Jenn-Air CCE1400 User manual

mmmJENN-AIR
Use and Care Manual
Electric Cooktops with Grill
and Downdraft Options
Models CCE1400, CVE1400, CVE4180,
CVE4210, CVE4270, CVE4370
Model CVE1400
Model CVE4270

Read before operating your cooktop
All appliances - regardless of the manufacturer -have the potential through
improper or careless use to create safety problems. Therefore the following
safety precautions should be observed:
1. Be sure your appliance is properly installed and grounded by aqualified
technician.
2. Never use your appliance for warming or heating the room.
3. Children should notbe left alone or unattended in area where appliance is
in use. They should never be allowed to sit or stand on any part of the
appliance.
4. Wear proper apparel. Loose-fitting or hanging garments should never be
worn while using the appliance.
5. Do not repair or replace any part of the appliance unless specifically
recommended in this manual. All other servicing should be referred to an
authorized Jenn-Air Service Contractor.
6. Flammable materials should not be stored near surface units.
Do notuse water on grease fires. Smother fire orflame oruse dry chemical
or foam-type extinguisher.
8. Use only dry potholders. Moist or damp potholders on hot surfaces may
resultinburnsfrom steam. Do not let potholder touchhotheating elements.
Do not use a towel or other bulky cloth.
9. Use proper pan size. Many appliances are equipped with one or more
surface units of different size. Select cookware having flat bottoms large
enough to cover the surface unitheating element. The use of undersized
cookware will expose a portionof the heating element to direct contact and
may result inignitionofclothing. Proper relationship of cookware to heating
element will also improve efficiency and performance.
10. Never leave surface units unattended at high heat settings. Boil over
causes smoking and greasy spillovers that may ignite.
1!. On conventional element cooktops make sure that drip pans are in place.
Absence of these pans during cooking may subject wiring or components
underneath to damage.
12. Do not use aluminum foil to line surface unit drip pans or grill basin.
Installation of these liners may result in an electric shock or fire hazard.
13. Glazed cookware - only certain types of glass, glass-ceramic, ceramic,
earthenware, or other glazed cookware are suitable for cooktop surface
without breaking due to the sudden change in temperature. Use only such
cookware as you know has been approved for this purpose.
2

14. Cookware handles should be turned inward and not extend over adjacent
surface heating elements to avoid burns, ignition of flammable materials
and spillage due to unintentional contact with the cookware.
15. Do not soak or immerse removable heating elements in water.
16. CAUTION - Do not store items of interest to children in cabinets above
cooktop- children climbing on the cooktop to reach items could be seriously
injured.
17. Do not touch surface units or areas near units. Surface units or heating
elements may be hot even though they are dark in color. Areas near
surface units may become hot enough to cause burns. During and after
use, do not touch or let clothing or other flammable materials contact these
areas until they have had sufficient time to cool. Other surfaces may
become hot enough to cause burns - among these surfaces are the
cooktop.
18. Do not cook on glass-ceramic cooking surface if the cooktop is broken.
Cleaning solutions and spillovers may penetrate the broken cooktop and
create ashock hazard. Contact an authorized Jenn-Air Service Contractor.
19. Clean glass-ceramic cooktops with caution. If wet sponge or cloth is used
to wipe spills on a hot cooking area, be careful to avoid steam burns. Some
cleansers can produce noxious fumes if applied to a hot surface.
20. Do not operate with damaged cooking element after any product malfunc-
tion until proper repair has been made.
21. Keep all switches "OFF" when unit is not in use.
22. Clean only parts listed in this manual and use procedures recommended.
23. This appliance has been tested for safe performance using conventional
cookware. Do not use any devices or accessories that are not specifically
recommended in this manual. Do not use eyelid covers forthe surface units
or stovetop grills. The use of devices or accessories that are not expressly
recommended in this manual can create serious safety hazards, result in
performance problems, and reduce the life of the components of the
appliance.
- SAVE THESE INSTRUCTIONS -
3

Congratulationson your choice of a Jenn-Air electric cooktop. The chart below de-
scribes the differences between models.
Model#
CVE'1400
CVE4180
CVE 4210
no
........................yes
yes
,., ,,. Yes
yes
Convertible _Grill/Elements included, ......
no 4 _il elements
4 coil elements
1"grill, 2 c0il elements "
none
............................1 grill
1 grill
no
left bay
2bays
.............2 bays
3 bays
Before you begin cooking with your new cooktop, please take a few minutes to read
and become familiar with the instructionsin this book. On the following pages you will
find a wealth of information regarding all aspects of using your new cooktop. By
following the instructions carefully, you will be able to fully enjoy and properly maintain
your cooktop and achieve excellent results with the food you prepare.
Should you have any questions about using your Jenn-Air cooktop or need a use and
care manual for your cooktop cartridge, write to us at Jenn-Air Customer Assis-
tance, c/o Maytag Customer Service, P.O. Box 2370, Cleveland, TN U.S.A. 37320-
2370. Be sure to provide the model number for the manual requested.
Accessories ...................... Installing ................................................................... 12
Optional ................................................................... 20
Cartridges ........................ Installing ..................................................................... 7
Optional ................................................................... 21
Cleaning ........................... Cooktop Parts .................................................... 17-18
Grill ........................................................................... 16
Conventional Cdii Cooktop ........................................................................... 10-11
Cookware ......................... General ............................................................ 8-9, 10
Canning ................................................................ 9,11
Ducting ................................................................................................................ 19
Grill .................................. Cleaning ................................................................... 16
Grill Guide ................................................................ 14
Grilling Tips .............................................................. 15
Installing ................................................................... 12
Usage ...................................................................... 13
Safety Precautions ........................................................................................... 2-3
Service Information ............................................................................................. 22
Surface Controls ................................................................................................... 6
Ventilation System ................................................................................................ 5
4

The built-in ventilation system removes cooking vapors, odors and smoke from foods
prepared on the cooktop, grill and grill accessories. Regular use of this system will
insure a more comfortable and less humid kitchen which is free of heavy cooking
odors and fumes that normally create a frequent need for cleaning and redecorating.
I,',','Usingthe Ventilation System i
• To operate the ventilation system manually, push the switch located in front of the
air grille. If you push on the left side of the switch, the fan will operate at the Lo
speed. If you push on the right side of the switch, the fan will operate at the Hi
speed. To turn the fan off, the switch should be returned to the middle (level)
position.
• The ventilation system will operate automatica//y when the grill element is in use.
During grilling,the fan speed is automatically set for the Hi setting AND cannot be
changed to Lo speed.
• Use Hi fan speed for capturing steam. Use Lo fan speed for capturing smoke
when pan frying.
• The fan can be used to remove strong odors from the kitchen as when chopping
onions near the fan.
I NOTE CVE1400 OWNERS: The cooktop is designed with an automatic
control that may turn on the downdraft fan when large cookpots are used
for extended periods on the large elements. The fan will shut off when
the cooktop has cooled down. (See p. 10.)
ICleaning the Ventilation System I
Air Grille: The airgrille lifts off easily. Wipe clean or wash in sink with mild household
detergents. May be cleaned in dishwasher.
Filter: Turn offventilation system before removing. Turn filter
retainer clipto remove filter.The filter is a permanent type and
should be cleaned when soiled. Clean in sink with warm water
_and liquid dishwashing detergent or in dishwasher.
IMPORTANT: DO NOT OPERATE SYSTEM W/THOUT
FILTER. Filter should always be placed at an angle. As you
face the front of the cooktop, the top of the filter should rest
against the left side of the vent opening and the bottom of the
filter should rest against the right side of the vent chamber at
the bottom. (NOTE: Iffilter isflat against the fan wall, ventilation
effectiveness is reduced.)
Ventilation Chamber: This area, which houses the filter,
should be cleaned inthe event of spillsor whenever it becomes
coated with a film of grease. The ventilation chamber may be
cleaned with paper towel, damp cloth, or sponge and with a
mild household detergent or cleanser.
5

Theinfinitesurfacecontrolsprovideflexibilityin settingselectionwhenusingthecook-
topor grill.
iTo Set Controls J
• Since the controls are a push-turn type, they must be pushed down before turn-
ing. To set (from the OFF position), push down on control knob and turn in either
direction to desired setting.
• When the control is in any position, other than OFF, it may be turned in any direc-
tion without pushing down.
• The red light bar (in front of the control knob area) willglow when any control knob
is ON.
......................, ii i !
1. Leftrear element (rear Energy-Saveror Standardgrill)
2. Leftfront element (frontEnergy-Saver)
3. Rightfront element (frontEnergy-Saver or Standard grill)
4. Rightrear element (rearEnergy-Saver)
Note: For model CVE4370, the rightbay isfor 2.
cooktopcartridgesonly. J,.......................
NOTE:The =Energy-Saver' grillelement (right) isincludedwithsome cook-
tops or may be purchasedas an optionfor most models. This permits
utilizingonly halfof the grillarea, if desired,or usingdifferentcontrolset-
tingsfor the front and rear positionof the element. When usingthisele-
ment, bothcooktopcontrols,front and rear,must be turned on in orderto
use the fultgrillarea. FormodelCVE4180, the standardgdllwas included.
See directionsabove. ............................., ..................
(Suggested Control Settings for Surface Elements !
J
i
i!
,.d
J
The size and type of cookware used and the amount and type of food being cooked will
influence the setting needed for best cooking results. Electrical line voltage may also
vary, which will affect the needed control setting. The setting indicated should serve as
a guide while you become familiar with your cooktop.
Hi Afastheattostartcookingquickly,tobringliquidstoa boil,topreheatoilfordeepfat frying.
Usedfor mostgrilling.
7-10 (MediumHigh)Forfastfryingorbrowningfoods,tomaintainrapidboiloflargeamountsoffood,
tomaintainoiltemperaturefor deepfatfrying.
5-6 (Medium) Forfoods cookedinadoubleboiler,saut6ing,slowboiloflargeamounts offood, and
mostfrying.
3-4 (Medium Lo) Tocontinuecookingfoods startedon higher settings.
Lo-2 Maintaining serving temperatures offoods, simmeringfoods, melting butterorchocolate.
The controlsofferflexibility insetting selection. On settings other than Hi, you may adjust
the controls above or below the numbered setting for best results. This applies to
settings when using cooktop cartridges or when using the grillor any ofthe accessories.
Suggested settings are provided as general guidelines.
6

Cooktop cartridges can be installed in most cooktops.
conventional coil, halogen, radiant, or solid element. Cartridge options include
[To Install Cartridges ]
1. If the grill grates, element, and/or grill-rocks are in place, remove before installing
acooktop cartridge. Clean basin pan of any grease accumulation. (See page 16
for cleaning recommendations.)
2. To install any of the optional cooktop cartridges, be sure controls are OFF. Position
the cartridge terminal plug towards the terminal receptacle.
3. Slide the cartridge towards the receptacle until the cartridge terminal plug is
completely engaged.
4. Lower the opposite end of the cartridge into the cooktop until it is flush with the
surface. Your cooktop is now ready to use.
iTo Remove Cartridges i
1. Controls must be OFF and the cartridge should be cool.
2. Lift up onthe "tab" located on the cartridge untiltop of cartridge clears the opening
of the cooktop by about 2 inches. Liftingthe cartridge too high while stillengaged
in the receptacle could damage the terminal plug.
3. To disengage terminal, hold cartridge by the sides and slide away from the terminal
receptacle. Lift out when fully unplugged.
4. A storage tray, Model A350 is available and can be used for storing a cartridge.
5. Do not stack cartridges where they may fall or be damaged. Never store other
materials on top of a glass-ceramic cartridges since this could damage or mar the
surface.
Note: Remember to replace the air grille before using the ventilation system.
[,,,,,,,HomeCanning i
For best results, canning should be done on the conventional coil cartridge/cooktop.
Canning element accessory, Model A145A, makes it possible to use large oversized
canners with the conventional coil cartridge/cooktop.
For additiona/ information, refer to use and care manua/ packaged with your cartridge.
7

To achieve optimum cooking performance, use heavy gauge, f/at, smooth bottom
cookpotsthat conform to the diameter of the element (no more than one inch overhang).
Proper cookpots will minimize cookingtimes, use less electricity, cook food more evenly
and require less water or oil.
Cookpots with thin, uneven bottoms do not adequately conduct heat from the element
to the food in the cookpots which results in hot spots, burned or underdone food. Using
bad cookpots also requires more water, time, and energy to cook food.
ii
I Selecting Proper Cookware I
• Select heavy gauge cookpots. Usually heavy gauge cookpots will not change
shape when heated.
• Use cookpots with flat, smooth bottoms. The two ways todetermine if cookpots
have a flat, smooth bottom are the ruler test and the cooking test.
Ruler Test: I
1. Place the edge of ruler across the
bottom of the pot.
2. Hold up to the light.
3. No light should be visible under the
ruler.
I Cooking Test: I
1. Put 1 inch of water into the cookpot.
2. Place cookpot on the element. Turn
control to the HI setting.
3. Observe the bubble formation to determine the heat distribution. Ifthe bubbles are
uniform across the cookpot, the cookpot will perform satisfactorily. If the bubbles
are not uniform, the bubbles will indicate the hot spots.
• Match the size of the cookpot to the size of the element. Ideally, the cookpot
will be the same size or slightly larger.
8

[ ImproPer C0okware I
• Do not use cookware that extends more than 1inch beyond the edge of the
element.
• Do not use a small cookpot on a large element. Not only can this cause the element
to require more energy and time, but it can also result in spillovers burning onto the
element which cause extra effort in cleaning.
• Do not use nonflat specialty items that are oversized, uneven or do not meet
proper cookware specifications such as round bottom woks with rings, griddles,
rippled bottom canners, lobster pots, large pressure canners, etc.
i Home Canning I
Acceptable canning pots should not be oversized and must have aflat bottom. Note:
Canning element accessory, A145A, makes it possible to use large oversized, flanged
or rippled bottom canners. (See p 11 .) When canners do not meet these standards, the
use of the HI heat setting becomes excessive and may result in damage to the cooktop.
In addition, water may not come to a boil and canners may not reach 10 lb. of pressure.
The acceptable canning procedure uses the HI setting just long enough to bring the
water to a boil, then lower the setting to maintain the water temperature.
ICharacteristics of Cookware Materials J
Heavy gauge cookpots with flat, smooth bottoms will usually work in a similar way.
However, there are some differences in the cooking performance of various materials.
•Aluminum cookpots heat quickly and evenly. Best suited for simmering, braising,
boiling and frying.
•Stainless steel cookpots will evenly distribute heat if constructed of tri-ply or
combined with other metals such as aluminum and copper. Use for cooking
functions similar to aluminum.
•Cast iron cookpots are slow to heat but cook more evenly once temperature is
reached. Use for long term low heat cooking or for browning and frying.
•Glass ceramic, earthenware, heat-proof glass or glazed cookpots can be used if
recommended by the manufacturer for cookpot cooking. Do not use with trivets.
Best used on low to medium control settings.
•Porcelain enamel-on-steel or porcelain enamel-on-cast iron should be used
according to manufacturer's directions. Do not allow to boil dry.

Ic°°king''''Pr°ceduresI
• For best results, always use recommended cookware.
• Different cookpots and different amounts of food being prepared will influence the
control settings needed for best results. For fastest cooking, start with the surface
control on Hi for one minute; then turn the control to the lower desired setting.
Covering pans, whenever possible, speeds cooking and is more energy efficient.
• Do not allow pans to boil dry as this could damage both the cooktop and the pan.
• Do not drop heavy cookware on the cooktop surface.
ISelecting Proper Cookware I
•Select cookware with flat bottoms. Flat bottom pans are the fastest and best
conductors of heat and provide the most consistent and satisfactory results. The
entire bottom ofthe pan shouldtouch the heating element evenly. Avoid using pans
with convex, concave or irregular bottoms. A pan which is not flat receives the most
heat at the point of contact, which causes "hot spots"and uneven heat distribution.
Hot spots can result in scorching or burningof the food. Uneven heat distribution
slows the cooking process and wastes energy.
• To determine if pan is flat, lay a straight edge ruler against the bottom. (See p. 8)
• Do not use a pan with aturned down flange around the bottom or aripple bottom.
• Do not use a pans that extend more than 1 inch on either side of the element. Use
the correct size pan for the size ofthe heating element. (See exceptions forcanners
and stockpots below.)
• Do not use wire trivets or any kind of heat retarding pad between the pan and
element. Reduce the control setting instead.
• Special cooking equipment without flat bottoms, such as the Oriental wok, should
not be used on the cooktop. Use the Jenn-Air wok accessory, Model A0142, on
the cooktop. It has a flat bottom and isdesigned to be used on the small element.
• Large stockpots and canners should be used with Jenn-Air's "Big-pot" canning
element only (Model A145A). The use of large pans on the large element on Hi for
extended periods of time can cause damage to the cooktop, discolor chrome drip
pans, shorten the life ofthe etement, as well as trap excess heat inside the cooktop.
NOTE: CCE1400 OWNERS: Sustained trapped heat can cause the large elements ......
to cycle off. Elements wilt cycle back on after the cooktop has cooled down.
CVE1400 OWNERS: Sustained trapped heat can cause the downdraft fan to cycle
on. Downdraft fan will cycle off after the cooktop has cooled down.
[ Large Stockpots or Canners I
Canning element accessory, Model
A145A, makes itpossibleto use large
oversized flanged or rippled bottom
canners. RIGHT _WRON_::: ..... WRONG_ _'
10