CFR CASCADE P20 Series User manual
CASCADE
IMPORTANT SAFETY INSTRUCTIONS
CFR CASCADE
2
TABLE OF CONTENTS
INTRODUCTION
Parts and Service
Serial Number
CFR CASCADE 3
UNPACKING INSTRUCTIONS
Note:
7
5
1
4
8
❻
CFR CASCADE
4
COMPONENTS
Control Panel
WARNING!
WARNING!
CFR CASCADE 5
SAFETY INSTRUCTIONS
WARNING!Do not attach any device that would engage the trigger in the on position.
WARNING!
Grounding Instructions
WARNING!
Transporting the Cascade
Preparing for Cleaning
Planning
If you have a rectangular room:
If you have an irregularly shaped room:
Vacuuming
Pre-Spraying
Spotting
CFR CASCADE
6
2
3
CFR CASCADE 7
OPERATING INSTRUCTIONS
Pre-Use Inspection
WARNING!
❶
❷
❸
❻
CFR CASCADE
8
Filling the Tank
CAUTION!
CAUTION!
WARNING!
❶
❷
CFR CASCADE 9
Operating the Cascade
P20SP
Note:P20 OZ
P20
Note:
CFR CASCADE
10
Operating the Cascade
Maintenance Mode
Restorative Mode
CAUTION!
CAUTION!
CFR CASCADE 11
MAINTENANCE
Routine Daily Maintenance
Tank and Filters
❷
❸
❻
CFR CASCADE
12
Tool Head
Warning:
B
C
4
6
A
CFR CASCADE 13
General
Hand tools & wands
OPTIONAL ACCESSORIES
Wand and Tool Usage
Attaching Wand/Hand Tool
A
B
CFR CASCADE
14
Carpets/Hard Floor and Surfaces
CAUTION!
CAUTION!
Upholstery
CAUTION!
CFR CASCADE 15
Periodic Maintenance
Trouble Shooting Guide
CFR CASCADE
16
Ref # Part # Description
01 72505A Handle, Cascade
02* X8261 Screw, #6 x ? Phil Pan Black
03* 72008A Micro Switch
04* 72382A Bracket, Finger Swith
05* 72398A Handle, Finger Switch
06 72510A Handle Glide
07 72056A Screw, #8 x 5/8”, Self Tap
08* 72566A Motor Control, 125VDC
09 70050B Rocker, Switch, 15A, 2-Pole
10 72116A Switch Cover, Blank
Replaced by 70050B for
ozone models
11 72387A Screw, #8 x 5/8 Phil PH Black
Ref # Part # Description
12* 72579A Knob, Speed Control
X8151C Plug, 3/8” Hole, Plastic, Black
13 72411A Hour Meter, AC
71544A Hour Meter, 230V
14 7FC007 Circuit Breaker, 5A
7FC009 Circuit Breaker, 3A, 230V
7FC010 Circuit Breaker, 8A, 230V
7FC003 Circuit Breaker, 15A, 115V
15** 70895A Rocket, Switch, 15A, 4 Pole
16 PX112 Pigtail, Black 12/3 SJT x 39”
17 72570A Screw, Long, Hex Head
18 X8235 Washer, ?” Flat USS Zinc
19 72173A Clip, Hand-Holding Spring
Ref # Part # Description
20 PD8 Strain Relief, ?” NPT
21 72574A Switch Panel, P-20
22 X8282 Bolt, ?-20 x 1” Hex SS
23 X8008N Nut, Lock, ?” Steel Conduit
24 72434A Jumper Tab #6
25 72432A Terminal Block, 7 Positions
26 72361A Panel, Motor Control
27 X8256 Nut, 8-32 Keps, Zinc
28 72052A Screw, #8 x 5/8, Phil Pan TS
29 7BS002 Screw, 8-32 x ? Phil Pan
30 71952A Fiber Optic Cable --- OZ
* For self-propelled models only.
** Replace by 70050B in non SP model.
CFR CASCADE 17
Handle Assembly
Ref # Part # Description
01 72438B Component Bracket
02* 72566B Motor Control, 125VDC
72614A Motor Control, 230V ---SP
03** 72052A Screw, #8 X 5/8 Phil Pan TS
– Add 2 for 230V models
04*** 71379A Relay, 25A, 120V
Ref # Part # Description
04 71379B Relay, 230V -
– Use 3 for 230V models
05 72387A Screw, #8 x 5/8”, Black
06 72434A Jumper, Tab #6
07 72433A Terminal Block 3 Positions
09* 72650A Fuse, 5A / 32V
Ref # Part # Description
09 72649A Fuse, 3A / 32V --230V
10*** 72430A Fuse Clip
11 72388A Screw, #10 x 5/8 Phil Tap
* For self-propelled models only
** Use only three in non self-propelled models
*** Use only one in non self-propelled models
Component Panel Assembly
Ref # Part # Description
01 72504A Base, Cascade 20
02 72020A Screw, Self Tap, PHMS Zinc
03 X8235 Washer, ?” Flat USS Zinc
04 72385A Pump Assembly
05 7GF033 Pad, Motor Mount
06 7BF003 Nut, Kep #10-24 Zinc
07 72000A Rod, All Threaded
08 72365A Vacuum Motor, 3 Stage
72611A Vacuum Motor, 230V
09 70020B Gasket, Vacuum Motor Seal
10 7DL005 Hose Clamp, 1-1/2” SS
11 72388A Screw, #10 x 5/8 Phil Tap
12 72538A Panel, Vacuum Motor
13 72540A Gasket, Vacuum P-20
14 72535A Transaxle Cover Plate
15 72379A Screw, 3/8-16 x 2-3/4 Hex
16 7DL003 Clamp Hose
17 71817A Hose, 29” Long
Ref # Part # Description
18 72372A Panel, Mounting Regulator
19 7BS002 Screw, 8-32 x ? Phil Pan SS
20 72369A Pad, Mounting Regulator
21 X8256 Nut, 8-32 Keps Zinc
22 72052A Screw, #8 X 5/8 Phil Pan TS
23 72561A Lever, Straight
24 7CW002 Screw
25 72499A Plate, Hole Cover w/ cut-out
26 72567A Cover, Relay Bracket
27 71313A Screw, ?-20 x 2 Socket Cap
28 7BF004 Nut, Kep ?-20 Zinc
29 72559A Label, Base (CFR)
30 72511A Wheel, 10” Diameter
31 72571A Bushing, 7/8” Wide
32 72586A Transaxle / Motor, 90V
72591A Transaxle / Motor, 230V
33 72453A Key, Machine 3/16”
34 72422A Flat Washer
Ref # Part # Description
35 72602A Screw, 5/16-24 x 7/8” Hex
36 72338C Plate, Transaxle Mounting
37 7DT001 Bolt, 5/16-18 x 5/8” Hex
38 X8235 Washer, ? USS Flat, Zinc
39 72551A Caster, 4” x 2” Wheel
40 70100A Coupler, QD 1/8F
41 SW139 Elbow, 1/8 Street, 90 degree
42 71366A Hose, Teflon, 1/8” x 1/8”
43 7AG002 Bushing, ?-1/8 NPT
44 71492A Solenoid, 1/8 Orifice
71545A Solenoid, 1/8 Orifice, 230V
45 7CX002 Nipple, Hex ? MPT
46 7AR013 Nipple, ? NPT x 3” L SS
47 PX6 Female Quick Disonnect
48 72539A Bracket, Quick Disconnect
49 7AE003 Elbow, Wtreet ? NPT
50 7AV001 Tee Union ? NPT
51 72390A Latch, Soft
52 72404A Cable Short, Tool head
53 72502A Support Bracket, Tool Lifting
54 72406A Pin Clevis, Tool head Cable
55 72467A Cotter Pin, 1/16” x ?” LG
56 72405A Cable, Long
57 72403B Lifting Plate, Adjustable
58 71639A Bolt, ?-20 x 2-1/2 Hex Tap
59 72436A Gasket, VAC Exhaust
60 7GR032 Flanged 2” White PVC
61 7GF006 Gasket, Flanged Short
62 70079C Hose, 34” Long
63 7DL008 Clamp Hose Ozone models
64 72495A Label, Cascade Tool
65 X8235A Washer, ?” x 1” OD, Flat
66 72590A Screw, #8 x 5/8”
67 72568A Wand Holder
68 SW158 Cable Clamp
69 72600A Screw, #14 x 1, Phil Pan
70 72601A Handle, Grab
71 X8295+ Screw, Phil Flat TS
72 72472A Shim, Transaxle
73 7DL010 7/8” Cable Clamp
74 72605A Spacer, Vac, 3.5” Long
75 7CM003 Washer, OZ models
76* 71952A Convertor Kit, OZ Long
71953A Convertor Kit, 230V
77* 71716A Carbon Filter Assembly
78* 71717A Cover, Carbon Filter
79* 71875A Rivet, Pop, (.25 Grip)
80* 71775A Elbow, 1/2” Hose x 3/8”
81* X9179+ Pump Motor, 100 psi, 115V
71819A Pump/Motor, 230V
82* 7GG003 Hose A/S Braided
83* 71570A Injector, Ozone
84* 71810A Hose, Clear, Tygon
85* 71629A O-Ring, Shaft End Pulley
86* 71999A Barb Hose, 1/2”H
87* 71644A Screw, #10 x 1“, Phil Pan
88 7BF005 Nut, Kep, 5/16-18, Zinc
89 7CM004 Washer, 3/8 USS Flat
90 7CT002 Bolt, 5/16-18 x 1“, Hex Tap
* For ozone models only
CFR CASCADE
18
Base Assembly P20SP
Ref # Part # Description
01 72504A Base, Cascade 20
02 72020A Screw, Self Tap, PHMS Zinc
03 X8235 Washer, Flat USS Zinc
04 72385A Pump Assembly
05 7GF033 Pad, Motor Mount
06 7BF003 Nut, Kep #10-24 Zinc
07 72000A Rod, All Threaded
08 72365A Vacuum Motor, 3 Stage
72611A Vacuum Motor, 230V
09 70020B Gasket, Vacuum Motor Seal
10 7DL005 Hose Clamp, 1-1/2” SS
11 72388A Screw, #10 x 5/8 Phil Tap
12 72538A Panel, Vacuum Motor
13 72540A Gasket, Vacuum P-20
14 72535A Transaxle Cover Plate
Ref # Part # Description
15 72379A Screw, 3/8-16 x 2-3/4
16 7DL003 Clamp Hose
17 71817A Hose, Braided, 29” Long
18 72372A Panel, Mounting Regulator
19 7BS002 Screw, Phil Pan SS
20 72369A Pad, Mounting Regulator
21 X8256 Nut, 8-32 Keps Zinc
22 72052A Screw, #8 X 5/8 Phil Pan TS
23 7CW002 Screw, #6 x ? Phil Pan TS
24 72499A Plate, Hole Cover w/ cut-out
25 72567A Cover, Relay Bracket
26 SW158 Cable Clamp
27 72559A Label, Base (CFR)
28 72592A Bushing, 7/8”
29 72580A Wheel, 10” Diameter
Ref # Part # Description
30 72597A Push Nut, 5/8”
31 72587A Axle, Cascade 20
32 71520A Washer, 5/8” SAE, Flat Zinc
33 7DT001 Bolt, 5/16-18 x 5/8” Hex Tap
34 7CR004 Washer, 5/16 USS Flat
35 72551A Caster, 4” x 2” Wheel
36 72590A Screw, #8 x 5/8” Oval Head,
37 72568A Wand Holder
38 7AR013 Nipple, NPT x 3” L SS
39 PX6 Female Quick Disonnect,
40 72539A Bracket, Quick Disconnect
41 PC38 Coupling, Double Thread
42 72390A Latch, Soft
43 72595A Cover Plate, Lift Mechanism
44 72436A Gasket, VAC Exhaust
45 7GR032 Adaptor Flanged 2” PVC
46 7GF006 Gasket, Flanged Elbow
47 70079C Hose, 34” Long
48 7DL008 Clamp Hose
49 7DL010 7/16” Cable Clamp
50 72605A Spacer, Vac, 3.5” Long
51 7CM003 Washer, #10 USS, Flat 18-8
52* 71952A Convertor Kit, OZ Long
71953A Convertor Kit, 230V models
53* 71716A Carbon Filter Assembly
54* 71717A Cover, Carbon Filter
55* 71875A Rivet, Pop, (.25 Grip)
56* 71775A Elbow, 1/2” Hose x 3/8”
57* X9178+ Pump Motor, 100 psi, 115V
71819A Pump/Motor, 230V
58* 7GG003 Hose A/S Braided
2” Long to Ozone Pump
and 80” Long to Orifice
59* 71570A Injector, Ozone
60* 71810A Hose, Clear, Tygon
61* 71629A O-Ring, Shaft End Pulley
62* 71999A Barb Hose, 1/2”H – PVC
63* 71644A Screw, #10 x 1”, Phil Pan
64 7BF005 Nut, Kep, 5/16-18, Zinc
65 7CM004 Washer, 3/8 USS Flat, 18-8
66 7CT002 Bolt, 5/16-18 x 1“, Hex Tap
* For ozone models only
CFR CASCADE 19
Base Assembly P20
CFR CASCADE
20
Tank Assembly
This manual suits for next models
11
Table of contents
Popular Cleaning Equipment manuals by other brands
MDT
MDT CASTLE 2415-UW Service manual
Alfalaval
Alfalaval GJ A2 instruction manual
AWH
AWH Tanko JX70-2 Operating & installation instructions
Wap
Wap Alto SQ 650-61 operating instructions
ECOVACS
ECOVACS WINBOT 920 instruction manual
Menzer
Menzer ESM 406 Floor Tec Translation of the original operating instructions
