Cruisers Yachts 430 Sports Coupe User manual

V2570100 (Rev. 0) 430 Sports Coupe
430 Sports Coupe
Table of Contents
1. Introduction........................................................................................................ 1-1
2. Model Specific Information............................................................................... 2-1
3. Controls and Indicators .................................................................................... 3-1
4. Basic Systems Operation ................................................................................. 4-1
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

430 Sports Coupe
430 Sports Coupe
This Page Intentionally Left Blank
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

1-1 430 Sports Coupe
Section 1
Introduction
Welcome Aboard!! ........................................................ 1-2
Skipper’s Kit .................................................................. 1-2
Owner’s Manual ................................................................. 1-2
Safety Symbols .................................................................. 1-3
Safety................................................................................. 1-3
Owner’s Manuals for Onboard Systems and
Components.................................................................... 1-4
Warranty Information ................................................... 1-5
Dealership Responsibilities ................................................ 1-5
Your Responsibilities ......................................................... 1-5
Warranty Service ............................................................... 1-5
Safety Label Locations ................................................. 1-6
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 1
1-2
430 Sports Coupe
WELCOME ABOARD!!
Welcome to the Cruisers Yachts family of happy yacht owners.
We wish to thank you for making our 430 Sports Coupe your
recreational choice for boating enjoyment. Extensive design and
engineering research went into the development of all Cruisers
Yachts. We feel there is a beautiful balance between structural
integrity and creature comforts.
Your yacht was manufactured by trained craftsmen in the tradition of
meeting or exceeding existing safety and quality standards
established by the United States Coast Guard and the Boating
Industry of America.
Cruisers Yachts has been manufacturing boats for over 50 years. We
take pride in our craftsmanship and hull performance. We are
confident you will enjoy the ride. For you, the Cruisers Yachts name
is your assurance that your yacht will hold its value while providing
many years of boating pleasure. We have made a commitment to this
industry and are glad to have you as a partner.
Congratulations on your choice – let us know if we can be of further
service.
SKIPPER’S KIT
The Skipper’s Kit contains the 430 Sports Coupe owner’s manual.
Also included is information about onboard systems and components
furnished by suppliers other than Cruisers Yachts.
Owner’s Manual
The owner’s manual contains specific information concerning the
operation of the 430 Sports Coupe. The descriptions contained
within this manual will introduce you to features of the 430 Sports
Coupe, and provide you with a general knowledge of how the
equipment works. This manual is divided into several sections, and
each section is introduced by a table of contents to help you quickly
find needed information.
The Getting Started owner’s manual contains additional general
information concerning operation and the necessary information for
boating safely and care of your yacht. The Getting Started manual is
also divided in the same manner as the owner’s manual to help you
quickly find needed information. Become familiar with the material in
each section of both manuals. Always keep both manuals together
and with your yacht for future use, and for anyone who may operate
your yacht. The following are the topics found in the Getting Started
manual:
INTRODUCTION
BOATING SAFETY
CONTROLS AND INDICATORS
BASIC SYSTEMS OPERATION
GENERAL ACCESSORY ITEMS
GETTING UNDERWAY
GENERAL MAINTENANCE
STORAGE AND EXTENDED LAY-UP
TROUBLESHOOTING
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

1-3 430 Sports Coupe
Introduction
Safety Symbols
Safety
In emergency situations, it may be necessary to resort to measures
which are not normally practiced. Always assess the dangers of being
in harm’s way before the protection of equipment.
Keep a sound mind during an emergency and always think safety.
The following precautions are used throughout this manual.
The “signal words” of DANGER, WARNING and CAUTION have
specific meaning to alert you to relative level of hazard.
Section 1 contains a description of the Skipper’s Kit and information
about the warranty.
Section 2 contains your yacht specifications such as dimensions and
capacities. There are also layout diagrams to introduce you to
floorplans as well as the locations of various components.
Section 3 contains descriptions of all the controls and indicators on
the dash of the helm.
Section 4 contains principles of operation for the major systems
onboard the 430 Sports Coupe.
AThe Safety Alert Symbol means
ATTENTION! Be alert to the possibility
of personal injury or death.
DANGER
Indicates an imminently hazardous situation which, if
not avoided, will result in death or serious injury.
WARNING
Indicates a potentially hazardous situation which, if
not avoided, could result in death or serious injury.
CAUTION
Indicates a potentially hazardous situation, which, if
not avoided, could result in minor or moderate injury.
CAUTION
Indicates the presence of a hazard which might result
in damage to property or equipment.
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 1
1-4
430 Sports Coupe
Owner’s Manuals for Onboard Systems and
Components
Spend some time becoming familiar with all the information contained
in the Skipper’s Kit. Besides containing separate warranty information,
the kit also contains literature which provides important safety
information and operating and maintenance instructions for those
systems and components not manufactured by Cruisers Yachts.
Depending on the options you chose, the kit may contain some or all
of the following literature:
• Engine
• Hydraulic Steering
• RACOR Fuel Filter/Water Separator
• Electric Stove
• Battery Charger
• Water Heater
• Trim Tabs
• Refrigerator/Freezer
• Generator
• Electric Anchor Windlass
• Air Conditioner/Heater
•StereoSystem
• Compass
• Microwave/Convection Oven
• Marine Toilet
• Fire Suppression System
• Carbon Monoxide (CO) Detector
• Refrigerator/Ice Maker
• Propeller Shaft
• Washer/Dryer
• Bow Thruster
• Central Vacuum
• Spotlight Operation
• Television, DVD Player, FM Radio
• Electronic Dash Components
•TrashCompactor
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

1-5 430 Sports Coupe
Introduction
WARRANTY INFORMATION
Warranties for onboard systems and components furnished by
suppliers other than Cruisers Yachts are located inside the Skipper’s
Kit. Your Cruisers Yachts Dealer will go through these with you. It is
your responsibility to fill out any warranty registration that may be
required.
The warranty provided by Cruisers Yachts is printed on the last page
of this manual. You and the Cruisers Yachts Dealer have certain
responsibilities to fulfill to keep the warranty in force.
Dealership Responsibilities
1. The dealer will discuss the terms of all warranties and stress the
importance of registering warranties with the appropriate
manufacturers.
2. The dealer will provide instruction for obtaining warranty service.
3. The dealer will go over the predelivery service record with you and
then sign it to certify that all work has been accomplished.
4. The dealer will provide you with thorough instructions in the
operation of your yacht and all its systems.
Your Responsibilities
1. Sit down with the dealer and go over all warranties. Fill in the
Cruisers Yachts Limited Warranty Registration card which is
located inside the Skipper’s Kit. Keep a record of the hull number
for future reference.
2. Inspect the boat at the time of delivery to ensure that all systems
are operating properly.
3. Sit down with the dealer and go over the predelivery service
record. Sign this record to indicate that it has been explained to
you.
4. Operate all equipment per the manufacturer’s instructions.
5. Cruisers Yachts recommends that you refer to your engine
warranty for initial inspection and service requirements.
6. Perform or provide for the appropriate periodic maintenance
outlined in the owner’s manuals and service guides.
Warranty Service
You are entitled to all the benefits and services set down in the
warranties. If a problem arises with your 430 Sports Coupe as a
result of workmanship or materials, contact your Cruisers Yachts
Dealer as soon as possible. Please have your hull identification
number and necessary model numbers on hand for the items that
may need service or repair. Your hull identification number is located
below the rub rail on the starboard side of the transom.
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 1
1-6
430 Sports Coupe
SAFETY LABEL LOCATIONS
The actual location and number of safety labels throughout your
Cruisers Yacht vary from yacht to yacht. These illustrations are used
as a reference to identify some of the labels. Some of the labels
shown may not appear as the actual labels on your yacht. The
number identifying the label corresponds with the legend and
describes the general location of the label on your yacht.
1. Davit Lift, if equipped
2. Transom/Swim Platform
3. Cabin Entrance Door
4. Power Cable Connectors
5. AC/DC Control Panel, Cabin
6. Helm
7. Steering Wheel
8. City Water Hook-up
2
CSR_SLMS_001A
3
DANGER
(CaliforniaOnly)
7
6
4
8
5
1
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

1-7 430 Sports Coupe
Introduction
9. Rumble Seat
10. Helm
11. Engine Room Hatch
12. Cockpit
13. Helm
14. Helm
15. Helm
16. Swim Platform
17. AC/DC Control Panel, Cabin
9
17
12
16
13
10 11
15
14
CSR_SLMS_001B
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 1
1-8
430 Sports Coupe
18. Cockpit
19. Cabin Entry Door
20. Cabin
21. Cockpit
22. AC/DC Control Panel, Cabin
23. Cabin
24. Galley
25. Engine Compartment
26. Cleats
27. Head
CSR_SLMS_001C
18 20
2221
19
27
23
24
26
25
DISCHARGE OF OIL PROHIBITED
The Federal Water Pollution Control Act
prohibitsthe discharge of oil or oily waste into
or upon the navigable watersand contiguous
zone of the United Statesif such discharge
causesa film or sheen upon, or discoloration
of, the surface of the water, or causesa sludge
or emulsion beneath the surface of the water.
Violatorsare subject to a penalty of $5,000.
FUEL VALVES
NOTE ValvesOpen When
In Line With Flow
OPERATION
NORMAL Open Outside Valves
and Close Center
EMERGENCY Close Valve to
Empty or Contaminated
Tank and Open Center
Do Not Open A l Three Valves
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

2-1 430 Sports Coupe
Section 2
Model Specific Information
Specifications................................................................. 2-2
Deck Hardware General Layout.................................... 2-3
Interior General Layout – Salon.................................... 2-4
Plumbing Hardware ....................................................... 2-5
Fuel Layout – Yanmar Diesel........................................ 2-6
Engine Room Bulkhead and Electrical
Panel – Yanmar ........................................................... 2-7
Engine Room General Layout – Yanmar ..................... 2-8
Engine Room Vent Layout – Yanmar........................... 2-9
Fuel Layout – Volvo IPS .............................................. 2-10
Engine Room General Layout Bulkhead –
Volvo IPS.................................................................... 2-11
Engine Room Ventilation / Oil Exchange
Layout – Volvo IPS.................................................... 2-12
Freshwater Layout....................................................... 2-13
Waste Layout ............................................................... 2-14
Raw Water Layout ....................................................... 2-15
Hardtop Sliding Sunroof ............................................. 2-16
Walk-Thru Windshield................................................. 2-17
Windshield Washer System / Ice Maker Valve.......... 2-17
Sun Deck Lounge ........................................................ 2-18
Rumble Seat – Optional .............................................. 2-18
Dinette Tables .............................................................. 2-19
Transom Gate .............................................................. 2-19
Cockpit Sun Bed.......................................................... 2-19
Cockpit TV.................................................................... 2-20
Aft State Room............................................................. 2-20
Lifting and Storing Your Boat .................................... 2-21
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 2
2-2
430 Sports Coupe
SPECIFICATIONS
Measurements (US / Metric)
L.O.A. with Swim Platform ..............................................43'0" / 13.1 m
Beam ................................................................................13'6" / 4.1 m
Approximate Weight, Gas Engines*.................... 22,000 lbs / 9,979 kg
Approximate Weight, Diesel Engines* .............. 23,500 lbs / 10,659 kg
Swim Platform Capacity........................................... 650 lbs / 294.8 kg
Fuel Capacity............................................................. 300 gal / 1,136 L
Water System Capacity ..................................................75 gal / 284 L
Holding Tank Capacity ....................................................50 gal / 189 L
Cabin Headroom.................................................................6'5" / 2.0 m
Height - Keel to Top of Hardtop.........................................13'6" / 4.1 m
Bridge Clearance to Top of Hardtop .................................11'5" / 3.5 m
Draft: Hull / Underwater Gear
Draft VD...........................................................................41" / 1.0 m
Draft IPS..........................................................................44" / 1.1 m
Deadrise .............................................................................16 degrees
Sleeping Accommodations ...................................................5 persons
*Weights are estimates and can vary from options and equipment
added.
Engines
GAS:
Mercury 8.1, HRZ, DTS, VD, 270 HP FWC
Mercury 8.1, HO, DTS, VD, 420 HP FWC)
Volvo 500G IPS, 375 HP
DIESEL:
Volvo D6 EVC/EC VD 370 HP
Volvo D6 EVC/EC VD 435 HP
Volvo D6 500 IPS 370 HP
Volvo D6 600 IPS 435 HP
Yanmar 6LY3UTP EC VD 380 HP
Yanmar 6LY35STP EC VD 440 HP
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

2-3 430 Sports Coupe
Model Specific Information
DECK HARDWARE GENERAL LAYOUT
1
28 3112 19 16 821 425 29 611 27 20 15
30
5
3
2324
22
17
26
14
10
2
18
12
31
7
13
10
11 9
7
50-R002D
Hatch
Grab Rail
Table Base
Bow Roller
WalkthruRail
Sun Deck Lounge
Drink Holder
Port Grab Rail
17.
18.
19.
20.
21.
22.
23.
24.
9.
10.
11.
12.
13.
14.
15.
16.
Ladder
Cleat
Cleat
Drink Holder
Cockpit Courtesy Light
Drink Holder
Spotlight
Grab Rail
1.
2.
3.
4.
5.
6.
7.
8.
City Water Receptacle
Cockpit Faucet
Hatch
Air Horn
Windlass
Windlass Deck Switch
Washdown Shower System
Compass
25.
26.
27.
28.
29.
30.
31.
Starboard Grab Rail
Cabin Door
Navigation Light
Dock TV Receptacle
Washdown Faucet
Chain Snubber
Deck Fill Plate - Fuel
Purple = optional equipment
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 2
2-4
430 Sports Coupe
INTERIOR GENERAL LAYOUT – SALON
72312 113367
11
10
9
8
4
5
3
650-R006BA
IPOD / I-Video Cradle
Stereo Amplifier
Speaker
Stereo Receiver
26" TV
DVD Player
19" TV
Microwave Oven / Coffee Maker
Refrigerator / Freezer
Electric Stove
Galley Sink
Power Distribution Panel
EPLEX Panel
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
Purple = optional equipment
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

2-5 430 Sports Coupe
Model Specific Information
PLUMBING HARDWARE
17 76 5312 18 219 15 17 11 16 14
4
21 2
3
1
20
16
8
13
21
17 9
10
Purple = optional equipment
50-R006DA
Galley Faucet
Washdown Faucet
Waste Tank
Macerator Pump
Thru-hull Seacock
Air Conditioner Unit - Forward, Salon
Air Conditioner Unit - Aft, Salon
Shower Sump Pump
9.
10.
11.
12.
13.
14.
15.
16.
Bilge Pump, 2200 GPH
(8328LPH) / Float Switch
Water Pickup / Seacock
Strainer
Air Conditioner Raw Water Pump
High Water Alarm / Float Switch
17.
18.
19.
20.
21.
Water Tank
Head Faucet
Head
City Water Receptacle
Cockpit Faucet
Washdown Shower System
Water Heater
Freshwater Pump
1.
2.
3.
4.
5.
6.
7.
8.
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 2
2-6
430 Sports Coupe
FUEL LAYOUT – YANMAR DIESEL
1. Port Fuel Tank
2. Starboard Fuel Tank
3. Genset
4. Port Fuel Filter / Strainer
5. Starboard Fuel Filter / Strainer
6. Genset Fuel Filter / Strainer
7. Fuel Crossover Assembly
8. Deck Fill Plate
9. Fuel / Air Separator
10. Vent
11. Fuel Tank Fill Hose
12. Fuel Tank Vent Hose
13. Port Fuel Tank Feed to
Crossover
14. Crossover to Port Engine
Fuel Filter
15. Port Engine Fuel Filter to
Port Engine
16. Port Engine Return to
Crossover
17. Crossover to Port Fuel
Tank Return
18. Starboard Fuel Tank Feed to
Crossover
19. Crossover to Starboard Engine
Fuel Filter
20. Starboard Engine Fuel Filter to
Starboard Engine
21. Starboard Engine Return to
Crossover
22. Crossover to Starboard Fuel
Tank Return
23. Port Fuel Tank to Genset
Fuel Filter
24. Genset Fuel Filter to Genset
25. Genset Return to Port Fuel Tank
82311 14 19 1 1312
17
9
16
22
7
21
10 12 9
24
2
18
25 15
311 8
520
21
6
9
22
7
2 18 12
24
811
3
4
15
25
6
20
5
8131231131291419 10
17
7
16
STARBOARD PROFILE
PORT PROFILE
41-R004D
45-R039Ba
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

2-7 430 Sports Coupe
Model Specific Information
ENGINE ROOM BULKHEAD AND ELECTRICAL PANEL – YANMAR
56125
4
7
3
Purple = optional equipment
41-R003DA
Extinguisher
Fuel Crossover Assembly
Port Teleflex Control Board
Starboard Teleflex Control
Board
Blower
Reverso Oil Pump
Power Terminal Bar
1.
2.
3.
4.
5.
6.
7.
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 2
2-8
430 Sports Coupe
ENGINE ROOM GENERAL LAYOUT – YANMAR
1
10
15
19
25
24
23
20
19
11
3
16
12
14
17
22
7
6
9
6
8
4
5
21 18 132
Battery, Port Engine
Battery, Acc.
Battery, Acc.
Battery, Starboard Engine
Battery, Genset
Battery Switch, Port Engine
Battery Switch, Acc.
Battery Switch, Genset
Battery Switch, Starboard Engine
Strainer / Racor Fuel Filter
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
Port Fuel Tank
Starboard Fuel Tank
Genset
Strainer
Seawater Strainer
ThruHull Seacock
Raw Water Strainer
Raw Water Strainer
Bilge Pump, 2200 GPH /
Float Switch / High Water Alarm
1.
2.
3.
4.
5.
6.
7.
8.
9.
Strainer / Racor Fuel Filter
DSL, 500MA30
Muffler
Exhaust Hose
Trim Tab
Battery Isolator
Water Heater
20.
21.
22.
23.
24.
25.
41-R003DB
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

2-9 430 Sports Coupe
Model Specific Information
ENGINE ROOM VENT LAYOUT – YANMAR
1
1
3
1
3
2
3
Blower
Blower Vent
Ducting Hose
1.
2.
3.
41-R017B
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com

Section 2
2-10
430 Sports Coupe
FUEL LAYOUT – VOLVO IPS
50-R008D
621
1. Port Fuel Tank
2. Starboard Fuel Tank
3. Deck Fill Plate
4. Fuel Filter Separator
5. Crossover Kit
6. Genset
7. Racor Fuel Filter Mounting Plate
8. Port Tank Return to Crossover
9. Port Engine Return to
Crossover
21
8 9 15 16 11 2 17
5
12
4
322
10
STARBOARD PROFILE
14
TO PORT SIDE OF BOAT
322 9151428
10
16
4
12
11
12113171822371920
10. Starboard Engine Return to
Crossover
11. Starboard Tank Return to Crossover
12. Port Fuel Filter to Crossover
13. Starboard Fuel Filter to Crossover
14. Port Tank Feed to Fuel Filter
15. Crossover to Port Engine Feed
16. Crossover to Starboard Engine Feed
17. Starboard Tank Feed to Fuel Filter
18. Port Tank Feed to Genset
Filter
19. Genset Return to Tank Return
20. Genset Filter to Genset Feed
21. Fuel Tank Vent Hose
22. Fuel Tank Fill Hose
Purple = optional equipment
Downloaded from CruisersOwnersForum
http://www.CruisersOwnersForum.com