Beachside Lighting ТК-1 User manual

TK-1 GAS TIKI TORCH
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
DANGER
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
• Shut off gas to the appliance.
• Extinguish any open ame.
• If odor continues, leave the area immediate-
ly.
• After leaving the area, call your gas supplier
or re department.
Failure to follow these instructions could result
in re or explosion, which could cause proper-
ty damage, personal injury, or death.
Do not store or use gasoline, or other
ammable vapors and liquids, in the vi-
cinity of this or any other appliance.
An LP-cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
WARNING
Installation and service must be per-
formed by a qualied installer, service
agency, or the gas supplier.
WARNING: For Outdoor Use Only.
INSTALLER: Leave this manual with the
appliance.
CONSUMER: Retain this manual for fu-
ture reference.
WARNING: If the information in this manual
is not followed exactly, a re or explosion may
result causing property damage, personal inju-
ry, or loss of life.
This appliance can produce carbon monoxide, which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space such as a camper,
tent, car, or home.
CARBON MONOXIDE HAZARD
DANGER
CSA Listed
U.S. and Canada
ANSI
Z21.97-2017
905 Kalanianaole Hwy, Spc. 2901
Kailua, Hawaii 96734
800-405-6732 • 808-263-5717 (Oahu)
www.BeachsideLighting.com
Ensure manual gas valve is completely closed after shutdown. Propane gas is heavier than air. If unignited
gas ow is present, it will form ‘pools’ of gas at ground level.
Keep this instruction manual in a convenient place. The two included English and French Installation warning labels MUST
BE AFFIXED IN A CONSPICUOUS LOCATION adjacent to the torch, such as on the gas supply pipe beneath the coupling.
WARNING:
Improper installation, adjustment, alteration, or service can cause property damage or injury. Refer to this
instruction manual. For assistance or additional information, consult a qualied installer.
This appliance is direct match ignition. If gas ow is detected before attempting to light, STOP, shut off manual
valve, and wait 5 minutes before attempting to light this appliance.
An appropriate gas pressure regulator must be installed upstream of torch assembly to ensure proper gas ow
and pressure. See attached installation diagram.

CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
DANGER
DANGER
RISQUE D’INCENDIE OU D’EXPLOSION
S’il y a une odeur de gaz:
• Coupez l’admission de gaz de l’appareil.
• Éteindre toute amme nue.
• Si l’odeur persiste, éloignez-vous de l’ap-
pareil et appelez immédiatement le fournis-
seur de gaz ou le service d’incendie.
Ne pas observer ces instructions pourrait en-
traîner incendie ou explosion causant dom-
mages matériels, blessures corporelles ou
mort.
Ne pas entreposer ni utiliser de l’es-
sence ni d’autres vapeurs ou liquides
inammables dans le voisinage de l’ap-
pareil, ni de tout autre appareil.
Une bouteille de propane qui n’est pas
raccordée en vue de son utilisation,
ne doit pas être entreposée dans le
voisinage de cet appareil ou de tout au-
tre appareil.
ADVERTISSEMENT
ADVERTISSEMENT: Si vous n’observez pas
à la lettre les instructions contenues dans le
présent document, un incendie ou une explo-
sion pourrait survenir et entraîner des dom-
mages matériel, des blessures ou la perte de
vie.
Cette appareil peut produire du monoxyde de carbone, un gaz
inodore.
L’utilisation de cet appareil dans des espaces clos peut entrain-
er la mort.
Ne jamais utiliser cet appareil dans un espace clos comme un
véhicule de camping, une tente, une automobile ou une maison.
MONOXYDE DE CARBONE
DANGER
Ne pas utiliser cet appareil s’il a été plongé, même partiellement, dans l’eau. Appeler un technicien qualié pour inspecter
l’appareil et remplacer toute partie du système de commande et toute commande qui a été plongée dans l’eau.
L’installation et la réparation de cet ap-
pareil doivent être effectuées par un in-
stallateur qualié, un centre de service
licencié ou votre fournisseur de service
du gaz.
ADVERTISSEMENT: Pour utilisation
à l’extérieur seulement.
INSTALLATEUR: Laissez ce manuel avec l’appareil.
CONSOMMATEUR: Conserver ce manuel pour référence future
Gas Pressure Requirements
Minimum inlet gas supply pressure for adjustment purposes: 4.0 inches water column for natural gas, 8.0 in. for propane.
Maximum inlet gas supply pressure: 10.5 inches water column for natural gas, 13.0 in. for propane.

• Keep appliance free and clear of ammable material.
• Brush debris from torch head.
• Clean insects and debris from fresh air inlet openings (propane torches only--see diagram).
• Use damp soapy cloth to clean copper body.
• Do not introduce cleaning compounds near printed instruction label or torch head.
• Inspect burner head and ame (see General Precautions below). If it is evident that the burner head is damaged, it must be replaced
prior to the appliance being put into operation. Contact Beachside Lighting for appropriate replacement parts.
Daily Maintenance
Conversion requires a separate orice and may require inlet holes or plugs. Contact Beachside Lighting for details.
Gas Conversion
• Although agency tested, per ANSI standards, observed satisfactory wind and rain tests, this appliance should be extinguished in the
event of moderate to severe storm conditions.
• Ensure rigidity of the steel conduit/support with another anchored device. DO NOT install this appliance in a location where the public
or heavy objects may lean or bump into the assembly.
• Keep the holes in the base of the torch free from debris and insects (see diagram). These holes are for supplementary air intake and
rain water drainage.
• The torch body can become hot after long operation. Do not touch torch until cooled.
• The ame should appear yellow with some blue at its base. This indicates proper burning.
• If gas supply pressure is between 4-5 in. water column, contact Beachside Lighting for a replacement main gas orice.
General Precautions
Turn on manual gas valve. Allow gas to ow for 2-3 seconds. Use an extended match or lighter to ignite torch by touching screen at top
of torch head.
Lighting and Extinguishing Instructions
For safe and enjoyable use:
• When an appliance is for connection to a xed piping system, the installation must conform with local codes, or in the absence of local
codes with the National Fuel Gas Code, ANSI Z223.1 • NFPA 54; Natural Gas and Propane Installation Code, CSA B149.1; or Propane
Storage and Handling Code, CSA B149.2, as applicable.
• Solid fuels shall not be burned in this appliance.
• Keep the appliance area clear and free from combustible materials, gasoline, and other ammable vapors and liquids.
• The appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure
testing of the gas supply piping system at test pressures equal to or less than ½ psi (3.5 kPa)
• Minimum 4 feet (1.22 meters) to walls and combustible plants, furniture, etc.
• No overhead obstructions, such as roof overhangs, tree limbs, etc.
Safe Operating Clearances
Do not use this appliance if any part has been under water. Immediately call a qualied service technician to inspect the
appliance and to replace any part of the control system and any gas control that has been under water.
• Gas supply cylinder must be constructed and marked in accordance with the U.S. Department of Transportation (D.O.T.) Specications
for LP-Gas Cylinders, or the Standard for Cylinders, Spheres and Tubes for Transportation of Dangerous Goods and Commission,
CAN/CSA-B339, as applicable.
• Gas supply cylinder must be provided with a listed overlling prevention device
• Gas supply cylinder must be provided with a cylinder connection device compatible with the connection for the appliance.
Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid
burns or clothing ignition.
Young children should be carefully supervised when they are in the area of the appliance.
Clothing or other ammable materials should not be hung from the appliance or placed on or near the appliance.
Any guard, barrier, or other protective device removed for servicing the appliance shall be replaced prior to oper-
ating the appliance.
Installation and repair should be done by a qualied service person. The appliance should be inspected before
use and at least annually by a qualied service person. More frequent cleaning may be required as necessary. It is
imperative that the control compartment, burners, and circulating air passageways of the appliance are kept clean.
Installation is re hazard tested and approved by CSA for clearances of 4 feet from any side wall and 6 feet to a ceiling above. However,
Beachside Lighting only recommends open-air installations with no overhead obstructions.
Shutdown: Close manual valve to extinguish ame.

GRADE
18" MIN
12"
MIN
7'-0" TYP
(7'-6" MAX) 6'-6" MIN
18"
HEAVY-DUTY GAS BALL VALVE
1" DIAMETER GALVANIZED STEEL PIPE
(BY OTHERS). PAINT ALL EXPOSED
PIPING WITH TWO (2) COATS OF
PAINT.
UNDERGROUND PIPE
PROTECTION WRAP
RECOMMENDED
CONCRETE: MIN. 24" x 12" x 18" DEEP
(4) AIR INLET HOLES (PROPANE ONLY)
CLOSE COMPLETELY TO
EXTINGUISH FLAME
IGNITE WITH EXTENDED MATCH
OR LIGHTER AT BURNER HEAD
(4) DRAIN HOLES
PROPER OPERATION SHOWS
YELLOW FLAME APPROXIMATELY
12 " TO 18" LONG
CONSULT A LICENSED PLUMBER FOR GAS PIPE LAYOUT AND INSTALLATION
Failure to position the parts in accordance with these diagrams or failure to use only parts
specically approved with this appliance may result in property damage or personal injury.
WARNING:

GRADE
18" MIN
12"
MIN
HEAVY-DUTY GAS BALL VALVES
UNDERGROUND PIPE
PROTECTION WRAP
RECOMMENDED
CONCRETE: MIN. 24" x 12" x 18" DEEP
CLOSE COMPLETELY TO
EXTINGUISH FLAME
1" DIAMETER GALVANIZED STEEL PIPE
(BY OTHERS). PAINT ALL EXPOSED
PIPING WITH TWO (2) COATS OF
PAINT.
CONSULT A LICENSED PLUMBER FOR GAS PIPE LAYOUT AND INSTALLATION
Failure to position the parts in accordance with these diagrams or failure to use only parts
specically approved with this appliance may result in property damage or personal injury.
WARNING: