Champion 93001i-DF-UK User manual

OPERATOR'S MANUAL
MODEL #93001i-DF-UK
3000W DUAL FUEL INVERTER GENERATOR
REV 20230329
REGISTER YOUR PRODUCT ONLINE
at championpowerequipment.co.uk
or visit www.championpowerequipment.co.uk
[phone]
SAVE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do
so could result in serious injury. This manual should remain with the product.
Specifications, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.
This product meets the requirements of the PGMA (Portable Generator Manufacturers’ Association) standard ANSI/PGMA G300-2018 (Safety and Performance of
Portable Generators).
Covered by one or more of the following U.S. Patent Numbers: 10,641,187, 10,862,414 and other U.S. and foreign patents pending.
Original Instructions

www.TakeYourGeneratorOutside.com
As the only safe way to use a portable generator, taking your generator
outside is absolutely mandatory to keep your family safe from carbon
monoxide. But there’s even more you can do. By educating yourself
about all carbon monoxide risks, you’ll be better prepared to protect
your family from this colorless, oderless threat.
CARBON MONOXIDE SAFETY: THE BIG PICTURE
KNOW THE SYMPTOMS
• Headache
• Nausea
• Shortness of breath
• Dizziness
• Fatigue
STAY ALERT WITH CARBON
MONOXIDE DETECTORS
POINT FUMES AWAY FROM
NEARBY PEOPLE
KEEP IT OUTSIDE AND AWAY FROM
DOORS, WINDOWS, AND GARAGES
ALWAYS READ
THE OPERATOR’S
MANUAL FIRST
MANUAL
IF YOU FEEL SYMPTOMS,
LEAVE RIGHT AWAY
CARBON MONOXIDE KILLS

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR TABLE OF CONTENTS
3
TABLE OF CONTENTS
Introduction...................................................4
Safety Definitions ..........................................4
Important Safety Instructions.......................5
Fuel Safety ........................................................ 7
Safety and Dataplate Labels...................................... 8
Safety Symbols.................................................... 9
Operation Symbols ............................................... 10
Quickstart Label Symbols........................................ 11
Controls and Features ................................. 12
Generator ......................................................... 12
Control Panel ..................................................... 13
Parts Included .................................................... 14
Assembly ..................................................... 15
Unpacking ........................................................ 15
Add Engine Oil.................................................... 15
Add Fuel: Petrol .................................................. 16
Add Fuel: Propane (LPG) ......................................... 17
Grounding ........................................................ 18
Operation..................................................... 18
CO Shield®- Carbon Monoxide (CO) Detection and Auto-shutoff
System ............................................................. 18
Generator Location............................................... 20
Surge Protection ................................................. 20
Starting the Engine: Petrol....................................... 20
Starting the Engine: Propane (LPG) ............................. 21
Connecting Electrical Loads ..................................... 23
Do Not Overload Generator ...................................... 23
Eco (Economy) Mode............................................. 23
Parallel Operation ................................................ 24
12V DC Regulated Automotive Style Outlet ..................... 24
Parallel Operation ................................................ 24
Stopping the Engine.............................................. 24
Moving the Generator ............................................ 25
Operation at High Altitude ....................................... 26
Maintenance ................................................26
Cleaning the Generator .......................................... 26
Changing the Engine Oil ......................................... 27
Cleaning and Adjusting the Spark Plug.......................... 27
Cleaning the Air Filter ............................................ 28
Cleaning the Spark Arrestor ..................................... 28
Adjusting the Governor........................................... 28
Maintenance Schedule........................................... 28
Storage ........................................................29
Mid Term Storage (30 days – 1 year) ........................... 29
Long Term Storage (more than 1 year).......................... 30
Removing from Storage.......................................... 30
Specifications..............................................31
Generator Specifications......................................... 31
Engine Specifications ............................................ 31
Oil Specifications................................................. 31
Fuel Specifications ............................................... 31
Temperature Specifications...................................... 31
Figure A Parts Diagram .........................................33
Figure A Part List.................................................34
Figure E Parts Diagram ......................................... 35
Figure E Part List.................................................36
Figure F Parts Diagram .......................................... 37
Figure F Part List ................................................. 38
Figure G Parts Diagram ......................................... 39
Figure G Part List.................................................40
Figure B Engine Parts Diagram .................................. 41
Figure B Engine Part List ........................................ 42
Figure C Parts Diagram ..........................................43
Figure C Part List................................................. 44
Figure D Parts Diagram .......................................... 45
Figure D Part List................................................. 46
Wiring Diagram................................................... 47
Troubleshooting...........................................48
WARRANTY*.................................................50
Warranty Qualifications .......................................... 50
Repair/Replacement Warranty................................... 50
Do Not Return The Unit To The Place Of Purchase ............. 50
Warranty Exclusions ............................................. 50
Other Exclusions ................................................. 50
Limits of Implied Warranty and Consequential Damage........ 50
Contact Information .............................................. 50

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR INTRODUCTION
4
SAFETY DEFINITIONS
The purpose of safety symbols is to attract your attention to
possible dangers. The safety symbols, and their explanations,
deserve your careful attention and understanding. The safety
warnings do not by themselves eliminate any danger. The
instructions or warnings they give are not substitutes for proper
accident prevention measures.
ADANGER
DANGER indicates a hazardous situation which, if not avoided,
will result in death or serious injury.
AWARNING
WARNING indicates a hazardous situation which, if not
avoided, could result in death or serious injury.
ACAUTION
CAUTION indicates a hazardous situation which, if not avoided,
could result in minor or moderate injury.
NOTICE
NOTICE indicates information considered important, but not
hazard-related (e.g., messages relating to property damage).
INTRODUCTION
Congratulations on your purchase of a Champion Power Equipment
(CPE) product. CPE designs, builds, and supports all of our
products to strict specifications and guidelines. With proper
product knowledge, safe use, and regular maintenance, this
product should bring years of satisfying service.
Every effort has been made to ensure the accuracy and
completeness of the information in this manual at the time of
publication, and we reserve the right to change, alter and/or
improve the product and this document at any time without prior
notice.
CPE highly values how our products are designed, manufactured,
operated, and serviced as well as providing safety to the operator
and those around the generator. Therefore, it is IMPORTANT to
review this product manual and other product materials thoroughly
and be fully aware and knowledgeable of the assembly, operation,
dangers and maintenance of the product before use. Fully
familiarize yourself, and make sure others who plan on operating
the product fully familiarize themselves too, with the proper safety
and operation procedures before each use. Please always exercise
common sense and always err on the side of caution when
operating the product to ensure no accident, property damage,
or injury occurs. We want you to continue to use and be satisfied
with your CPE product for years to come.
When contacting CPE about parts and/or service, you will need to
supply the complete model and serial numbers of your product.
Transcribe the information found on your product’s nameplate
label to the table below
CPE TECHNICAL SUPPORT TEAM
[phone]
MODEL NUMBER
93001i-DF-UK
SERIAL NUMBER
DATE OF PURCHASE
PURCHASE LOCATION

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS
5
IMPORTANT SAFETY INSTRUCTIONS
ADANGER
Generator exhaust contains carbon monoxide, a colourless,
odorless, poisonous gas. Breathing carbon monoxide will
cause nausea, dizziness, fainting or death. If you start to feel
dizzy or weak, get to fresh air immediately.
OPERATE GENERATOR OUTDOORS ONLY IN A WELL
VENTILATED AREA AND POINT EXHAUST AWAY.
DO NOT operate the generator inside building, including
garages, basements, crawlspaces, sheds or enclosure
or compartment, vehicles and(or) including the generator
compartment of a recreational vehicle.
DO NOT allow exhaust fumes to enter a confined area through
windows, doors, vents or other openings.
ADANGER
Using a generator indoors CAN KILL YOU IN MINUTES.
Generator exhaust contains carbon monoxide. This is a poison
you cannot see or smell.
NEVER use inside a home or garage or any out buildings,
EVEN IF doors and windows are open.
ONLY use OUTSIDE and far away from windows, doors,
and vents.
Install battery-operated carbon monoxide alarms or plug-in
carbon monoxide alarms with battery back-up according to the
manufacturer’s instructions.
AWARNING
Although the generator contains a spark arrester, maintain
a minimum distance of 5 ft. (1.5 m) from dry vegetation to
prevent fires.
ADANGER
Operate equipment with guards in place.
Rotating parts can entangle hands, feet, hair, clothing and/or
accessories. Traumatic amputation or severe laceration can
result.
Keep hands and feet away from rotating parts.
Tie up long hair and remove jewelry.
DO NOT wear loose-fitting clothing, dangling drawstrings or
items that could become caught.
ADANGER
Generator produces powerful voltage.
DO NOT touch bare wires or live sockets.
DO NOT use electrical cords that are worn, damaged or frayed.
Use only Champion electrical cords for proper application.
DO NOT operate generator in wet weather including rain or
snow.
DO NOT allow children or unqualified persons to operate or
service the generator.
Use a ground fault circuit interrupter (GFCI) in damp areas and
areas containing conductive material such as metal decking.
Connection to your home’s electrical system requires a listed
100A transfer switch installed by a licensed electrician and
approved by the local authority having jurisdiction. The
connection must isolate the generator from the utility power
and must comply with all applicable laws and electrical codes.
AWARNING
Do not use generator for medical and life support uses.
In case of emergency, call emergency services immediately.
NEVER use this product to power life support devices or life
support appliances.
NEVER use this product to power medical devices or medical
appliances.
Inform your electricity provider immediately if you or anyone in
your household depends on electrical equipment to live.
Inform your electrical provider immediately if a loss of power
would cause you or anyone in your household to experience a
medical emergency.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS
6
AWARNING
Spark from removed spark plug wire can result in fire or
electrical shock.
When servicing the generator:
Disconnect the spark plug wire and place it where it cannot
contact the plug or any other metal object.
DO NOT check for spark with the plug removed.
Use only approved spark plug testers.
AWARNING
Running engines produce heat. Severe burns can occur on
contact. Combustible material can catch fire on contact.
DO NOT touch hot surfaces including exhaust/muffler and
engine, always allow to cool.
Avoid contact with hot exhaust gases.
Allow equipment to cool min 30 mins before touching or
handling.
Maintain at least 3 ft. (91.4 cm) of clearance on all sides to
ensure adequate cooling.
Maintain at least 5 ft. (1.5 m) of clearance from combustible
materials.
AWARNING
Rapid retraction of the recoil cord will pull hand and arm
towards the engine faster than you can let go. Broken bones,
fractures, bruises or sprains could result. Unintentional
startup can result in entanglement, traumatic amputation or
laceration.
ACAUTION
When starting the engine, pull the recoil cord slowly until
resistance is felt, release cord back and use one strong rapid
pull to start, this avoids any kickback or damage to the recoil
assembly. Rigorously pulling will result in damage to the recoil
assembly and void any warranty.
ACAUTION
Exceeding the generator’s running capacity can damage the
generator and/or electrical devices connected to it.
DO NOT overload the generator.
DO NOT tamper with the governed speed.
DO NOT modify the generator in any way.
DO NOT install or modify the exhaust/muffler with any xtension
or extraction, by doing so will void any warranty offered.
ACAUTION
Start the generator and allow the engine to stabilize before
connecting electrical loads.
Connect electrical equipment in the off position, and then turn
them on for operation.
Turn electrical equipment off and disconnect before stopping
the generator.
ACAUTION
Improper treatment or use of the generator can damage it,
shorten its life or void the warranty.
Use the generator only for intended uses.
Operate only on Flat level surfaces.
DO NOT expose generator to excessive moisture, dust,
or dirt.
DO NOT allow any material to block the cooling slots.
If connected devices overheat, turn them off and disconnect
them from the generator.
DO NOT use the generator if:
–Electrical output is lost
–Equipment sparks, smokes or emits flames
–Equipment vibrates excessively

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS
7
Fuel Safety
ADANGER
PETROL, PETROL VAPORS AND PROPANE (LPG) ARE
HIGHLY FLAMMABLE AND EXPLOSIVE.
Fire or explosion can cause severe burns or death.
Petrol and petrol vapors:
–Petrol is highly flammable and explosive.
–Petrol can cause a fire or explosion if ignited.
–Petrol is a liquid fuel but it’s vapors can ignite.
–Petrol is a skin irritant and needs to be cleaned up immediately
if spilled on skin or clothes.
–Petrol has a distinctive odor, this will help detect potential
leaks quickly.
–In any petroleum gas fire, flames should not be extinguished
unless by doing so the fuel supply valve can be turned OFF.
This is because if a fire is extinguished and a supply of fuel is
not turned OFF, then an explosion hazard could be created.
–Petrol expands or contracts with ambient temperatures.
Never fill the fuel tank to full capacity, as petrol needs room to
expand if temperatures rise.
LPG:
–LPG is highly flammable and explosive.
–LPG is under pressure and can cause a fire or explosion if
ignited.
–LPG is heavier than air and can settle in low places while
dissipating.
–LPG has a distinctive odor added to help detect potential leaks
quickly.
–In any petroleum gas fire, flames should not be extinguished
unless by doing so the fuel supply valve is turned OFF. This
is because if a fire is extinguished and a supply of fuel is not
turned OFF, then an explosion hazard could be created.
–When exchanging LPG cylinders, check that the cylinder valve
is of the same type.
–Always keep the LPG cylinder in an upright position.
–LPG will burn skin if it comes in contact with it. Keep any and
all LPG away from skin at all times.
When adding or removing petrol:
DO NOT light or smoke cigarettes.
Turn the generator off and let cool for at least two minutes before
removing the fuel cap. Always loosen the cap slowly to relieve
pressure in the tank.
Only fill or drain petrol outdoors in a well-ventilated area.
DO NOT pump petrol directly into the generator at the gas station.
Always use an approved container to transfer the fuel to the
generator.
DO NOT overfill the fuel tank.
Always keep petrol away from sparks, open flames, pilot lights,
heat and other sources of ignition.
When starting the generator:
DO NOT attempt to start a damaged generator.
Always check that the petrol cap, air filter, spark plug, fuel lines
and exhaust system are properly in place.
Always allow spilled petrol to evaporate fully before attempting to
start the engine.
Always be certain that the generator is resting firmly on level
ground.
When operating the generator:
DO NOT move or tip the generator during operation, when
refueling or adding oil.
When transporting or servicing the generator:
Always check that the fuel valve is in the OFF position and the fuel
tank is empty.
For LPG compatible models, check that the LPG cylinder is
disconnected and stored securely away from the generator.
Disconnect the spark plug wire.
When storing the generator:
Store away from sparks, open flames, pilot lights, heat and other
sources of ignition.
Do not store generator, petrol or LPG cylinders near furnaces,
water heaters, or any other appliances that produce heat or have
automatic ignitions.
ADANGER
NEVER place a petrol container, fuel tank, LPG cylinder or any
combustible material in the path of the exhaust stream during
operation of the engine.
AWARNING
Never use a petrol container, fuel tank, LPG connector hose,
LPG cylinder or any other fuel item that is broken, cut, torn or
damaged.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS
8
Safety and Dataplate Labels
These labels warn you of potential hazards that can cause serious injury. Read them carefully.
If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.
LABEL DESCRIPTION
A
ACTION LABEL
PO INT AWAY
AUTOMATIC SHUTOFF – YOU MUST:
Move generator to an open,
outdoor area. Point exhaust away.
Don’t run generators in enclosed
Move to fresh air and get medical help if sick,
dizzy or weak.
EXHAUST
A DANGER
1106-BY-L-A
Using a generator indoors CAN KILL YOU IN
MINUTES. Generator exhaust contains carbon
monoxide. This is a poison you cannot see or
smell.
NEVER use inside a home or garage or any out
building, EVEN IF doors and windows are
open.ONLY use OUTSIDE and far away from
windows, doors, and vents.
areas (eg sheds, garages, houses or any out
buildings).
K2945 123 482 152
ColorsAPN 1106-BY-L
Rev A
Size ~203 x 75 m m
Artwork Notes
2mm safe margin; white to b e printed sh own in 50%
process magenta
Revision Changes
This art work belongs to Champ ion Power Equipment. T he contents are con fidential and privile ged and shall not be discl osed to or used by or for
outside pa rties without t he explicit consen t of Champion Power Eq uipment.
P
Safety Symbols/
CO Danger
CO Shield®Action –
automatic shutoff
*See CO Shield®
section
B
C
K123 --- --- ---
ColorsLPN
Rev
Size 78 x 20 mm
Artwork Notes
3mm corner radius; 2mm safe margin
Revision Changes
This artwork belongs to Champion Power Equipment. The contents are confidential and privileged and shall not be disclosed to or used by or for
outside parties without the explicit consent of Champion Power Equipment.
1001-BY-L
1001-BY-L-C
B: Changed Swedish to French
C: Added E5 Logo
UNLEADED FUEL ONLY. Minimum octane
rating of 85. Maximum 10% ethanol.
NUR BLEIFREIES BENZIN. Mindest-
Oktanzahl 85. Maximal 10% Ethanol.
ESSENCE SANS PLOMB SEULEMENT. Indice
od’octane minimal de 85. Maximum 10 % 'éthanol.
Fuel
C
AC AMPS
Performance Class
Quality Class
Net WeightFREQUENCY (Hz)
RPM
PHASE
POWER FACTOR
RATED VOLTAGE
Year of Manufacture
IP Grade
SERIAL NO.
MODEL INSULATION CLASS
MAX AMBIENT TEMP
Rated Output
Max Power
PROPANE WATTS
93001i-DF-UK
CHAMPION POWER EQUIPMENT, INC.
12039 SMITH AVENUE
SANTA FE SPRINGS, CA 90670
USA / É.-U.
MADE IN CHINA
Low Power Generating Set
XXXXXXXXXXXX
xxxx
IP23M
11.7A
G2
50
4600
1
1.0
240V/50Hz
A
21.5kg
F
COP:2.8kW
2.95kW S2 5min
2.52kW
104°F/40°C
K--- --- --- ---
ColorsLPN
Rev
Size 123 x 40 mm
Artwork Notes
3mm corner radius; 2mm safe margin; remove
“PROPANE WATTS” if not applicable
Revision Changes
This ar twork belongs to Champion Power Equipment. The contents are confidential and privileged and shall not be disclosed to or used by or for
outside parties without the explicit consent of Champion Power Equipment.
CHAMPION POWER EQUIPMENT, INC.
12039 SMITH AVENUE
SANTA FE SPRINGS, CA 90670
USA / É.-U.
MADE IN CHINA
Low Power Generating Set
Dataplate
D
123 ---
ColorsLPN 1077-BY-L
Rev A
Size 147 x 32 mm
Artwork Notes
3mm corner radius; 2mm safe margin; to be printed
on
white substrate.
Revision Changes
This ar twork belong s to Champion Power Equipment. The contents are c onfidential a nd privileged an d shall not be disclosed to or used by or for
outside parties wit hout the explicit consent of Champion Power Equipment.
K185 165
-
WARNUNG
NICHT ANFASSEN! Abgase, Schalldämpfer und Motorkomponent-
en sind extrem heiß und verursachen Verbrennungen. Der Betrieb
dieser Geräte kann Funken erzeugen, die in der Umgebung von
trockener Vegetation Brände auslösen können. Ein Funkenfänger
kann erforderlich sein. Der Betreiber sollte sich an die ör tlichen
Brandschutzbehörden wenden, um sich über die Gesetze und
Vorschriften in Bezug auf Brandschutzanforderungen zu
informieren. Wenn installiert, alle 100 Stunden oder zu jedes Jahr
reinigen. 1077-BY-L-A
DO NOT TOUCH!
Exhaust gases,
muffler and engine
components are
extremely HOT and
cause burns.
Operation of this equipment may create
sparks that can start fires around dr y
vegetation. A spark arrestor may be
required. The operator should contact
local fire agencies for laws and
regulations relating to fire prevention
requirements. If installed, clean every
100 hour s or every season.
Hot Surface
Top
A
B
Side Muffler
C
D

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS
9
Safety Symbols
Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these
symbols will allow you to more safely operate the product.
SYMBOL MEANING
Caution.
Read The Operator’s Instruction Manual Before Use. To reduce the risk of injury, user must read and
understand operator’s manual before using this product.
Not For General Waste Disposal.
The generating set must not be connected to other power sources, such as the power company supply
mains.
Electric Hazard. Failure to use in dry conditions and to observe safe practices can result in electric
shock. Improper connections to a building can allow current to backfeed into utility lines, creating an
electrocution hazard. A transfer switch must be used when connecting to a building.
Fire Hazard. Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause
severe burns or death. Keep generator at least 5 feet (1.5m) from all objects to prevent combustion.
Risk Of Being Burnt. To reduce the risk of injury or damage, avoid contact with any hot surface.
Carbon Monoxide(co) Danger.
Wet Conditions Alert. Do not expose to rain or use in damp locations except as follows:
If you must operate in rain or damp locations, DO NOT operate without proper protection of the electrical
components.
Use of a safety canopy that is fire retardant and will provide proper air ventilation for the engines exhaust
stream can be used. Keep all objects a minimum of 5 feet (1.5m) away from the generator at all times.
Heat from the muffler surface and exhaust stream can ignite combustible materials.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS
10
Operation Symbols
Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these
symbols will allow you to more safely operate the product.
SYMBOL MEANING
Propane Hose Inlet
Engine Run: Propane
Engine Run: Petrol
Choke
Stop or Off
ECO
Economy Mode Button
Low Oil
Overload Reset Button
SYMBOL MEANING
Circuit Breaker Reset: Push
Ground Terminal
Neutral Floating. Neutral circuit IS
NOT electrically connected to the frame/
ground of the generator.
Parallel Connection(s)
12V Direct Current
High CO Warning. Move generator to
an open, outdoor area. Move to fresh
air and get medical help if sick, dizzy or
weak.
CO Shield System Fault. Electrical
issue, end of life.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR IMPORTANT SAFETY INSTRUCTIONS
11
Quickstart Label Symbols
Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these
symbols will allow you to more safely operate the product.
Starting the Engine
ADANGER
Move generator outside and far away from windows,
doors and intake ventilation covers.
1. Check oil level.
Recommended oil is 10W-30.
2. Add fuel. Check petrol level. When adding petrol, use a
minimum octane rating of 85 and an ethanol content of 10%
or less by volume.(E5 or E10）
3. Turn the fuel vent lever to the “ON” position.
4. Move the EZ Start dial to the “CHOKE” position.
5. Pull the recoil cord.
6. Turn EZ Start dial to petrol icon for petrol “RUN”.
7. Plug in desired device.
Stopping the Engine
1. Turn off and unplug all connected electrical loads.
2. Turn the fuel vent lever to the “OFF” position.
3. Turn the EZ Start dial to the “STOP” position.
For adding fuel and starting the engine with LPG see Add Fuel:
Propane (LPG) in Assembly section and Starting the Engine:
Propane (LPG) in the Operation section.
10W-30


1234567
3
2
1
1116-BY-L-A
K2945 354 7621 376 186 152 CG1
ColorsLPN 1116-BY-L
Rev A
Size ~170 x 21 mm
Artwork Notes
3mm corner radius; 2mm safe margin; to be printed
on
White substrate.
Revision Changes
---
This artwork belongs to Champion Power Equipment. The contents are confidential and privileged and shall not be disclosed to or used by or for
outside parties without the explicit consent of Champion Power Equipment.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR CONTROLS AND FEATURES
12
CONTROLS AND FEATURES
Read this operator’s manual before operating your generator. Familiarize yourself with the location and function of the controls and
features. Save this manual for future reference.
Generator
1. Carrying Handle –Used to lift or carry the unit.
2. Fuel Gauge
3. Recoil Starter – Used to manually start the engine.
4. Control Panel –See Control Panel section.
5. Fuel Cap – Remove to add fuel.
6. Fuel Lever Vent – Turn this valve to the “ON” position to
supply air to the tank.
7. Spark Plug Access Cover
8. Maintenance Cover
9. Muffler
8
9
7
1
2
3
4
5
6

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR CONTROLS AND FEATURES
13
Control Panel
1. Circuit Breakers (Push Reset) – Protects the generator
against electrical overloads.
2. Economy Mode Button – Enables/disables automatic idle
control.
3. Low Oil Warning Indicator Light – When ON, engine will
shut down and not run. Check oil level.
4. AC Overload Reset Button – Used to re-energize
receptacles after overload fault.
5. CO Shield®LED – The CO Shield®technology monitors
for accumulation of poisonous carbon monoxide (CO) gas
produced by engine exhaust when the generator is running. If
CO Shield®detects elevated levels of CO gas, it automatically
shuts off the engine.
6. Parallel Outlets – Used to parallel two inverters together for
increased power output. (parallel kit sold separately).
7. LPG Inlet – Used to connect LPG fuel source to generator.
8. Ground Terminal – Consult an electrician for local grounding
regulations.
9. EZ Start Dial – Used to turn on petrol or propane (LPG) fuel
source, operate the choke plate, and stop the engine
RECEPTACLES
A
240V AC, 16A
May be used to supply electrical power for
operation of 240 Volt AC, 16 Amp, single phase,
50 Hz electrical loads.
Bz12V DC, 8A (Automotive)
May be used to supply electrical power for
operation of 12 Volt DC, 8 Amp electrical loads.
AWARNING
When charging a device, do not place on the exhaust side of
the generator. Extreme heat caused by exhaust can damage
the device and cause a potential fire hazard. Prolonged
exposure to engine exhaust can cause serious injury or death.
5
1
2
3
4
7 8
9
6
A
B

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR CONTROLS AND FEATURES
14
Parts Included
Accessories
LPG Hose with Regulator ..........................................1
12V DC Battery Charging Cable ...................................1
12V DC USB Adapter ...............................................1
16A Plug- Dual 13A Sockets Adpater .............................1
Oil Funnel...........................................................1
Spark Plug Socket..................................................1

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR ASSEMBLY
15
ASSEMBLY
Your generator requires some assembly. This unit ships from our
factory without oil. It must be properly serviced with fuel and oil
before operation.
If you have any questions regarding the assembly of
your generator, call our Technical Support Team at
[phone]. Please have your serial number and model
number available.
Unpacking
1. Set the shipping carton on a solid, flat surface.
2. Remove everything from the carton except the generator.
3. Using the carrying handles of the unit, carefully remove the
generator from the box (two people lifting is recommended).
Add Engine Oil
ACAUTION
DO NOT attempt to crank or start the engine before it has been
properly filled with the recommended type and amount of oil.
Damage to the generator as a result of failing to follow these
instructions will void your warranty.
NOTICE
The generator rotor has a sealed, pre-lubricated ball bearing
that requires no additional lubrication for the life of the bearing.
NOTICE
The recommended oil type for typical use is 10W-30
automotive oil. However, using the listed conventional oils
shown in the “Recommended Engine Oil Type” chart may be
used for typical use including the first 5 hours of the break-in
run time period of the engine.
If running generator in extreme temperatures, refer to the
“Recommended Engine Oil Type” chart.
-20 020 40 60
Ambient temperature
Recommended Engine Oil Type
80 100 120
-28.9
°F
°C -17.8 -6.7 4.4 15.6 26.7 37.8 48.9
10W-30
5W-30 Full Synthetic
10W-405W-30
1. Place the generator on a flat, level surface.
2. Loosen the four cover screws and remove the maintenance
cover.
3. Remove oil fill cap/dipstick to add oil.
4. Using a funnel, add up to 16.9 fl. oz. (500 ml) of oil and
replace oil fill cap/dipstick and secure maintenance cover. DO
NOT OVERFILL.
5. Check engine oil level before each use and add as needed.
MAX
OIL DIP STICK
NOTICE
Once oil has been added, on flat level surface as a general rule
oil should be visible about 1-2 threads from top of the oil port
hole. If using the dipstick to check oil level, DO NOT screw in
the dipstick while checking simply rest it against the top of the
port and take reading.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR ASSEMBLY
16
NOTICE
Check oil level often during the break-in period. Refer to the
Maintenance section for recommended service intervals.
ACAUTION
This engine is equipped with a low oil shut-off and will stop
when the oil level in the crankcase falls below the threshold
level.
NOTICE
The first 5 hours of run time are the break-in period for the
unit. During the break in period stay at or below 50% of the
running watt rating and vary the load occasionally to allow
stator windings to heat and cool. Adjusting the load will also
cause engine speed to vary slightly and help seat piston rings.
After the 5 hour break-in period, change the oil.
NOTICE
Synthetic oil may be used after the 5 hour initial break-in
period. Using synthetic oil does not decrease the recommended
oil change interval. Full synthetic 5W-30 oil will aid in starting
in cold ambient < 41º F (5º C) temperatures.
Add Fuel: Petrol
ADANGER
Petrol vapors are highly flammable and extremely explosive.
DO NOT light or smoke cigarettes. Fire or explosion can cause
severe burns or death.
Only fill or drain fuel outdoors in a well-ventilated area. DO
NOT pump petrol directly into the generator. Use an approved
container to transfer the fuel to the generator.
Never use a petrol container, fuel tank, or any other fuel
item that is broken, cut, torn or damaged.
DO NOT overfill the fuel tank. Always keep fuel away from
sparks, open flames, pilot lights, heat and other sources of
ignition.
Use clean, fresh, regular unleaded petrol with a minimum octane
rating of 85 and an ethanol content of 10% or less by volume.
DO NOT mix oil with petrol.
1. Remove the fuel cap.
2. Slowly add petrol to the tank. DO NOT OVERFILL. Petrol can
expand after filling. A minimum of ¼ in. (6.4 mm) of space
left in the tank is required for petrol expansion, although more
than ¼ in. (6.4 mm) is recommended. Petrol can be forced
out of the tank as a result of expansion if overfilled, and can
affect the stable running condition of the generator.
3. The approximate fuel level is shown on the fuel gauge on top
of the fuel tank.
Empty Full
4. Screw on the fuel cap and wipe away any spilled fuel.
ACAUTION
Use unleaded petrol with a minimum octane rating of 85 and
an ethanol content of 10% or less by volume.
DO NOT light cigarettes or smoke when filling the tank.
DO NOT mix oil and petrol.
DO NOT overfill the tank. Fill tank to approximately ¼ in.
(6.4 mm) below the top of the tank to allow for petrol
expansion.
DO NOT pump petrol directly into the generator at the pump.
Use an approved fuel container to transfer the petrol to the
generator.
DO NOT fill fuel tank indoors, in garages, in sheds or in any out
building.
DO NOT fill fuel tank when the engine is running or hot, always
allow min 30 mins cooling.
AWARNING
Pouring petrol too fast through the fuel screen may result in
petrol splashing over the generator and operator while filling.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR ASSEMBLY
17
NOTICE
The generator engine works well with 10% or less ethanol
blended petrol. When using ethanol-petrol blends there are
some issues worth noting:
–Ethanol-petrol blends can absorb more water than petrol
alone.
–These ethanol blends can eventually separate, leaving
water or a watery goo in the tank, fuel valve and
carburetor. The compromised petrol can be drawn into the
carburetor and cause damage to the engine and/or create
potential hazards.
–If a fuel stabilizer is used, confirm that it is formulated to
work with ethanol-petrol blends.
–Any damages or hazards caused by using ethanol blended
petrol higher than 10% by volume, improperly stored
petrol, and/or improperly formulated stabilizers, are not
covered by manufacturer’s warranty.
It is advisable to always shut off the petrol supply and run the
engine to starvation after each use. See Storage instructions
for extended non-use.
Add Fuel: Propane (LPG)
ADANGER
NEVER place a petrol container, fuel tank, LPG cylinder or any
combustible material in the path of the exhaust stream during
operation of the engine.
1. Confirm the dial is in the OFF position.
2. If using a new propane cylinder, remove the plastic cap from
the cylinder valve.
3. Attach the LPG hose assembly (included) to the propane
cylinder valve and hand tighten until snug. DO NOT OVER
TIGHTEN.
4. Remove the rubber boot covering the propane connection port
on the inverter.
5. Align the plastic finger on the male hose fitting on the LPG
hose assembly with the slot next to the female quick connect
coupling on the inverter.
6. Insert the hose fitting into the quick connect coupling and
push in until you hear a “click” and the outside collar of the
quick connect coupling moves forward.
7. Check all connections for leaks by wetting the fittings with a
solution of soap and water. Bubbles which appear or bubbles
which grow indicate that a leak exists. If a leak exists at a
fitting then turn off the valve on the cylinder and tighten the
fitting. Turn the valve back on and recheck the fitting with the
soap and water solution. If the leak continues or if the leak
is not at a fitting then do not use the generator and contact
customer service.
NOTICE
–The LPG hose included with this unit works with standard
20 and 30 pound LPG tanks.
–Verify the requalification date on the cylinder has not
expired.
–All new cylinders must be purged of air and moisture prior
to filling. Used cylinders that have not been plugged or kept
closed must also be purged.
–The purging process should be done by an LPG supplier.
(cylinders from an exchange supplier should have been
purged and filled properly already).
–Always position the cylinder so the connection between the
cylinder valve and generator inlet won’t cause sharp bends
or kinks in the LPG hose.
ACAUTION
Do not allow children to tamper or play with the LPG cylinder
or hose connections.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR OPERATION
18
ACAUTION
Use approved LPG cylinders equipped with an OPD (overfilling
prevention device) valve. Always keep the cylinder in a vertical
position with the valve on top and installed at ground level
on a flat surface. Cylinders must not be installed near any
heat source and should not be exposed to sun, rain, and dust.
When transporting and storing, turn off the cylinder valve and
generator LPG valve, and disconnect the cylinder. Plug the
outlet, usually by a plastic protective cap, if one is available.
Keep cylinders away from heat and ventilated when in a
vehicle.
AWARNING
If there is a strong smell of LPG: Close valve on the cylinder.
Check all connections for leaks by wetting the fittings with a
solution of soap and water. Bubbles which appear or bubbles
which grow indicate that a leak exists. Do not smoke or light a
cigarette, or check for leaks using a match, open flame source
or lighter. Contact a qualified technician to inspect and repair
an LPG system if a leak is found, before using the generator.
Grounding
Your generator must be properly connected to an appropriate
ground to help prevent electric shock.
AWARNING
Failure to properly ground the generator can result in electric
shock.
A ground terminal connected to the panel of the generator has
been provided (see Controls and Features for terminal location).
For remote grounding, connect a length of heavy gauge
(12 AWG minimum) copper wire between the generator ground
terminal and a copper rod driven into the ground. We strongly
recommend that you consult with a qualified electrician to ensure
compliance with local electrical codes.
Neutral Floating*(This generator)
–Neutral circuit IS NOT electrically connected to the frame/
ground of the generator.
–The generator (stator winding) is isolated from the frame and
from the AC receptacle ground pin.
–Electrical devices that require a grounded receptacle pin
connection will not function if the receptacle ground pin is not
functional.
Neutral Bonded to Frame*
–Neutral circuit IS electrically connected to the frame/ground of
the generator.
–The generator system ground connects lower frame cross-
member below the alternator. The system ground is connected
to the AC neutral wire.
* See your Specifications section for specified type of grounding.
OPERATION
CO Shield®- Carbon Monoxide (CO) Detection
and Auto-shutoff System
CO Shield®technology monitors the accumulation of carbon
monoxide (CO), a poisonous gas produced by engine exhaust when
the generator is running. If CO Shield®detects unsafe elevated
levels of CO gas, it automatically shuts off the engine.
CO SHIELD®IS NOT A SUBSTITUTE FOR AN INDOOR CARBON
MONOXIDE ALARM OR FOR INDOOR OPERATION.
DO NOT allow engine exhaust fumes to enter a confined area
through windows, doors, vents or other openings.
Generators must ALWAYS be used outdoors, far away from
occupied buildings with engine exhaust pointed away from people
and buildings.
If misused and operated in an unapproved and unsafe location
that results in the accumulation of poisonous CO gas inside
an enclosed or partially enclosed space, for example a house,
garage or a garage with the door partially open, CO Shield®will
automatically shut off the generator and then will illuminate a
blinking red LED light. Read the action label for next steps.
ACTION LABEL
PO INT AWAY
AUTOMATIC SHUTOFF – YOU MUST:
Move generator to an open,
outdoor area. Point exhaust away.
Don’t run generators in enclosed
Move to fresh air and get medical help if sick,
dizzy or weak.
EXHAUST
ADANGER
1106-BY-L-A
Using a generator indoors CAN KILL YOU IN
MINUTES. Generator exhaust contains carbon
monoxide. This is a poison you cannot see or
smell.
NEVER use inside a home or garage or any out
building, EVEN IF doors and windows are
open.ONLY use OUTSIDE and far away from
windows, doors, and vents.
areas (eg sheds, garages, houses or any out
buildings).
K2945 123 482 152
ColorsAPN 1106-BY-L
Rev A
Size ~203 x 75 mm
Artwork Notes
2mm safe margin; white t o be printe d shown in 50%
process magenta
Revision Changes
This art work belongs to Cha mpion Power Equipmen t. The contents a re confidential a nd privileged and sh all not be disclosed t o or used by or for
outside p arties withou t the explicit conse nt of Champion Power E quipment.
P
In the event of an engine shut off, when you approach the
generator to investigate, a blinking red LED light in the CO Shield®

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR OPERATION
19
area provides notification that the generator shut off due to an
accumulating CO hazard. The red LED light will blink for at least
five (5) minutes after an engine shut off event.
AUTOMATIC SHUTOFF
SEE ACTION LABEL
AUTOMATIC SHUTOFF
SEE ACTION LABEL
AUTOMATISCHE ABSCHALTUNG
SIEHE AKTIONSKENNZEICHNUNG
AUTOMATISCHE ABSCHALTUNG
SIEHE AKTIONSKENNZEICHNUNG
AUTOMATISCHE ABSCHALTUNG
VOIR ETIQUETTE D’ACTION
AUTOMATISCHE ABSCHALTUNG
VOIR ETIQUETTE D’ACTION
Move the generator far away to an open, outdoor area and point
the exhaust away from people and buildings. Once relocated
to a safe area, the generator can be restarted, and the proper
electrical connections made. Introduce fresh air and ventilate the
location where the generator shut off.
When restarting, the red and yellow LED will blink ten (10) times
simultaneously to indicate the LED is working.
NOTICE
This blinking LED light does not indicate CO ShieldR is
working,CO ShieldR is on and active at all times when the
generator is running.LED light will not blink (10) times if the
generator was restarted within 1 minute after it was turned
off. This LED blinking indication does not occur if the generator
is shut down from a high CO event.
If CO ShieldR system experiences a fault and no longer provides
protection, the generator will shutoff automatically and the yellow
LED light will blink for at least five (5) minutes to notify you of the
fault
SERVICESERVICE
Call our Technical Support Team at [phone] for
repair. The generator can be restarted, but will continue to shutoff.
NOTICE
CO ShieldR will detect an accumulation of carbon monoxide
(CO) from other fuel burning sources such as engine powered
equipment, and(or) heaters used in the area of its operation. If
another generator is used and the exhaust stream is pointed
in the direction of the CO ShieldR equipped generator, the CO
ShieldR will initiate a shutoff due to rising carbon monoxide
(CO) levels. This is not a fault, It simply means high levels
of Poisonous carbon monoxide (CO) has been detected.You
must take action to move and direct the generator exhaust or
heaters stream to better disperse carbon monoxide (CO) far
away from people or buildings as possible..
ADANGER
Tampering with the CO Shield®system will result in a
hazardous condition and will void your warranty.
Removing the CO ShieldR module is not allowed and will result
in the generator not being able to start, by doing so this will
void any warranty.

93001i-DF-UK - 3000W DUAL FUEL INVERTER GENERATOR OPERATION
20
Generator Location
AWARNING
NEVER operate the generator inside any building, garage,
basement, crawlspace, shed, enclosure or compartment,
including a generator compartment of a recreational vehicle.
NEVER operate or start the generator in the back of an
SUV, camper, trailer, truck bed (regular sides, flat or other
configuration), under staircases, stairwells, next to walls
or buildings or in any other location that will not allow for
adequate cooling of the generator or for the proper exit of the
exhaust flow from the muffler system.
DO NOT operate or store the generator in wet weather
conditions such as rain or snow. Using a generator in wet
conditions could result in serious injury or death due to
electrocution.
In some state’s generators may be required to be registered
with the local utility company when used at construction sites
and may be subject to additional rules and regulations, consult
your local municipal authority.
Generators should always be operated on a flat, level surface
at all times (even when not in operation).
Generators must have a minimum of 5 feet (1.5 m) of
clearance from all combustible material.
Generators must also have a minimum of 3 feet (91.4 cm)
of air flow clearance on all sides to allow for adequate
performance cooling, maintenance and servicing.
Always place the generator in a well-ventilated area. NEVER
place the generator near air intake vents or where exhaust
fumes could be drawn into occupied or confined spaces.
Always carefully consider wind and air currents when
positioning generator.
Always allow generators to properly cool before transport or
for storage purposes.
Failure to follow proper safety precautions may result in
personal injury, damage to the generator and void the
manufacturer’s warranty.
AWARNING
During operation the muffler and exhaust fumes will become
hot. If adequate cooling and breathing space are not supplied,
or if the generator is blocked or enclosed, temperatures can
become extremely heated and may lead to fire.
ACAUTION
Do not modify or try to install a exhaust/muffler extension
otherwise you will cause degraded engine performance and
may damage the engine resulting in voiding any warranty.
AWARNING
Do not expose to rain or use in damp locations.
Keep all objects a minimum of 5 feet (1.5m) away from the
generator at all times. Heat from the muffler surface and
exhaust gas stream can ignite combustible materials.
AWARNING
If you must operate in rain or damp locations, DO NOT operate
without proper protection of the electrical components.
Use of a safety canopy that is fire retardant and will provide proper
air ventilation for the engine exhaust gas stream may be used.
Visit championpowerequipment.com or call to find your Storm
Shield cover.
Surge Protection
Electronic devices, including computers and many programmable
appliances use components that are designed to operate within a
narrow voltage range and may be affected by momentary voltage
fluctuations. While there is no way to prevent voltage fluctuations,
you can take steps to protect sensitive electronic equipment.
–Install UL1449, CSA-listed, plug-in surge suppressors on the
outlets feeding your sensitive equipment.
Surge suppressors come in single- or multi-outlet styles.
They’re designed to protect against virtually all short-duration
voltage fluctuations.
Starting the Engine: Petrol
1. Make certain the generator is on a flat, level surface.
2. Disconnect all electrical loads from the generator. Never start
or stop the generator with electrical devices plugged in or
turned on.
3. Turn the fuel vent lever to the “ON” position.
4. Move the EZ Start dial to the “CHOKE” position.