Compex WLM54AG Manual

WLM54AG_1B.log
**********************************
invalid calibration data in EEPROM
**********************************
Loading values for devNum [0] from eep file ar5006xs_mb62ag.eep
Operating in 11a at channel 5.220GHz
=============================================
| UNKNOWN BOARD |
=============================================
Devlib Revision 5.2 BUILD #58 Mainline
Devices detected:
PCI deviceID : 0xff16 Sub systemID : 0xffff
MAC revisionID: 0xa5 BB revisionID: 0x61
RF productID : 0x6 RF revisionID: 0x3
Using defaults from //depot/sw/branches/ART_525/bringup/ar5k/config/eagle2_0.cfg#1
Base Addr: 0xFFEE0000 Interrupt: 17
Wireless MAC ADDR: 0xFFFF_FFFF_FFFF
Reading in Calibration Setup from calsetup.txt
Reading in Target Powers and CTL Info from calTrgtPwr_ar5006xs_mb62ag.txt
=======================================
Plug in DUT (Device Under Test)
Press any key to start or <ESC> to quit
=======================================
=======================================
Waiting for other test set to finish
=======================================
Setting up Power Meter
Setting up Spectrum Analyzer
Setting up Attenuator
using cal fixed gain for mode 11a from calsetup.txt ... FG6
using cal fixed gain for mode 11b from calsetup.txt ... FG6
using cal fixed gain for mode 11g from calsetup.txt ... FG6
Manufacturing Test start ...
Collecting raw data for the adapter for mode 11a
ch: 5180 --> max pwr is 22.70 dBm
ch: 5320 --> max pwr is 24.10 dBm
ch: 5600 --> max pwr is 22.37 dBm
ch: 5745 --> max pwr is 21.17 dBm
ch: 5825 --> max pwr is 20.01 dBm
Collecting raw data for the adapter for mode 11g
Page 1

WLM54AG_1B.log
ch: 2412 --> max pwr is 23.35 dBm
ch: 2442 --> max pwr is 23.29 dBm
ch: 2472 --> max pwr is 22.44 dBm
Collecting raw data for the adapter for mode 11b
ch: 2412 --> max pwr is 24.18 dBm
ch: 2442 --> max pwr is 24.03 dBm
ch: 2472 --> max pwr is 23.42 dBm
Start Target Power Control Test in 11a mode
FREQ 6Mbps 36Mbps 48Mbps 54Mbps Limits:+1.0/-1.5 dB
measured/target
5180 17.4/18.0 16.8/17.0 15.9/16.0 12.7/13.0
5260 17.0/18.0 16.0/17.0 15.4/16.0 12.1/13.0
5600 17.7/18.0 16.4/17.0 15.4/16.0 12.6/13.0
5825 17.8/18.0 16.6/17.0 15.7/16.0 12.7/13.0
Start TX EVM Test in 11a mode
5180 MHz 54 Mbps EVM: -28.31 -4.52 ppm Pwr 12.8 dB
5320 MHz 54 Mbps EVM: -28.58 -4.54 ppm Pwr 12.7 dB
5600 MHz 54 Mbps EVM: -29.34 -4.56 ppm Pwr 12.6 dB
5745 MHz 54 Mbps EVM: -29.91 -4.52 ppm Pwr 12.4 dB
5825 MHz 54 Mbps EVM: -29.11 -4.53 ppm Pwr 13.1 dB
Start RX PER Test in 11a mode
5180 MHz 54 Mbps @ -68.0 dBm SEN 99.0 (24) [ 1] [99]
5320 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (28) [ 0] [100]
5600 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (30) [ 0] [100]
5745 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (31) [ 0] [100]
5825 MHz 54 Mbps @ -68.0 dBm SEN 99.0 (31) [ 1] [99]
Start Target Power Control Test in 11g mode
FREQ 6Mbps 36Mbps 48Mbps 54Mbps Limits:+1.0/-1.5 dB
measured/target
2422 19.7/20.0 17.7/18.0 16.8/17.0 15.7/15.0
2452 19.7/20.0 17.8/18.0 16.9/17.0 15.5/15.0
2467 20.1/20.0 18.2/18.0 17.3/17.0 15.8/15.0
Start TX EVM Test in 11g mode
2412 MHz 54 Mbps EVM: -32.18 -4.61 ppm Pwr 15.5 dB
2442 MHz 54 Mbps EVM: -32.87 -4.61 ppm Pwr 15.9 dB
2472 MHz 54 Mbps EVM: -32.66 -4.60 ppm Pwr 15.3 dB
Start RX PER Test in 11g mode
2412 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (29) [ 0] [100]
2442 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (29) [ 0] [100]
2472 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (29) [ 0] [100]
Start Target Power Control Test in 11b mode
FREQ 1Mbps 5.5Mbps(S) 11Mbps(L) 11Mbps(S) Limits:+1.0/-1.5 dB
measured/target
2412 19.7/20.0 19.7/20.0 19.8/20.0 19.8/20.0
Page 2

WLM54AG_1B.log
2442 20.1/20.0 19.7/20.0 19.7/20.0 19.7/20.0
2472 19.9/20.0 20.0/20.0 20.0/20.0 20.0/20.0
Start Spectral Mask Test for mode 11b
spec mask - chan:2412 No. Bad Points: 0
spec mask - chan:2442 No. Bad Points: 0
spec mask - chan:2472 No. Bad Points: 0
Start TX EVM Test in 11b mode
2412 MHz 11 Mbps EVM: -24.76 -4.59 ppm Pwr 19.8 dB
2442 MHz 11 Mbps EVM: -24.67 -4.69 ppm Pwr 20.2 dB
2472 MHz 11 Mbps EVM: -24.11 -4.65 ppm Pwr 19.8 dB
Start RX PER Test in 11b mode
2412 MHz 11 Mbps @ -68.0 dBm SEN 100.0 (31) [ 0] [100]
2442 MHz 11 Mbps @ -68.0 dBm SEN 100.0 (31) [ 0] [100]
2472 MHz 11 Mbps @ -68.0 dBm SEN 100.0 (31) [ 0] [100]
Timing Report ...
time taken for instrument setup = 0.2
time taken for 11a cal = 6.7
time taken for 11g cal = 4.8
time taken for 11b cal = 5.0
time taken for program eeprom = 4.6
time taken for 11a target pwr ctl = 2.9
time taken for 11a PER and RXSEN = 7.2
time taken for 11g target pwr ctl = 2.8
time taken for 11g PER and RXSEN = 4.4
time taken for 11b target pwr ctl = 3.0
time taken for 11b spectral mask = 3.6
time taken for 11b PER and RXSEN = 9.3
time taken for other things = 4.7
Total test time = 59.2 s [1.0 min]
Wrote MAC address: 0080:483C:6060
###########################################################################
Cal Date: 2005/11/05, Cal Time: 14:02, Cal SSID: 0x2062, Cal Result: PASS
Cal wlan mac ID: 0080:483C:6060
######## ### ###### ######
## ## ## ## ## ## ## ##
## ## ## ## ## ##
######## ## ## ###### ######
## ######### ## ##
## ## ## ## ## ## ##
## ## ## ###### ######
Page 3

WLM54AG_1B.log
###########################################################################
==============================================
Test complete. Replace DUT (Device Under Test)
Press any key to start or <ESC> to quit
==============================================
.......... WMAC function
Attached to the Device for instance = 1
Loading values for devNum [0] from eep file ar5006xs_mb62ag.eep
=======================================
Waiting for other test set to finish
=======================================
Setting up Power Meter
Setting up Spectrum Analyzer
Setting up Attenuator
using cal fixed gain for mode 11a from calsetup.txt ... FG6
using cal fixed gain for mode 11b from calsetup.txt ... FG6
using cal fixed gain for mode 11g from calsetup.txt ... FG6
Manufacturing Test start ...
Collecting raw data for the adapter for mode 11a
ch: 5180 --> max pwr is 23.42 dBm
ch: 5320 --> max pwr is 24.16 dBm
ch: 5600 --> max pwr is 22.29 dBm
ch: 5745 --> max pwr is 21.20 dBm
ch: 5825 --> max pwr is 20.39 dBm
Collecting raw data for the adapter for mode 11g
ch: 2412 --> max pwr is 23.85 dBm
ch: 2442 --> max pwr is 23.57 dBm
ch: 2472 --> max pwr is 23.08 dBm
Collecting raw data for the adapter for mode 11b
ch: 2412 --> max pwr is 24.66 dBm
ch: 2442 --> max pwr is 23.70 dBm
ch: 2472 --> max pwr is 24.06 dBm
Start Target Power Control Test in 11a mode
FREQ 6Mbps 36Mbps 48Mbps 54Mbps Limits:+1.0/-1.5 dB
measured/target
5180 17.6/18.0 16.7/17.0 15.6/16.0 12.3/13.0
5260 17.5/18.0 16.3/17.0 15.0/16.0 12.1/13.0
5600 17.9/18.0 16.7/17.0 15.2/16.0 12.1/13.0
5825 17.5/18.0 16.9/17.0 15.4/16.0 12.7/13.0
Start TX EVM Test in 11a mode
5180 MHz 54 Mbps EVM: -28.97 -5.25 ppm Pwr 12.0 dB
5320 MHz 54 Mbps EVM: -29.81 -5.25 ppm Pwr 12.0 dB
Page 4

WLM54AG_1B.log
5600 MHz 54 Mbps EVM: -28.84 -5.26 ppm Pwr 12.0 dB
5745 MHz 54 Mbps EVM: -28.90 -5.24 ppm Pwr 12.8 dB
5825 MHz 54 Mbps EVM: -29.99 -5.24 ppm Pwr 12.6 dB
Start RX PER Test in 11a mode
5180 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (28) [ 0] [100]
5320 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (26) [ 0] [100]
5600 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (30) [ 0] [100]
5745 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (31) [ 0] [100]
5825 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (30) [ 0] [100]
Start Target Power Control Test in 11g mode
FREQ 6Mbps 36Mbps 48Mbps 54Mbps Limits:+1.0/-1.5 dB
measured/target
2422 19.8/20.0 17.8/18.0 16.8/17.0 15.4/15.0
2452 19.8/20.0 18.0/18.0 17.2/17.0 15.6/15.0
2467 19.9/20.0 17.7/18.0 16.7/17.0 15.9/15.0
Start TX EVM Test in 11g mode
2412 MHz 54 Mbps EVM: -34.07 -5.25 ppm Pwr 15.4 dB
2442 MHz 54 Mbps EVM: -33.34 -5.27 ppm Pwr 15.1 dB
2472 MHz 54 Mbps EVM: -30.69 -5.24 ppm Pwr 15.8 dB
Start RX PER Test in 11g mode
2412 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (29) [ 0] [100]
2442 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (29) [ 0] [100]
2472 MHz 54 Mbps @ -68.0 dBm SEN 100.0 (28) [ 0] [100]
Start Target Power Control Test in 11b mode
FREQ 1Mbps 5.5Mbps(S) 11Mbps(L) 11Mbps(S) Limits:+1.0/-1.5 dB
measured/target
2412 19.9/20.0 20.0/20.0 19.9/20.0 19.9/20.0
2442 19.9/20.0 19.9/20.0 19.9/20.0 19.9/20.0
2472 19.7/20.0 19.8/20.0 19.8/20.0 19.8/20.0
Start Spectral Mask Test for mode 11b
spec mask - chan:2412 No. Bad Points: 0
spec mask - chan:2442 No. Bad Points: 0
spec mask - chan:2472 No. Bad Points: 0
Start TX EVM Test in 11b mode
2412 MHz 11 Mbps EVM: -24.52 -5.22 ppm Pwr 19.9 dB
2442 MHz 11 Mbps EVM: -24.42 -5.21 ppm Pwr 19.9 dB
2472 MHz 11 Mbps EVM: -23.91 -5.07 ppm Pwr 19.6 dB
Start RX PER Test in 11b mode
2412 MHz 11 Mbps @ -68.0 dBm SEN 100.0 (31) [ 0] [100]
2442 MHz 11 Mbps @ -68.0 dBm SEN 100.0 (30) [ 0] [100]
2472 MHz 11 Mbps @ -68.0 dBm SEN 100.0 (30) [ 0] [100]
Page 5

WLM54AG_1B.log
Timing Report ...
time taken for instrument setup = 0.0
time taken for 11a cal = 6.6
time taken for 11g cal = 4.5
time taken for 11b cal = 4.6
time taken for program eeprom = 4.6
time taken for 11a target pwr ctl = 3.0
time taken for 11a PER and RXSEN = 6.9
time taken for 11g target pwr ctl = 2.7
time taken for 11g PER and RXSEN = 5.0
time taken for 11b target pwr ctl = 3.3
time taken for 11b spectral mask = 3.6
time taken for 11b PER and RXSEN = 8.9
time taken for other things = 6.0
Total test time = 59.8 s [1.0 min]
Wrote MAC address: 0080:483C:6061
###########################################################################
Cal Date: 2005/11/05, Cal Time: 14:04, Cal SSID: 0x2062, Cal Result: PASS
Cal wlan mac ID: 0080:483C:6061
######## ### ###### ######
## ## ## ## ## ## ## ##
## ## ## ## ## ##
######## ## ## ###### ######
## ######### ## ##
## ## ## ## ## ## ##
## ## ## ###### ######
###########################################################################
Page 6