CTM E-TRIKE 24 User manual

Phone: [phone]
Fax: [phone]
E-mail: ebik[email protected]
www.chitumaelectricbicycles.com.au
3/6 KLAUER ST SEAFORD VIC
AUSTRALIA 3198
C H I T U M A A U S T R A L I A P T Y L T D
•
E-TRIKE 26/24
Series II
C H I T U M A A U S T R A L I A P T Y L T D
OWNER MANUAL
Da te: 01/01/2015

Page 2
THANK YOU FOR CHOOSING OUR ELECTRIC ASSISTED
TRICYCLE
OUR E-TRIKE CAN BE OPERATED VERY EASILY.IT CAN
BE OPERATED BY THE MOTOR ALONE OR BY PEDALING
ALONE OR A COMBINATION OF BOTH AT THE SAME
TIME.IN ORDER TO GIVE YOU A LONG AND SAFE US-
AGE PLEASE READ THE INSTRUCTIONS BEFORE USING.
SAFTEY CHECK BEFORE RIDING
YOUR
BICYCLE
1.CHECK AND TIGHTEN ALL NUTS ,BOLTS,
STRAPS
AND FASTENERS
2.CHECK THAT BRAKES OPERATE CORRECTLY
3.CHECK TYRES FOR WEAR, DAMAGE AND
CORRECT PRESSURES.PRESSURES ARE USUALY
WRITTEN ON TYRE WALLS.
4.CHECK WHEELS FOR TRUENESS
5.CHECK LIGHTS FOR OPERATION AND AD-
JUSTMENT
6.CHECK AUDIABLE WARNING DEVICE [BELL
OR HORN
ALWAYS WEAR AN APPROVED
BICYCLE HELMET AND OBEY THE
ROAD RULES AT ALL TIMES

Page 3
YOUR TRICYCLE IS DESIGNED FOR USE
ONLY ON PAVED ROADS OR PATHS
(WHERE THE LAWS PERMIT)
DO NOT USE OFF THESE SURFACES
OPERATION
PERFORM SAFTEY CHECKS AND ADJUST SEAT
FOR COMFORTABLE RIDING
THE ROCKER SWITCH ON THROTTLE HANDLE
TURNS THE MOTOR ON OR OFF
SQUEEZE LEFT HAND BRAKE AND ALIGHT TRIKE
FROM SAME SIDE
POSITION YOUR SELF ON TRIKE WITH BOTH FEET
ON THE PEDALS NOT ON THE GROUND. USE
HANDBRAKE TO MAINTAIN A STATIONARY POSI-
TION
YOUR TRIKE IS NOW READY TO GO.YOU MAY
EITHER PEDAL OR BY TWISTING THE R/HAND GRIP
BACK
TOWARDS YOU USE THE ELECTRIC MOTOR.THE
FURTHER YOU TWIST THE FASTER YOU WILL
TRAVEL
APPLYING EITHER HANDBRAKE WILL CUT MOTOR
POWER AUTOMATICALLY.
TRIKES REQUIRE YOU TO TURN HANDLE BAR
MUCH MORE THAN A 2WHEEL BIKE AND REQUIRE
YOU TO MANUALLY TURN THE HANDLE BAR BACK
TO THE STRAIGHT AHEAD POSITION OTHERWISE
YOU WILL KEEP TRAVELLING IN CIRCLES

Page 4
ON /OFF AND PEDAL EFFECT SWITCHES
CHARGING
YOU MUST ONLY USE THE CHARGER THAT WE
SUPPLY
DO NOT PLUG KETTLE CORD OR COMPUTOR
LEAD INTO BATTERY POWER OUT PLUG
ONLY USE IN A DRY WELL VENTILATED
ENVIROMENT .
WITH THE LEAD UNPLUGGED FROM 240V POWER SUPPLY PLUG THE
SMALL ROUND PLUG INTO POINT LOCATED ON LEFT HAND SIDE OF
BATTERY BOX OR ON SMALL BOX LOCATED IN FRONT BASKET .PLUG
3 PIN PLUG INTO STANDARD HOUSE HOLD POWER SUPPLY AND
SWITCH ON.YOU WILL SEE A RED LIGHT ON CHARGER ,THIS INDI-
CATES THE UNIT IS ON AND CHARGING THE BATTERY.WHEN
CHARGED LIGHT WILL CHANGE TO GREEN AND CHARGER WILL
SWITCH AND GO INTO MAINTENANCE MODE.I T IS ALRIGHT TO
LEAVE IT IN THIS MODE FOR A SHORT PERIOD OF TIME BUT WE
RECOMMEND THAT YOU TURN IT OFF AND UNPLUG FROM POWER
POINT AND BIKE AFTER 12 HOURS
REMEMBER ALWAYS SWITCH OFF AT POWER POINT BEFORE PLUG-
ING OR UNPLUGING FROM TRICYCLE
MAXIMUN BATTERY LIFE WILL BE ACHIEVED BY CHARGING EVERY
DAY AFTER BEING USED . BATTERIES LEFT IN A SEMI DISCHARGED
STATE WILL PREMATURALLY FAIL.
AFTER ALIGHTING HOLD HANDBRAKE
AND TURN ON ON/OFF SWITCH. BAT-
TERY INDICATOR ILL LIGHT . TURN OFF
BEFORE DISMOUNTING
WHEN PEDALLING THE MOTOR WILL
CUT IN AND ASSIST YOU .IF YOU DO
NOT DESIRE THIS PUSH THE PEDAL
EFFECT BUTTON TO TURN OFF
Hold throttle at desired speed for
approx 30secs and it will enter cruise
control mode and travel at this speed
without touching throttle .touch either
brake or throttle to exit cruise control
Page 5
PERIODIC MAINTENANCE
ITEM 500klms 1000klms 1500klms 2000klms
3000klms
BRAKES A A A A
ALL CABLES L I L I
CHAIN L I I L I
TYRES I I I I
FRONT FORKS L I I L I I
PEDAL ASSYS I I I I
ALL NUTS BOLTS
FASTENERS ETC I I I I
A = ADJUST L= LUBRICATE I = INSPECT FOR WEAR ,TIGHTNESS AND
CONDITION
PLEASE NOTE THE ABOVE MAINTENANCE IS A SUGGESTED MINIMUMN
AND IS NOT IN PLACE OF DAILY SAFTEY CHECKS PRIOR TO RIDING
FOR ADVICE ON BRAKE ADJUSTMENT CHECK WITH YOUR DEALER OR
LOCAL BIKE SHOP