED
Passage Mode%ASYAND!DVANCEDMODE%NABLING0ASSAGEMODEALLOWSCONTINUOUS
ENTRYFORNONRESTRICTEDTRAFlC0ASSAGEMODEISENABLEDORDISABLEDTHROUGHFEATURE
PROGRAMMINGBYEITHERTHE-ASTEROR3UPERVISORCODE7HENTHEUNITISIN0ASSAGE
-ODETHEGREENUNLOCKEDPADLOCKWILLAPPEARONTHESCREEN
Master Code!DVANCEDMODEONLY4HE-ASTERCODEISUSEDFORPROGRAMMING3UPERVISOR
CODESANDALSOFORFEATURESETTINGS4HE-ASTERCODEWILLNOTOPERATETHELOCK
Re-lock Time!FTERSUCCESSFULCODEENTRYANDTHEUNITUNLOCKSITWILLAUTOMATICALLYRE
LOCKAFTERADEFAULTOFlVESECONDS2ELOCKTIMEISADJUSTABLEFROMONETOTEN
SECONDSIN!DVANCEDMODEONLYTHROUGHFEATURESETTINGS
Shut Down Time4HEUNITWILLSHUTDOWNFORADEFAULTOFONEHUNDREDANDEIGHTYSEC-
ONDSANDNOTALLOWOPERATIONAFTERTHEWRONGCODEENTRYLIMITHASBEENMET3HUTDOWN
TIMEISADJUSTABLEFROMONETOTWOHUNDREDANDlFTYlVESECONDSIN!DVANCED
MODEONLYTHROUGHFEATURESETTINGS7HENTHEUNITISIN3HUT$OWNTHEREDLOCKEDPAD-
LOCKICONWILLBEmASHING
Silent Mode%ASYAND!DVANCEDMODE%NABLING3ILENTMODESHUTSOFFTHECODECONlR-
MATIONTONEPLAYBACKFORUSEINQUIETAREAS3ILENTMODEISENABLEDORDISABLEDTHROUGH
FEATUREPROGRAMMINGBYEITHERTHE-ASTEROR3UPERVISORCODE
Status LED,OCATEDONINSIDEESCUTCHEON&LASHESGREENTOINDICATELOCKIN0ASSAGE
MODE
Supervisor Code%ASYAND!DVANCEDMODE4HE3UPERVISORCODEISUSEDFORPROGRAM-
MING5SERCODESANDALSOFORFEATURESETTINGS4HE3UPERVISORCODEWILLOPERATETHE
LOCK
User Code%ASYAND!DVANCEDMODE4HE5SERCODEISUSEDFOROPERATINGTHELOCK
User Lockout!DVANCEDMODEONLY4HISFEATURECANBEENABLEDONLYBYTHE3UPERVISOR
CODE7HENENABLEDITRESTRICTS5SER0).CODEACCESSONLYFORSPECIlED5SERNUMBERS
CORRESPONDINGTOTHAT3UPERVISOR
Wrong Code Entry Limit!FTERADEFAULTOFlVEUNSUCCESSFULATTEMPTSATENTERINGAVALID
0).CODETHEUNITWILLSHUTDOWNANDNOTALLOWOPERATION7RONGCODEENTRYLIMITISAD-
JUSTABLEFROMONETOTENTIMESIN!DVANCEDMODEONLYTHROUGHFEATURESETTINGS
Definitions

12
¥!22/7,OCK$OOR(ARDWAREs2EV#
)NITIALPROGRAMMINGISPERFORMEDBYTHEUSEOFTHE BUTTON
LOCATEDUNDERTHEBATTERYCOVEROFTHEINSIDEESCUTCHEON
ANDVOICEGUIDEDINSTRUCTION3UBSEQUENTCHANGESTO
PROGRAMMINGCANBEPERFORMEDTHROUGHTHETOUCHSCREENBY
THEUSEOFTHE3UPERVISORCODE
7HILEIN%ASYMODETHELOCKCANBEPROGRAMMEDFOR
0ASSAGEMODE3ILENTMODEORALTERNATE,ANGUAGESETTINGS
!UTO2ELOCKTIMEWRONGCODEENTRYLIMITSANDSHUTDOWN
TIMESARENOTADJUSTABLEANDWILLREMAINASFACTORYDEFAULT
.OTE!FTERINITIALSETUPINDIVIDUAL5SER0).CODESCANNOT
BEADDEDTOORDELETEDFROMPROGRAMMING5PONENTERING
THE2EGISTER#HANGEUSERCODEFUNCTION!,,EXISTING5SER
CODESAREDELETEDANDMUSTBEREENTEREDIFNEEDED
4HEOPERATINGMODECANBECHANGEDFROM%ASYTO!DVANCED
ORVISAVERSAFORANYLOCK#HANGINGTHEMODERESETSTHE
LOCKTOFACTORYDEFAULTSANDALLPRIORPROGRAMMINGAND0).
CODESWILLBELOST3EEPAGEFORMOREINFORMATION
0ROVIDESASIMPLEEASYTOUSESYSTEMFORGENERALUSE)N%ASYMODEATOTALOF0).
CODESAREAVAILABLEFORACCESS#ODEASSIGNMENTSCONSISTOFONE3UPERVISORCODE
ANDEIGHT5SERCODES
/0%2!4).'-/$%3
Easy Mode
User 2
Supervisor
User 3
User 4
User 5
User 1
User 6
User 7
User 8
Feature Supervisor User
Entrance Authorization x x
Register/Change User Code x
Set Passage Mode x
Set Silent Mode x
Set Language Setting Mode x
Settings Factory Defaults
Supervisor Code 1234567890
Passage Mode Disabled
Silent Mode Disabled
Re-lock Time 5 Seconds
Wrong Code Entry Limit 5 Times
Shut Down Time 180 Seconds
Language English
4OUCHLOCKWITHPALM
OFHANDORlNGERS
TOACTIVATE
Operation of Lock
%NTER0).CODE 0ALMORTOUCHTHE KEY
TOCONlRMTHESELECTION
4URNLEVERTO
OPENDOOR
Programming I-Button Touchscreen
Set/Change Supervisor PIN x
Set/Change User PIN (1 - 8) x x


¥!22/7,OCK$OOR(ARDWAREs2EV#
SU
1 - 8
 4OUCHTHESCREENWITHTHE
PALMOFYOURHANDOR
lNGERSTOACITIVATE 
 %NTERTHEDIGIT
3UPERVISOR0).CODE
FOLLOWEDBYTHE KEY
,OCK2ESPONSEhMenu
mode, enter number, press
the key to continuev
 %NTERDIGITCORRESPONDING
TOTHEFUNCTIONTOBE
PERFORMEDFOLLOWEDBYTHE
KEY
&OLLOWTHEVERBALCOMMANDS
 Press the KEYTOCOMPLETE
THEPROCESSANDCONCLUDETHE
PROGRAMMINGSESSION
Feature Programming Through Menu Mode via Supervisor Code
1 2 3 4
Register User Code
S
1 - 8
U
Passage Mode Enable
Disable
Silent Mode Enable
Disable
Language Setting Mode English
Spanish
French
51
Unscrew battery
cover hex screw
using tool
provided. Slide
battery cover up
and off to reveal
the button
located above the
batteries.
Press the button one
time.
Enter the new Supervisor PIN
code (4 to 12 digits), followed by
the key.
Press the button
to complete the
process after the last
playback sequence.
32
Lock Response:
hRegister User code.
Enter one Supervisor
then up to 8 users.
Enter a 4 to 12 digit
PIN code, each fol-
lowed by the key.
Press the button
to complete.”
Lock Response:
hRegistered."
Enter the first User PIN code (4 -
12 digits) followed by the key.
4
Lock Response: Sounds a tone for
each PIN code digit with digits
flashing in the sequence entered
to confirm the entry. Chime sig-
nals when playback is complete.
Lock Response: Sounds a tone for
each PIN code digit with digits
flashing in the sequence entered
to confirm the entry. Chime sig-
nals when playback is complete.
Continue to enter add User
PIN codes (4 to 12 digits each)
followed by the key. Up to
eight User PIN codes can be
entered.
Register / Change PIN Codes (including Supervisor Code) through I-Button
1 2 3 4 5
Note: When registering User codes, the code
must be entered with in 20 seconds. If time
expires, no codes are registered and the process
must be re-started.


¥!22/7,OCK$OOR(ARDWAREs2EV#
0ROVIDESATIER0).CODESYSTEMFORCOMMERCIALUSE)N!DVANCEDMODEATOTALOF
0).CODESAREAVAILABLEFORACCESS4HE0).CODESAREDIVIDEDINTOTWENTY
3UPERVISORGROUPSOFlFTY5SERCODESPERGROUP
!DVANCEDMODEALSOHASA-ASTERCODEWHICHISUSEDONLYFORPROGRAMMINGANDDOES
NOTGRANTACCESS
!LLPROGRAMMINGISPERFORMEDTHROUGHTHE
TOUCHSCREENUSINGTHE-ASTEROR3UPERVISOR
CODEANDVOICEGUIDEDPROMPTS/NLYTHE
3UPERVISORCODECANESTABLISH5SERCODES
7HILEIN!DVANCEDMODETHELOCKCANBE
PROGRAMMEDFOR0ASSAGEMODE3ILENTMODE
,OCKOUTMODEORALTERNATE,ANGUAGESETTINGS
!UTORELOCKTIMEWRONGCODEENTRYLIMITS
ANDSHUTDOWNTIMESAREADJUSTABLECANBE
CHANGEDFROMFACTORYDEFAULT
4HEOPERATINGMODECANBECHANGEDFROM
!DVANCEDTO%ASYORVISAVERSAFORANYLOCK
#HANGINGTHEMODERESETSTHELOCKTOFACTORY
DEFAULTSANDALLPRIORPROGRAMMINGAND0).
CODESWILLBELOST3EEPAGEFOR
MOREINFORMATION
Advanced Mode
Master
Supervisor
00
User
01
User
02
User
03
User
49
User
48
User
01
User
02
User
03
User
49
User
48
User
01
User
02
User
03
User
49
User
48
Supervisor
04 Supervisor
09 Supervisor
19
4OUCHLOCKWITHPALM
OFHANDORlNGERS
TOACTIVATE
%NTER0).CODE 0ALMORTOUCHTHE KEY
TOCONlRMTHESELECTION
4URNLEVERTO
OPENDOOR
Settings Factory Defaults
Master Code 123456
Lockout Mode Disabled
Passage Mode Disabled
Silent Mode Disabled
Re-lock Time 5 Seconds
Wrong Code Entry Limit 5 Times
Shut Down Time 180 Seconds
Language English
Settings Master Supervisor User
Entrance Authorization x x
Register/Change Master Code x
Register/Change/Delete Supervisor Code x
Register/Change/Delete User Code x
Set All Code Lockout Mode x
Set Group Lockout Mode x x
Set User Lockout Mode x
Set Passage Mode x x
Set Silent Mode x x
Set Re-lock Time x
Set Wrong Code Entry Limit x
Set Shut Down Time x
Set Language Setting Mode x
Operation of Lock

15
¥!22/7,OCK$OOR(ARDWAREs2EV#
4OUCHTHESCREENWITHTHEPALMOFYOURHANDORlNGERSTOACITIVATE 
%NTERTHEDIGIT-ASTER0).CODEFOLLOWEDBYTHE KEY
,OCK2ESPONSEhMenu mode, enter number, press the key to continuev
%NTERDIGITCORRESPONDINGTOTHEFUNCTIONTOBEPERFORMEDFOLLOWEDBYTHE KEY
&OLLOWTHEVERBALCOMMANDS
0RESSTHE KEYTOCOMPLETETHEPROCESSANDCONCLUDETHEPROGRAMMINGSESSION
Register Master Code
M
English
Spanish
French
M
00-19
00-19
00-19
S
Register Supervisor Code
All Code Lockout Mode
Group Lockout Mode
Passage Mode
Silent Mode
Lock Setting Mode
Register
Delete
Enable
Disable
Re-lock Time
Wrong Code Entry Limit
Shut Down Time
Enable
Disable
Enable
Disable
Enable
Disable
1 2 3 4
4OUCHTHESCREENWITHTHEPALMOFYOURHANDORlNGERSTOACTIVATE 
%NTERTHEDIGITDEFAULT-ASTER0).CODEFOLLOWEDBYTHE KEY
,OCK2ESPONSEh-ENUMODEENTERNUMBERPRESSTHE KEYTOCONTINUEv
%NTERhvFOLLOWEDBYTHE KEY
%NTERNEWDIGIT-ASTER0).CODEFOLLOWEDBYTHE KEY
0RESS KEYTOCOMPLETETHEPROCESSANDCONCLUDETHEPROGRAMMINGSESSION
Change Default Master Code Before Programming
Feature Programming Through Master Code
Language Setting Mode

16
¥!22/7,OCK$OOR(ARDWAREs2EV#
5SER#ODESCANONLYBEPROGRAMMEDTHROUGH3UPERVISOR#ODE
4OUCHTHESCREENWITHTHEPALMOFYOURHANDORlNGERSTOACITIVATE 
%NTERTHEDIGIT3UPERVISOR0).CODEFOLLOWEDBYTHE KEY
,OCK2ESPONSEhMenu mode, enter number, press the key to continuev
%NTERFOLLOWEDBYTHE KEY
%NTERAGAINFOLLOWEDBYTHE KEY
%NTERTHE5SERNUMBERTOBEREGISTEREDFOLLOWEDBYTHE KEY
%NTERADIGIT0).CODEFORTHE5SERNUMBERFOLLOWEDBYTHE KEY
0RESSTHE KEYTOCOMPLETETHEPROCESSANDCONCLUDETHEPROGRAMMINGSESSION
4OUCHTHESCREENWITHTHEPALMOFYOURHANDORlNGERSTOACITIVATE 
%NTERTHEDIGIT-ASTER0).CODEFOLLOWEDBYTHE KEY
,OCK2ESPONSEhMenu mode, enter number, press the key to continuev
%NTERFOLLOWEDBYTHE KEY
%NTERFOLLOWEDBYTHE KEY
%NTERTHE3UPERVISORNUMBERTOREGISTERFOLLOWEDBYTHE KEY
%NTERADIGIT0).CODEFORTHE3UPERVISORNUMBERFOLLOWEDBYTHE KEY
0RESSTHE KEYTOCOMPLETETHEPROCESSANDCONCLUDETHEPROGRAMMINGSESSION
Set Up Supervisor Codes
To Set Up User Codes
Feature Programming Through Supervisor Code
Register User Code
S
Group User Lockout Mode
User Code Lockout Mode
Enable
Disable
Enable
Disable
Passage Mode Enable
Disable
Silent Mode Enable
Disable
Register
Delete
U



4OUCHTHESCREENWITHTHEPALMOFYOURHANDORlNGERSTOACTIVATE
%NTERTHEDIGIT3UPERVISOR0).CODEFOLLOWEDBYTHE KEY
,OCK2ESPONSE-ENUMODEENTERNUMBERPRESSTHE KEYTOCONTINUE
%NTERDIGITCORRESPONDINGTOTHEFUNCTIONTOBEPERFORMEDFOLLOWEDBYTHE KEY
&OLLOWTHEVERBALCOMMANDS
0RESSTHE KEYTOCOMPLETETHEPROCESSANDCONCLUDETHEPROGRAMMINGSESSION
1 2 3 4


¥!22/7,OCK$OOR(ARDWAREs2EV#
MISCELLANEOUS INFORMATION
.OTE#HANGINGTHEOPERATINGMODEFROM
%ASYTO!DVANCEDORVICEVERSADELETESALL
PRIORPROGRAMMING
4HEOUTSIDEASSEMBLYREMAINSASSEMBLED
2EMOVEINSIDELEVER
2EMOVEBATTERYCOVERUSING!LLEN
WRENCHPROVIDEDWITHLOCK
2EMOVEFOUR!!ALKALINEBATTERIES
2EMOVETHEXPANHEAD
SCREWFROMTHECENTEROFTHEBATTERY
HOUSINGINTOTHEBARRELNUTOFTHE
OUTSIDEASSEMBLY
2EMOVEINSIDEESCUTCHEON
/NTHEBACKOFTHE0#BOARDCHANGE
THEPOSITIONOFTHEEASYADVANCEDSWITCH
4OREASSEMBLETHELOCKREFERTOSTEPS
THROUGHONPAGE
Easy / Advanced Setting
EASY
EXT-PWR / REMOTE / MOTOR
ADVANCED
EXT-PWR / REMOTE / MOTOR
6
4ORETURNTHELOCKTOPROGRAMMINGDEFAULTSwithout changing the operating mode:
&OLLOWSTEPSTHROUGHABOVE
)NSERTTHEFOUR!!ALKALINEBATTERIES
4HELOCKRESPONDS 7ELCOMETOTHE!RROW$IGITAL7ORLD 
2EMOVETHEBATTERIES
#HANGETHEPOSITIONOFTHEEASYADVANCEDSWITCHTOORIGINALSTATE
2EASSEMBLETHELOCKBYREFERRINGTOSTEPSTHROUGHONPAGE
!LLPROGRAMMINGSHOULDBERETURNEDTOFACTORYDEFAULTS
Emergency Power Suppy and Battery Replacement
6BATTERYCONNECTIONSARELOCATEDUNDERTHEFRONTOFTHEOUTSIDE
ESCUTCHEON)NTHECASETHATTHE!!ALKALINEBATTERIESARE
COMPLETELYDISCHARGEDA6BATTERYCANBEUSEDTOSUPPLY
POWERTOTHELOCK7HILECONNECTINGTHE6BATTERYTHE
LOCKCANBEOPERATEDASNORMALTHUSGRANTINGACCESS
SOTHE!!ALKALINEBATTERIESCANBEREPLACED
$ISCHARGEDBATTERIESSHOULDBEREPLACEDRIGHTAWAY
To Return Lock to Programming Defaults
To Change Operating Modes

18
¥!22/7,OCK$OOR(ARDWAREs2EV#
42/5",%3(//4).'
Symptom Suggested Action
Lock does not respond – door is open
and accessible.
s The touchscreen will become active when pressed with the palm or fingers in at least
3 areas simultaneously.
s Use a larger area of the palm or fingers and verify contact with at least 3 areas.
s If touchscreen numbers are visible, check to see if they respond when pressed.
s Check batteries are installed and oriented correctly in the battery case.
s Check batteries are in good condition; replace batteries if discharged (page 17).
s Check to see if touchscreen cable is properly connected and not pinched (page 7).
Lock does not respond – door is locked
and inaccessible.
s Batteries may be completely discharged.
s Use mechanical key to gain entry and replace batteries.
s Connect a 9-volt battery to the emergency power supply terminal which is
located on the outside escutcheon, under the lever. With the 9-volt battery con-
nected, palm the touchscreen, enter PIN code, and palm touchscreen
again (page 17). Replace batteries.
The unit is on for a while, and then
shows no reaction. Lights dim.
s The batteries do not have enough power. Replace the batteries.
Unit chimes to indicate code accep-
tance, but the door will not open.
s Check to see if there is another locking device on the door (i.e. deadbolt).
s Check the door gaps for any foreign objects between door and frame.
s Check that the motor cable is firmly connected to the PC board header marked
“MOTOR” (page 7).
Unit operates to allow access, but will
not automatically re-lock.
s Check to see if Passage Mode is enabled (pages 15-16).
s If the Passage Mode icon on the touchscreen and the status indicator on the
s interior escutcheon flicker for several seconds, it is set at Passage Mode
(page 9). Disable Passage Mode to lock the door.
s If low battery indicator is lit (page 10), change batteries.
PIN codes will not register. s PIN codes must consist of 4 to 12 digits to register.
s The same PIN code cannot be used for multiple users.
s In Advanced Mode, registration/management of PIN codes is set at the authority of
Master and/or Supervisor.
s Contact the Master or Supervisor.
s In Advanced mode, the Master PIN code does not unlock the door.
s In Easy Mode, User codes must be entered within 20 seconds (while the touchscreen
is active) or the process will have to be restarted.
s In Easy Mode, the Supervisor PIN code can only be registered using the I-Button.
s The star (*) or pound (#) can not be used as part of the PIN code.
Upon entering a PIN code and pressing
the star (*) key, the unit displays and
“invalid code” error or the lock times
out without responding.
s Either All Code, Group or User Lockout Mode is enabled (15-16).
s Only the Master or Supervisor can enable Lockout Mode.
s Contact the Master user or Supervisor.
Upon entering a PIN code and pressing
the (*) key, the red padlock icon ap-
pears and there are different tones.
s Check to see if either you or your group is set at Lockout Mode.
s Setting/managing Lockout Mode is up to Master and Supervisor.
Contact the Master user or Supervisor.
The unit operates, but it makes
no sound.
s Check to see if Silent Mode is enabled (page 13, 15).
The unit responds “Low Battery” s This is the voice alarm alerting that it is time to replace the batteries. Replace all
four (4) batteries with new AA Alkaline batteries.
Upon entering a PIN code and pressing
the star (*) key, the unit responds
“Wrong digit numbers.”
s The digits entered were incorrect or incomplete. Re-enter the code.

19
¥!22/7,OCK$OOR(ARDWAREs2EV#
0).#/$%-!.!'%-%.43!-0,%3(%%43
Easy Mode PIN Code Management
Door Number: Door Number:
Name PIN Number User Name PIN Number
Supervisor Supervisor
User 1 User 1
User 2 User 2
User 3 User 3
User 4 User 4
User 5 User 5
User 6 User 6
User 7 User 7
User 8 User 8
Advanced Mode PIN Code Management
Location: Door Number: User User Name Group # User # PIN Code
User Type User Name Group # User # PIN Code User 24
Master User 25
Supervisor User 26
User 01 User 27
User 02 User 28
User 03 User 29
User 04 User 30
User 05 User 31
User 06 User 32
User 07 User 33
User 08 User 34
User 09 User 35
User 10 User 36
User 11 User 37
User 12 User 38
User 13 User 39
User 14 User 40
User 15 User 41
User 16 User 42
User 17 User 43
User 18 User 44
User 19 User 45
User 20 User 46
User 21 User 47
User 22 User 48
User 23 User 49

Arrow Architectural Hardware
!22/7ISAREGISTEREDTRADEMARKOF!RRROW!RCHITECTURAL(ARDWAREAN!33!!",/9'ROUPCOMPANY
2EVOLUTION©ISATRADEMARKOF!RRROW!RCHITECTURAL(ARDWAREAN!33!!",/9'ROUPCOMPANY
/THERPRODUCTSBRANDNAMESMAYBETRADEMARKSORREGISTEREDTRADEMARKSOFTHEIRRESPECTIVEOWNERSANDAREMENTIONED
FORREFERENCEPURPOSESONLY4HESEMATERIALSAREPROTECTEDUNDER53COPYRIGHTLAWS
!LLCONTENTSCURRENTATTIMEOFPUBLICATION
!RROW!RCHITECTURAL(ARDWAREAN!33!!",/9'ROUPCOMPANYRESERVESTHERIGHTTOCHANGEAVAILABILITY
OFANYITEMINTHISCATALOGITSDESIGNCONSTRUCTIONANDORITSMATERIALS
#OPYRIGHT¥!RROW!RCHITECTURAL(ARDWAREAN!33!!",/9'ROUPCOMPANY!LLRIGHTSRESERVED
2EPRODUCTIONINWHOLEORINPARTWITHOUTTHEEXPRESSWRITTENPERMISSIONOF!RROW!RCHITECTURAL(ARDWAREISPROHIBITED
¥!22/7,OCK$OOR(ARDWAREs2EV#
ARROW USA
!RROW$RIVE
.EW(AVEN#4
0HONE
&AX
CUSTOMERSERVICE ASSAABLOYRSSCOM
/RDERS#USTOMER3ERVICE
!RROW,OCK$OOR(ARDWARE
0/"OX
3ALEM6!
0HONE53!
&AX
0HONE#ANADA
&AX
)NVOICE0AYMENTS/NLY
!RROW,OCK!CCOUNTS2ECEIVABLE
0/"OX
0ITTSBURGH0!
2ETURN'OODS/NLY2'!2EQUIRED
!RROW,OCK$OOR(ARDWARE
!RROW,OCK$RIVE
.EW(AVEN#4