Coleman 9941 User manual

®
Propane Stove
9941 Series
INSTRUCTIONS FOR USE
U.S. and other Patents Pending
© 2001 The Coleman Company, Inc.
www.coleman.com
For Outdoor Use Only
IMPORTANT
Read this manual carefully before assembling,
using or servicing this stove. Keep this manual
for future reference.If you have questions about
assembly, operation, servicing or repair of this
stove, please call Coleman at 1-800-835-3278
or TDD: 316-832-8707. In Canada call
1-800-387-6161.
CSA 11.2-2000

2
Contents General Safety Information
General Safety Information
To Set-up
Leak Check
Water Pan
Operation
To Light
Cooking Tips
To Turn Off
Tear Down/Clean
Storage
Maintenance
Troubleshooting
Service
Things You Should Know
Replacement Parts List
Accessories
Warranty
DANGER
• CARBON MONOXIDE HAZARD
• This appliance can produce carbon monoxide
which has no odor.
• Using it in an enclosed space can kill you.
• Never use this appliance in an enclosed space
such as a camper, tent, car or home.
If you smell gas:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
FOR YOUR SAFETY
Do not store or use gasoline or other liquids with
flammable vapors in the vicinity of this or any other
appliance.
FOR YOUR SAFETY
This manual contains important information about the assembly, oper-
ation and maintenance of this outdoor stove. General safety information is
presented in these first few pages and is also located throughout the man-
ual. Particular attention should be paid to information accompanied by the
safety alert symbols:“ DANGER”, “ WARNING”, “ CAUTION”.
Keep this manual for future reference and to educate new users about
this product. This manual should be read in conjunction with the labeling
on the product.
Safety precautions are essential when any mechanical or propane-
fueled equipment is involved.These precautions are necessary when
using, storing, and servicing. Using this equipment with the respect
and caution demanded will reduce the possibilities of personal injury or
property damage.
The symbols shown below and on page 3 are used extensively
throughout this manual. Always heed these precautions, as they are
essential when using any mechanical or fueled equipment.
DANGER
DANGER indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
WARNING
WARNING indicates a potentially hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION
CAUTION indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate personal injury, or property
damage.
Failure to comply with the precautions and instructions provided with this
outdoor stove can result in death, serious bodily injury and property loss or
damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Only persons who can understand and follow the instructions should use or
service this outdoor stove.
If you need assistance or outdoor stove information such as an instruction
manual or labels, contact the Coleman Co., Inc.
DANGER
Improper installation, adjustment, alteration,
service or maintenance can cause injury or prop-
erty damage. Read the Installation, Operation, &
Maintenance Instructions thoroughly before
installing or servicing this equipment.
WARNING
WARNING: For Outdoor Use Only

3
General Safety Information cont.
DANGER
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open flames, pilot lights, direct
sunlight, other ignition sources or where temperatures exceed 120
degrees F (49°C).
• Propane is heavier than air and can accumulate in low places. If you
smell gas, leave the area immediately.
• Never install or remove propane tank while outdoor stove is lighted,
near flame, pilot lights, other ignition sources or while outdoor stove is
hot to touch.
• During operation, this product can be a source of ignition. Never use
the stove in spaces that contain or may contain volatile or airborne com-
bustibles, or products such as gasoline, solvents, paint thinner, dust par-
ticles or unknown chemicals. Minimum clearances from combustible
materials: one foot from the sides & four feet from the top.
• Provide adequate clearances around air openings into the combustion
chamber.
WARNING
We cannot foresee every use which may be made of this cooking stove.
Check with your local fire safety authority if you have questions
about use.
Other standards govern the use of fuel gases and heat producing
products for specific uses.Your local authorities can advise you about
these.
• Never refill disposable cylinders.
• Use the preset regulator that came with the stove. Do not attempt to
adjust.
• CARBON MONOXIDE HAZARD
• This stove is a combustion appliance. All combustion appliances pro-
duce carbon monoxide (CO) during the combustion process.This
product is designed to produce extremely minute, non-hazardous
amounts of CO if used and maintained in accordance with all warn-
ings and instructions. Do not block air flow into or out of the cook
stove.
• Carbon Monoxide (CO) poisoning produces flu-like symptoms,
watery eyes, headaches, dizziness, fatigue and possibly death.
You can’t see it and you can’t smell it. It’s an invisible killer. If these
symptoms are present during operation of this product get fresh air
immediately!
• For outdoor use only.
• Never use inside house, or other unventilated or enclosed areas.
This cook stove consumes air (oxygen). Do not use in unventilat-
ed or enclosed areas to avoid endangering your life.
DANGER
WARNING
• This product is fueled by propane gas. Propane gas is invisible,
odorless, and flammable. An odorant is normally added to help detect
leaks and can be described as a “rotten egg” smell.The odorant can
fade over time so leaking gas is not always detectable by smell alone.
• Propane gas is heavier than air and leaking propane will sink to the
lowest level possible. It can ignite by ignition sources including match-
es, lighters, sparks or open flames of any kind many feet away from
the original leak. Use only propane gas set up for vapor withdraw.
• Propane gas should be stored and used in compliance with local
ordinances and codes or with ANSI/NFPA 58. Turn off propane when
not in use.
CALIFORNIA PROPOSITION 65:
WARNING: Propane and byproducts of combustion of propane contain
chemicals known to the state of California to cause cancer, birth defects,
or other reproductive harm.
• BURN HAZARD
• Never leave the outdoor stove unattended when hot or in use.
• Keep out of reach of children.
WARNING
• SERVICE SAFETY
• Keep all connections and fittings clean. Make sure propane tank valve out-
let is clean.
• During set up, check all connections and fittings for leaks using soapy
water. Never use a flame.
• Use as a cooking appliance only. Never alter in any way or use with any
device or part not expressly approved by Coleman.
CAUTION

4
To Set Up
■ Unfold the stand.
Extend legs.
■ Be sure that the locking button
securely engages leg extension.
■ Swing wire brace into position
and insert ends of wire brace
into holes in the leg.
■ Insert side tables.
■ Place the
stand outdoors
and set on sturdy,
flat surface.
■ Adjust foot pad
levels if grilling on
uneven surface.
■ Place the stove
onto the stand.
The base of the
stove is designed
to snuggly fit the
stand.
Step 2
Step 1
Step 3
Step 4
■ Remove
components
from package:
(1) Stand
(2) Side tables
(1) Stove
(1) Lid
(1) Waterpan
(1) Regulator
(1) Grill
(1) Griddle
■ See replace-
ment parts list
for identification.
Step 5
Step 6
Locking
Button
Wire
Brace
■ Make sure both burner
valves are off.
Step 7
■ Remove plastic cap
from top of propane
cylinder. Save cap for
use in storing. Screw
propane cylinder into
REGULATOR. Be care-
ful not to cross-thread.
HAND TIGHTEN only.
Step 8
Foot
Pad

5
Leak Check
CAUTION
• Do not use the stove without the water pan in place.
• Coleman recommends water in the water pan when in use.This will
help prevent a grease flare-up.
WARNING
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor stove until connection has been leak tested
and does not leak.
■ Check the connection between
the cylinder and the regulator with
soapy water. Bubbles indicate a
leak. Check that the connection is
not cross-threaded and that it is
tight. Perform another leak check.
If there is still a leak, remove the
cylinder and contact Coleman for
service or repairs.
■ Insert the regulator pipe firmly.
The regulator uses a push-on
fitting to attach to the stove. It is
necessary to hold the stove to
make sure the fitting is seated.
Align the regulator to the fuel
tube on the rear of the stove and
push on until you hear the retain-
er “click” in place. Gently pull on
the regulator to ensure that the
connection is secure.
■ If using the stove on a table-
top, allow the base of the
propane cylinder to rest on the
surface of the table-top.
■ If using the stove with stand, a
slotted support bracket is provid-
ed to support a propane cylinder.
Extend the slotted support brack-
et into position.
Slotted Support
Bracket
Fill Pan with Water
■ Cleanup will be improved
if you fill WATER PAN to
mark indicated (MAX).
Fill Pan with Water cont.
■ Place the grill
and griddle onto
the stove.
Operation
• CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, or other unventilated or enclosed areas.
This outdoor stove consumes air (oxygen). Do not use in unventi-
lated or enclosed areas to avoid endangering your life.
DANGER
DANGER
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open flames, pilot lights, direct
sunlight, other ignition sources or where temperatures exceed 120°F
(49°C).
• Propane is heavier than air and can accumulate in low places. If you
smell gas, leave the area immediately.
• Never install or remove propane tank while outdoor stove is lighted,
near flame, pilot lights, other ignition sources or while outdoor stove is
hot to touch.
• This stove is red hot during use and can ignite flammables too close to
the burner. Keep flammables at least 12" from sides and 48" from top.
Keep gasoline and other flammable liquids and vapors well away from
outdoor stove.
• Disconnect propane tank from stove if the stove is to be stored
indoors.
■ Do not attempt to operate until you have read and understood all
General Safety Information in this manual and all assembly is complete
and leak checks have been performed.
Leak
Check

6
To Light To Turn Off
■ Open the stove lid. Do not
attempt to light the stove with lid
closed.
■ Open either BURNER VALVE
and push igniter button several
times until burner lights. (If the
stove is wet the igniter may not
spark.)
■ The unit may be match lighted
if there is no ignition. Hold lit
match next to BURNER and
open BURNER VALVE slowly.
■ Left knob controls left burner.
■ Right knob controls right burn-
er.
■ Adjust flame to desired heat
level.
Cooking Tips
CAUTION
• Do not place a pot or a pan on the nonstick grill or griddle surfaces.
Damage will occur and void the warranty.
■ The grill and griddle have
a nonstick coating. Use only non-
metallic utensils to prolong the life
of the nonstick coating.
■ Use the flat griddle surface for
eggs, thin pieces of meat, fish or
vegetables.
■ The grill surface is ideal
for steaks, hamburgers or chicken.
■ When grilling, always place food
on grill before lighting the burner.
■ Coleman recommends fresh
water in the water pan when in
use. Fresh water in the water pan
will help food taste better and keep
it from drying out.
■ Use the optional chromed
stove grate (sold separately) any-
time you wish to place a pot on
the stove.
■ The lid is removable.Tilt
forward and lift.
■ Push the burner valve knobs
inward and close burner valves
firmly.
Tear Down/Clean
■ Be sure stove is cool.
■ Always detach propane cylin-
der outdoors away from ignition
sources.
■ The fitting on the regulator
has a sliding collar that secures
the regulator to the stove fuel
line. Slide the collar away from
the stove and then pull the
regulator off the stove fuel line.
■ Detach propane cylinder
from regulator and replace the
plastic protective cap onto
cylinder threads.
■ Remove the grill and grid-
dle.The grill and griddle are
dishwasher-safe.
■ Remove the water pan
and discard the water and
grease.
■ Clean the water pan with
warm water and mild house-
hold cleaner. Do not use
abrasives.
■ Wipe the stove clean
with soft cloth and mild
household cleaner. Do not
use abrasives.
■ Collapse & fold the legs
on the stand.
Storage
■ Disconnect regulator from cylinder.
■ Store propane tank in safe manner. Refer to Chapter 5 of Standard for
Storage and Handling of Liquefied Gases
, ANSI/NFPA 58. Follow all local
codes. Always store propane tanks outdoors.
■ Store stove in a dry, clean and safe place.
■ Place the cleaned water pan, grill, griddle and REGULATOR into the
stove for storage.
■ For long-time storage, clean and dry all stove parts and the stand
before storing. Use a Coleman carry case and store indoors.This will
keep the unit clean and ready for the next season.
■ If a Coleman carry case is not available, you may place the stove in a
plastic bag and tie it shut.

Maintenance
• BURN HAZARD
• Do not touch or attempt any maintenance on stove for at least one hour
after use.
• Make sure all controls are off and propane tank has been removed
before doing maintenance.
WARNING
To enjoy years of outstanding performance from your stove, perform the
following maintenance activities on a regular basis:
• Keep exterior surfaces clean.
• Use warm soapy water for cleaning. Never use flammable or corrosive
cleaning agents.
Problem Possible Cause Solution
Burner won’t light Gas pressure is low. Cylinder is empty. Replace cylinder
Air in gas line. Burner may take up to one minute to light
after a propane bottle has been connected.
Igniter is wet. Light the stove with a match.
Burner won’t stay lit Dust and/or dirt built up around burner Clean dirt and/or dust from around burner
Burner flame is low Gas pressure is low Replace cylinder.
Outdoor temperature is less than 40Þ F Use a full cylinder.
and tank is less than 1/4 full.
Fuel flow is restricted. Check burner and orifices for blockage. Adjust control
knob to full ON position.
Fuel flow is restricted. Check burner, orifices and venturi for blockage (bugs,
dirt, cobwebs).
Troubleshooting
Improper Flame
(Flame should be blue
with hint of yellow on tips)
•Airflow must be unobstructed. Keep controls, burner and circulating
air passages clean. Signs of possible blockage include:
-Gas odor
-Stove makes popping noises
-Smoky flame.
• Spiders and insects can nest in burner orifices.This condition can
damage the stove and render it unsafe for use. Clean burner holes
by using a heavy-duty pipe cleaner. Compressed air may help clear
away small particles.
• Carbon deposits may create a fire hazard. Clean burner with warm
soapy water if any carbon deposits develop.
• If the stove has been left uncovered and is wet from rain, snow,
yard sprinklers, etc., allow to dry (at least 30 minutes prior to use).
• NOTE: In a salt-air environment (such as near an ocean), corrosion
occurs more quickly than normal. Frequently check for corroded
areas and repair them promptly.
Service
■ Repair to gas passages and associated components
should be done only by Coleman or an authorized service
person.
■ Owner repair and service should be limited and performed
only to the the following:
• Cleaning
• Cylinder replacement
Things you should know
1. It is unsafe and illegal in some places to store or use propane cylinders of
greater than 1.14 kg (2.5 lbs) water capacity (approximately 1 lb. propane) in
occupied enclosures.
2. If using refillable propane cylinder, use only Coleman parts and accessories.
3.The usual storage areas for camping and picnic equipment are the basement, attic,
or garage.To avoid the accumulation of dust, cobwebs, etc., that is common in these
areas, place your stove in a plastic bag and seal it with a rubber band.
4. For repair service call one of the numbers listed below for location of your nearest
Coleman Service Center. If product must be mailed to Service Center, attach to prod-
uct your name, address and a description of problem and mail to Service center with
shipping and insurance prepaid. If necessary to write the Service Center or
factory, refer to your stove by model number. Do not send propane cylinder.
5. If not completely satisfied with the performance of this product, please call one of
the numbers listed on the cover of this manual.
7

8
1
4
56
8
9
13
Replacement Parts 9941-700 Stove
7
2
3
11
10
Parts List
No.Part No.Description
1 9941-5021 Lid and Handle Assembly (Black)
9941-5071 Lid and Handle Assembly (Stainless Steel)
9941-5081 Lid and Handle Assembly (Blue)
2 9941A3171 Griddle, Nonstick Cast Aluminim
3 9941A3151 Grill, Nonstick Cast Aluminum
4 9941-3311 Water Pan
5 9941-5471 Burner Assembly – left
6 9941-5461 Burner Assembly – right
7 9942-5251 Regulator Assembly
8 9942-5851 Igniter/Electrode
9 9942-3811 Side Handle Assembly w/boots and screws
10 9942-1381 Igniter Button Cover
11 9942-1491 Control Knob (package of two)
12 9941-1711 Fascia Kit (includes igniter button cover)
13 9941-3191 Stove Grate
12

9
Parts List
No.Part No.Description
1 9941-5631 Side Table Assembly
2 9941-5611 Leg Assembly
3 9941-5601 Foot Assembly
4 9941-1881 Foot Pad
Replacement Parts 9941-700 Stove Stand
34
1
2

10
Accessories
The following accessories are available:
•Grill – Nonstick Cast Aluminum
R9941A315C
•Griddle – Nonstick Cast Aluminum
R9941A317C
•Carry Case (soft)
R9941-100C
•Stove Grate
R9941-319C
•5 ft. High Pressure Hose &
Adapter (connects appliance to
refillable propane cylinder)
5470-7931