Cello Platinum 6 User manual

(501577365/6438313251248)
1-26
27-52
53-78
79-104
105-130
131-155
156-180

CELLO
1
IMPORTANT: READ ALL INSTRUCTIONS AND OPERATIONS BEFORE OPERATING THIS
UNIT.
FOLLOW ALL STEPS IN ORDER. NEVER ALLOW CHILDREN TO OPERATE THIS UNIT.
Warnings:
-Only to be used outdoors.
-Read the instructions before using the appliance.
-Accessible parts maybe very hot, keep young children away.
-Do not move the appliance during use.
-Turn off the gas supply at the gas cylinder after use.
-Any modification of the appliance may be dangerous.
-Parts sealed by the manufacturer or his agent must not be altered by the user.
Attention:
Some parts of this appliance become very hot, take special care when children or elderly are
present.
For your safety:
Do not store or use gasoline or mentholated fuels or any other flammable vapors and liquids in
the vicinity of this or any other appliance.
Never light a gas grill with gasoline or comparable fluids!
Suggestion: user should not change the assembly that the manufacturer packaged.
1. Technical data
Kesko Ltd.
Ty pajankatu 12, 00580 HELSINKI, FINLAND
P. [phone]
2575CU0359CS02602
2575-20

CELLO
2
2. Exploded View
3. Single part list
Seq. NO.
Appellation
Qty.
Seq. NO.
Appellation
Qty.
1
Lid
1
2
Lid handle
1
3
Thermometer
1
4
Enamel wiring warm rack
1
5
Cast iron cooking grids
4
6
Heat distribution panel
8
7
Firebox assembly
1
8
Main burner tube assembly
6
9
Right side table
1
10
Side burner layer
1
11
Reinforce bar
4
12
Control panel assembly
1
13
Battery box
1
14
Control knob
8
15
Grease tray
1
16
Grease cup assembly
1
17
Cart front beam
1
18
Door magnet
1
19
Leg-A
2
20
Leg-B
2
21
Cart side panel
2
22
Cart rear panel
1
23
Cart bottom panel assembly
1
24
Swivel caster
4

CELLO
3
25
Cart door assembly
2
26
Infrared side burner nozzle base
1
27
Infrared side burner cover
1
28
Infrared side burner cooking grid
1
29
Infrared side burner assembly, left
1
30
Infrared side burner insert tray
1
31
Cart attachment bracket
4
32
Infrared side burner grease cup
1
33
Ice Bucket
1
34
Infrared side/rear burner
electronic ignition button
1
35
Support rack
1
36
Hook
4
37
Chopping Board
1
38
Rear burner windshield cover
1
39
Rear burner assembly
1
40
Rear burner bellows protective
cover
1
4. Fixing elements
5. Mounting steps
Make sure your grill is assembled properly. Detailed assembly instructions are packed with each
grill giving specific assembly procedures for each model. Follow these instructions carefully to
ensure the correct and safe assembly of the grill.
Caution: Although we take every effort to ensure that the assembly process is as easy as
possible, it is inherent with fabricated steel parts that corners and edged can cause cuts if
improperly handled during assembly procedures. Be careful while handling any parts during
assembly. It is strongly recommended that you protect hands with a pair of work gloves.

CELLO
4
Figure 1

CELLO
5
Figure 2

CELLO
6
Figure 3

CELLO
7
Figure 4
Figure 5

CELLO
8
Figure 6

CELLO
9
Figure 7

CELLO
10
TOP TIP:
To prolong your fat tray life span, put double layer of
aluminum foil onto the fat tray and make a hole to the
foils above the grease cup. Cover the foils with a layer
cat sand. You may also use play sand. Replace both
(foils and sand) at least once a year depending how
much you barbeque.
Figure 8

CELLO
11
Figure 9
Figure 10

CELLO
12
Figure 11
Figure 12

CELLO
13
Figure 13

CELLO
14
Figure 14
Figure 15
Insert 8 x Part 6
TOP TIP:
You may buy set of circle shaped hot
plate, sear plate and pizza stone
(Cello Cooking System) and store
them into this rack.

CELLO
15
Figure 16
6. Preparation
You will need to purchase a gas cylinder and the pressure regulator should correspond to the
pressure and gas category of the appliance, which can be obtained from your nearest Gas
Retailer. The regulator should be complying with EN16129 with current version and national
regulation.
You will need to purchase a gas cylinder and a 28-30/37 mbar regulator for I3+(28-30/37) and 30
mbar regulator for I3B/P(30), 50 mbar regulator for I3B/P(50) to operate this gas grill which can
be obtained from your nearest Gas Retailer.
See point 9 for further instructions.
Strongly recommended procedures/usage:
When using the gas cylinder, it must always be kept in upright position.
This appliance must only be used with an approved hose and regulator.
Energy saving tips:
a) Reduce the opening time of the lid.

CELLO
16
b) Turn the grill off as soon as cooking is completed.
c) Preheat the gas grill for 10 to 15 minutes only. (Except for the first use)
d) Do not preheat longer than recommended.
e) Do not use a higher setting than required.
If the hose and regulator are not included by the manufacturer, then only hoses and regulators
which meet national and regional codes are to be used. Connect the hose and regulator to the
gas cylinder at the left side of the gas grill .Keeping in mind that the gas cylinder must be kept
away from heat and in a safe position.
7. Installation
After purchasing your gas cylinder you will then be ready to set it up with your gas grill.
a) When changing the gas cylinder which shall be carried out away from any source of
ignition. Position the gas cylinder in the cabinet gas cylinder holder.
b) When ready to use your gas grill insert the regulator into the gas cylinder valve and tighten
firmly. The recommended hose length is about 1.0 m. The hose must not be longer than
1.5 m.
Warning: Before attempting to light your gas grill you must refer to your lighting
instructions and warning / safety points.
Check the hose before each use, searching for cracking, cuts or any abrasions. If the hose is
found to be faulty in any way do not attempt to use your gas grill.
When changing your gas cylinder ensures that there are no sources of ignition close by i.e. fires,
cigarettes, naked flames etc. Make sure that the appliance is switched off.
Ensure that the hose is not subjected to twisting which will affect the gas flow when using
your gas grill. Also the hose must not have undue tension and must not touch any part of the gas
grill which may be hot.
Please choose flexible hose whose heatproof higher than 80⁰C
Every 2 years changing the flexible hose when the national conditions require it.
How to connect a gas cylinder
c) Turn the orange cap so that the arrow is pointing to the gap in the shroud.
d) Remove the orange safety cap by pulling the lanyard out, then out. Do not use tools. Leave
the cap hanging.
e) Check that the black sealing washer is fitted inside the cylinder valve. Place the regulator
down over the valve with switch.
f) Turn the switch clockwise on gas cylinder-then turn on the gas grill as instructed.

CELLO
17
Warning: Always test gas line for leaks at connector with soap water finishing all
connections.
How to disconnect a gas cylinder
g) Except for twin-cylinder installations with a changeover valve, turn off the gas tap if fitted to
the appliance. Wait until the burner and pilot light have gone out. For installations with a
changeover valve, it is only necessary to switch off the empty cylinder.
h) Replace the orange safety cap onto the empty cylinder.
GENERAL
Althoughall gasconnectionsonthegrill areleak testedatthefactorypriortoshipment,acomplete
gastightnesscheckmustbeperformedatthe installationsiteduetopossiblemishandling in
shipment,orexcessivepressureunknowinglybeing applied totheunit.Periodicallycheckthewhole
systemforleaksfollowingtheprocedureslisted below.Ifthesmellofgasisdetectedatanytime you
shouldimmediatelychecktheentiresystemforleaks.
BEFORETESTING
Makesurethatallpackingmaterialisremovedfrom thegrill includingtie-down straps.
DONOTSMOKEWHILELEAKTESTING. NEVERPERFORMLEAKTESTWITHANOPEN FLAME.
Makeasoapsolution ofonepartliquiddetergentand onepartwater.You
willneedaspraybottle,brush,or ragtoapply thesolution tothefittings.Fortheinitial
leaktest,makesuretheL.P.cylinderis80%full.
TO TEST
1. Makesurethecontrolvalvesarein theOFF position,andturnonthegassupply.
2. Checkallconnectionsfromthe gas regulatorand supplyvalveuptoandincluding
theconnectiontothemanifoldpipe assembly (thepipe thatgoestotheburners).Soap
bubbleswillappear where aleak ispresent.
3. Ifaleakispresent,immediatelyturnoffthegas supplyandtightentheleakyfittings.
4. Turnthegasbackonand recheck.
5. Shouldthegascontinuetoleakfromanyofthe fittings,turnoffthegassupply.
Install Regulator Hose Install Gas Tank & Regulator Hose
Do notusethegrill untilall connectionshave beencheckedanddonotleak.
ALWAYSCHECKFORLEAKSAFTEREVERY GAS TANKCHANGE
Checkallgassupplyfittingsforleaksbeforeeach use.Itishandytokeepaspraybottleofsoapy
waterneartheshut-offvalveofthegassupplyline. Sprayallthefittings.Bubblesindicateleaks.
8. Warning and safety points

CELLO
18
Please read the following points before using your gas grill:
a) Read the instructions before using the appliance. Please follow all assembly instructions
in this manual; if instructions are not followed it may cause problems in use.
b) This gas grill accessible parts maybe very hot when being used. Keep young children
away. Use protective when handling particularly hot components.
c) In the event of a gas leak shut off gas to the gas grill, extinguish any open flames, open lid
and if leak continues check for damages, poor connections etc. Contact your local gas dealer
immediately if the problem can’t be solved.
d) Do not move Gas grill during use.
e) Do not use or store any flammable liquids or vapors in the vicinity when operating the gas
grill.
f) This gas grill only to be used outdoors.
g) Do not use a naked flame to check for gas leaks.
h) Do not operate gas grill if there is a gas leak. Turn off the gas supply.
i) Do not attempt to disconnect any gas fitting part if your gas grill is being used, on the gas grill
or the gas regulator / cylinder.
j) Care is advised when operating your gas grill, you should never leave unattended when in
use. Turn off the gas supply at the gas container after use.
k) The gas grill should be cleaned on a regular basis.
Take care not to enlarge burner ports or orifice/nozzle openings when cleaning the burner or
valves.
l) Do not attempt to use this appliance in a garage or any enclosed area. Also this appliance
must be keep away from flammable materials, etc. We recommend keeping a distance of
at least 0.5 to 1.0 meter clear of any flammable materials.
m) We would recommend that this gas grill be serviced by your local gas retail outlet at least
once a year by a competent engineer. Do not attempt to service this appliance yourself.
n) Any modification of the appliance may be dangerous. Do not attempt any unauthorized
interference of the main controls on this gas grill, i.e. gas taps, injectors, valves etc.
WARNING: The Handle Black Area (See above picture for reference) Will Become
Hot When the Gas grill In Use. BE CAREFUL! Do Not Touch The Black Area.
“Since this barbecue has no restriction in the emission of unburned gas, this barbecue must be
installed and/or used outdoors or in an amply ventilated area.”
Strongly recommends minimum clearances from combustible materials must be:
Rear – 450mm
Sides – 250 mm
Top – 1000 mm

CELLO
19
9. Safety precautions
a) Always test gas line for leaks at connector with soapy water after making connections.
b) The top lid must always be open when lighting the burner.
c) Use oven gloves and sturdy, long handled gas grill tools when cooking on the grill.
d) Be prepared if an accident or fire should occur. Know where the first aid kit and fire
extinguishers are and know how to use them.
e) Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
f) Always cook with great care.