Columbia Products SANI-LAV ES2-503L User manual

1
AC OR BATTERY POWERED
SINKS WITH ELECTRONIC SENSORS
Columbia does not recommend use with harsh chemicals.
NSF/ANSI Standard 2 - Food Equipment and NSF/ANSI 372 low-lead.
Operating Manual for Hands-Free Floor Mounted Sinks
AC Models ES2-503L and ES2-503L-0.5
Battery Models ESB2-503L and ESB2-503L-0.5

2
SINKS WITH ELECTRONIC SENSORS
AC OR BATTERY POWERED
1622 Browning Irvine, CA 92606-4809 Phone: [phone] Toll Free: 800.626.2117 Fax: [phone] www.columbiasinks.com email: [e-mail]
©2019 Columbia Products
COLUMBIA SPECIFICATIONS
Tools Required
Tape Measure
Adjustable Wrench
Drill Motor and Drill Bits
Pipe Wrench
Level
Safety Glasses
Screw Drivers: 1 Phillips & 1 Standard
Pencil
Socket Wrench
Installation Instructions
Step 1
1. Establish sink location on the wall.
2. Measure a recommended 41.5” from finished floor and draw a level line which will be the top
edge of the wall mounting bracket.
3. Hold the wall mounting bracket against the wall and mark the wall where the holes are. Drill
holes and secure bracket to the wall as shown in illustration A. Screws are not provided.
Step 2
1. Install faucet assembly to the sink following the instructions provided with sensor unit.
2. Install strainer assembly.
3. Install mixing check valve to inlet filter on faucet.
Step 3
1. Position the sink onto wall bracket.
2. Mark holes for fastening side mounting brackets as shown in illustration B.
3. Remove sink from the wall bracket.
4. Drill holes in wall for securing sink to wall.
5. Hang sink on the wall bracket and secure to the wall.
Step 4
1. Connect waste line or drain pipe to strainer assembly.
2. Connect hot and cold water from the source to the mixing check valve.
3. Remove aerator from the spout assembly and flush water system.
4. Check connections for leaks.
5. Replace aerator onto the spout.
Parts List
(1) Sink bowl
(1) Pedestal base
(1) Set of 6 mounting nuts to attach bowl to pedestal base
(1) AC or battery powered sensor faucet assembly
(1) Strainer assembly with basket
(1) Mixing check valve
WARNING: This product can expose you to chemicals including Chromium (hexavalent compounds),
Lead, and Phthalates (DEHP) which are known to the State of California to cause cancer and birth defects
or other reproductive harm. For more information go to www.P65Warnings.ca.gov.
NOTE: Lead content originates from Brass components in valves and faucets and is certied under
NSF/ANSI 372 as containing less than 0.25% lead in wetted surfaces.
Notice for California Consumers
Illustration A
Illustration B

3
SINKS WITH ELECTRONIC SENSORS
AC OR BATTERY POWERED
1622 Browning Irvine, CA 92606-4809 Phone: [phone] Toll Free: 800.626.2117 Fax: [phone] www.columbiasinks.com email: [e-mail]
©2019 Columbia Products
COLUMBIA SPECIFICATIONS
16.5”
(419mm)
21”
(533mm)
501 ES2-ESB2
19” (483mm)
17” (432mm)
2” drain hole
9.5”
(241mm)
7”
(197mm)
25” (635mm)
1.25” R
32mm
Hole Configuration
Front Side
Top
5.5” (140 mm)
18”
(457mm)
14”
(356mm)
2” (51mm)
9.5”
(241mm) 9.5” (241mm)
6” (152mm)
9.5” (241mm)
.875” (22mm)
dia. key hole
7.5” (191mm)
45º
6” (152.4mm)
0.875” (22.225mm)
11.375” (288.925mm) 4.25” (107.95mm)
Floor Mounting Detail
.375” dia. Floor
Mounting Holes
4.25” on Center