Child Craft Orbit F30201 User manual

1
5216 Portside Dr., Medina, OH 44256 USA • PH: 1 330.723.0599 • FAX: [phone]
www.childcraftbaby.com
KEEP INSTRUCTIONS FOR FUTURE USE .
Assembled as Toddler Bed
FOR CUSTOMER SERVICE CALL
330-723-0599. DO NOT CALL
RETAILER OR RESELLER FOR SERVICE
AS THEY ARE NOT AUTHORIZED TO
RESOLVE ANY SERVICE ISSUES.
FOR WARRANTY AND FEDERAL SAFETY
STANDARD COMPLIANCE CERTIFICATES,
PLEASE VISIT OUR WEBSITE AT
www.childcraftbaby.com Assembled as Crib
AB20493_G1
AB20493_G2
AB20493B
Record the information for your product here:
Model number: ___________________
Manufacture date: ___________________
PO number: ___________________
ASSEMBLY ASSISTANCE
IMPORTANT: Retain for future reference and
read carefully.
Child Craft strives for the highest quality in our
products but occasionally a missing part or
problem can occur during assembly.
If any parts are missing or broken or you need
assistance with assembly, DO NOT return the
product to your dealer. Go to our website at
www.childcraftbaby.com or call Child Craft for
assistance at 1-330-723-0599 (Monday through
Friday, 9:00 a.m.– 4:00 p.m. Eastern Time). Please
have the model number and manufacture date
available when you call or write us at:
Child Craft, 5216 Portside Dr., Medina, OH 44256
• Adult assembly required.
• Read all instructions BEFORE assembly and USE
of product.
• Unpack carton, remove packing materials,
including polybag. Identify and check all parts.
ASSEMBLY INSTRUCTIONS
THIS IS THE ASSEMBLY INSTRUCTIONS FOR CRIBS
SOLD IN THE UNITED STATES AND CANADA.
Orbit Flat Top Crib
Model Covered: F30201

2
Part Description Part Number Qty.
A. Footboard 22304264 1
B. Short Side 22304272 2
C. Headboard 22304252 1
D. Spring 11200624 1
AA. Allen Head Bolt 55mm Long 11200984 8
BB. Dowel 11201383 4
CC. Allen Head Bolt 20mm Long 11200423 4
DD. Connector Nut 11201001 4
EE. Allen Head Bolt 16mm Long 11200913 4
FF. Allen Wrench 11200978 1
GG. Connector Nut 11200531 4
PARTS LIST
PREPARATION
Carefully remove and lay out all hardware and parts.
Check quantities and match the parts list. Construct
furniture on an even at oor.
Note: during the assembly process whenever using
screws or bolts, check each with the parts list by letter
and size identication. Place each screw or bolt on the
diagram of the item which is sketched actual size. Be
sure to use the proper size specied in the assembly
directions. If any parts are missing or broken or you need
assistance with assembly DO NOT return your product
to the dealer. Please identify the furniture by the model
number identication stamped on the inside face of the
assembly when you call or write to Child Craft.
Make note of all identification numbers and include this
information with your request.
DO NOT Substitute Parts!
SUGGESTED TOOLS
#2 Medium Straight Screwdriver
Crib Parts
Hardware Package
AB20493_G3
A
B
D
C
AB20493_G4
AA
BB
FF
CC
DD
EE
GG

3
STEP 1
C x 1
DD x 4
EE x 4
DD x 2
DD x 2
EE x 2
EE x 2
C
AB20493_G5
C
B x 1
C x 1
AA x 2
BB x 1
B
AA x 2
BB
AB20493_G6
STEP 2

4
STEP 3
B
BB
AA x 2
B x 1
AA x 2
BB x 1
AB20493_G7
3
1
2
D
CC
CC
D x 1
CC x 4
AB20493_G8
STEP 4

5
STEP 5
A x 1
AA x 4
BB x 2
AB20493_G9
AA
AA
BB
BB
MATTRESS INSTALL
Place a purchased full sized
mattress on the spring.
The warnings for the United
States and Canada can be found
after the maintenance, cleaning,
and storage information section.
AB20493_G11

6
CAUTION (For United States)
• ANY MATTRESS USED IN THIS CRIB SHALL
BE AT LEAST 27 1/4 BY 51 5/8 IN. WITH A
THICKNESS NOT EXCEEDING 6 IN. IF
YOUR CRIB IS DESIGNED TO CONVERT TO
A TODDLER BED, THE MATTRESS MUST BE
AT LEAST 4 IN. (100 MM) THICK.
TODDLER BED CONVERSION
A x 1
AA x 4
BB x 2
AB20493_G12
AA
AA
BB
BB

7
GUARD RAIL OPTION & INSTALLATION
AA x 2
AA x 2
GG x 2
GG x 2
AA x 4
GG x 4
AB20493_G10
Shop for Your Crib’s Matching
Guard Rails
WARNINGS (For Toddler Bed)
WARNING: INFANTS HAVE DIED IN TODDLER BEDS FROM
ENTRAPMENT. Openings in and between bed parts can entrap head and neck of a
small child. NEVER use bed with children younger than 15 months. ALWAYS follow
assembly instructions.
WARNING: STRANGULATION HAZARD: NEVER place bed near windows
where cords from blinds or drapes may strangle a child. NEVER suspend strings over
bed. NEVER place items with a string, cord or ribbon, such as hood strings or
pacifier cords, around a child’s neck. These items may catch on bed parts.
CAUTION: ENTRAPMENT HAZARD: To avoid dangerous gaps, any
mattress used in this bed shall be a full-sized crib mattress at least 51 5/8 in. (1310
mm) in length, 27 1/4 in. (690 mm) in width, and 4 in. (100 mm) in thickness.
• The users maximum weight shall not be greater than 50 lbs. (22.7 kg).
• Mattress MUST be moved into lowest position for proper positioning.
•This crib contains all components necessary to convert to a toddler bed. However,
a guardrail may be available for purchase to provide additional security. Contact
Child Craft for assistance. Refer to maintenance section for contact information.

8
MAINTENANCE, CLEANING, AND STORAGE
MAINTENANCE:
Upon completion of the assembly, check to make sure all screws, bolts and connectors are tightened and secure.
Periodically check crib for damaged hardware, loose joints, missing parts or sharp edges before and after assembly
and frequently during use.
DO NOT use crib if any parts are missing or broken.
If any parts are missing, broken or you need assistance DO NOT return crib to your dealer.
Call Child Craft at 330.723.0599 and include model identication numbers recorded on page 1.
DO NOT substitute parts.
CLEANING:
Mix a mild solution of gentle dishwashing soap and water, apply to surface using a clean cloth lightly dampened in
the solution. Rinse well with clear water using a soft clean cloth, then dry all surfaces with a soft dry cloth.
DO NOT use abrasive cleaners or any cleaners with harsh chemicals that would contact a child’s skin, scouring
pads, steel wool or coarse rags. This crib should be treated the same as any ne furniture.
STORAGE:
When storing crib use caution as extreme temperature or humidity changes could be harmful.
Use caution when a vaporizer is in use. Always aim vapor stream away from crib as well as away from any wood
furniture item.
After completing the assembly, the user is advised to read and be aware of
ALL WARNINGS, CAUTIONS, CLEANING, STORAGE USE, AND MAINTENANCE notices in these
directions and printed on the storage pouch on the crib spring. A printed pouch is attached to
the crib spring for the permanent storage of the assembly directions. Please place the complete set
of assembly directions into the pouch for future referral. We caution the user to not place excess
hardware in the pouches as it could present danger to the child if retrieved.
FULL SIZE BED CONFIGURATION
C x 1
S x 1
T x 4
U x 4
C
S
U x 2
T x 2
U x 2
T x 2
AB20493_G13
Shop for Your Crib’s Matching
Bed Rails
ATTENTION: THE FOLLOWING HARDWARE NEEDED FOR THE FULL SIZE
BED CONVERSION ARE NOT PROVIDED BY CHILD CRAFT, BUT MAY BE
PURCHASED AT YOUR LOCAL HARDWARE STORE.
S. Full Size Hollywood Style Bed Frame.
T. 1/4”-20 x 3” Long Bolts.
U. 1/4”-20 Nuts.
Align Hollywood Bed Frame with holes in Headboard (C). Insert Bolts (T)
Through Headboard (C) and Bed Frame.

9
• Read all instructions before assembling crib. Keep instructions for future use. A pouch is
attached to the crib for permanent storage of the instructional literature.
• To reduce the risk of SIDS, pediatricians recommend healthy infants be placed on their backs to
sleep, unless otherwise advised by your physician.
• Strings can cause strangulation! DO NOT place items with a string around a child’s neck, such as
hood strings or pacifier cords. DO NOT suspend strings over a crib or attach strings to toys.
• To help prevent strangulation, tighten all fasteners. A child can trap parts of the body or clothing
on loose fasteners.
• DO NOT place crib near window where cords from blinds or drapes may strangle a child.
• When child is able to pull to standing position, set mattress to lowest position and remove bum
per pads, large toys and other objects that could serve as steps for climbing out.
• Stop using crib when child begins to climb out or reaches the height of 35 in. (89 cm).
• After raising side, make sure latches are secure (if your unit has a movable side).
• DO NOT leave child in crib with side lowered. Be sure side is in raised and locked position when
ever child is in crib (if your crib has a moveable side).
• Check this product for damaged hardware, loose joints, loose bolts or other fasteners, missing
parts or sharp edges before and after assembly and frequently during use. Securely tighten bolts
and other fasteners. DO NOT use the crib if any parts are missing, damaged or broken. If any
parts are missing or broken or you need assistance with assembly, DO NOT return the product to
your dealer. Call Child Craft for assistance at 1.330.723.0599 for replacement parts and
instructional literature if needed. Include model identication numbers recorded on page 1 with
your request. DO NOT substitue parts.
• Replace teething rail(s) if damaged, cracked or loose (if equipped with teething rails).
• If renishing use a non-toxic nish specied for children’s products.
• Follow warnings on all products in a crib.
• NEVER use plastic shipping bags or other plastic lm as mattress covers because they can cause
suffocation.
• Infants can suffocate in gaps between crib sides and a mattress that is too small.
• DO NOT use a water mattress with this crib.
• When disassembling this crib, DO NOT remove any item attached with wood screws.
FAILURE TO FOLLOW THESE WARNINGS AND THE ASSEMBLY INSTRUCTIONS
COULD RESULT IN SERIOUS INJURY OR DEATH.
WARNING (For United States)
WARNING: Infants can suffocate on soft bedding. NEVER add a pillow
or comforter. NEVER place additional padding under an infant.
WARNING

10
WARNING (For Canada)
• DO NOT use this crib if you cannot exactly follow the accompanying instructions.
• DO NOT use this crib for a child who can climb out of it or who is taller than 90cm.
• DO NOT place in or near this crib any cord, strap or similar item that could become
wrapped around a child’s neck.
•DO NOT place this crib near a window or a patio door where a child could reach
the cord of a blind or curtain and be strangled.
• Check this crib regularly before using it and do not use it if any parts are loose or
missing or if there are any signs of damage. Do Not substitute parts. Contact the
manufacturer if replacement parts or additional instructions are needed.
• Children can suffocate on soft bedding. Do Not place pillows, comforters or soft
mattresses in this crib.
• Use a crib mattress that is no thicker than 15 cm thick and is of such a size that,
when it is pushed firmly against any side of the crib, it does not leave a gap of
more than 3 cm between the mattress and any part of the sides of the crib.
Meets CPSC
Safety Requirements
5216 Portside Dr.
Medina,Ohio 44256 USA
Telephone: [phone]
Fax: [phone]
www.childcraftbaby.com
IMPORTED BY:
Foundations Worldwide Inc.
30 Casebridge Court
Scarborough, ON M1B 3M5 CAN
330.722.5033
Shop More for Your
Nursery, Toddler,
Playroom & Beyond