Backyard Discovery 1606029 User manual

Made in China
INS-1606029-A-CARIBBEAN-ENG 02/18/22
Please visit www.backyarddiscovery.com
For the most up to date assembly manual, to register your set, or to order replacement parts
Para obtener instrucciones en español, visite www.backyarddiscovery.com
Model # 1606029
CARIBBEAN
MANUFACTURED BY:
Backyard Discovery
3305 Airport Drive, Pittsburg, KS 66762
800-856-4445
Swing Set
Basepoint Business Centre: Rivermead Drive,Westlea, Swindon SN5 7EX Phone: [phone]
J.P. Coenstraat 7, The Bridge, The Hague, 2595 WP, Netherlands Phone: [phone]
WARNING
Adult Assembly Required.
Not suitable for children under 36 months due to small parts.
FOR DOMESTIC USE ONLY. INTENDED FOR OUTDOOR USE.
The assembly manual must be retained
since it contains important information

Important Assembly Notes
1) While assembling unit, take time before and after each phase to make sure fort is level. If fort is
not level, assembly will be difficult and improper assembly may result. Extra care must be taken to
ensure the fort is square.
2) Tighten bolts securely, tighten nuts on bolts flush to the tube or member.
3) Pay close attention to the ITEMS NEEDED FOR EACH PHASE. They can be a valuable aid when
sorting your wood and hardware. Assembly will be made easier if items are sorted by phase.
4) Pay close attention to make sure you are using the correct hardware in the correct phases. Using
incorrect hardware may result in improper assembly.
5) Whenever a T-nut is used, follow these directions. Place T-nut in pre-drilled hole. Tap in with hammer.
Place bolt with washers in the opposite side. Hand tighten to make sure the bolt is in the T-nut.
DO NOT over tighten.
6) Read the steps of each phase thoroughly. The written steps may include important information not
shown in the illustrations.
Basic Setup Dimensions
Place the set on level ground, not less than 6 ft [2 m] from any structure or obstruction such
as a fence, garage, house, overhanging branches, laundry lines, or electrical wires.
Safe Play Zone
Safe play height: 18'-5" [5.6 m]
Maximum fall height: 6'-8 1/2" [2 m]
General Information:
Your set has been designed and engineered for
children only and for residential use only.
A maximum of 150 lbs. per child is recommended for
play activities designed for individual use.
A maximum of 120 lbs. per child is recommended for
play activities designed for multiple child use.
A maximum of 9 children is recommended for this
swing set.
20'-6 1/2"
[6.3 m]
6'
[1.8 m]
6'
[1.8 m]
16'-5 1/2"
[5 m]
28'-5 1/2"
[8.7 m]
32'-6 1/2"
[9.9 m]
12'-4 1/2"
[3.8 m]
6'-8 1/2"
[2 m]
2

Parts Identification
Wood Components
(NOT TO SCALE)
A50 - SWING BEAM - W4L06169
3 3/8"x5 1/4"x89 1/2" (86x134x2274)
1)
E1 - UPRIGHT - W4L06195
1 3/8"x3 3/8"x86 1/8" (36x86x2186)
1)
E2 - UPRIGHT - W4L06190
1 3/8"x3 3/8"x86 1/8" (36x86x2186)
1)
E3 - UPRIGHT - W4L06069
1 3/8"x3 3/8"x63" (36x86x1600)
1)
E4 - UPRIGHT - W4L06085
1 3/8"x3 3/8"x63" (36x86x1600)
1)
E5 - UPRIGHT - W4L06090
1 3/8"x3 3/8"x63" (36x86x1600)
1)
E6 - UPRIGHT - W4L06091
1 3/8"x3 3/8"x63" (36x86x1600)
1)
E7 - UPRIGHT - W4L06051
1 3/8"x3 3/8"x57 3/8" (36x86x1457)
1)
E8 - UPRIGHT - W4L06058
1 3/8"x3 3/8"x57 3/8" (36x86x1457)
1)
E9 - UPRIGHT - W4L06061
1 3/8"x3 3/8"x57 3/8" (36x86x1457)
1)
E10 - UPRIGHT - W4L06053
1 3/8"x3 3/8"x34 1/4" (36x86x869)
1)
E11 - UPRIGHT - W4L06127
1 3/8"x3 3/8"x10 7/8" (36x86x275)
1)
E50 - END SUPPORT - W4L06172
1 3/8"x3 3/8"x44 1/8" (36x86x1120)
1)
E51 - ANGLE BRACE - W4L06171
1 3/8"x3 3/8"x88 3/4" (36x86x2254)
2)
E13 - FLOOR JOIST - W4L06320
1 3/8"x3 3/8"x63 3/4" (36x86x1618)
1)
E72 - LEFT RAIL - W4L06335
1 3/8"x3 3/8"x61 1/8" (36x86x1553)
1)
3

Parts Identification
Wood Components
(NOT TO SCALE)
F1 - UPRIGHT - W4L06131
1 3/8"x2 3/8"x34 7/8" (36x60x887)
2)
F2 - POST - W4L06070
1 3/8"x2 3/8"x30 3/8" (36x60x772)
1)
F3 - POST - W4L06074
1 3/8"x2 3/8"x30 3/8" (36x60x772)
1)
F4 - POST - W4L06093
1 3/8"x2 3/8"x30 3/8" (36x60x772)
1)
G1 - WALL RAIL - W4L06086
1"x5 1/4"x76 3/4" (24x134x1948)
1)
G2 - LADDER UPRIGHT - W4L06144
1"x5 1/4"x64 1/2" (24x134x1637)
2)
G50 - GROUND BOARD - W4L06173
1"x5 1/4"x86 3/4" (24x134x2202)
1)
H1 - HANDRAIL - W4L06132
1"x3 3/8"x88 3/4" (24x86x2253)
1)
H2 - FLOOR SUPPORT - W4L06060
1"x3 3/8"x76 3/4" (24x86x1948)
1)
H3 - FLOOR SUPPORT - W4L06352
1"x3 3/8"x76 3/4" (24x86x1948)
1)
H4 - FLOOR SUPPORT - W4L06189
1"x3 3/8"x73 1/8" (24x86x1858)
1)
H5 - SAFETY RAIL - W4L06059
1"x3 3/8"x68 5/8" (24x86x1742)
1)
H6 - WALL RAIL - W4L06088
1"x3 3/8"x54 1/2" (24x86x1384)
1)
H7 - WALL RAIL - W4L06100
1"x3 3/8"x54 1/2" (24x86x1384)
2)
E73 - RIGHT RAIL - W4L06336
1 3/8"x3 3/8"x61 1/8" (36x86x1553)
1)
F5 - POST - W4L06323
1 3/8"x2 3/8"x30 3/8" (36x60x772)
2)
F6 - FLOOR JOIST - W4L06351
1 3/8"x2 3/4"x13 7/8" (36x70x352)
2)
4

Parts Identification
Wood Components
(NOT TO SCALE)
H8 - FLOOR SUPPORT - W4L06079
1"x3 3/8"x54 3/8" (24x86x1382)
1)
H9 - WALL RAIL - W4L06102
1"x3 3/8"x54 3/8" (24x86x1382)
2)
H10 - FLOOR SUPPORT - W4L06062
1"x3 3/8"x52 1/2" (24x86x1334)
1)
H11 - HANDRAIL - W4L06133
1"x3 3/8"x46" (24x86x1170)
1)
H12 - FLOOR SUPPORT - W4L06321
1"x3 3/8"x63 3/4" (24x86x1618)
1)
H13 - WALL SPACER - W4L06126
1"x3 3/8"x3 3/8" (24x86x86)
1)
H22 - DECK BRACE - W4L06082
1"x3 3/8"x18 3/8" (24x86x466)
3)
J1 - WALL RAIL - W4L06104
1"x2 3/8"x54 1/2" (24x60x1384)
1) J2 - FLOOR JOIST - W4L06068
1"x2 3/8"x52 1/2" (24x60x1334)
2)
J3 - WALL RAIL - W4L06092
1"x2 3/8"x27 1/4" (24x60x691)
2) J4 - OUTER CURTAIN ROD HOLDER - W4L05293
1"x2 3/8"x2 3/8" (24x60x60)
2) J5 - INNER CURTAIN ROD HOLDER - W4L05294
1"x2 3/8"x2 3/8" (24x60x60)
1)
J6 - WALL RAIL - W4L06089
1"x2 3/8"x25 5/8" (24x60x650)
4) J7 - WALL RAIL - W4L06192
1"x2 3/8"x66 1/8" (24x60x1678)
2)
H23 - DECK BRACE - W4L06179
1"x3 3/8"x17 7/8" (24x86x453)
6)
H83 - WALL BOARD - W4L06182
1"x3 3/8"x61 1/4" (24x86x1557)
3)
H84 - WALL BOARD - W4L06183
1"x3 3/8"x61 1/4" (24x86x1557)
1)
H85 - SAFETY RAIL - W4L06184
1"x3 3/8"x75" (24x86x1904)
1)
H86 - ANGLE BRACE - W4L06186
1"x3 3/8"x49 3/8" (24x86x1254)
2)
H14 - FLOOR SUPPORT - W4L06193
1"x3 3/8"x45" (24x86x1142)
1)
H15 - FLOOR SUPPORT - W4L06327
1"x3 3/8"x31" (24x86x788)
1)
H16 - SWING RAIL SUPPORT - W4L06341
1"x3 3/8"x9 1/8" (24x86x232)
2)
H17 - SIDE BACK RAIL - W4L06343
1"x3 3/8"x18" (24x86x456)
2)
H18 - SIDE SEAT SUPPORT - W4L06344
1"x3 3/8"x16 1/8" (24x86x410)
2)
H19 - CENTER SEAT SUPPORT - W4L06345
1"x3 3/8"x16 1/8" (24x86x410)
1)
H20 - CENTER BACK RAIL - W4L06346
1"x3 3/8"x18" (24x86x456)
1)
H21 - LEFT ARM REST - W4L06347
1"x3 3/8"x19 3/8" (24x86x492)
1)
H24 - RIGHT ARM REST - W4L06348
1"x3 3/8"x19 3/8"(24x86x492)
1)
5

Parts Identification
Wood Components
(NOT TO SCALE)
J9 - SUPPORT BOARD - W4L06064
1"x2 3/8"x3" (24x60x76)
6)
K1 - GROUND BOARD - W4L06052
5/8"x5 1/4"x74 1/2" (16x134x1893)
1)
K2 - GROUND BOARD - W4L06056
5/8"x5 1/4"x74 1/2" (16x134x1893)
1)
K3 - ARCHED RAIL - W4L06191
5/8"x5 1/4"x73 1/8" (16x134x1858)
1)
K4 - GROUND BOARD - W4L06049
5/8"x5 1/4"x54 1/2" (16x134x1384)
1)
K5 - GROUND BOARD - W4L06054
5/8"x5 1/4"x54 1/2" (16x134x1384)
1)
K6 - ARCHED RAIL - W4L06084
5/8"x5 1/4"x54 1/8" (16x134x1374)
1)
K7 - ARCHED RAIL - W4L06105
5/8"x5 1/4"x52 1/2" (16x134x1334)
1)
K8 - WALL RAIL - W4L06095
5/8"x5 1/4"x49 1/2" (16x134x1256)
1)
K10 - STAIR STEP BOARD - W4L06123
5/8"x4 5/8"x19" (16x119x483)
8)
K11 - HALF MOON PLATE - W4L06115
5/8"x5 1/4"x12 5/8" (16x134x320)
2)
K12 - GROUND BOARD - W4L06185
5/8"x5 1/4"x89 1/2" (16x134x2274)
1)
J10 - SUPPORT BOARD - W4L06194
1"x2 3/8"x3" (24x60x76)
1)
J11 - WALL RAIL - W4L06324
1"x2 3/8"x44 5/8" (24x60x1135)
2)
J12 - SWING RAIL SUPPORT - W4L06342
1"x2 3/8"x9 1/8" (24x60x232)
2)
K13 - WALL RAIL - W4L06322
5/8"x5 1/4"x45" (16x134x1142)
1)
K14 - WALL RAIL - W4L06325
5/8"x5 1/4"x44 5/8" (16x134x1135)
1)
K15 - ARCHED RAIL - W4L06326
5/8"x5 1/4"x30 3/8" (16x134x772)
1)
6

Parts Identification
Wood Components
(NOT TO SCALE)
L1 - SUPPORT BOARD - W4L06128
5/8"x3 5/8"x22 3/4" (16x92x579)
1)
M1 - GROWTH BOARD - W4L06143
5/8"x3 3/8"x60 1/4" (16x86x1530)
1)
M2 - WALL BOARD - W4L06097
5/8"x3 3/8"x61 1/4" (16x86x1557)
1)
M3 - WALL BOARD - W4L06099
5/8"x3 3/8"x61 1/4" (16x86x1557)
1)
M4 - WALL BOARD - W4L06109
5/8"x3 3/8"x61 1/4" (16x86x1557)
2)
M5 - WALL BOARD - W4L06111
5/8"x3 3/8"x61 1/4" (16x86x1557)
1)
M6 - FLOOR BOARD - W4L06066
5/8"x3 3/8"x54 1/2" (16x86x1384)
14)
M7 - WALL RAIL - W4L06087
5/8"x3 3/8"x54 1/2" (16x86x1384)
1)
M8 - ARCHED RAIL - W4L06101
5/8"x3 3/8"x54 1/2" (16x86x1384)
1)
M9 - WALL BOARD - W4L06148
5/8"x3 3/8"x54 1/4" (16x86x1377)
2)
M10 - ARCHED RAIL - W4L06103
5/8"x3 3/8"x53 1/8" (16x86x1350)
1)
M11 - ROOF RAFTER - W4L06114
5/8"x3 3/8"x43 7/8" (16x86x1114)
4)
M13 - WALL RAIL - W4L06112
5/8"x3 3/8"x29 1/4" (16x86x744)
1)
L2 - SUPPORT BOARD - W4L06142
5/8"x4 3/8"x15 5/8" (16x112x397)
1)
M12 - ROCK WALL BOARD - W4L06337
5/8"x2 3/4"x27 3/4" (16x70x704)
1)
7

Parts Identification
Wood Components
(NOT TO SCALE)
M14 - WALL RAIL - W4L06113
5/8"x3 3/8"x28 5/8" (16x86x728)
1)
M15 - FLOOR BOARD - W4L06120
5/8"x3 3/8"x29 1/8" (16x86x740)
17)
M16 - FLOOR BOARD - W4L06130
5/8"x3 3/8"x27 3/4" (16x86x704)
1)
M17 - WALL RAIL - W4L06094
5/8"x3 3/8"x27 1/4" (16x86x692)
1)
M18 - WALL BOARD - W4L06108
5/8"x3 3/8"x27" (16x86x686)
2)
M19 - WALL BOARD - W4L06096
5/8"x3 3/8"x27" (16x86x686)
11)
M20 - ATTACHMENT BOARD - W4L06146
5/8"x3 3/8"x21 1/2" (16x86x547)
1)
M21 - FLOOR BOARD - W4L06080
5/8"x3 3/8"x21 1/4" (16x86x540)
13)
M22 - FLOOR BOARD - W4L06081
5/8"x3 3/8"x21 1/4" (16x86x540)
1)
M23 - STAIR STEP BOARD - W4L06122
5/8"x3 1/4"x19" (16x83x483)
24)
M24 - WALL RAIL - W4L06107
5/8"x3 3/8"x15 5/8" (16x86x398)
2)
M25 - WALL RAIL - W4L06098
5/8"x3 3/8"x6 3/4" (16x86x172)
1)
M26 - WALL RAIL - W4L06110
5/8"x3 3/8"x5 3/8" (16x86x138)
1)
N1 - FLOOR BOARD - W4L06067
5/8"x2 3/8"x54 1/2" (16x60x1384)
2)
N2 - SUNBURST BOARD - W4L06116
5/8"x2 3/8"x24 3/8" (16x60x620)
2)
M27 - CORNER BOARD - W4L06147
5/8"x3 3/8"x50 3/8" (16x86x1280)
2)
M28 - WALL BOARD - W4L06180
5/8"x3 3/8"x61 1/4" (16x86x1557)
1)
M29 - WALL BOARD - W4L06181
5/8"x3 3/8"x28 5/8" (16x86x726)
14)
M30 - ATTACHMENT BOARD - W4L06338
5/8"x3 3/8"x29" (16x86x736)
1)
M70 - SLIDE BED SUPPORT - W100935
5/8"x3 3/8"x19 7/8" (16x86x505)
1)
M74 - ROCK WALL BOARD - W4L06332
5/8"x3 3/8"x27 3/4" (16x86x704)
9)
M75 - ROCK WALL BOARD - W4L06333
5/8"x3 3/8"x27 3/4" (16x86x704)
4)
M76 - ROCK WALL BOARD - W4L06334
5/8"x3 3/8"x27 3/4" (16x86x704)
4)
M108 - TOP BOARD - W4L06331
5/8"x3 3/8"x29" (16x86x736)
1)
8

Parts Identification
Wood Components
(NOT TO SCALE)
N3 - FLOOR BOARD - W4L06078
5/8"x2 3/8"x19 3/4" (16x60x502)
2)
N4 - SUNBURST BOARD - W4L06118
5/8"x2 3/8"x19 5/8" (16x60x500)
8)
N6 - SUNBURST BOARD - W4L06117
5/8"x2 3/8"x15 7/8" (16x60x404)
4)
O1 - PICKET - W4L06135
5/8"x1 3/8"x31 1/4" (16x34x795)
22)
Q1 - SUPPORT BOARD - W4L06129
1"x4 3/8"x22 3/4" (24x112x579)
1)
SP50 - SWING BEAM SUPPORT - W4L06170
3 3/8"x3 3/8"x49 3/8" (86x86x1254)
1)
T1 - SUPPORT BOARD - W4L06075
1"x1 3/8"x50" (24x34x1270)
1)
T2 - SUPPORT BOARD - W4L06065
1"x1 3/8"x49 5/8" (24x34x1260)
2)
T3 - PICKET - W4L06136
1"x1 3/8"x27 1/8" (24x34x688)
1)
T4 - SUPPORT BOARD - W4L06077
1"x1 3/8"x23 7/8" (24x34x606)
1)
T5 - SUPPORT BOARD - W4L06076
1"x1 3/8"x21 1/2" (24x34x546)
1)
T6 - PICKET - W4L06137
1"x1 3/8"x19 5/8" (24x34x500)
1)
T7 - PICKET - W4L06138
1"x1 3/8"x18 3/8" (24x34x468)
1)
T8 - SUPPORT BOARD - W4L06119
1"x1 3/8"x16 5/8" (24x34x423)
2)
T9 - PICKET - W4L06139
1"x1 3/8"x15 1/4" (24x34x386)
1)
N5 - FLOOR BOARD - W4L06328
5/8"x2 3/8"x26 1/4" (16x60x668)
1)
N7 - SWING BACK SUPPORT - W4L06349
5/8"x2 3/8"x26 5/8" (16x60x676)
1)
N8 - SWING SEAT SUPPORT - W4L06350
5/8"x2 3/8"x24 3/4" (16x60x628)
1)
O2 - SWING SEAT BOARD - W4L06339
5/8"x1 3/8"x26 5/8" (16x36x676)
7) O3 - SWING SEAT BOARD - W4L06340
5/8"x1 3/8"x28 1/2" (16x36x724)
7)
9

Parts Identification
Wood Components
(NOT TO SCALE)
T10 - PICKET - W4L06140
1"x1 3/8"x12" (24x34x304)
1)
T11 - PICKET - W4L06141
1"x1 3/8"x8 3/4" (24x34x222)
1)
E12 - UPRIGHT - W2A01864
1 3/8"x3 3/8"x57 3/8" (36x86x1457)
1)
RP1 - ROOF PANEL - W2A01860
1 3/8"x12 1/4"x59 1/2" (35x311x1532)
2)
RP2 - ROOF PANEL - W2A01861
1 3/8"x16 1/8"x59 1/2" (35x410x1532)
2)
RP3 - ROOF PANEL - W2A01862
1 3/8"x16 1/8"x59 1/2" (35x410x1532)
2)
SR1 - STAIR RAIL - W2A01863
1"x8 3/8"x82 5/8" (24x214x2099)
1)
SR2 - STAIR RAIL - W2A01868
1"x8 3/8"x82 5/8" (24x214x2099)
1)
T12 - SUPPORT BOARD - W4L06329
1"x1 3/8"x40 1/2" (24x34x1029)
2)
10

Parts Identification
Hardware
- NUT BARREL WH 5/16x7/8 BLK - H100192
30)
- BOLT WH 5/16x2-3/4 BLK - H100195
2)
- BOLT WH 5/16x2-1/4 BLK - H100205
67)
- LAG SCREW WH 5/16x3 BLK - H100206
4)
- BOLT WH 5/16X6 BLK - H100363
1)
- BOLT WH 5/16x1 3/4 BLK - H100378
18)
- BOLT WH 5/16x1/2 BLK - H100396
7)
- BOLT WH 5/16x1 1/2 BLK - H100407
29)
- BOLT WH 5/16x3 BLK - H100416
6)
- BOLT WH 5/16x2 BLK - H100457
42) - LAG SCREW WH 5/16x2 BLK - H100458
28)
- BOLT WH 5/16x1 1/4 BLK - H100459
1)
- BOLT WH 5/16x1 BLK - H100468
4)
- LAG SCREW WH 5/16x1-1/2 BLK - H100471
43)
- BOLT WH 5/16x4 3/4 BLK - H100480
2)
- BOLT WH 5/16x3 1/4 BLK - H100484
1)
11

Parts Identification
Hardware
- BOLT HEX 3/8x5-1/2 - H100654
(13)
- SCREW PFH 8x1-1/4" - H100087
(176)
- SCREW PFH 8x1-1/8" - H100088
(216)
- SCREW PFH 8x1-3/4" - H100089
(87)
- SCREW PFH 8x2 1/2 - H100090
(62)
- SCREW PFH 8x2 - H100111
(11)
- SCREW PFH 8x3/4 - H100121
(4)
- SCREW PWH 8x5/8 - H100128
(2)
- BOLT HEX 5/16x4 1/4 BLK - H100476
(2)
- BOLT HEX 5/16x1 1/4 BLK - H100481
(4)
- SCREW PFH 8x3 - H100092
(13)
- SCREW PFH 8x1-1/2" - H100086
(348)
- BOLT HEX 5/16x1-1/2 - BLK - H100498
(7)
- NUT BARREL WH 1/4x7/8 BLK - H100399
(4)
- BOLT WH 1/4x1 1/2 BLK - H100406
(2)
- NUT BARREL WH 1/4x5/8 BLK - H100404
(11)
- SCREW PWH 8x1/2 BLK - H100408
(4)
- BOLT WH 1/4x1/2 BLK - H100401
(4)
- BOLT WH 1/4x5/8 BLK - H100486
(4)
- BOLT WH 1/4x1 BLK - H100171
(9)
- LAG SCREW WH 1/4x2 BLK - H100487
(4)
- LAG SCREW WH 1/4x1-1/2 BLK - H100403
(21)
- BOLT WH 5/16x1 1/4 - H100009
(9)
- NUT BARREL WH 5/16x5/8 - H100004
(3)
- BOLT WH 5/16x1/2 - H100115
(15)
- NUT BARREL WH 5/16x1 1/2 - H100006
(9)
- BOLT PTH 1/4x3/4 - H100063
(26)
12

Parts Identification
Hardware
- WASHER LOCK INT 8x15 - H100108
(26)
- T-NUT 5/16 - H100074
(3)
- T-NUT 1/4 - H100072
(26)
- WASHER LOCK EXT 12x19 - H100031
(3)
- WASHER FLAT 8x27 - H100105
(2)
- T-40 TORX WRENCH - A100041
(1)
- T-40 TORX BIT - A100042
(1) - T-30 TORX BIT - H100147 (1)
- T-30 TORX WRENCH - H100114
(1)
- SWING HANGER QUICK LINK 86 BOARD - H100098
(2)
- WASHER FLAT 11x25 - H100102
(13)
- WASHER FLAT 9x18 BLK - H100474
(24)
- WASHER LOCK EXT 8x19 BLK - H100198
(224)
- NUT LOCK 5/16 BLK - H100479
(9)
- NUT LOCK 5/16 - H100110
(2)
- WASHER LOCK EXT 12x19 BLK - H100199
(25)
- WASHER LOCK INT 10x18 - H100107
(13)
- T-NUT 3/8 - H100073
(13)
- T-NUT 5/16 BLK - H100379
(148)
- WASHER SAFETY 17x30 - H100103
(2)
- WASHER FLAT 8x27 BLK - H100478
(9)
- WASHER SPLIT 5/16 BLK - H100477
(7)
- WASHER LOCK EXT 6x15 BLK - H100405
(14)
- T-NUT 1/4 BLK - H100398
(4)
- WASHER LOCK EXT 8x15 BLK - H100400
(15)
- SCREW SETTER - H100764
(1)
- MAGNETIC DRIVER - H101100
(1)
13

Parts Identification
Accessories
(NOT TO SCALE)
EF - CHAIN GREEN 57" - A100047
4)
- BYD ID TAG (LARGE) AGES 3-10 - A1001641)
- QUICK LINK - A100069
10)
- CHAIN GREEN 31" - A100177
2)
- "A" REVISION TAG - A100314
1)
- SWING HANGER - A4M00505
6)
- 90° L-BRACKET - BLK - A4M00555
6)
- METAL TUBE - A4M00597
47)
- METAL TUBE - A4M00620
15)
- HAND GRIP METAL BLACK 381 c/c - A4M00613
4)
- L BRACKET BLK - A4M00615
2.5x38x50x55
2)
- METAL RUNG 547 - A4M00616
5)
- SWING BEAM EXTENSION
BRACKET-RIGHT - A4M00618
1)
- L BRACKET 66x66x127 - BLK - A4M00619
2)
- TRAPEZE YELLOW - A6P00034
1)
- SWING SEAT GREEN 22" - A6P00054
2)
- PLASTIC CURTAIN ROD - A6P00090
1)
- AUGER GROUND STAKE - A100178
10)
- METAL DECK BRACE 380 C/C - A4M00630
2)
- SLIDE TUBE SUPPORT - A6P00487
4)
- SWING BEAM EXTENSION
BRACKET-LEFT - A4M00617
1)
14

Parts Identification
Accessories
(NOT TO SCALE)
- CURTAIN - A6P00089
2)
- HAMMOCK - A6P00066
1)
483 - SLIDE RAIL 10' BOTTOM LEFT GREEN - A6P00483
1)
484 - SLIDE RAIL 10' BOTTOM RIGHT GREEN - A6P00484
1)
485 - SLIDE RAIL 10' TOP LEFT GREEN - A6P00485
1) 486 - SLIDE RAIL 10' TOP RIGHT GREEN - A6P00486
1)
- SLIDE BED 10' LIGHT GREEN - A100035
1)
- GREEN HC ROCK #1 - A6P00036
6)
- GREEN HC ROCK #2 - A6P00037
6)
- CHAIN - A4M00638
2)
- TIE STRAP PLATE BLK - A4M00631
2)
- CHAIN SUPPORT BRACKET BLK - A4M00632
2)
15

H100194 BOLT WH
5/16 x 2-1/2
(x2)
PRE-ASSEMBLY STEP 1 - SORTING PARTS
It is critical for ease of assembly that you take the time to sort and organize the wood and hardware.
WOOD PARTS:
• Organize wood parts by the three-digit, alpha-numeric number stamped on each board (ex. P01).
• If there are multiple boards with the same stamped number, stack those pieces together.
• Stamps can be found on the flat surface of the boards or on the end of the boards.
• Allow yourself plenty of room - the wood pieces can take up a significant amount of space.
NOTE: CARTONS ARE NOT ORGANIZED BY BOARD NUMBER.
HARDWARE PARTS:
• We recommend that you have a separate table to organize the hardware.
• Hardware bags are printed with a seven-digit, alpha-numeric part number.
• You can organize your hardware by part number or group by hardware type (i.e. bolts, nuts, etc.).
• During assembly you only need to reference the last four digits of the number.
16

PRE-ASSEMBLY STEP 2 - TOOLS REQUIRED
Cordless Drill or
Electric Drill
Drill Attachments:
Phillips Head
Open End Wrenches 1/2" & 9/16"
Phillips Screw Driver
1/8", 3/16", 3/8" & 7/16"
Drill Bits
3/8" Drive Ratchet, 1/2" &
9/16" STD Sockets 1/2" & 9/16" Deep
Sockets
Claw Hammer Rubber Mallet - Optional
Tape Measure
Square
Level 24"
17

PRE-ASSEMBLY STEP 3 - CHOOSE YOUR ASSEMBLY METHOD
There are several types of assembly instructions available to you.
1. Printed Assembly Manual included with your set
2. BILT APP - 3D interactive instructions
3. Combination of the Printed Manual and BILT APP (Note: Step numbers can differ between the two
methods)
18

ROCKWALL ASSEMBLY
STEP 1
T-NUT 5/16 BLK
(2 PLCS)
M30
SCREW PFH 8x1-1/2"
(72 PLCS)
M12
E72
E73
M74
M76
M74
M75
M74
M76
M74
M75
M74
M76
M74
M75
M74
M76
M75
M74
M74
E72 - LEFT RAIL - W4L06335
1 3/8"x3 3/8"x61 1/8" (36x86x1553)
1)
E73 - RIGHT RAIL - W4L06336
1 3/8"x3 3/8"x61 1/8" (36x86x1553)
1)
M12 - ROCK WALL BOARD - W4L06337
5/8"x2 3/4"x27 3/4" (16x70x704)
1)
M74 - ROCK WALL BOARD - W4L06332
5/8"x3 3/8"x27 3/4" (16x86x704)
9)
M76 - ROCK WALL BOARD - W4L06334
5/8"x3 3/8"x27 3/4" (16x86x704)
4)
M75 - ROCK WALL BOARD - W4L06333
5/8"x3 3/8"x27 3/4" (16x86x704)
4)
M30 - ATTACHMENT BOARD - W4L06338
5/8"x3 3/8"x29" (16x86x736)
1)
SCREW PFH
8x1-1/2"
(72)
T-NUT 5/16
BLK
(2)
START AT TOP
19

ROCKWALL ASSEMBLY
STEP 2
SCREW PFH 8x1-1/2"
(2 PLCS)
M108
BOARD WITH T-NUTS
(T-NUTS TO INSIDE)
SCREW PFH 8x1-1/2"
(4 PLCS)
BOARD WITH T-NUTS M108 - TOP BOARD - W4L06331
5/8"x3 3/8"x29" (16x86x736)
1)
5/8
SCREW PFH
8x1-1/2"
(6)
20