BlueRhino Endless Summer 71400 User manual

Owner’s Manual
Manual del Usuario
Model No.
71400
WARNING
FOR YOUR SAFETY:
Improper installation,
adjustment, alteration,
service or maintenance
can cause injury or property
damage. Read the installation,
operation and maintenance
instructions thoroughly before
installing or servicing this
equipment.
ADVERTENCIA
PARA SU SEGURIDAD:
Una instalación, ajuste,
alteración, reparación o
mantenimiento inadecuados
puede causar lesiones o daños
a la propiedad. Lea
atentamente las instrucciones
de instalación, funcionamiento
y mantenimiento del equipo
antes de instalarlo o ponerlo en
marcha.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
Solamente Para Uso En
Exteriores
(fuera de cualquier recinto)

1Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Table of Contents
Safety First! . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Assembly Instructions
Hardware & Component Listing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
General Components & Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Additional Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Step 1 Attach Emitter Screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Step 2 Attach Top Wire Guard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Step 3 Attach Dome to Emitter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Step 4 Gas Hook-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Step 5 Check for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Step 6 Install Access Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Step 7 Securing the tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Operation
Before Turning Gas Supply ON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Before Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Re-Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Shutdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Operation Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
The use and installation of this product must conform to local codes.
In absence of local codes, use the National Fuel and Gas Code, ANSI
Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases,
ANSI/NFPA 58 or CSA B149.1, Natural Gas and Propane Installation
Code.
Save these instructions for future reference.
If you are assembling this unit for someone else, give
this manual to him or her to save for future reference.
WARNING
FOR YOUR SAFETY:
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. If odor continues, contact
your gas supplier or local
fire department.
WARNING
California Proposition 65:
Chemicals Known To The
State Of California To Cause
Cancer, Birth Defects, Or
Other Reproductive Harm Are
Created By The Combustion
Of Propane.
WARNING
FOR YOUR SAFETY:
Do not store or use gasoline
or other flammable vapors or
liquids in the vicinity of this
or any other appliance.
WARNING
FOR YOUR SAFETY:
1. Gas leaks may cause a fire
or explosion which can
cause serious bodily injury
or death, or damage to
property.
2. You must follow all leak-
checking procedures as
outlined in step 5 before
operating this unit.
3. Never use an open flame to
check for leaks.

2
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Safety First!
Read and become familiar with this entire manual, especially the following
precautions. If you are unsure of anything in these instructions or the
operation of your heater, STOP and contact 1-800-762-1142 for assistance.
Caution: This appliance is for outdoor use only (outside any enclosure).
Always make sure there is fresh air ventilation.
• Always maintain at least 36” clearance from combustible materials.
• Always place heater on a hard and level surface.
• Do not use if the wind velocity is greater than 10 miles per hour.
• Heater operates at reduced efficiency below 40ºF (5ºC).
• Keep sprinklers and other water sources away from burner and controls.
• When using the gas extension hose always locate the hose out of
pathways where people may trip over it or in areas where the hose may
be subject to accidental damage.
• Always use extreme caution when near heater. Alert both children
and adults to the hazards of high temperatures, especially to avoid
burns or clothing catching fire.
• Young children and pets should be carefully supervised when they
are in the area of heater.
• Do not hang clothing or other flammable materials either on or
near heater.
• Any guard or other protective device removed for servicing the
heater must be replaced prior to operating the heater.
• Certain materials or items, when stored under heater, will be subjected to
radiant heat and could be seriously damaged.
• Do not modify heater in any manner.
• The pressure regulator and hose assembly supplied with the appliance
must be used and replacements must be those specified by the
manufacturer.
• Inspect heater and extension hose before each use of the appliance. If a
damaged part is detected, do not operate until an original equipment
replacement part has been properly installed. Use of unauthorized parts
will void warranty and create an unsafe condition.
• Do not attempt to use this appliance without a functional factory-supplied
gas regulator in place. If regulator becomes damaged, use only a factory-
supplied replacement.
• During operation, do not touch burner assembly. The surface of heater’s
emitter can reach temperatures approaching 1600ºF.
• After shutdown, do not touch emitter assembly until heater has cooled
(approximately 45 minutes after use).
Notice: This product should not be used with any fuel other than liquid
propane. Use of other fuels will detract from heaters performance and will
void your warranty.
WARNINGS
FOR YOUR SAFETY:
• Purchaser assumes all risk in
the assembly and operation of
this unit. Failure to follow this
manual’s warnings and
instructions can result in
severe personal injury, death
or property damage.
• Combustion of propane creates
carbon monoxide, which,
when used in enclosed
areas, can kill you.
• Dome is extremely hot to the
touch during operation. Never
touch the dome while the heater
is operating. Wait for unit to
cool down (approximately 45
minutes) after use.
• Do not use in an explosive
atmosphere. Keep heater away
from areas where flammable
liquids, gasoline, vapors, or
explosives are stored or used.
Before you do anything else,
read and understand all
precautions in Safety First!

3Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Caution: Liquid propane (LP) gas is flammable and hazardous if handled
improperly. Become aware of the characteristics before using any LP
product.
• LP Characteristics – Flammable, explosive, heavier than air - settles in
low areas.
•In its natural state, propane has no odor. For your safety, an odorant is
added that smells like rotten cabbage.
• Contact with liquid LP can cause freeze burns to skin.
• This heater is shipped from the factory for LP gas use only.
• Use only Department of Transportation (DOT) approved “20 lb.” LP gas
cylinders (same as commonly used on gas grills) with Acme Type 1/QCC
safety valves. These valves can be quickly identified by their external and
internal threads.
• Never use a cylinder with a damaged body, valve, collar or foot ring.
• When using a “20 lb.” LP gas cylinder, the cylinder supply system must be
arranged for vapor withdrawl.
• When using a “20 lb.” LP gas cylinder, the cylinder used must include a
collar to protect the cylinder valve.
• When heater is not in use, turn Control Valve OFF.
• Always perform a leak test on gas connections whenever a cylinder is
connected (see Steps 6 & 7). Never use a flame to test for leaks. Do not smoke
while performing a leak test.
Caution: It is essential to keep the heater’s valve compartment,
burners, and circulating air passages clean.
• Spiders and insects can create a dangerous condition that may damage heater
or make it unsafe. Keep burner area clean of all spiders, webs, or insects.
• Inspect heater before each use.
• Have heater inspected annually and repairs should be made by a
qualified service person.
• Check heater immediately if any of the following conditions exist:
• The smell of gas in conjunction with extreme yellow tipping of burner
flames.
•Heater does not reach proper temperature. Note – At temperatures less than
40ºF (5ºC), heat output will be restricted.
• Heater’s glow is excessively uneven.
• Burner makes popping noises during use. Note – A slight pop is normal
when burner is extinguished.
• Carbon deposits may create a fire hazard. Keep dome and emitter clean at
all times.
• Do not clean heater with combustible or corrosive cleaners. Use warm,
soapy water.
• Do not paint any part of this product.
FOR YOUR SAFETY:
Beware of Spiders
Spiders or small insects can get into
the burner tube or other openings of
your heater, and spin webs or build
nests. These obstructions can lead
to gas flow problems. It is important
to make frequent inspections of
these areas and clean them when
necessary.
Before operating your heater for the
first time, be sure to check for
obstructions that may have occurred
during shipment.
Need a cylinder or gas?
Try Blue Rhino cylinder exchange
service. It’s easy, fast, safe, and
available at tens of thousands of
conveniently located retail outlets
nationwide. You can purchase a
new full cylinder or exchange your
empty for a precision filled one.
For your nearest Blue Rhino retailer
visit www.bluerhino.com. Note: When using a 20 lb. Cylinder, it is necessary to use the special hose
adaptor provided for this connection. This adapter is supplied with a type POL
connecter at the cylinder connection end.
“20 lb.” LP Cylinder
Valve
18”-19”
Collar
Body
Foot

4
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Dome
Top Wire Guard
Emitter Assembly
Bottom Wire Guard
Post
Shroud Cover
Housing
Access Panel
Base
Components
Used In
Picture Qty Description Step
4Medium Screw 1
3Cap Nut 3
1Extension Hose 6
Hardware
Extension Hose
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03

5Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Assembly Instructions
General Components & Features
Familiarize yourself with all components before proceeding. Refer to page 4 for all hardware components.
Do NOT attempt assembly unless all components are available. If you believe a component is missing or damaged,
contact 1-800-762-1142 for assistance.
Additional Requirements
The following items are not included, but are necessary for the proper assembly of your heater. Do NOT attempt to
assemble without proper tools.
(1) - 7/16” Wrench
(1) - #2 Phillips Head Screwdriver
(1) - Leak Detection Solution (Instructions on how to make solution are included in Step 5)
(1) - 20 lb.(4-5 gallon) precision filled LP Gas Grill Cylinder
Note: You must follow all steps to properly assemble heater.
Step 1 – Attach Emitter Screen
• Line up 4 holes on bottom of Emitter Screen with corresponding holes
in Emitter Bottom, and insert (4) Medium Screws in holes until tight.

6
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Step 2–Attach Top Wire Guard
• Line up 4 prongs on Wire Guard Bottom with 4 holes on Emitter
Bottom, and Insert.
Note: It may be necessary to adjust the prongs slightly to line them up
with the holes.
Step 3–Attach Dome to Emitter
• Line up three studs in Emitter with holes in Dome. Slide Dome
carefully over studs, clamping Top Wire Guard securely in place.
Note: It may be necessary to adjust prongs of the Top Wire Guard
slightly to provide a secure fit.
• Install (3) Cap Nuts on studs and tighten with 7/16” wrench.
Do not over tighten.

7Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Step 4 – Gas Hook-up
Note: For best results, use heater with a 20 lb. cylinder.
The pressure regulator and hose assembly supplied with the appliance
must be used and replacements must be those specified by the
manufacturer.
To connect 20 lb. Cylinder
• Slip end of flexible gas line with brass fitting through center hole of
Base and up to threaded portion of regulator.
• Line up threads on fitting with those on regulator and rotate clockwise
until snug. HAND TIGHTEN ONLY. DO NOT USE ANY HAND
TOOLS TO MAKE THIS CONNECTION. BE CAREFUL NOT TO
CROSS THREADS WHEN SCREWING IN FITTING.
Note: if heater uses center clamp, hose can be routed through opening
in base and table.
• Set heater on base, making sure that flexible gas line is routed
through small slot in base.
• Attach gas line to cylinder by turning black plastic knob counter
clockwise into cylinder valve until tight.
Note: Be careful not to kink flexible gas line.
• When using the gas extension hose always locate the hose out of
pathways where people may trip over it or in areas where the hose
may be subject to accidental damage.
To connect 14.1 oz or 16.4 oz cylinder
Note: Some 1-lb cylinders may form frost when near empty.
• Line up threads on canister with those on regulator, insert and rotate
canister clockwise until they fit snugly together. HAND TIGHTEN
ONLY. BE CAREFUL NOT TO CROSS THREADS WHEN
SCREWING IN CANISTER.
Step 5 – Check for Leaks
To check for leaks:
• Make 1-2 oz. of leak solution by mixing one part liquid dishwashing
soap and 3 parts water.
• Spoon several drops (or use squirt bottle) of the solution onto the
regulator/canister connections.
• Inspect the connections and look for bubbles
• If NO bubbles appear, the connection is safe.
• If bubbles appear, there is a leak:
• Loosen and re-tighten this connection.
• Re-check for a leak.
• If you continue to see bubbles after several attempts, disconnect
propane source and contact 1-800-762-1142.
Caution:
Your Endless Summer Portable Heater
has been checked at all factory
connections for leaks. Recheck all
connections, as movement in shipping
can loosen connections. Check for
leaks even if your unit was assembled
for you at the store.
Caution:
Before you attempt to use a propane
cylinder, understand all cylinder and
propane related precautions in Section
#1 – “Safety First.”

8
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Step 6 – Install Access Panel
• Rotate door up to closed position and tighten thumb screw
Step 7 – Securing the Tank
Mount your 20 lb. cylinder to a sturdy object such as a table or post
within 3 to 4 feet of your heater when in use, this will prevent movement
or tipping of the cylinder during operation.
The clamp on the cylinder ring will attach to any round pole from 1” to
2” in diameter, or a square post from 1” to 2” square. It will also adapt to
various other shapes up to 2” wide.
Determine where to locate your 20 lb. cylinder. Be sure that it is within
2” what you are mounting it to.
Place the bracket halves around the object and insert the 2” bolts
through the open holes in one bracket and into the matching threaded
holes in the second bracket. Position bracket within 6” of the middle of
the cylinder. Finger tighten bolts.
Slide the 20 lb. cylinder into the curved portion of the bracket, making
sure strapping ends are not between cylinder and bracket. Enclose
cylinder in strap and securely tighten strap in buckle.
Using a 7/16” wrench, tighten the 2” bolts until they are secure. DO
NOT OVER TIGHTEN.
In some cases you may wish to secure your cylinder to a larger object
or a wall. It is possible to mount the bracket attached to the straps to
these surfaces by drilling matching holes and using screws and nuts or
lag screws (not provided) to secure your cylinder.
Note: Once you have read “safety first” and successfully completed
Steps 1 – 7, you are ready to begin operating your heater.

9Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Operation
Before Turning Gas Supply ON
Your heater was designed and approved for OUTDOOR USE ONLY.
DO NOT use it inside a building, garage, or any other enclosed area.
Make sure surrounding areas are free of combustible materials,
gasoline, and other flammable vapors or liquids.
Ensure that there is no obstruction to air ventilation.
Be sure all gas connections are tight and there are no leaks (see step 5).
Be sure the access panel is clear of debris.
Be sure any component removed during assembly or servicing is
replaced and fastened prior to starting.
Before Lighting
Heater should be thoroughly inspected before each use, and by a
qualified service person at least annually.
If relighting a hot heater, always wait at least 5 minutes for gas to
dissipate.
Lighting
1. Turn Gas Control Knob to OFF position.
2. Push in Control Knob and rotate to “ON” position. This will light
burner. If necessary, keep depressing and rotating Knob until burner
lights.
3. Once burner is lit, hold Control Knob in for at least 30 seconds and
release.
4. If burner does not stay lit, wait 5 minutes and repeat steps 2 and 3.
5. Once burner is lit, rotate Knob to desired heating level.
6. Replace Access Panel.
If you experience any ignition problem, turn off the heater and gas
supply, and consult “Troubleshooting” on page 12.
WARNINGS
FOR YOUR SAFETY:
• Do NOT attempt to operate
heater until you have read
and understand all
precautions in section 1
“Safety First.” Failure to do
so can result in serious
personal injury, death, or
property damage.
• If at any time you are unable
to light burner and smell gas,
wait 5 minutes to allow gas
to dissipate before
attempting to light heater.
• Do NOT touch emitter or
dome or move heater for at
least 45 minutes after use.
OFF
ON
HIGH
LOW
OFF
ON
HIGH
LOW

10
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Caution: Avoid inhaling fumes emitted from the heater’s first use.
Smoke and odor from the burning of oils used in manufacturing
will appear. Both smoke and odor will dissipate after
approximately 30 minutes. The heater should NOT produce thick
black smoke.
Note: The burner may be noisy when initially turned on. To eliminate
excessive noise from the burner, turn the Control Knob to the LOW
position. Then, turn the knob to the level of heat desired.
When heater is ON:
Emitter screen will become bright red due to intense heat. The color is
more visible at night.
Burner will display tongues of blue flame. These flames should not
be yellow or produce thick black smoke, indicating an obstruction of
airflow through the burners.
If yellow flame is detected, turn off heater and gas supply and consult
“Troubleshooting” on page 12.
Re-lighting
Note: For your safety, Control Knob cannot be turned ON without first
depressing Control Knob in OFF position and then rotating to ON.
1. Turn Gas Control Knob to OFF.
2. Wait at least 5 minutes to let gas dissipate before attempting to
relight burner.
3. Repeat the “Lighting” Steps 2 and 3 on prior page.
Shut Down
1. Rotate Gas Control Knob to OFF position. Normally, burner will
make a slight popping sound when extinguished.
2. Turn off gas at cylinder.
3. Remove Access Panel.
4. Unscrew gas line from regulator.
5. Close Access Panel.
Note: After use, some discoloration of the emitter screen is normal.
WARNING
FOR YOUR SAFETY:
Be careful when attempting to
manually ignite this heater.
Holding in the contrrol know for
more than 10 seconds before
igniting the gas will cause a ball
of flame upon ignition.

11 Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Operation Checklist
For a safe and pleasurable heating experience, perform this check before
each use.
Before Operating
 I am familiar with entire owner’s manual and understand all precautions
noted in “Safety First.”
 All components are properly assembled, intact and operable.
 No alterations have been made.
 All gas connections are secure and do not leak.
 Wind velocity is below 10 mph.
 Outdoor temperature is greater than 40 degrees F.
 Heater is outdoors (outside any enclosure).
 There is adequate fresh air ventilation.
 Heater is away from gasoline or other flammable liquids or vapors.
 Heater is away from windows, air intake openings, sprinklers and other
water sources.
 Heater is at least 36” from combustible materials.
 Heater is on a hard and level surface.
 There are no signs of spider or insect nests.
 All burner passages are clear.
 All air circulation passages are clear.
 Children, pets, clothing, flammable materials and items that can be
damaged from radiant heat are away from the heater.
 Children and adults in the area have been alerted to the high
temperature hazards: especially burns and clothing fires.
 Children and adults in the area have been warned not to touch heater
near engine during operation and until unit has cooled.
After Operation
 Gas control is in OFF position.
 Gas tank valve is OFF
 Disconnect Gas line.
 Heater is upright in a secure location.

12
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Troubleshooting
If the problem is: And this condition exists: Then do this
Burner won’t light Gas pressure is low
Blockage in burner openings
Blockage in venturi tube
Blockage in gas line
Control knob is not in ON position
Replace cylinder or canister
Clear blockage
Clean venturi
Check gas line for blockage
Turn control knob to ON
Burner won’t stay lit Bad thermocouple
Corrosion at thermocouple
Burner flame not touching
thermocouple
Replace thermocouple
Clean contact
Contact certified technican
Burner flame is low
Note: Heater operates at reduced
efficiency below 40ºF (5ºC)
Gas pressure is low
Outdoor temperature is less than
40ºF and tank is less than 1/4 full
Control knob fully ON
Turn Control Knob OFF and replace
cylinder or canister
Use a full cylinder or canister
Check burner and all openings for blockage
Emitter glows unevenly Gas pressure is low
Heater not level
Burner tilted
Replace cylinder or canister
Level heater
Straighten burner
Carbon build-up Base is not on a level surface
Heater is level
Dirt or film on reflector and emitter
Place heater on a level surface
Clean burner
Clean reflector and emitter
Thick black smoke Blockage in burner Remove blockage and clean burner inside
and outside

13 Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Maintenance
To enjoy years of outstanding performance from your heater make sure you
perform the following maintenance activities on a regular basis:
• Keep exterior surfaces clean.
• Use warm soapy water for cleaning. Never use flammable or corrosive
cleaning agents.
• While cleaning your unit, be sure to keep the area around the burner
and pilot assembly dry at all times. Do not submerge the control valve
assembly. If the gas control is submerged in water, do NOT use it.
It must be replaced.
Air flow must be unobstructed. Keep controls, burner, and circulating air
passageways clean. Signs of possible blockage include:
• Gas odor with extreme yellow tipping of flame
• Heater does NOT reach the desired temperature.
• Heater glow is excessively uneven.
• Heater makes popping noises.
Spiders and insects can nest in burner or orifices. This dangerous condition
can damage heater and render it unsafe for use. Clean burner holes by
using a heavy-duty pipe cleaner. Compressed air may help clear away
smaller particles.
Carbon deposits may create a fire hazard. Clean dome and emitter with
warm soapy water if any carbon deposits develop.
Note: In a salt-air environment (such as near an ocean) corrosion occurs
more quickly than normal. Frequently check for corroded areas and repair
them promptly.
TIP:
Use high-quality automobile wax to help maintain the appearance of your
heater. Apply to exterior surfaces from the pole down. Do not apply to
emitter screen, dome, or wire guard.

14
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Storage
Between uses:
Turn Control Knob OFF.
Disconnect LP source.
Store heater upright in an area sheltered from direct contact with
inclement weather (such as rain, sleet, hail, snow, dust and debris).
If desired, cover heater to protect exterior surfaces.
Note: Wait until heater is cool before covering.
During periods of extended inactivity or when transporting:
Turn Control Knob OFF.
Disconnect LP source and move to a secure, well-ventilated location
outdoors.
Store heater upright in an area sheltered from direct contact with
inclement weather (such as rain, sleet, hail, snow, dust and debris).
If desired, cover heater to protect exterior surfaces.
Note: Wait until heater is cool before covering.
Never leave LP cannister exposed to direct sunlight or excessive heat.
Service
To learn how to service and procure parts for worn out, defective or damaged
components contact 1-800-762-1142 for assistance or e-mail
[email protected]. Please supply model number and serial
ID number for best service support. These numbers can be found on the
heater’s rating plate, located on the housing.
Caution: The pressure regulator and hose assembly supplied with
the appliance must be used and replacements must be those specified
by the manufacturer. Use only original equipment replacement parts.
Use of unauthorized parts or modification of parts will void warranty
and create an unsafe condition.
Caution: Always allow heater to cool before attempting service.
FOR YOUR SAFETY:
Never attempt to refill disposable
canister. Refilling may cause
explosion. To discard, contact
local refuse hauler or recycle
center.
Do not puncture or incinerate.

Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
15 Owner’s manual and assembly instructions: 71400 portable outdoor heater 2/25/03
Warranty
Warranty Period
Heater’s warranty extends for 1 year from date of purchase by original purchaser.
Warranty Terms
Manufactured by Blue Rhino Global Sourcing 104 Cambridge Plaza Drive, Winston-Salem, NC 27104. 1-800-762-1142.
Manufacturer will cover: All parts found to be defective due to materials or workmanship for 1 year from the date of original purchase.
Proof of purchase is required before warranty performance will be rendered. Sales receipt and validation of product registration are
valid forms of proof of purchase.
Manufacturer will repair or replace parts returned prepaid freight in the U.S.A. at its sole discretion.
There are no other express or implied warranties.
Warranty Exclusion
Manufacturer will NOT cover:
Assembly or start-up
Normal adjustment to burner
Cleaning and/or general maintenance
Shipping damage
Any misuse which will be determined at the sole discretion of manufacturer
Damage or repairs due to service by an unauthorized agency or the use of unauthorized parts
Improper assembly, such as: no regulator, improper hook-up, etc.
Damage or repairs related to spider or insect nesting
Damage due to weather conditions
Warranty Procedures
For service or replacement parts, please call 1-800-762-1142 for return authorization and further instructions.
All returns must be sent via prepaid freight.
Legal Rights
No one else is authorized to make any warranties on behalf of manufacturer.
THIS WARRANTY IS IN LIEU OF ANY OTHER WARRANTY, EXPRESS OR IMPLIED, ORAL OR WRITTEN, INCLUDING, BUT NOT
LIMITED TO, ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE.
BLUE RHINO GLOBAL SOURCING SHALL NOT BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES
RESULTING FROM ANY DEFECTIVE PRODUCT, INCLUDING, BUT NOT LIMITED TO, LOST REVENUE OR PROFITS, BUSINESS
INTERRUPTION, OR ANY LEGAL THEORY UPON WHICH ANY CLAIM MAY BE BASED.
PURCHASER ASSUMES ALL RISK IN THE ASSEMBLY AND OPERATION OF THIS UNIT. FAILURE TO FOLLOW THIS MANUAL’S
WARNINGS AND INSTRUCTIONS CAN RESULT IN SEVERE PERSONAL INJURY, DEATH OR PROPERTY DAMAGE.
Some states do not allow limitations on how long an implied warranty lasts, or the exclusion or limitation relevant to incidental or
consequential damages.
This warranty gives you specific legal rights. You may also have other legal rights which vary from state to state.
Since product improvement is an ongoing process at the manufacturer, we reserve the right to change this product’s
specifications or design without notice.

16
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.
Specifications
Certifications:
CSA International Requirement 5.90
Canadian National Standard CAN1-2.23-M82
Rating:
Maximum 14,000 BTU/hr. input
Heat Range:
Up to 10 foot diameter
Fuel:
Liquid Propane Gas (LP)
Cylinder Size:
Nominal 20 lb / 5 Gallon
OR
14.1 oz. (400 grams)
16.4 oz. (465 grams)
Inlet gas supply pressure:
Maximum – 150 PSI
Minimum – 5 PSI
Manifold Pressure:
11.00 in. W.C.
Supply Pressure:
0.41 psig (11.00 in. W.C.)
Engine:
IPP E8
Safety Features:
100% Burner shut-off
Tilt Switch
Manufacturer:
Blue Rhino Global Sourcing
Made In:
China

17 Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.

18
Owner’s manual and assembly instructions: 71400 portable outdoor heater 3/3/03
Contact 1-800-762-1142 for assistance.
Do not return to place of purchase.

Índice
¡La Seguridad, lo Primero! . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Instrucciones de montaje
Lista de componentes y equipo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Componentes generales y características . . . . . . . . . . . . . . . . . . . . . . . . . 5
Requisitos adicionales . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Paso 1 Fijar la malla del conjunto de emisión de calor . . . . . . . . . . . . . . 5
Paso 2 Acoplar la protección de alambre superior . . . . . . . . . . . . . . . . . 6
Paso 3 Acoplar la cúpula al conjunto de emisión de calor . . . . . . . . . . . 6
Paso 4 Conexión de gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Paso 5 Comprobar si hay fugas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Paso 6 Instalar el panel de acceso . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Paso 7 Asegurar la bombona . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Operación
Antes de activar la alimentación de gas (ON) . . . . . . . . . . . . . . . . . . . . . . 10
Antes del encendido . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Encendido . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Reencendido . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Apagado . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Lista de control de operaciones . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Resolución de problemas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Mantenimiento . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Almacenamiento . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Servicio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Garantía . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Especificaciones . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
El uso y la instalación de este producto deben conformarse con los
códigos locales. En la ausencia de códigos locales, utilice el
código nacional del combustible y del gas, ANSI Z223.1/NFPA 54, el
almacenaje y la dirección de los gases licuefechos del petróleo,
ANSI/NFPA 58 o CSA B149.1, gas natural y código de la instalación
del propano.
1Manual de usuario e instrucciones de montaje: calentador de exterior portátil, 714000 3/3/03
Si necesita ayuda llame al 1-800-762-1142
No devuelva el artículo al lugar de compra
Conserve estas instrucciones para futuras consultas. Si está montando esta
unidad para otra persona, entréguele este manual para futuras consultas.
ADVERTENCIA
PARA SU SEGURIDAD:
Si huele a gas -
1. Cierre la entrada de gas al
aparato.
2. Apague cualquier llama activa.
3. Si el olor persiste, póngase en
contacto con su uministrador
de gas o con el departamento
de bomberos.
ADVERTENCIA
PARA SU SEGURIDAD:
1. Las fugas de gas pueden
provocar un fuego o una
explosión, que pueden
causar heridas personales de
gravedad o la muerte, así
como daños a la propiedad.
2. Debe seguir todos los proce-
dimientos de comprobación
de fugas, tal y como se
describen en el paso 13,
antes de utilizar esta unidad.
3. No utilice nunca una llama
abierta para comprobar si
hay fugas.
ADVERTENCIA
PARA SU SEGURIDAD:
No almacene ni utilice gasolina,
ni cualquier otro gas o líquido
inflamable cerca de éste o de
cualquier otro aparato.
ADVERTENCIA
Proposición del estado de
California Nº 65:
Existen productos químicos
que el Estado de California
reconoce como causantes de
Cáncer, Defectos Congénitos o
cualquier otro Daño durante la
Reproducción Creados por la
Combustión del Propano.