Curtis CAFE0AP10A000 User manual

CAFE Series Airpot/ Thermal Decanter
Pourover Coffee Brewing System
USER GUIDE
READ AND SAVE THESE INSTRUCTIONS
NOTICE TO INSTALLER: Please leave this booklet with the machine.
'$$"'&(-"44%&$"/5&3#3&8&3'30/5$07&3øøøøø /$
'SFW/$

CONTENTS CL36
.H\)HDWXUHV6SHFLÀFDWLRQV6\VWHP5HTXLUHPHQWV..............................................................................................FS36
,PSRUWDQW6DIHJXDUGV............................................................................................................................................... IS2
,QVWDOODWLRQ,QVWUXFWLRQV*HQHUDO...............................................................................................................................II4
,QVWDOODWLRQ,QVWUXFWLRQV/HYHOLQJ(OHFWULFDO..............................................................................................................II5
2SHUDWLQJ,QVWUXFWLRQV ............................................................................................................................................OI29
&OHDQLQJ,QVWUXFWLRQV%UHZHUV ...............................................................................................................................CI1
&OHDQLQJ,QVWUXFWLRQV7KHUPDO'LVSHQVHUV ............................................................................................................CI9
&OHDQLQJ,QVWUXFWLRQV'HOLPLQJ ...........................................................................................................................CI12
3URJUDPPLQJ*XLGH ............................................................................................................................................. 3*
5RXJK,Q'UDZLQJ................................................................................................................................................. 5'
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV................................................................................................................... IP65
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV7DQN$VVHPEO\'RPHVWLF....................................................................... IP66
,OOXVWUDWHG3DUWV5HFRPPHQGHG3DUWV7DQN$VVHPEO\([SRUW ........................................................................... IP67
(OHFWULFDO6FKHPDWLF'RPHVWLF............................................................................................................................ES68
(OHFWULFDO6FKHPDWLF([SRUW ................................................................................................................................ES69
7URXEOHVKRRWLQJ*XLGH ..........................................................................................................................................7*
3URGXFW:DUUDQW\....................................................................................................................................................3:
Contact Information
Wilbur Curtis Co., Inc.
6913 Acco Street | Montebello, CA 90640 US
Phone: [phone] | Toll Free: 800-421-6150
Email: [email protected] | Web: www.wilburcurtis.com
'PSUIFMBUFTUTQFDJmDBUJPOTBOEJOGPSNBUJPOHPUPXXXXJMCVSDVSUJTDPN
5PMM'SFF].POEBZ'SJEBZA.M.- 4:00 P.M.PT
Email: [email protected]
%VFUPDPOUJOVFEQSPEVDUJNQSPWFNFOUUIFQSPEVDUTJMMVTUSBUFEQIPUPHSBQIFEJOUIJTHVJEFNBZWBSZTMJHIUMZGSPNUIFBDUVBMQSPEVDU
$"'&"*31055)&3."-%&$"/5&3#3&8&3$0/5&/54-*45øø  /$

KEY FEATURES/SPECIFICATIONS/SYSTEM REQUIREMENTS FS36
Key Features
• Pourover operation – No plumbing required.
• Powerful heating element provides quick recovery for faster brewing.
• Large-volume water tank for greater brewing capacity.
• Space-saving design.
• Stainless steel construction with textured black powder coating.
6SHFLÀFDWLRQV6HOHFWHG0RGHOV
(OHFWULFDO6XSSO\5HTXLUHPHQWV
02'(/ '(6&5,37,21 3+$6( 92/76 $036 +($7,1*&21),* :,5( :$776 +(57= *$/+5
&$)($3$ Pourover Airpot Brewer 1 PH 120 V 12.1 A 1 x 1450 W 2W + G 1450 W 50/60 Hz 4.2
&$)(33$ Pourover Pourpot Brewer 1 PH 120 V 12.1 A 1 x 1450 W 2W + G 1450 W 50/60 Hz 4.2
(;3257
&$)($3$ Pourover Airpot Brewer, Export 1 PH 230 V 9.5 A 1 x 2000 W 2W + G 2185 W 50/60 Hz 6.0
&$)(33$ Pourover Pourpot Brewer, Export 1 PH 230 V 9.5 A 1 x 2000 W 2W + G 2185 W 50/60 Hz 6.0
'LPHQVLRQV
02'(/ +(,*+7 :,'7+ '(37+ 6+,3:(,*+7 6+,3&8%(
&$)($3$ 24.88” 9.25” 17.88” 31.0 lbs 5.60 cu ft
&$)(33$ 17.63” 9.25” 17.88” 23.0 lbs 3.92 cu ft
(;3257
&$)($3$ 24.88” 9.25” 19.00” 31.0 lbs 5.60 cu ft
&$)(33$ 17.63” 9.25” 19.00” 23.0 lbs 3.92 cu ft
CAFE AIRPOT/THERMAL DECANTER BREWER, KEY FEATURES/SPECS/SYSTEM REQUIREMENTS 101817NC

IMPORTANT SAFEGUARDS IS2
Symbols
This is the safety alert symbol. It is used to alert you to potential physical injury hazards. Obey all safety
messages that follow this symbol to avoid possible injury or death.
DANGER - Indicates a hazardous situation which, if not avoided, will result in death or serious injury.
WARNING - Indicates a hazardous situation which, if not avoided, could result in death or serious injury.
CAUTION - Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
NOTICE - Indicates a situation which, if not avoided, could result in property damage.
IMPORTANT - Provides information and tips for proper operation.
SANITATION REQUIREMENTS
Important Safeguards/Conventions
WARNING:
• Make sure that this appliance is installed and grounded according to the INSTALLATION
*/4536$5*0/4CZRVBMJmFEQFSTPOOFMCFGPSFBUUFNQUJOHUPVTFJU'BJMVSFUPGPMMPXUIF*/45"--"5*0/
INSTRUCTIONS could result in personal injury or void the warranty.
• This appliance is designed for commercial use. Any service other than cleaning and preventive
maintenance should be performed by an authorized Wilbur Curtis service technician.
• 5PSFEVDFUIFSJTLPGmSFPSFMFDUSJDTIPDL%0/05PQFOUIFTFSWJDFQBOFMT5IFSFBSFOPVTFS
serviceable parts inside.
• Keep hands, arms and other items away from hot surfaces of the unit during operation.
• Clean the appliance and any dispensers completelyCFGPSFVTJOHUIFNGPSUIFmSTUUJNFBTBDDPSEJOHUP
the CLEANING INSTRUCTIONS. Clean them regularly as instructed in the CLEANING INSTRUCTIONS.
• Use this appliance only for its intended use, brewing/dispensing hot and/or cold beverages/water.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory
or mental capabilities or lack of experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person responsible for their safety. Children should
be supervised to ensure that they do not play with the appliance.
• Avoid spillage onto the power (mains) connector.
$0''&&5&"#3&8&34*.1035"/54"'&(6"3%44:.#0-4 &
WARNING - 5IJTQSPEVDUDBOFYQPTFZPVUPDIFNJDBMTJODMVEJOH"DSZMBNJEFBOE#JTQIFOPM"#1"
which are known to the State of California to cause cancer and birth defects or other reproductive harm.
'PSNPSFJOGPSNBUJPOWJTJUXXX18BSOJOHTDBHPW

IMPORTANT SAFEGUARDS IS2
$0''&&5&"#3&8&34*.1035"/54"'&(6"3%44:.#0-4 &
CE Requirements
• This appliance must be installed in locations where it can be overseen by trained personnel.
• 'PSQSPQFSPQFSBUJPOUIJTBQQMJBODFNVTUCFJOTUBMMFEXIFSFUIFUFNQFSBUVSFJTCFUXFFO¡$UP¡$
• "QQMJBODFTIBMMOPUCFUJMUFENPSFUIBO¡GPSTBGFPQFSBUJPO
• "OFMFDUSJDJBONVTUQSPWJEFFMFDUSJDBMTFSWJDFBTTQFDJmFEJODPOGPSNBODFXJUIBMMMPDBMBOEOBUJPOBMDPEFT
'PSTBGFVTFBOBMMQPMFEJTDPOOFDUJPONVTUCFJODPSQPSBUFEJOUPUIFmYFEXJSJOHJOBDDPSEBODFXJUIUIF
XJSJOHSVMFTPVUMJOFEJODMBVTFPG*&$GPSNFFUJOHUIFNJOJNVNFMFDUSJDBMTBGFUZPGUIJTTUBOEBSE
• This appliance must not be cleaned by water jet.
• 5IJTBQQMJBODFDBOCFVTFECZQFSTPOTBHFEGSPNZFBSTBOEBCPWFJGUIFZIBWFCFFOHJWFOTVQFSWJTJPOPS
instruction concerning use of the appliance in a safe way and if they understand the hazards involved.
• ,FFQUIFBQQMJBODFBOEJUTDPSEPVUPGSFBDIPGDIJMESFOBHFEMFTTUIBOZFBST
• "QQMJBODFTDBOCFVTFECZQFSTPOTZFBSTBOEBCPWFXJUISFEVDFEQIZTJDBMTFOTPSZPSNFOUBMDBQBCJMJUJFT
or lack of experience and knowledge if they have been given supervision or instruction concerning use of the
appliance in a safe way and understand the hazards involved.
• $IJMESFOVOEFSUIFBHFPGZFBSTTIPVMECFTVQFSWJTFEUPFOTVSFUIFZEPOPUQMBZXJUIUIFBQQMJBODF
• If the power cord is ever damaged, it must be replaced by the manufacturer or authorized service personnel
with a special cord available from the manufacturer or its authorized service personnel in order to avoid a
hazard.
• Machine must not be immersed for cleaning.
• $MFBOJOHBOEVTFSNBJOUFOBODFTIBMMOPUCFNBEFCZDIJMESFOVOMFTTUIFZBSFPMEFSUIBOZFBSTBOE
supervised.
• This appliance is intended to be used in household and similar applications such as:
 oTUBGGLJUDIFOBSFBTJOTIPQTPGmDFTBOEPUIFSXPSLJOHFOWJSPONFOUT
 oCZDMJFOUTJOIPUFMTNPUFMTBOEPUIFSSFTJEFOUJBMUZQFFOWJSPONFOUT
– bed and breakfast type environments.
• This appliance not intended to be used in applications such as:
– farm houses
• Access to the service areas permitted by Authorized Service personnel only.
• 5IF"8FJHIUFETPVOEQSFTTVSFMFWFMJTCFMPXE#"

INSTALLATION INSTRUCTIONS II4
Installation Instructions
Installation Requirements
• A secure surface capable of supporting the weight of the appliance.
• For appliances without an attached cord set: Appropriately sized, UL listed, grounding type power cable to
NFFUUIFFMFDUSJDBMTQFDJmDBUJPOTGPSUIFVOJU*GZPVIBWFRVFTUJPOTBCPVUUIFDPSSFDUDBCMFTJ[FBOEMFOHUI
DPOTVMUBRVBMJmFEJOTUBMMFS'PSBQQMJBODFTUIBUXJMMCFIBSEXJSFEUPBKVODUJPOCPYUIFQPXFSDBCMFNVTUCF
long enoughTPUIBUUIFCSFXFSDBOCFNPWFEGPSDMFBOJOHVOEFSOFBUI
• "HSPVOEFEFMFDUSJDBMDPOOFDUJPOUPBOFMFDUSJDBMDJSDVJUUIBUNFFUTUIFFMFDUSJDBMTQFDJmDBUJPOTPGUIF
appliance (see SPECIFICATIONS). The circuit must be protected by the appropriate sized circuit breaker.
*GZPVBSFOPUDFSUBJOUIBUUIFFYJTUJOHDJSDVJUNFFUTUIFSFRVJSFNFOUTGPSZPVSCSFXFSDPOTVMUBMJDFOTFE
electrician.
WARNING:*NQSPQFSFMFDUSJDBMDPOOFDUJPONBZSFTVMUJOBOFMFDUSJDTIPDLIB[BSE5IJTBQQMJBODFNVTUCF
properly grounded.
WARNING:*GJOTUBMMBUJPOPGBQPXFSQMVHJTSFRVJSFEJUNVTUCFJOTUBMMFEPOMZCZBRVBMJmFEJOTUBMMFS
IMPORTANT:0CTFSWFBMMHPWFSOJOHDPEFTBOEPSEJOBODFT
(&/&3*$/0/1-6.#&%*/45"--"5*0/*/4536$5*0/4 /$

Installation
Leveling
1 Position the brewer on the countertop near an
electrical outlet that meets the SPECIFICATIONS.
Level the brewer left to right and front to back by
turning the bottom of the legs.
Connecting the Brewer Power Plug - Export Units
2 Connect the appropriate type of grounded power plug
to the end of the power cord coming from the back of
the unit.
INSTALLATION INSTRUCTIONS II5
CAFE, INSTALLATION INSTRUCTIONS 121217B
WARNING: Use the leveling legs to level the
brewer only. Do not use them to adjust brewer
height. Do not extend them higher than
necessary.
NOTICE - This brewer is shipped with the
thermostat turned ON. DO NOT plug in the
brewer before pouring 3 pots/192 oz. of water
into the opening as instructed below; damage to
the heating element and/or thermostat will result.
&RQ¿JXUDWLRQ
YDULHV
&RQ¿JXUDWLRQ
YDULHV
Prepare the Brewer for Use
3 Place an empty glass decanter on the warmer deck,
under the spray head.
4 Insert the empty brew basket into the brew rails of the
brewer, below the control panel.
5 Fill the water tank by slowly pouring room temperature
water through the opening on the top cover, until
water starts running in a steady stream from the
brew basket. It takes approximately three pots or 192
PVODFTUPmMMUIFUBOLJOEJDBUFECZXBUFSDPNJOHPVU
of the brew basket.

INSTALLATION INSTRUCTIONS II5
CAFE, INSTALLATION INSTRUCTIONS 121217B
Powering Up the Brewer
6 Connect the power cord to the electrical outlet.
7 Make sure that the circuit breaker supplying power to the
brewer is on.
8 Some brewers are equipped with a main power switch
on the back or front of the unit. Turn it to the ON position.
9 Depending on the water temperature and the electrical
TQFDJmDBUJPOTUIFXBUFSUBOLUZQJDBMMZSFRVJSFTUP
minutes to reach operating temperature. When the water
has heated, the READY TO BREW light will come on.
Power Switch (some units)
WARNING: Connect the power cords only to the
appropriate type and size electrical outlet. If the
electrical outlet is not compatible with the power
cords, have it upgraded by a licensed electrician.
Do not modify the power plug. Do not use an
extension cord. Do not use a power cord/plug that is
damaged.
IMPORTANT: When operating the brewer at
FMFWBUJPOTIJHIFSUIBOGFFUNFUFST
IBWFBRVBMJmFEJOTUBMMFSBEKVTUUIFUIFSNPTUBU
inside the unit. See the PROGRAMMING GUIDE
section.

WARNING - TO AVOID SCALDING, AVOID SPLASHING. The brew basket contains hot coffee grounds.
Keep body parts clear of the brewer during brewing. Allow the brew basket to drain before removing it. Be
DBSFGVMOPUUPQPVSNPSFXBUFSJOUPUIFQPVSPWFSPQFOJOHUIBUXJMMmMMUIFDPOUBJOFSCFMPX
OPERATING INSTRUCTIONS OI29
$"'&"*31055)&3."-%&$"/5&301&3"5*/(*/4536$5*0/4øø /$
Brewing Instructions
2 Center an empty airpot or
thermal decanter under the
brew basket.
3 *OTFSUBDMFBOQBQFSmMUFSJOUP
the brew basket.
4 Fill the brew basket with the
proper amount of ground
coffee. Level the coffee in the
mMUFS
5 4MJEFUIFmMMFECSFXCBTLFU
into the brew rails under the
control panel. Slide it all the
way back until it stops.
 The brewer should be plugged
in and the “READY TO BREW"
light should be lit. On units
with a rear toggle switch,
make sure it is in the ON
position.
6 Using a pitcher, pour room
temperature water into the
pourover opening on the top.
%0/05PWFSmMM5IFCSFXUJNF
will be about three minutes.
NOTICE - #FGPSFQMVHHJOHUIFCSFXFSJOGPSUIFmSTUUJNFmMMUIFXBUFSUBOLBDDPSEJOHUPUIFINSTALLATION
INSTRUCTIONS section. Connecting the power without a full water tank will damage the brewer.
Before Brewing:
• A pitcher with a volume less than or equal to the volume of the airpot/thermal dispenser is required for brewing.
• Some water in the water tank may evaporate if the brewer is left on for long periods of time. When this occurs,
QPVSJOFOPVHIXBUFSUPSFmMMUIFUBOLVOUJMXBUFSDPNFTPVUPGUIFTQSBZIFBECFGPSFCSFXJOH

NOTICE - Do not use cleaning liquids, compounds or powders containing chlorine (bleach) or corrosives.
5IFTFQSPEVDUTQSPNPUFDPSSPTJPOBOEXJMMEBNBHFUIFmOJTIFT USE OF THESE PRODUCTS WILL VOID
THE WARRANTY.
CLEANING INSTRUCTIONS CI1
Cleaning The Brewer - Daily
BREWERS - GENERIC, CLEANING INSTRUCTIONS 080416B
WARNING: HOT SURFACES - To avoid injury, allow the brewer and dispenser(s) to cool before cleaning.
The brewer should be OFF.5VSOUIFCSFXFSPGGCZnJQQJOHUIFSFBSUPHHMFTXJUDIUPUIF0''QPTJUJPO
1 Remove the dispenser(s). Wipe exterior brewer surfaces with a damp cloth to remove spills and debris.
2 Remove the brew basket(s) and clean them in a mild detergent solution. Use a soft bristled brush for hard to
clean areas. Rinse with clean water, then dry.
3 Wipe the spray head area with a cloth soaked in a mild detergent solution. Rinse with a cloth soaked with
clean water removing any residual detergent. Use a clean, soft cloth to dry.
4 Dump out the drip tray(s) (if applicable). Rinse with clean water, then dry with a soft, clean cloth.
Cleaning The Brewer - Weekly
The brewer should be OFF.5VSOUIFCSFXFSPGGCZnJQQJOHUIFSFBSUPHHMFTXJUDIUPUIF0''QPTJUJPO
1 Remove the spray head(s), unscrewing counterclockwise from the dome plate.
2 Thoroughly clean and rinse the dome plate area.
3 Clean the brew basket rails with a brush soaked with a mild detergent solution. Rinse the area with a cloth
soaked with clean water, removing any residual detergent.
4 Dry the area with a soft, clean cloth.
5 Reattach the spray head(s).
WARNING: DO NOT immerse the brewer in water or any other liquid.

Cleaning the Airpot/Pour Pot (Daily)
CLEANING INSTRUCTIONS CI9
10631054"*31054$-&"/*/(*/4536$5*0/4ø #
WARNING: DO NOT immerse the airpot/pour pot or lid assembly in water or any other liquid. Do not place the
airpot/pour pot or lid in a dishwasher. Placing a airpot or pour pot in a dishwasher will void the warranty.
Cleaning Airpots
 Wash - Wipe the exterior surfaces of the airpot and
lid with a sponge soaked with the detergent solution
to remove spills and debris. Fill the liner with the
detergent solution. Use a sponge cleaning brush to
clean inside. Clean the spout/siphon tube with the
detergent solution.
 Rinse - Rinse the airpot and the spout/siphon tube
with clean, warm water.
3 Sanitize - Sanitize the interior of the airpot, the
spout/siphon tube and the lid, using a commercial
sanitizer suitable for food grade applications. Swab,
brush or pressure spray the sanitizing solution
according to the directions on the package.
 Air Dry - Turn the airpot and lid upside down.
Allow all parts to air dry.
Cleaning Pour Pots
 Wash - Wipe the exterior surfaces of the pour pot
and lid with a sponge soaked with the detergent
solution to remove spills and debris. Fill the liner with
the detergent solution. Use a sponge cleaning brush
to clean inside.
 Rinse - Rinse the pour pot and the lid with clean,
warm water.
3 Sanitize - Sanitize the interior of the pour pot and
the lid, using a commercial sanitizer suitable for
food grade applications. Swab, brush or pressure
spray the sanitizing solution according to the
directions on the package.
 Air Dry - Turn the pour pot and lid upside down
and allow to air dry.
Start by preparing a mild solution of detergent and warm water. Remove the airpot/pour pot from the brewer and
remove/open the lid. On airpots, remove the nozzle assembly. Rinse.
Nozzle
assembly
TLXA2201G000 shown. Appearance and size varies
with model number.
CLXP6401S100 shown. Appearance and size varies
with model number.
NOTE: The stem on the bottom of TFT series pour pot lids have a built-in sensor used for the FreshTrac®
feature. Keep this stem free from coffee oil build-up for proper operation. After cleaning, inverting the lid
GPSTFDPOETSFTFUTUIF'SFTI5SBDUJNFS

CLEANING INSTRUCTIONS CI12
#3&8&3%&-*.*/($-&"/*/(*/4536$5*0/4ø /$
De-liming Procedure*
NOTICE - 5IFEFMJNJOHQSPDFEVSFNVTUCFQFSGPSNFECZBRVBMJmFETFSWJDFUFDIOJDJBO
5IFEFMJNJOHTQSJOHQSPWJEFEXJUIUIFCSFXFSJTGPSDMFBOJOHMJNFEFQPTJUTGSPNXJUIJOUIFTJQIPOUVCF
 3FNPWFUIFTQSBZIFBE
2 *OTFSUTQSJOHJOUPUIFTJQIPOUVCF5XJTUUIFTQSJOHDMPDLXJTFBTZPVQVTIJOXBSE0ODFQBTUUIFCFOEJOUIF
UVCJOHZPVDBOTMJEFJUCBDLBOGPSUIUPSFNPWFIBSEMJNFEFQPTJUT
5IJTQSPDFEVSFNBZOFFEUPCFQFSGPSNFEEBJMZJOBSFBTXJUIFYUSFNFMZIBSEXBUFS

Electronic Thermostat
The electronic thermostat has two settings; 200°F (93°C) and 190°F (88°C). The factory default setting is 200°F. If
operating the brewer at altitudes higher than 4000 feet (1200 m), set it to 190°F.
1 Unplug the brewer power cord.
2 Remove the back cover.
3 Locate the thermostat, attached to a bracket near the top of the compartment.
4 Locate the temperature setting jumper pins. It is labeled “200°F” on the printed circuit board.
5 When jumpered, the board is set to 200ºF. When the jumper is removed, it is set to 190ºF. When setting
the thermostat to 190ºF, slip the jumper over (only) one of the pins, in the event that the board needs to be
changed back.
6 Replace the back cover and reconnect power.
continued....
Thermostat Adjustment
The brewer is equipped with either an electronic or
mechanical (capillary) type thermostat. The tank
temperature (thermostat) adjustment procedure is
different for each type.
PROGRAMMING GUIDE PG11
$"'&130(3"..*/((6*%&ø "
WARNING -5IFGPMMPXJOHQSPDFEVSFTBSFUPCFQFSGPSNFEPOMZCZBRVBMJmFEJOTUBMMFSPSTFSWJDFUFDIOJDJBO
Electronic Thermostat Mechanical Thermostat
Jumper in
200°F position
(default)
Jumper in
190°F position
Remove jumper
to change
setting

PROGRAMMING GUIDE PG11
$"'&130(3"..*/((6*%&ø "
Mechanical Thermostat
The mechanical thermostat has an adjustment screw used to set the temperature. The factory default setting is
200°F (93°C). When operating the brewer at higher elevations, reduce the operating temperature by 2°F for each
1000 feet of elevation above 4000 feet (1200 m).
1 Unplug the brewer power cord.
2 Remove the top cover.
3 Locate the thermostat, attached to a bracket near the back of the compartment.
4 6TJOHBnBUCMBEFTDSFXESJWFSUVSOUIFBEKVTUNFOUTDSFXPOUPQPGUIFUIFSNPTUBUDPVOUFSDMPDLXJTFUP
MPXFSUIFUFNQFSBUVSFPGBUVSOPOUIFTDSFXMPXFSTUIFUFNQFSBUVSFBQQSPYJNBUFMZ¡'¡$
When the screw is turned all the way clockwise, the thermostat is set to 200°F.
5 Replace the back cover and reconnect power.
6 If the brew temperature of the water is too cool, readjust following the above steps, keeping in mind that
too high a temperature setting at higher altitudes may cause the water in the tank to boil.
Adjustment
screw

ROUGH-IN DRAWINGS RD42
CAFE0AP Series Coffee Brewers
CAFE AIRPOT/THERMAL DECANTER BREWER, ROUGH-IN DRAWING 112316NC
* Units equipped with a toggle switch only
24.88 in
[63.2 cm]
24.5 in
[62.2 cm]
17.88 in
[45.4 cm]
19.00 in*
[48.3 cm]
9.25 in
[23.5 cm]

ROUGH-IN DRAWINGS RD42
CAFE0PP Series Coffee Brewers
CAFE AIRPOT/THERMAL DECANTER BREWER, ROUGH-IN DRAWING 112316NC
* Units equipped with a toggle switch only
17.63 in
[44.8 cm]
17.13 in
[43.5 cm]
17.88 in
[45.4 cm]
19.00 in*
[48.3 cm]
9.25 in
[23.5 cm]

ILLUSTRATED PARTS LIST IP65
CAFE GLASS DECANTER BREWER, ILLUSTRATED PARTS/RECOMMENDED PARTS 102617NC
Supplies and Accessories - All Models
CAB-1 - Cleaning BrushWC-29025 - Spray Head
10
11
6
9
17
13
7A
7B
16
14
4
3
5
8
12A
12B
2A
2B
15A
15B
1
CAFE0AP, CAFE0PP - Main Chassis - Exploded View
Water tank assemblies:
- Domestic, see section IP66
- Export, see section IP67
&KDVVLVFRQ¿JXUDWLRQYDULHVZLWKPRGHO

ILLUSTRATED PARTS LIST IP65
CAFE GLASS DECANTER BREWER, ILLUSTRATED PARTS/RECOMMENDED PARTS 102617NC
ITEM # PART # DESCRIPTION
1 WC-54121 PAN, POUR CAFÉ
2A WC-207 1,3 LIGHT, BREW 115V GREEN
2B WC-208 2,4 LIGHT, BREW 250V GREEN
3 WC-3502 LEG, 8-32 STUD SCREW BUMPER
4 WC-3645 SPRING, DELIMING .041 X 20”
GALVANIZED WIRE HARD DRAWN
5 WC-54118 TRAY, ASSY CAFE POUR OVER
6 WC-4213 NUT, 5/8 LOCK PLATED
7A WC-735-101 1,3 THERMOSTAT, TEMPERATURE
CONTROL 120VAC POUROVER CAFE
7B WC-504 2,4 THERMOSTAT, CAPILLARY SPST 250V
25A GEM
8 WC-39371 LABEL, SW PANEL CAFÉ AP CURTIS
9 WC-29025 SPRAYHEAD, PURPLE ADVANCE FLOW
ITEM # PART # DESCRIPTION
10 WC-29054 TUBE, W/A CAFE POUR OVERS
11 WC-3621-101 BREW CONE, NON-METAL UNIVERSAL
(WITH SPLASH POCKET)
12A WC-13301-101 1,3 HARNESS ASSY, CAFE AP 120V FOR
ELECTRONIC THERMOSTAT
12B WC-13301 2,4 HARNESS ASSY, CAFÉ AP 220V
13 WC-5310 TUBE, 5/16 ID x 1/8W SILICONE GEN USE
14 WC-1408 CORD GRIP, 7/8” O.D.
15A WC-1200 1,3 CORD, 14/3 SJTO 6’ BLK W/PLUG
15B WC-1231-103 2,4 CORD, 2.5 mm² PRE-CUT W/
CONNECTORS
16 WC-103 2,4 SWITCH, TOGGLE NON-LIT DPST 25A
125/250VAC RESISTIVE
17 WC-5231 COMPOUND, SILICONE 5 OZ
CAFE0AP, CAFE0PP - Main Chassis - Parts List
1CAFE0AP10A000, 2CAFE0AP30A000, 3CAFE0PP10A000, 4CAFE0PP30A000
ITEM # PART # DESCRIPTION
9 WC-29025 SPRAYHEAD, PURPLE ADVANCE FLOW
13 WC-5310 TUBE, 5/16 ID x 1/8W SILICONE GEN USE
16 WC-103 SWITCH, TOGGLE NON-LIT DPST 25A
125/250VAC RESISTIVE
ITEM # PART # DESCRIPTION
17 WC-5231 COMPOUND, SILICONE 5 OZ
CAFE0AP, CAFE0PP - Main Chassis - Recommended Parts to Stock

ILLUSTRATED PARTS/RECOMMENDED PARTS IP66
8$ø5"/,"44&.#-:*--6453"5&%1"3543&$0..&/%&%1"354 /$
ITEM # PART # DESCRIPTION
1 WC-54117 TANK, COMPLETE 1450W 120V CAFÉ
2 WC-54125-101 COVER, W/A HEATING TANK CAFE
3 WC-43062 GASKET, TANK LID
4 WC-5418 CLIP, RESET THERMOSTAT GEN USE
5 WC-917-04 ELEMENT, HEATING 1.45KW 120V W/JAM NUTS &
SILICONE O-RING
6 WC-1438-101 SENSOR, TEMPERATURE TANK
7 WC-4394 GUARD, SHOCK/HEATING ELEMENT FOR SINGLE
HEATING ELEMENT
ITEM # PART # DESCRIPTION
3 WC-43062 GASKET, TANK LID
5 WC-917-04 ELEMENT, HEATING 1.45KW 120V W/JAM NUTS &
SILICONE O-RING
6 WC-1438-101 SENSOR, TEMPERATURE TANK
7 WC-4394 GUARD, SHOCK/HEATING ELEMENT FOR SINGLE
HEATING ELEMENT
WC-54117 - Recommended Parts to Stock
ITEM # PART # DESCRIPTION
8WC-521 THERMOSTAT, HI-LIMIT SPST 120V 15A AUTO-RE-
SET
9 WC-2627 BUSHING, CONICAL .583ID X .945 OD .886LG
12mm GEN USE
10 WC-2628 BUSHING, CONICAL.469 ID X .945 OD X .986 LG
8mm GEN USE
ITEM # PART # DESCRIPTION
8WC-521 THERMOSTAT, HI-LIMIT SPST 120V 15A AUTO-RE-
SET
9 WC-2627 BUSHING, CONICAL .583ID X .945 OD .886LG 12mm
GEN USE
10 WC-2628 BUSHING, CONICAL.469 ID X .945 OD X .986 LG
8mm GEN USE
11 WC-29042 HOSE, VENTILATION HEATING TANK CAFÉ
WC-54117 - Tank Assembly
2
3
6
7
4
8
1
5
9
WC-54117 - Tank Assembly - Parts List
11
10

ILLUSTRATED PARTS/RECOMMENDED PARTS IP67
8$ø5"/,"44&.#-:*--6453"5&%1"3543&$0..&/%&%1"354 /$
ITEM # PART # DESCRIPTION
1 WC-54117 TANK, COMPLETE 1450W 120V CAFÉ
2 WC-54125-101 COVER, W/A HEATING TANK CAFE
3 WC-43062 GASKET, TANK LID
4 WC-5418 CLIP, RESET THERMOSTAT GEN USE
5 WC-906-04 KIT, ELEMENT, HEATING 2KW 220V W/ JAM NUT &
SILICONE O-RING
6 WC-1438* SENSOR, TEMPERATURE TANK
7 WC-4394 GUARD, SHOCK/HEATING ELEMENT FOR SINGLE
HEATING ELEMENT
ITEM # PART # DESCRIPTION
3 WC-43062 GASKET, TANK LID
5 WC-917-04 ELEMENT, HEATING 1.45KW 120V W/JAM NUTS &
SILICONE O-RING
6 WC-1438 SENSOR, TEMPERATURE TANK
7 WC-4394 GUARD, SHOCK/HEATING ELEMENT FOR SINGLE
HEATING ELEMENT
WC-54145 - Recommended Parts to Stock
ITEM # PART # DESCRIPTION
8WC-521 THERMOSTAT, HI-LIMIT SPST 120V 15A AUTO-RE-
SET
9 WC-2627 BUSHING, CONICAL .583ID X .945 OD .886LG
12mm GEN USE
10 WC-2628 BUSHING, CONICAL.469 ID X .945 OD X .986 LG
8mm GEN USE
ITEM # PART # DESCRIPTION
8WC-521 THERMOSTAT, HI-LIMIT SPST 120V 15A AUTO-RE-
SET
9 WC-2627 BUSHING, CONICAL .583ID X .945 OD .886LG 12mm
GEN USE
10 WC-2628 BUSHING, CONICAL.469 ID X .945 OD X .986 LG
8mm GEN USE
11 WC-29042 HOSE, VENTILATION HEATING TANK CAFÉ
WC-54145 - Tank Assembly
2
3
6
7
4
8
1
5
9
WC-54145 - Tank Assembly - Parts List
11
10
* Not used on models that are equipped with a capillary type thermostat.