Coleman 5461 SERIES User manual

IMPORTANT
Read these instructions for use carefully. Familiarise yourself with the
appliance before connecting it to a gas cylinder. Keep these instructions
for future reference. This instruction manual contains important information
necessary for the proper assembly and safe use of the appliance. Follow all
warnings and instructions when using the appliance. If you have questions
about assembly, operation, servicing or repair of this product, please call
Coleman on 1800 224 350. Coleman Brands Pty Ltd. Suite W2C1, 75-85
O’Riordan St, Alexandria, NSW 2015.
Gas cylinders shall be changed in a well-ventilated location, preferably
outside away from people and any sources of ignition, such as naked
ames, pilot ames, electric heaters / equipment. If there is a leak on
your appliance (smell of gas) and you cannot stop the gas ow, remove
the appliance to a well-ventilated location away from any ignition source.
Check for leaks using soapy water. Do not try to detect leaks using a
ame. This appliance must only be serviced by an authorised person. Gas
cylinders must be stored outdoors in a well ventilated area out of the reach
of children, any indoor storage shall comply with AS/NZS 1596.
This appliance shall only be used with Propane LPG Coleman disposable
gas cylinders certied to DOT-39 NRC 232/290 M1110. OR rellable
Propane LPG cylinder certied to AS2030 & Coleman hose assembly.
IT MAY BE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES OF GAS
CONTAINERS.
CAUTION: accessible parts may be very hot. Keep young children away,
USE OUTDOORS ONLY. Must only be operated on a horizontal surface.
Not suitable for marine environments. Do not modify this appliance.
Note: Propane tank is not included. Griddle is optional.
Propane Stoves
Instructions for use
© 2014 The Coleman Company, Inc
colemanaustralia.com.au
INSTASTART™ Electronic Ignition
Standard Ignition
5461 Series
* Model may vary from
picture.

1
If you smell gas:
1. Do not attempt to
light appliance.
2. Extinguish any
open flame.
3. Disconnect from
fuel supply.
FOR YOUR
SAFETY
Do not store or
use gasoline or
other liquids with
flammable vapors in
the vicinity of this or
any other appliance.
FOR YOUR
SAFETY
DANGER indicates an imminently
hazardous situation which, if not
avoided, will result in death or
serious injury.
DANGER
WARNING indicates a potentially
hazardous situation which, if not
avoided, could result in death or
serious injury.
WARNING
CAUTION indicates a potentially
hazardous situation which, if
not avoided, may result in minor
or moderate personal injury, or
property damage.
CAUTION
CARBON MONOXIDE
HAZARD
•ONLY USE IN WELL-
VENTILATED AREAS.
•CARBON
MONOXIDE
HAZARD—USING
THIS APPLIANCE
IN AN ENCLOSED
SPACE MAY CAUSE
DEATH.
•DO NOT USE IN
CARAVANS, TENTS,
MARINE CRAFT,
CARS, MOBILE
HOMES OR SIMILAR
LOCATIONS.
DANGER
This manual contains important
information about the assembly, operation
and maintenance of this outdoor propane
appliance. General safety information is
presented on this page and is also located
throughout these instructions. Particular
attention should be paid to information
accompanied by the safety alert symbol
“ DANGER”, “ WARNING”,
“ CAUTION”.
Keep this manual for future reference and
to educate new users of this product. This
manual should be read in conjunction with
the labeling on the product.
Safety precautions are essential
when any mechanical or propane fueled
equipment is involved. These precautions
are necessary when using, storing, and
servicing. Using this equipment with the
respect and caution demanded will reduce
the possibilities of personal injury or
property damage.
The following symbols shown
below are used extensively throughout
these instructions. Always heed these
precautions, as they are essential when
using any mechanical or propane
fueled equipment.

2
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and by products
of combustion of this fuel, contain
chemicals known to the state of
California to cause cancer, birth defects,
or other reproductive harm.
• Failure to comply with the
precautions and instructions
provided with these stoves can
result in death, serious bodily
injury and property loss or damage
from hazards of fire, explosion,
burn, asphyxiation, and/or carbon
monoxide poisoning.
• Only persons who can understand
and follow the instructions should
use or service these stoves.
• If you need assistance or information
such as an instruction manual
or labels, contact The Coleman
Company, Inc.
DANGER
• This product is fueled by propane
gas. Propane gas is invisible,
odorless, and flammable. An odorant
is normally added to help detect
leaks and can be described as a
“rotten egg” smell. The odorant can
fade over time so leaking gas is not
always detectable by smell alone.
• Propane gas is heavier than air and
leaking propane will sink to the
lowest level possible. It can ignite by
ignition sources including matches,
lighters, sparks or open flames of
any kind many feet away from the
original leak. Use only propane gas
set up for vapor withdrawal.
• Propane gas should be stored
or used in compliance with local
ordinances and codes or with ANSI/
NFPA 58. Turn off propane when not
in use.
WARNING
EXPLOSION - FIRE HAZARD
• Never store propane near high heat,
open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed
120 ºF (49 °C).
• Propane is heavier than air and can
accumulate in low places. If you
smell gas, leave the
area immediately.
• Never install or remove propane
tank while outdoor stove is lighted,
near flame, pilot lights, other ignition
sources or while outdoor stove is hot
to touch.
• During lighting and operation, this
product can be a source of ignition.
Never use the stove in spaces that
contain or may contain volatile or
airborne combustibles, or products
such as gasoline, solvents, paint
thinner, dust particles or
unknown chemicals.
• Minimum clearances from
combustible materials: 12 inches
from the sides and 48 inches from
the top.
• Provide adequate clearances around
air openings into the
combustion chamber.
DANGER
CARBON MONOXIDE HAZARD
• This stove is a combustion
appliance. All combustion appliances
produce carbon monoxide (CO)
during the combustion process.
This product is designed to produce
extremely minute, non-hazardous
amounts of CO if used and
maintained in accordance with all
warnings and instructions. Do not
block air flow into or out of the stove.
• Carbon Monoxide (CO) poisoning
produces flu-like symptoms, watery
eyes, headaches, dizziness, fatigue
and possibly death. You can’t see it
and you can’t smell it. It’s an invisible
killer. If these symptoms are present
during operation of this product get
fresh air immediately!
• For outdoor use only.
• Never use inside house, camper,
tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and
produces carbon monoxide
(CO). Do not use in unventilated
or enclosed areas to avoid
endangering your life.
DANGER

3
SERVICE SAFETY
• Keep all connections and fittings
clean. Inspect propane cylinder
and stove propane connections for
damage before attaching.
• During set up, check all connections
and fittings for leaks using soapy
water. Never use a flame. Bubbles
indicate a leak. Check that the
connection is not cross-threaded
and that it is tight. Perform another
leak check. If there is still a leak,
remove the cylinder and contact
Coleman for service or repairs.
• Use as a cooking appliance only.
Never alter in any way or use with
any device or part not expressly
approved by Coleman.
• Clean stove and stove griddle (if
equipped) frequently to avoid grease
accumulation and possible grease fires.
CAUTION
BURN HAZARD
• Never leave stove unattended when
hot or in use.
• Keep out of reach of children.
WARNING
CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper,
tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and produces
carbon monoxide (CO). Do not use
in unventilated or enclosed areas to
avoid endangering your life.
DANGER
Technical
Characteristics
To Set Up
Not for home or
recreational vehicle use.
We cannot foresee every use which
may be made of our products. Check
with your local fire safety authority
if you have questions about use.
Other standards govern the use of fuel
gases and heat producing products
for specific uses. Your local authorities
can advise you about these.
• Never refill disposable cylinders.
• Use the preset regulator that came
with the stove. Do not attempt
to adjust.
• Use only Coleman®accessories or
parts. During stove set-up, check all
fittings for leaks using soapy water.
Never use a flame.
WARNING
NOTE: Use Coleman®16.4 oz.
disposable propane cylinders. The
LP-gas cylinder(s) used with stoves
must be constructed and marked in
accordance with the specications for
LP-gas cylinders of the U.S. Department
of Transportation or Transport Canada,
CAN/CSA B339.
Open lid. (Fig. 2) Position wind
guards as desired.
(Fig. 3)
Remove components from carton.
(Fig. 1)
Input: 11.6 MJ/h per burner
Category: Pressure regulated propane
Fuel: 16.4 oz. disposable propane cylinders
Regulator: 5430
Injector size: 0.40mm
Fig. 3
Fig. 1
Fig. 2
Install pot
support as
shown. (Fig. 4)
Fig. 4
Pot Support
Regulator
Hose
Griddle
(optional)
Place griddle on
pot support, if
equipped. (Fig. 5)
NOTE: The griddle is
optional.
Fig. 5

4
SERVICE SAFETY
• Keep all connections and fittings
clean. Inspect propane cylinder
and stove propane connections for
damage before attaching.
• During set up, check all connections
and fittings for leaks using soapy
water. Bubbles indicate a leak. Never
use a flame.
CAUTION
Check that all seals between the appliance
and the gas cylinder are in place and in good
condition before connecting the gas cartridge.
Remove all transit protection material.
DO NOT move the appliance during operation.
After use, turn the gas cylinder valve off, wait
for the flame to go out, then turn the appliance
control valve(s) off.
Flexible gas hose maximum length is 1.5
meters, avoid twisting or kinking the flexible
hose.
To Light
Leak Check
BURN HAZARD
• Never leave stove unattended when
hot or in use.
• Keep out of reach of children.
WARNING
Standard Ignition Stove
Set on sturdy,
at surface. For
outdoor use only.
Hold lighted
match near
burner and
open burner
valve. (Fig. 11
and Fig. 12)
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor stove until
connection has been leak tested and
does not leak.
WARNING
EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can
accumulate in low places. If you
smell gas, leave the
area immediately.
• Always attach or detach propane
source outdoors; never while stove is
lighted, near flame, pilot lights, other
ignition sources or while stove is hot
to touch.
• This stove is very hot during use
and can ignite flammables too close
to the burners. Keep flammables at
least 12 inches from the sides and
48 inches from the top of the stove.
Keep gasoline and other flammable
liquids and vapors well away
from stove.
• The stove must not be exposed to
flammable vapors or liquids
during lighting.
DANGER
Push and screw regulator into stove
hand tight. (Fig. 7)
Remove plastic cap from top of
propane bottle and screw propane
bottle into regulator hand tight. (Fig. 8)
Propane cylinder correctly installed.
(Fig. 9)
Use hose to connect Propane bottle
and regulator if necessary.
(Fig. 9-1)
Never operate
stove with
propane cylinder
in an inverted
position. (Fig. 10)
Close both
burner
valves rmly.
(Fig. 6)
Fig. 6
Fig. 8
Fig. 11
Fig. 12
Fig. 10
Fig. 7
Fig. 9 Fig. 9-1

5
To Turn Off
To Clean
Make sure stove and griddle (if equipped)
are cool. Move stove away from ame
(including pilot lights) and other
ignition sources.
Remove propane cylinder from
regulator and replace protective cap
on cylinder. (Fig. 17)
Remove regulator from stove. (Fig. 18)
MAINTENANCE
• Keep stove area clear and free from
combustible materials, gasoline and
other flammable vapors and liquids.
• Do not obstruct the flow of
combustion and ventilation air.
• A good flame should be blue with
minimal yellow tip. Some yellow tips
on flames are acceptable as long as
no carbon or soot deposits appear.
• Wipe stove and stove griddle (if
equipped) clean with a soft cloth
and mild dish detergent. Do not use
abrasives. (Fig. 21)
To check if the gas cylinder is
empty, disconnect the cylinder
from the appliance and shake
from side to side. If there is no
sound or movement of liquid, the
cylinder is empty.
Annual service by an authorised
person is recommended. Or if
any of the following conditions
are noticed; incomplete ignition,
appreciable yellow tipping, carbon
deposition, lifting, floating, lighting
back or objectionable odor.
DO NOT use this appliance if
it has damaged or worn seals.
DO NOT use this appliance if it
is leaking, damaged or does not
operate properly.
Lift off
griddle and
pot support.
(Fig. 19 and
Fig. 20)
NOTE: The
griddle is
optional.
INSTASTART™
Electronic Ignition Stove
Set on sturdy,
at surface. For
outdoor
use only.
Open burner
valve and
repeatedly
push igniter
button until
burner
lights.
(Fig. 13 and
Fig. 14)
NOTE: If igniter
fails to light
stove, use
match to light
burner. If the
stove is wet the igniter may not spark.
Adjust ame
with burner
valve.
(Fig. 15)
Flame
should be
blue with
a hint of
yellow
on tips.
Close both
burner
valves rmly.
(Fig. 16)
Fig. 21
Fig. 13
Fig. 14
Fig. 15
Fig. 16
Fig. 18Fig. 17
Fig. 19
Fig. 20

6
Things You Should
Know
1. It is unsafe and illegal in some places
to store or use propane cylinders of
greater than 1.14 kg (2.5 lbs.) water
capacity (approximately 1 lb. propane)
in occupied enclosures.
2. The usual storage areas for camping
and picnic equipment are the
basement, attic, or garage. To avoid
the accumulation of dust, cobwebs,
etc., that is common in these storage
areas, place your stove in a plastic bag
and seal it with a rubber band.
3. If not completely satised with the
performance of this product, please
call one of the numbers listed on the
cover of this manual.
colemanaustralia.com.au
To Store
EXPLOSION - FIRE HAZARD
• Never store propane near high heat,
open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed 120 ºF
(49 °C).
• The cylinder must be disconnected
when the stove is in storage.
DANGER
Locate the
pot support
above the
griddle.
(Fig. 25)
Align and
place the
left and right
tabs on
bottom of
griddle into
the holes on
cook top.
(Fig. 23 and
Fig. 24)
NOTE: The
griddle is
optional.
For storage
or transport,
the regulator
may be
deposited
on cook top
directly as
shown in
Fig. 22.
Fig. 22
Fig. 24
Fig. 25
To carry the
stove, rmly
grasp the stove
by the hand
opening located
on the bottom.
(Fig. 26)
Fig. 26
Fig. 23

7
LIMITED ONE YEAR WARRANTY
EXPRESS
EXPRESS WARRANTY
Coleman Brands Pty. Ltd. (“Coleman”) warrants that for a period of one (1) year
from the date of original retail purchase, this product will be free from defects in
material and workmanship. Coleman will, depending on the circumstances, refund,
repair or replace this product or any component of the product found to be defective
during the warranty period. Replacement will be made with a new or remanufactured
product or component. If the product is no longer available, replacement may be
made with a similar product of equal or greater value. To the extent permitted by
law and subject to your non-excludable rights under the Australian Consumer Law
(Schedule 2 to the Competition and Consumer Act 2010 (Cth)) and the New Zealand
Consumer Guarantees Act, which are not limited to a one (1) year period, this is
your exclusive remedy for any breach of this limited warranty or for any other claims
otherwise relating to this limited warranty.
In Australia, our goods come with guarantees that cannot be excluded under the
Australian Consumer Law. You are entitled to a replacement or refund for a major
failure and compensation for any other reasonably foreseeable loss or damage. You
are also entitled to have the goods repaired or replaced if the goods fail to be of
acceptable quality and the failure does not amount to a major failure. The benefits
provided under this warranty are in addition to and do not affect purchaser’s statutory
rights under the Australian Consumer Law or other rights at law.
This warranty is valid for the original retail purchaser from the date of initial retail
purchase and is not transferable. Please keep your proof of purchase documentation,
such as the original sales receipt or the relevant credit card statement. Proof of
purchase is required to obtain warranty performance. Coleman dealers, Coleman
service centres, or retail stores selling Coleman®products do not have the right to
alter, modify or in any way change the terms and conditions of this warranty. The
warranty is valid only for products that are purchased new and unused in Australia
and New Zealand, from Coleman or Coleman dealers or retailers.
WARRANTY EXCLUSIONS AND LIMITATIONS
THE AUSTRALIAN CONSUMER LAW PROVIDES CONSUMERS WITH CERTAIN
‘CONSUMER GUARANTEES’. THESE GUARANTEES APPLY WHERE THE GOODS
AND SERVICES COLEMAN SUPPLIES TO YOU ARE OF A KIND ORDINARILY
ACQUIRED FOR PERSONAL, DOMESTIC OR HOUSEHOLD USE OR COST LESS
THAN $40,000, AND IN THE CASE OF GOODS, ARE NOT RE-SUPPLIED BY YOU.
NOTHING IN THIS LIMITED WARRANTY EXCLUDES, RESTRICTS OR MODIFIES
RIGHTS WHICH YOU HAVE UNDER THE AUSTRALIAN CONSUMER LAW IN
RESPECT OF THE CONSUMER GUARANTEES AND ALL OF THE PROVISIONS IN
THIS SECTION ARE TO BE READ SUBJECT TO THE AUSTRALIAN CONSUMER
LAW.
This warranty does not cover: (a)normal wear of the product and/or its parts; (b)
parts that are not genuine Coleman®parts, consumables, lost parts and accessories;
(c) damage resulting from any of the following: negligent use or misuse of the
product, commercial use of the product, use contrary to the operating instructions;
disassembly, repair or alteration by anyone other than Coleman or Coleman
service centre, the use of a part other than a genuine Coleman®part; or (d) acts of
God, such as fire, flood, hurricanes and tornadoes.
To the extent permitted by the Australian Consumer Law, the Competition and
Consumer Regulation 2010 and the New Zealand Consumer Guarantees Act,
Coleman’s liability is limited, depending on the circumstances, to refund, replacement
or repair of Coleman®products or components.
For the avoidance of doubt, any and all other warranties or conditions which are
not guaranteed by the Australian Consumer Law, the Competition and Consumer
Regulation 2010 and the New Zealand Consumer Guarantees Act and which are
not expressly included in this warranty as additional warranties or conditions are
expressly excluded, including liability for incidental or consequential damages caused
by the breach of any express or implied warranty or condition.
Warranty

8
MAKING A WARRANTY CLAIM - RETURN TO COLEMAN FOR REPAIR
Take the product to an authorised Coleman retailer or Coleman service centre as
soon as the warranty claim arises. You may locate the nearest authorised Coleman
retailer or Coleman service centre by visiting www.colemanaustralia.com.au or
calling 1800 224 350 or + 61 2 8762 5000. Please ensure that you provide a written
description of the problem with the product, together with your contact name,
address and telephone number and proof of purchase.
Subject to the applicable consumer laws in your jurisdiction, you must pay for the
costs of transporting the product, including packaging, freight and insurance costs, to
an authorised Coleman retailer or Coleman service centre for warranty service. If the
warranty claim is substantiated and accepted by Coleman, Coleman will at its cost,
repair or replace any product or parts and return the product to you. Additionally,
if the warranty claim is substantiated and accepted by Coleman, Coleman will
reimburse you for the costs of transporting the product to an authorized Coleman
retailer or Coleman service centre. Coleman reserves the right to seek reimbursement
for any costs and expenses incurred for a warranty claim if the product is found to be
in good working order.
If you have any questions regarding this warranty please call 1800 224 350 or + 61 2
8762 5000.
Coleman Brands Pty. Ltd.
ABN 74 091 681 195
Suite W2C1, 75-85 O’Riordan Street,
Sydney Corporate Park, Alexandria, NSW 2015
Australia
Telephone: [phone] or + 61 2 8762 5000
Email: [email protected]
www.colemanaustralia.com.au

9
Note:

10
Note:

Coleman Brands Pty. Ltd.
ABN 74 091 681 195
Suite W2C1, 75-85 O’Riordan Street,
Sydney Corporate Park, Alexandria, NSW 2015
Australia
Telephone: [phone] or + 61 2 8762 5000
colemanaustralia.com.au
© 2014 The Coleman Company, Inc.
All rights reserved. Made in China.
4010035392 (ECN20040918-02)