Ashley AP5660L User manual

Installation and Operating Manual
Model AP5660L
SAFETY NOTICE
Please read this entire manual before installation and use of this pellet fuel-burning room heater. Failure to follow instructions
may result in property damage, bodily injury, or even death.
If your heater is not properly installed, a house fire may result. For everyone’s safety, follow all Installation and Operating
Directions. Never use makeshift compromises during the installation of this appliance.
Contact your local building or fire officials about restrictions and installation inspection requirements in your area.
These Pellet Stove Room Heaters have been designed for use in the US and Canada and are suitable for mobile homes.
French version is available for download from the Vogelzang website: http://www.usstove.com/
Version française est disponible pour téléchargement à partir du site Vogelzang: http://www.usstove.comSave These
Instructions
United States Stove Company • 227 Industrial Park Road, South Pittsburg, TN 37380 • Phone #: [phone]
852072H-1903E
This unit is not intended to be used as a primary source of heat.
Certified for installations in the USA
and Canada.
U.S. Environmental Protection Agency
Certified to comply with 2015 particulate emissions standards.

IMPORTANT: Read this entire manual before installing
and operating this product. Failure to do so may result
in property damage, bodily injury, or even death. Proper
installation of this stove is crucial for safe and efficient
operation.
Install vent at clearances specified by the vent manu-
facturer.
Do not connect the pellet vent to a vent serving any other
appliance or stove.
Do not install a flue damper in the exhaust venting system
of this unit.
Use of outside air is not required for this unit.
Contact your local building officials to obtain a permit and
information on any additional installation restrictions or
inspection requirements in your area.
Do not throw this manual away. This manual has im-
portant operating and maintenance instructions that you
will need at a later time. Always follow the instructions
in this manual.
This appliance is designed for the use of pelletized fuel
that meet or exceed the standard set by the Pellet Fuel
Institute(PFI), The use of other fuels will void warranty.
Never use gasoline, gasoline-type lantern fuel, kerosene,
charcoal lighter fluid, or similar liquids to start or ’freshen
up’ a fire in this stove. Keep all such liquids well away
from the stove while it is in use.
A working smoke detector must be installed in the same
room as this product.
Install a smoke detector on each floor of your home;
incase of accidental fire from any cause it can provide
time for escape.
The smoke detector must be installed at least 15 feet
(4,57 M) from the appliance in order to prevent undue
triggering of the detector when reloading.
Do not unplug the stove if you suspect a malfunction. Turn
the ON/OFF SWITCH to ”OFF’ and contact your dealer.
Your stove requires periodic maintenance and cleaning
(see ”MAINTENANCE ”). Failure to maintain your stove
may lead to improper and/or unsafe operation.
Disconnect the power cord before performing any main-
tenance! NOTE: Turning the ON/OFF Switch to ”OFF”
does not disconnect all power to the electrical components
of the stove.
Never try to repair or replace any part of the stove unless
instructions for doing so are given in this manual. All other
work should be done by a trained technician.
Do not operate your stove with the viewing door open.
The auger will not feed pellets under these circumstances
and a safety concern may arise from sparks or fumes
entering the room.
Allow the stove to cool before performing any mainte-
nance or cleaning. Ashes must be disposed in a metal
container with a tight fitting lid. The closed container of
ashes should be placed on a non-combustible surface or
on the ground, well away from all combustible materials,
pending final disposal.
The exhaust system should be checked monthly during
the burning season for any build-up of soot or creosote.
Do not touch the hot surfaces of the stove. Educate all
children on the dangers of a high-temperature stove.
Young children should be supervised when they are in
the same room as the stove.
The hopper and stove top will be hot during operation;
therefore, you should always use some type of hand
protection when refueling your stove.
A power surge protector is required. This unit must be
plugged into a 110 - 120V, 60 Hz grounded electrical
outlet. Do not use an adapter plug or sever the grounding
plug. Do not route the electrical cord underneath, in front
of, or over the heater. Do not route the cord in foot traffic
areas or pinch the cord under furniture.
The heater will not operate during a power outage. If a
power outage does occur, check the heater for smoke
spillage and open a window if any smoke spills into the
room.
The feed door must be closed and sealed during opera-
tion.
Never block free airflow through the open vents of the unit.
Keep foreign objects out of the hopper.
The moving parts of this stove are propelled by high
torque electric motors. Keep all body parts away from the
auger while the stove is plugged into an electrical outlet.
These moving parts may begin to move at any time while
the stove is plugged in.
Do not place clothing or other flammable items on or
near this stove.
When installed in a mobile home, the stove must be
grounded directly to the steel chassis and bolted to
the floor. WARNING—THIS UNIT MUST NOT BE IN-
STALLED IN THE BEDROOM (per HUD requirements).
CAUTION—THE STRUCTURAL INTEGRITY OF THE
MOBILE HOME FLOOR, WALL, AND CEILING/ROOF
MUST BE MAINTAINED.
This appliance is not intended for commercial use.
CAUTION: Burning fuel creates carbon monoxide and can
be hazardous to your health if not properly vented.
* This appliance is a freestanding heater. It is not intended to be attached to any type of ducting. It is not a furnace.
Safety Precautions
2

WARRANTY INFORMATION CARD
Name__________________________________________ Telephone #: (_____)_____________
City____________________________________________ State_______ Zip_________________
Email Address __________________________________________________________________
Model # of Unit________________________________ Serial #___________________________
Fuel Type: Wood Coal Pellet Gas Other _________________________
Place of Purchase (Retailer)______________________________________________________
City____________________________________________ State_______ Zip_________________
If internet purchase, please list website address___________________________________
Date of Purchase _______________________________________________________________
Reason for Purchase: Alternative Heat Main Heat Source
Decoration Cost Other _________________________
What was the determining factor for purchasing your new USSC appliance?_______
I have read the owner’s manual that accompanies this unit and fully understand the:
Installation  Operation  and Maintenance  of my new USSC appliance.
Print Name Signature Date
Please attach a copy of your purchase receipt.
Warranty not valid without a Proof of Purchase.
Warranty information must be received within 30 days of original purchase.
Detach this page from this manual, fold in half with this page to the inside and tape together. Apply a
stamp and mail to the address provided. You may use an envelope if you choose.
You may register online by going to www.usstove.com
All information submitted will be kept strictly condential. Information provided will not be sold for advertising purposes.
Contact information will be used solely for the purpose of product notications.
3

CUT HERE CUT HERE

Fold Here Fold Here
United States Stove Company
P.O. Box 151
South Pittsburg, TN 37380
Fold Here
PLACE
STAMP
HERE
4

Fuel Burn Rate* (lowest setting) 5.1 lbs./hr.
Burn Time (lowest setting) 32hrs. (approximate)
Hopper Capacity 55 lbs.
BTU’S 43,900 per hour
HEATING SPECIFICATIONS
Height 34.05 in. (865 mm)
Width 24.41 in. (620 mm)
Depth 27.32 in. (693.9 mm)
Weight 270 lbs. (kg)
DIMENSIONS
Electrical Rating 115-120 volts, 60 HZ, 3.0 Amps
Watts (operational) 180W
Watts (igniter running) 346W
ELECTRICAL SPECIFICATIONS
* Pellet size may effect the actual rate of fuel feed and burn times. Fuel feed rates may vary by as much as 20%. Use PFI listed fuel for best results.
SPECIFICATIONS
This manual describes the installation and operation of the United States Stove
Company Model 5660 pellet stove. This heater meets the 2015 U.S. Environmental
Protection Agency’s crib wood emission limits for woodheaters sold after May 15,
2015. Under specific EPA test conditions burning Douglas Fir dimensional lumber
this heater has been shown to deliver heat at a rate of 11,370 to 34,260 Btu/hr. This
heater achieved a particulate emissions rate of 1.92 g/hr when tested to method ASTM
E 2779 / EPA Method 28R.
FUEL CONSIDERATIONS
Your pellet stove is designed and tested with premium grade pellets that comply with Pellet Fuels Institute(PFI)
standards. You can only burn premium grade pellets in this pellet heater. (Minimum of 40 lbs density per cubic ft, 1/4” to 5/16” diameter,
length no greater than 1.5”, not less than 8,200 BTU/lb, moisture under 8% by weight, ash under 1% by weight, and salt under 300 parts
per million). Pellets that are soft, contain excessive amounts of loose sawdust, have been, or are wet, will result in reduced performance
and may cause damage to your heater. Store your pellets in a dry place.
DO NOT store the fuel within the installation clearances of the unit or within the space required for refueling and ash removal. Doing
so could result in a house fire.
Do not overfire or use volatile fuels or combustibles, doing so may cause a personal and property damage hazards.
SAFETY AND EPA COMPLIANCE
Your pellet stove has been approved for installation in the USA and Canada. It may also be installed in a manufactured or mobile home.
Your stove conforms to ASTM E 1509, 2012, and Certified to ULC S627, 2000, and(UM) 84-HUD by INTERTEK Testing Services in
Fairview, Oregon USA.
Report No. 0215PS032E
5